NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
14 reportsClear category filterMileage unknown · May 18, 2024
Electrical SystemExterior LightingVisibility/wiper
Defective Keyless Access Unit Car will completely lose power Honda dealer confirmed defective keyless access unit Various problems experienced : a) Car is completely disabled b) Main Battery drained c) Flashing External Lights d) Flashing Dashboard cluster lights and indicators e) Anti Theft security Alarm Horn will sound f…
Read full complaint
Defective Keyless Access Unit Car will completely lose power Honda dealer confirmed defective keyless access unit Various problems experienced : a) Car is completely disabled b) Main Battery drained c) Flashing External Lights d) Flashing Dashboard cluster lights and indicators e) Anti Theft security Alarm Horn will sound f) Defective Hood Latch g) Windshield Wipers operational compromised
NHTSA ODI #11589452
Mileage unknown · Aug 29, 2023
EngineExterior LightingSteering
My 2016 Honda Pilot was recently repaired as the Cam-Shaft had move within the care engine. My car has 109,000 miles on the vehicle, and should not have this issue given the cars age and the way that the car is driven. I am a suburban mom, who drives the car to work and with both of my children within my car. This put my entir…
Read full complaint
My 2016 Honda Pilot was recently repaired as the Cam-Shaft had move within the care engine. My car has 109,000 miles on the vehicle, and should not have this issue given the cars age and the way that the car is driven. I am a suburban mom, who drives the car to work and with both of my children within my car. This put my entire family as risk driving within the care and could have hurt other drivers if the malfunction happened in the middle of the free-way or otherwise. The vehicle was inspected by the Honda Dealership for the issue. The vehicle has all of the dash lights flashing and the car was driving erratically, so much so that mid driving the car, it we were in a near miss accident due to the mechanical malfunction. The 2nd issue that has presented itself, it the start and stop button within the vehicle. It is a known defect to the vehicle.
NHTSA ODI #11541354
Mileage unknown · Jun 19, 2023
Electrical SystemEngineExterior Lighting
What component or system failed or malfunctioned, and is it available for inspection upon request? The auto stop idle feature in my 2016 Honda Pilot Touring failed to operate correctly. This feature automatically turns off the engine while keeping the electrical systems on. I can make the vehicle available for inspection upon re…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The auto stop idle feature in my 2016 Honda Pilot Touring failed to operate correctly. This feature automatically turns off the engine while keeping the electrical systems on. I can make the vehicle available for inspection upon request. How was your safety or the safety of others put at risk? The malfunction of the auto stop idle feature jeopardized my safety and the safety of others. When I stopped at a red light, the engine turned off as expected, but when I pressed the gas pedal to resume driving, all the vehicle's systems shut down. I attempted to start the car by holding the key fob to the Start/Stop button, but it would briefly start and then turn back off. The sudden loss of power and inability to restart the engine left me in a precarious situation. As a result, I was unable to activate the hazard lights, putting me at risk of being involved in a collision or not being visible to other drivers. Has the problem been reproduced or confirmed by a dealer or independent service center? At the time of filing this complaint, the problem has not been reproduced or confirmed by a dealer or independent service center. However, I strongly recommend conducting a thorough investigation by a certified technician to replicate the issue and address it appropriately. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by the police who responded to the incident when it occurred at the red light. However, no inspections have been conducted by the manufacturer, insurance representatives, or other parties at this point. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps, messages, or other symptoms indicating a problem prior to this failure. The feature had been working.
NHTSA ODI #11527791
Mileage unknown · May 15, 2023
Electrical SystemExterior Lighting
When car is locked alarm sporadically goes off on its own also when the headlights are set to auto and the car is turned off the headlights will come on sporadically and drain the battery. Having electrical components come on on their own is obviously a safety concern. The dashboard lights and warning icons will also flicker. Th…
Read full complaint
When car is locked alarm sporadically goes off on its own also when the headlights are set to auto and the car is turned off the headlights will come on sporadically and drain the battery. Having electrical components come on on their own is obviously a safety concern. The dashboard lights and warning icons will also flicker. There have been numerous complaints of this kind on the Honda Pilot forum Piloteers.Org
NHTSA ODI #11521968
Mileage unknown · Feb 21, 2023
Electrical SystemExterior LightingFuel/propulsion System
The instrument panel is flashing all alerts when the car is off. I am able to drive the car. It is unknown which component has malfunctioned. Several Honda owners on Google say to check the fuel injectors. I am hoping you all can assist me with that. My safety was put at risk as the alarm goes off randomly when the car is off. I…
Read full complaint
The instrument panel is flashing all alerts when the car is off. I am able to drive the car. It is unknown which component has malfunctioned. Several Honda owners on Google say to check the fuel injectors. I am hoping you all can assist me with that. My safety was put at risk as the alarm goes off randomly when the car is off. It is bothersome at my workplace. I am afraid to drive the vehicle. One of the alerts that flashes is the Antilock Brake System. I am afraid the brakes will go out during driving. The vehicle has not been inspected by the manufacturer. I hope to schedule an appointment as soon as possible. All warning lamps and messages were blinking after the car was turned off. There were no signs of issues prior to turning the car off. Since the first initial flashing of alerts, the alerts now stay on during driving however not all lights are flashing. Could it simply need a software update? I do feel this needs investigating and a recall issued.
NHTSA ODI #11508351
Mileage unknown · Jan 16, 2023
Electrical SystemEngineExterior Lighting
My car (2016 Honda Pilot Touring) SHUTS DOWN due to the auto shut off feature at least once a month and I am very nervous to hand it over to my daughter in a next year when she is old enough to drive. I have been stalled out at intersections...it is irresponsible of Honda to not issue a recall. People are going to get into accid…
Read full complaint
My car (2016 Honda Pilot Touring) SHUTS DOWN due to the auto shut off feature at least once a month and I am very nervous to hand it over to my daughter in a next year when she is old enough to drive. I have been stalled out at intersections...it is irresponsible of Honda to not issue a recall. People are going to get into accidents if they can't start their car in the middle of intersections! Why is this not being recalled. I understand it will cost Honda a substantial amount of money to correct, but it has to happen. What if you have an older battery that is losing its charge. Does this mean that WE are to blame for getting into an accident because the battery is not brand new and can't handle this auto shut off feature? It's totally unacceptable! I realize we can turn the feature off...but what happens if my daughter (new driver) forgets to push that button EVERY time she gets in the car. I'm sorry...I know some will say it's the driver's fault for forgetting but the potential of that mistake is real and the possibilities could be devastating.
NHTSA ODI #11501948
30,000 miles · Mar 14, 2021
Electrical SystemEngineExterior Lighting
IT HAPPENED TO MYSELF W/ MY CHILD IN MY CAR & THEN MY SPOUSE DRIVING MY CAR ALONE. HOWEVER THE SAME PROBLEM IS KNOWN TO HONDA BUT UNTIL SOMEONE IS KILLED, THEY ARE REFUSING TO ACKNOWLEDGE, THE CAMSHAFT SHUTTING OFF ALL CONTROLS WHILE DRIVING ON A HIGHWAY IS COMPLETELY DANGEROUS. AS AN EXPERIENCED DRIVER, I WAS ABLE TO AVOID A CO…
Read full complaint
IT HAPPENED TO MYSELF W/ MY CHILD IN MY CAR & THEN MY SPOUSE DRIVING MY CAR ALONE. HOWEVER THE SAME PROBLEM IS KNOWN TO HONDA BUT UNTIL SOMEONE IS KILLED, THEY ARE REFUSING TO ACKNOWLEDGE, THE CAMSHAFT SHUTTING OFF ALL CONTROLS WHILE DRIVING ON A HIGHWAY IS COMPLETELY DANGEROUS. AS AN EXPERIENCED DRIVER, I WAS ABLE TO AVOID A COLLUSION ON A MAJOR HIGHWAY SURROUNDED BY TRACTOR TRAILERS GOING 65MPH. ALTHOUGH THE HONDA DEALER HAS REPLACED THE CAMSHAFT TWICE ON MY 2016 HONDA PILOT WITH LESS THAN 46,000, I AM FEARFUL THIS WILL HAPPEN AGAIN. WE ARE LEFT WITH A BALANCE TO PAY OFF, THE SAFETY OF OUR FAMILY WHILE DRIVING THIS UNSAFE VEHICLE AND JUST CUT OUT LOSSES. HOWEVER, THIS WILL NOT SOLVE THE PROBLEM FOR THOSE WHO CANNOT AFFORD TO PURCHASE ANOTHER VEHICLE. I HAD A 2006 HONDA PILOT WITH VERY LITTLE PROBLEMS FOR 10 YEARS, 95K MILES ON IT. IT WAS WHY I PURCHASED ANOTHER HONDA PILOT. HOWEVER, I SPENT A LOT MORE MONEY. THIS 2016 PILOT WAS $30K WITH THE $10K TRADE IN. WE MAINTAIN ALL OUR VEHICLES AS WELL AS GARAGE KEEP THEM TO PROTECT THEM FROM THE HARSH PA WINTER ELEMENTS. AS A DRIVER FOR OVER 32 YEARS AND ZERO ACCIDENTS, I DO NOT WANT TO BE THE CAUSE OF A SERIOUS ACCIDENT BECAUSE HONDA IS NEGLECTING TO ACKNOWLEDGE THIS NEW GERMAN MADE ENGINE AS WELL AS THE TRANSMISSION IS A SIGNIFICANT PROBLEM. THERE HAVE BEEN OTHER PROBLEMS LIKE THIS ONE THAT BEGAN ONE YR AFTER PURCHASE I BROUGHT TO IMMEDIATE ATTENTION OF THE DEALER. I AM SURE THEY REPORT THESE FINDINGS TO THE MANUFACTURE AS WELL. THE REMOTE KEY STOPPED WORKING, SEVERAL INTERIOR OUTLETS FOR CHARGING HAS STOPPED WORKING, A DOME LIGHT DOESN'T WORK, THE GARAGE DOOR OPENER CAN'T BE PROGRAMMED ANYMORE AND OTHER FEATURES ARE NO LONGER WORKING. IT IS A DANGEROUS CAR TO DRIVE WITH THE RISK OF STARTING ON FIRE AS WELL AS STOPPING ABRUPTLY LIKE IT DID FOR ME IN 2018 AND 2021 FOR MY HUSBAND. VINART LV HONDA EMMAUS, PA
NHTSA ODI #11402871
30,000 miles · Jan 15, 2020
Electrical SystemEngineExterior LightingFire
ON JANUARY 13TH, I LEFT MY HOME TO PICK UP MY SON, JULIAN, 3 YEARS OLD, AT PRESCHOOL. HIS PRESCHOOL IS APPROXIMATELY 3 MILES FROM OUR HOME. I PICKED HIM UP, AND DROVE THE SAME DISTANCE BACK TO OUR HOUSE, ARRIVING HOME AROUND 4:45PM. I HAD NO UNUSUAL WARNING NOTIFICATIONS OR ANY UNUSUAL EXPERIENCE DRIVING TO AND FROM THE PRESCHOO…
Read full complaint
ON JANUARY 13TH, I LEFT MY HOME TO PICK UP MY SON, JULIAN, 3 YEARS OLD, AT PRESCHOOL. HIS PRESCHOOL IS APPROXIMATELY 3 MILES FROM OUR HOME. I PICKED HIM UP, AND DROVE THE SAME DISTANCE BACK TO OUR HOUSE, ARRIVING HOME AROUND 4:45PM. I HAD NO UNUSUAL WARNING NOTIFICATIONS OR ANY UNUSUAL EXPERIENCE DRIVING TO AND FROM THE PRESCHOOL. I PARKED THE CAR IN OUR DRIVEWAY. JULIAN AND I EXITED THE VEHICLE, AND WALKED TO OUR FRONT DOOR. AS WE APPROACHED THE FRONT DOOR I SMELLED SMOKE, AND LOOKED BACK AT THE CAR. I NOTICED A SMALL FLICKER IN THE PASSENGER SIDE LOWER HEADLIGHT. UPON CLOSER LOOK, I REALIZED THIS WAS IN FACT A FLAME. JULIAN AND I LEFT OUR BAGS ON THE PORCH, STEPPED OFF OF OUR FRONT PORCH, AND MOVED AWAY FROM THE HOUSE AND CAR, AND CALLED 911. AS WE WAITED FOR THE FIRE DEPARTMENT, WE WATCHED THIS SMALL FLAME GROW TO FULL FLAMES, ENGULFING THE ENGINE, FRONT HOOD, AND FRONT OF THE CAR. THE POLICE AND FIRE DEPARTMENT ARRIVED, AND PUT OUT THE FIRE. THE CAR WAS TOWED OUT OF OUR DRIVEWAY. A POLICE REPORT WAS FILED WITH THE MONTCLAIR POLICE DEPT. OFFICER ANTHONY SWAN #232 PATROL DIVISION MONTCLAIR POLICE HEADQUARTERS, 647 BLOOMFIELD AVE., MONTCLAIR NJ 07042 ASWAN@MONTCLAIRNJUSA.ORG REPORT # 20-005325 I THEN CALLED OUR INSURANCE PROVIDER, USAA, FOLLOWING THE INCIDENT. THEY HAVE TAKEN THE CAR INTO THEIR POSSESSION AND INITIATED AN ORIGIN & CAUSE INVESTIGATION. WE PURCHASED THE CAR NEW. WE HAVE NOT BEEN IN A COLLISION. THE CAR HAS BEEN SERVICED TWICE ANNUALLY. IT WAS SERVICED LAST WEEK. IT HAS ~30,000 MILES ON IT. THE DEALER THAT SOLD US THE CAR, PAUL MILLER HONDA, IN NJ, HAS BEEN UNRESPONSIVE, TELLING US TO REACH OUT THE THE NATIONAL HONDA OFFICE. I HAVE FILED A CASE WITH HONDA, AND HAVE BEEN TOLD SOMEONE WILL REACH OUT TO ME. THAT HAS NOT HAPPENED.
NHTSA ODI #11299501
67,851 miles · Jul 19, 2019
EngineExterior LightingService Brakes
IT ENGINE IS IDLE ALL THE TIME WHEN THE AC IS ON
NHTSA ODI #11233411
10,100 miles · Jul 7, 2017
Exterior LightingSeats
THE 2016 HONDA PILOT HAS A BAD HEADLIGHTS BEING TOO DIMMED DURING NIGHT DRIVES, THIS IS ESPECIALLY TRUE WHEN YOUR WINDOWS AND WINDSHIELDS ARE TINTED. SECONDLY, THE REVERSE OR BACKUP LIGHTS ARE LOCATED IN A VERY LOW POSITION DOWN AT THE BUMPER, WHEREIN IT MAY NOT BE SEEN BY CARS FROM BEHIND WHEN WE'RE REVERSING. THESE LIGHTING IS…
Read full complaint
THE 2016 HONDA PILOT HAS A BAD HEADLIGHTS BEING TOO DIMMED DURING NIGHT DRIVES, THIS IS ESPECIALLY TRUE WHEN YOUR WINDOWS AND WINDSHIELDS ARE TINTED. SECONDLY, THE REVERSE OR BACKUP LIGHTS ARE LOCATED IN A VERY LOW POSITION DOWN AT THE BUMPER, WHEREIN IT MAY NOT BE SEEN BY CARS FROM BEHIND WHEN WE'RE REVERSING. THESE LIGHTING ISSUES ARE A SAFETY RISK. THIRD, THE FRONT SEATS ARE QUITE UNCOMFORTABLE, POORLY DESIGNED FOR LONG-DRIVES AND IS A SAFETY RISK ESPECIALLY FOR HARD AND TIGHT TURNS WHERE WE SLIDE OFF TO THE SIDES OF OUR SEATS.
NHTSA ODI #11003545
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration