NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
29 reportsClear category filter33,000 miles · Feb 25, 2022
Power TrainService Brakes
The contact owns a 2016 Honda Pilot. The contact stated that while driving approximately 80-85 MPH uphill, the accelerator pedal was depressed and the warning message "Transmission Overheating" was illuminated. The contact stated that he continued to drive at a slower speed. The vehicle was taken to the dealer who informed the c…
Read full complaint
The contact owns a 2016 Honda Pilot. The contact stated that while driving approximately 80-85 MPH uphill, the accelerator pedal was depressed and the warning message "Transmission Overheating" was illuminated. The contact stated that he continued to drive at a slower speed. The vehicle was taken to the dealer who informed the contact that they could not replicate the failure. The contact stated that the failure reoccurred while driving uphill. The vehicle was taken to a second dealer, Moss Bros. Honda (27990 Eucalyptus Ave, Moreno Valley, CA 92555) who did not diagnose the vehicle but informed the contact that the transmission fluid needed to be flushed and replaced. The vehicle was taken to an independent mechanic and the transmission fluid was replaced. The contact also stated that the steering wheel was shaking whenever the brake pedal was depressed. The vehicle was taken to the independent mechanic where it was diagnosed that the front rotors needed to be replaced. The contact stated that he was unable to replace the front rotors himself as there were abnormally small compared to the replacement parts. The contact also stated that the front rotors were abnormally smaller than the rear rotors of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failures and a case was opened. The contact was awaiting a call back from the manufacturer. The failure mileage was approximately 33,000.
NHTSA ODI #11454083
Mileage unknown · Aug 21, 2021
Service Brakes
Steering wheel shaking violently when braking especially at highway (down hill) speed.
NHTSA ODI #11429952
99,000 miles · Dec 29, 2020
Air BagsService BrakesCrash
AIR BAG DID NOT DEPLOY ON IMPACT. DRIVING APPROXIMATELY 15 MPH ON A RESIDENTIAL ROAD WHEN BRAKE'S LOCKED AND CAR DID NOT RESPOND, RUNNING DIRECTLY INTO A TELEPHONE POLE WHILE ON A HILL/SLOPE. CAR PICKED UP SPEED BEFORE IMPACT. AIR BAG SENSOR OR ERROR APPEARED ON IMPACT, CAR SMELLED OF SMOKE/BURNING. FRONT BODY AND FRAME HAD EXTE…
Read full complaint
AIR BAG DID NOT DEPLOY ON IMPACT. DRIVING APPROXIMATELY 15 MPH ON A RESIDENTIAL ROAD WHEN BRAKE'S LOCKED AND CAR DID NOT RESPOND, RUNNING DIRECTLY INTO A TELEPHONE POLE WHILE ON A HILL/SLOPE. CAR PICKED UP SPEED BEFORE IMPACT. AIR BAG SENSOR OR ERROR APPEARED ON IMPACT, CAR SMELLED OF SMOKE/BURNING. FRONT BODY AND FRAME HAD EXTENSIVE DAMAGE, IE. RADIATOR CAGE(?). AIR BAGS DID NOT DEPLOY AND POLICE STATED THAT GIVEN THE IMPACT, THEY SHOULD HAVE. CAR IS BEING REPAIRED AND AIR BAG SENSOR CONTINUES TO DISPLAY WITHOUT KNOWN CAUSE.
NHTSA ODI #11385404
48,900 miles · Oct 30, 2020
Electrical SystemService BrakesVehicle Speed ControlCrash
SINCE BUYING THIS VEHICLE THE TRANSMISSION AND COMPUTER MODULE HAVE ALREADY BEEN REPLACED ONCE DUE TO SIMILAR PROBLEM. WHILE MY SON WAS DRIVING AROUND A CORNER ON A CITY BLOCK SO TURNING LEFT AT 15 MILES PER HOUR THE TRANSMISSION SUFFERED A FAILURE AND ERROR MESSAGE AND ACCELERATED FORCING HIM OFF THE ROAD. DEALER HAS DENIED A…
Read full complaint
SINCE BUYING THIS VEHICLE THE TRANSMISSION AND COMPUTER MODULE HAVE ALREADY BEEN REPLACED ONCE DUE TO SIMILAR PROBLEM. WHILE MY SON WAS DRIVING AROUND A CORNER ON A CITY BLOCK SO TURNING LEFT AT 15 MILES PER HOUR THE TRANSMISSION SUFFERED A FAILURE AND ERROR MESSAGE AND ACCELERATED FORCING HIM OFF THE ROAD. DEALER HAS DENIED ANY ASSISTANCE.
NHTSA ODI #11372442
70,000 miles · Oct 16, 2020
Electrical SystemService BrakesVehicle Speed Control
PURCHASED A 2016 PILOT EX-L CERTIFIED USED WITH 8K. WHILE PRESSING THE BRAKES, THEY WOULD GO PRETTY FAR DOWN BEFORE ENGAGING. IF I LET UP ON THE PEDAL AND PRESS AGAIN, THEY IMMEDIATELY GRAB LIKE THEY ARE SUPPOSED. I HAVE TAKEN THE VEHICLE IN SEVERAL TIMES, BRAKES BLED AND FLUSHED, STILL THE SAME. I WAS INFORMED THAT HONDA SAYS T…
Read full complaint
PURCHASED A 2016 PILOT EX-L CERTIFIED USED WITH 8K. WHILE PRESSING THE BRAKES, THEY WOULD GO PRETTY FAR DOWN BEFORE ENGAGING. IF I LET UP ON THE PEDAL AND PRESS AGAIN, THEY IMMEDIATELY GRAB LIKE THEY ARE SUPPOSED. I HAVE TAKEN THE VEHICLE IN SEVERAL TIMES, BRAKES BLED AND FLUSHED, STILL THE SAME. I WAS INFORMED THAT HONDA SAYS THE DISTANCE OF BRAKE PEDAL PRESSING DOWN IS 2" IS NORMAL. I ALSO HAD ISSUES WITH THE SCREEN GOING OUT, AND THE DRIVER SIDE VENT WOULDN'T STAY UP, AND THE A/C WASN'T COOLING PROPERTY. ALSO THE SYSTEM WONT CONNECT TO MY PHONE RANDOMLY. I NOW HAD A PROBLEM WITH THE TRANSMISSION. MAKES A RATTLING NOISE WHILE DRIVING/COASTING AT ANY SPEED. HAVE TAKEN IT IN AND WAS TOLD IT WAS THE BUMPER AND HOOD NOISE. AFTER PAYING FOR THAT, I STILL HAVE THE NOISE. THE RPMS JUMPS FROM UNDER 2 TO JUST ABOVE TWO, THEN DOWN AGAIN. WHEN THE RPMS DO THIS THE NOISE HAPPENS AND ALSO THE ECONO MODE TURNS OFF TO WHITE, THEN GREEN AGAIN. NOW IT FEELS LIKE WHEN THIS HAPPENS THE TRANSMISSION FEELS AS IFF IT IS TRYING TO GO INTO GEAR, SLIPPING. NOW WHEN DRIVING AND TRYING TO PASS, IT SEEMS TO SLIP. IT IS DEFINITELY A SAFETY ISSUE! COME ON HONDA PLEASE FIX THE ISSUES.
NHTSA ODI #11364653
67,851 miles · Jul 19, 2019
EngineExterior LightingService Brakes
IT ENGINE IS IDLE ALL THE TIME WHEN THE AC IS ON
NHTSA ODI #11233411
12,000 miles · Jul 10, 2019
Electrical SystemEngineService Brakes
WHILE IDOL AT RED LIGHT, THE AUTOMATIC IDOL KICKED IN FOR POWER SAVE YET JERKED AND ALL RED LIGHT INDICATORS TURNED ON, INCLUDING PARKING BREAKS, AND CAR SEIZED UP. NO POWER, NO ABILITY PUT CAR IN PARK OR DRIVE. ON/OFF SWITCH NO REACTION TO TURN CAR ON OR OFF. NO BRAKE FUNCTION. I SAT IN AN UNRESPONSIVE VEHICLE AT VERY BUSY INTE…
Read full complaint
WHILE IDOL AT RED LIGHT, THE AUTOMATIC IDOL KICKED IN FOR POWER SAVE YET JERKED AND ALL RED LIGHT INDICATORS TURNED ON, INCLUDING PARKING BREAKS, AND CAR SEIZED UP. NO POWER, NO ABILITY PUT CAR IN PARK OR DRIVE. ON/OFF SWITCH NO REACTION TO TURN CAR ON OR OFF. NO BRAKE FUNCTION. I SAT IN AN UNRESPONSIVE VEHICLE AT VERY BUSY INTERCETION. LUCKILY THE VEHICLE BEHIND ME WAS STOPPED AND ONLY LAID ON THEIR HORN FOR 2 RED LIGHT CYCLES RATHER THAN HITTING ME. I ACTIVATED MY EMERGENCY FLASHERS YET OTHER DRIVER DID NOT RESPOND. I REPETITIVELY KEPT PUSHING POWER BUTTON IN EFFORT FOR CAR TO RESPOND AND RESTART, EVENTUALLY DID AND WAS ABLE TO DRIVE OFF. HAVE APPT WITH DEALERSHIP IN AM.
NHTSA ODI #11230891
29,395 miles · Oct 8, 2018
Electronic Stability Control (esc)Service BrakesSteering
MY VEHICLE WAS IN MOTION ON A NEIGHBORHOOD STREET WHEN SEVERAL ALERTS WENT OFF ON MY DASHBOARD: ROAD DEPARTURE MITIGATION SYSTEM PROBLEM, TRAILER STABILITY ASSIST PROBLEM, HILL START ASSIST PROBLEM, VEHICLE STABILITY ASSIST PROBLEM, EMISSIONS SYSTEM PROBLEM, POWER STEERING SYSTEM PROBLEM. I COULD FIND NO REASON FOR THESE ALERTS.…
Read full complaint
MY VEHICLE WAS IN MOTION ON A NEIGHBORHOOD STREET WHEN SEVERAL ALERTS WENT OFF ON MY DASHBOARD: ROAD DEPARTURE MITIGATION SYSTEM PROBLEM, TRAILER STABILITY ASSIST PROBLEM, HILL START ASSIST PROBLEM, VEHICLE STABILITY ASSIST PROBLEM, EMISSIONS SYSTEM PROBLEM, POWER STEERING SYSTEM PROBLEM. I COULD FIND NO REASON FOR THESE ALERTS. I TOOK MY CAR INTO A DEALERSHIP THE NEXT DAY AND WAS TOLD THERE WAS NO ISSUE AND THE LIGHTS WERE TURNED OFF. 10 DAYS LATER THEY ALL CAME ON AGAIN AS I WAS DRIVING ON A LOCAL STREET. THE NEXT DAY WHEN I WENT TO TAKE MY CAR TO THE DEALER, THE LIGHTS HAD TURNED OFF. I TOOK IT IN ANYWAY, AND THEY AGAIN SAID THERE WAS NO ISSUE. I REPORTED THE ISSUE TO HONDA CORPORATION AND WAS TOLD BY ONE AGENT THAT THIS WASN'T THE FIRST TIME THE ISSUE HAD COME UP IN A NEWER MODEL PILOT. AGAIN 2 DAYS AGO, ALL THE LIGHTS CAME ON AND NOW ALSO THE BRAKE ASSIST ALERT IS ALSO ON. I WILL TAKE IT TO THE DEALERSHIP AGAIN. I AM CONCERNED ALL THE FALSE ALARMS MAY BE HIDING AN UNDERLYING ISSUE THAT COULD RESULT IN A DANGEROUS ACCIDENT. I ALSO FEEL THAT HONDA GLOBAL IS NOT TAKING ME SERIOUSLY AS I AM ACTIVE DUTY STATIONED OVERSEAS AND HAVE TO RELY ON LOCAL HONDA DEALERSHIPS THAT DO NOT HAVE MUCH EXPERIENCE WITH THE HONDA PILOT. THE DATES OF THE LIGHTS WERE 17 SEPT, 27 SEPT, AND 6 OCT 2018.
NHTSA ODI #11139016
2,000 miles · Dec 4, 2017
Service Brakes
I AM HEARING A CLICKING NOISE WHEN I STEP ON THE BRAKES. I TOOK IT RO HONDA AND THEY SAID IT'S SOMETHING PEOPLE COMPLAINING ABOUT AND THEY DON'T HAVE A FIX AND THWY KNOW ABOUT IT. THEY DON'T KNOW HOW TO ADDRESS THE SITUATION.
NHTSA ODI #11052131
15,000 miles · Oct 11, 2017
Fuel/propulsion SystemService BrakesVehicle Speed ControlCrashInjury
I HAD PULLED OUT OF A PARKING PLACE AND WAS WAITING IN THE TRAFFIC LANE TO EXIT THE AREA. THERE WERE TWO CARS IN FRONT OF US. THE CARS WERE STOPPED. I WAS APPROXIMATELY 20-25 FEET BEHIND THE CAR IN FRONT OF ME. I TOOK MY FOOT OFF THE BRAKE IN MY CAR TO LET IT IDLE FORWARD. AS I APPROACHED THE YUKON I REAPPLIED THE BR…
Read full complaint
I HAD PULLED OUT OF A PARKING PLACE AND WAS WAITING IN THE TRAFFIC LANE TO EXIT THE AREA. THERE WERE TWO CARS IN FRONT OF US. THE CARS WERE STOPPED. I WAS APPROXIMATELY 20-25 FEET BEHIND THE CAR IN FRONT OF ME. I TOOK MY FOOT OFF THE BRAKE IN MY CAR TO LET IT IDLE FORWARD. AS I APPROACHED THE YUKON I REAPPLIED THE BRAKE. THE CAR ACCELERATED TO WHAT SOUNDED LIKE FULL RPM'S AND I APPLIED THE BRAKES AS HARD AS I COULD AND NOTHING HAPPENED. THE CAR SLAMMED INTO THE YUKON WITH SUCH AN IMPACT THAT BOTH FRONT AIRBAGS DEPLOYED. THE DRIVER SIDE AIRBAG HIT ME IN THE FACE. THE PASSENGER AIRBAG DID NOT REACH MY WIFE IN THE PASSENGER SEAT. SHE IMMEDIATELY EXPERIENCED SEVERE CHEST PAIN AND RAPID HEART BEAT. BYSTANDERS CALLED 911 AND TWO PARK RANGERS ARRIVED IN APPROX. 15-20 MINUTES. THE RANGERS FINISHED TAKING PICTURES AND ASKED ME TO PULL IN TO A PARKING SPOT OUT OF THE TRAVEL LANE OF THE PARKING LOT. I STARTED THE CAR AND PROCEEDED SLOWLY AND TURNED INTO A PARKING SPOT. AS I APPLIED THE BRAKE TO PARK, THE SAME PHENOMENON OCCURRED AGAIN. THE CAR ACCELERATED FORWARD OVER A CURB AND WALKWAY AND STRUCK A PEDESTRIAN BEFORE COMING TO A STOP ON A RETAINING WALL. I DESPERATELY TRIED TO STOP THE CAR WITHOUT SUCCESS. THE EMS WAS THERE SHORTLY AFTER THIS OCCURRENCE. A RANGER ASKED ME HOW FAST I WAS MOVING AND I STATED I HAD NO IDEA. I ASKED HIM TO ASK THE RANGER WHO WAS RIGHT BEHIND ME AND HE SAID 5 MPH. I EXITED THE VEHICLE AFTER THEY TRANSPORTED THE PEDESTRIAN ON THE BACKBOARD.THE AMBULANCE WAS READY TO TAKE MY WIFE TO THE HOSPITAL SO I APPROACHED THE PARK RANGER AND TOLD HIM THAT I NEEDED TO RIDE IN THE AMBULANCE WITH MY WIFE.
NHTSA ODI #11032866
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration