NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
200 reportsClear category filterMileage unknown · Jun 6, 2024
Power Train
HONDA PILOT 2016 -THE TRANSMISSION CAUSES THE TRANSMISSION FLUID TO OVERHEAT. THE OVERHEATING ISSUE LEADS TO A 'JUDDER' IN THE TRANSMISSION. THE CAR ACCELERATES IN A VERY JERKY WAY ESPECIALLY BETWEEN 30 AND 50. THIS IS A BIG SAFETY ISSUE IF YOU ARE TRYING TO PASS SOMEONE. AS SOON AS THE VEHICLE REACHES 80,000 MILES HONDA WILL NO…
Read full complaint
HONDA PILOT 2016 -THE TRANSMISSION CAUSES THE TRANSMISSION FLUID TO OVERHEAT. THE OVERHEATING ISSUE LEADS TO A 'JUDDER' IN THE TRANSMISSION. THE CAR ACCELERATES IN A VERY JERKY WAY ESPECIALLY BETWEEN 30 AND 50. THIS IS A BIG SAFETY ISSUE IF YOU ARE TRYING TO PASS SOMEONE. AS SOON AS THE VEHICLE REACHES 80,000 MILES HONDA WILL NO LONGER COVER THE SO-CALLED 'REPAIR' to flush fluid and update software. HONDA IS AWARE OF THIS PROBLEM.
NHTSA ODI #11592891
Mileage unknown · May 23, 2024
EnginePower Train
My spouse was stopped at a traffic light, when the light turned green she accelerated but immediately lost power and the vehicle was stalled in the middle of the intersection. She tried to start it but would not restart. We had to leave the car in the intersection while waiting for the police and towing.She worried that a vehi…
Read full complaint
My spouse was stopped at a traffic light, when the light turned green she accelerated but immediately lost power and the vehicle was stalled in the middle of the intersection. She tried to start it but would not restart. We had to leave the car in the intersection while waiting for the police and towing.She worried that a vehicle would collide with our vehicle and until she was able to exit the vehicle and move to a nearby sidewalk.. Luckily she made it safely and no-one collided with the car. We had it towed to our local mechanic. The inspected the car and found that the bearing had seized up the crankshaft. I connected with Honda and they told me to take it to a local dealer to have it inspected by them. The dealer had the vehicle for two weeks and came up with the same conclusion. After a little back and forth with Honda they declined to give any help with fixing the engine, (a $20,000 repair estimate). I ended up selling the car for junk. Two weeks later a friend sent me an article that Honda was recalling 2016 Pilots for the same incident that happened to my car. There were no warnings prior to the engine failure. My vehicle is not listed on the recall. Honda knew the problem and was attempting to issue a recall.
NHTSA ODI #11590277
Mileage unknown · May 7, 2024
EnginePower Train
My vehicle has been loosing power when accelerating. This has been an ongoing issue for approximately six months or so. I' have taken it to two different mechanic shops locally and both have stated that some of the fuel injectors are not working properly and 5 cylinders are misfiring. That is the reason the vehicle is loosing p…
Read full complaint
My vehicle has been loosing power when accelerating. This has been an ongoing issue for approximately six months or so. I' have taken it to two different mechanic shops locally and both have stated that some of the fuel injectors are not working properly and 5 cylinders are misfiring. That is the reason the vehicle is loosing power. But they don't understand why the engine light or any other light are not coming up on the cluster board. Vechicle continues to jerk and shudder everytime we stop and only happens on 2 and 3 gear to the point we have to stay two cars back everytime it is in use to avoid rear ending any other vehicles. Feels like it looses power to the point of turning off then begans to pull. The RPM needle jumps up and down when the shuddering begins. It is a great concern such that i feel it poses a risk to my family and other drivers. I have been to the dealership but they will not do anything about it unless the engine light is on which at this point it has not turned on making impossible to diagnose the issue through the dealership. I did provide the dealership with documentation from other shops but they wouldn't accept them as they would have to run diagnostic themselves. I did check for recalls and other complaints. A recall was issued for the fuel injectors but as stated dealership will not do anything unless the engine light turns on. They wouldn't even test drive it to confirm the issue. I feel that if this issue isn't addressed my family or others drivers will end up getting hurt. There has been hundreds of people who have complained of the same issue on the internet forums and many have filed complaints with the NHTSA. This complaint is for record purposes in the event of injury due to engine failure on my vehicle.
NHTSA ODI #11587531
Mileage unknown · Apr 17, 2024
Power Train
Transmission slip/jerk/clunk when going above 2 RPMs. This has happened before 3 times with the first time happening in 2019, then 2022 and then again on [XXX], 2024. I've taking it to the dealer all 3 times and they performed a transmission fluid flush since apparently the transmission fluid gets too hot and needs to be flushed…
Read full complaint
Transmission slip/jerk/clunk when going above 2 RPMs. This has happened before 3 times with the first time happening in 2019, then 2022 and then again on [XXX], 2024. I've taking it to the dealer all 3 times and they performed a transmission fluid flush since apparently the transmission fluid gets too hot and needs to be flushed every so often. This last time they told me I needed a new torque converter ($5,500) to fix the issue. This a huge safety issue especially when driving in the highway as the cars loses speed and begins to jerk. I see similar issues with the 2017-2019 models [XXX] ) which sound the same as to what's happening to the 2016 models. There are a ton of complaints on the web for 2016 Pilot which the NHTSA should take into consideration. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11583722
Mileage unknown · Apr 8, 2024
EnginePower Train
Through diagnostic at Honda Dealership, the #5 bearing failed causing engine damage (crank shaft and connecting rod). This pilot year is included in the current Part 573 Safety Recall Report, however this particular VIN is not currently included.
NHTSA ODI #11581698
Mileage unknown · Mar 3, 2024
Electrical SystemPower TrainService Brakes
1) First and most annoying is the start button displays code on the screen "keyless start system problem ". Its done it for about two three now. There is no recall for my VIN. 2) Back wheels brakes make very loud kicking noise when car put in reverse and moves in reverse. It started 4 years ago. I took it to dealership and they …
Read full complaint
1) First and most annoying is the start button displays code on the screen "keyless start system problem ". Its done it for about two three now. There is no recall for my VIN. 2) Back wheels brakes make very loud kicking noise when car put in reverse and moves in reverse. It started 4 years ago. I took it to dealership and they said breaks are fine and they don't know why its kicking. In cold weather break sensor displays warning "apply break before putting in park" while breaks are applied. So it can't sense that breaks are applied. 3)blue ray DVD player quit working years ago. 4) Transmission is jerking when switches to third gear. This car has 56000 miles. 5) Roof molding in the front came off while driving. The clips somehow broke and it flew away. This car has been parked in the garage during the day and driven carefully with all needed oil changes and one owner. It should not have this problems. 6) the tires fell apart when car was 4 years old with about 25000 miles on it. The dealership said they don't know why and its was not normal. The top of the tires pilled off in chanks.
NHTSA ODI #11575124
Mileage unknown · Jan 19, 2024
EngineFuel/propulsion SystemPower Train
My engine broke and the 2016 Honda Pilot awd engine locked up and the dealership is saying it’s the same issue as the 2016-2019 recall. Also I own a 2008 Honda element awd windshield cracked. The recall for every Honda Element year except 2008. 2003-2007, 2009-2011. That doesn’t make since either. Phone [XXX] [XXX] [XXX] INFO…
Read full complaint
My engine broke and the 2016 Honda Pilot awd engine locked up and the dealership is saying it’s the same issue as the 2016-2019 recall. Also I own a 2008 Honda element awd windshield cracked. The recall for every Honda Element year except 2008. 2003-2007, 2009-2011. That doesn’t make since either. Phone [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11566532
Mileage unknown · Dec 13, 2023
EnginePower Train
ENGINE MADE NOISE. ENGINE STOPPED SUDDENLY ON HIGHWAY. VEHICLE WITH 3 OCCUPANTS HAD TO BE TOWED FROM HIGHWAY AND TRANSPORTED TO HONDA DEALERSHIP FOR REPAIRS. VEHICLE HAS BEEN INSPECTED AT GUNN HONDA, 14610 I-10 W SAN ANTONIO, TX ADVISED BY THE DEALER THE VEHICLE WILL REQUIRE EXTENSIVE (REPLACE ENGINE) REPAIRS. THERE IS A RECA…
Read full complaint
ENGINE MADE NOISE. ENGINE STOPPED SUDDENLY ON HIGHWAY. VEHICLE WITH 3 OCCUPANTS HAD TO BE TOWED FROM HIGHWAY AND TRANSPORTED TO HONDA DEALERSHIP FOR REPAIRS. VEHICLE HAS BEEN INSPECTED AT GUNN HONDA, 14610 I-10 W SAN ANTONIO, TX ADVISED BY THE DEALER THE VEHICLE WILL REQUIRE EXTENSIVE (REPLACE ENGINE) REPAIRS. THERE IS A RECALL FOR 2016 HONDA PILOT (23V751000) FOR CONNECTING ROD BEARING HOWEVER THIS VEHICLE DOES NOT FALL WITHIN THE MFG WINDOW.
NHTSA ODI #11559963
Mileage unknown · Dec 13, 2023
EnginePower Train
The dash began displaying 4 error codes EPS problem, VSA problem, Hill Assist problem, and TSA Problem. It began to jerk and lose power similar to running out of gas necessitating hazard lights and pulling off the road x3 after dark. 3 different shops ran a diagnosis code of P0369. The recommendation from Honda after having …
Read full complaint
The dash began displaying 4 error codes EPS problem, VSA problem, Hill Assist problem, and TSA Problem. It began to jerk and lose power similar to running out of gas necessitating hazard lights and pulling off the road x3 after dark. 3 different shops ran a diagnosis code of P0369. The recommendation from Honda after having the car three days was to replace #2 cylinder head assembly at an estimate of $6400! There would also be no guarantee that this repair would fix the problem. The vehicle only has 83,000ish miles. After speaking with American Honda, they were aware of this problem but said my vin number wasn’t included in the pool of “faulty manufactured parts” but did say that didn’t mean that I didn’t get faulty parts though. The vehicle is no longer under warranty. I just paid this vehicle off in May. This certainly doesn’t support Honda’s reputation as being a manufacturer of reliable vehicles. I have never owned a used vehicle that required this depth and cost of repair. I am waiting on their Goodwill Review to see if they decide to help me with this. The two representatives including a case manager I spoke with didn’t seem as though it was likely going to happen.
NHTSA ODI #11559949
Mileage unknown · Dec 11, 2023
EnginePower Train
When driving down the interstate with a car full of people. We noticed a clicking sound coming from the engine. The sound proceeded to get worse and louder. We pulled over and stopped driving. Had the car towed home and had our mechanic look at it who diagnosed it as a Rod knock. We have now towed it to the dealer and waiti…
Read full complaint
When driving down the interstate with a car full of people. We noticed a clicking sound coming from the engine. The sound proceeded to get worse and louder. We pulled over and stopped driving. Had the car towed home and had our mechanic look at it who diagnosed it as a Rod knock. We have now towed it to the dealer and waiting for a “official” diagnosis from “master Mechanic.” Honda doesn’t seem to promising in resolving the issue or willing to replace the engine. This car will be worthless if they are unable to live up to their quality control, take some ownership for their mistakes, and do the right thing to fix the car they messed up from the beginning.
NHTSA ODI #11559610
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration