NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
767 reportsClear category filter27,817 miles · Jun 11, 2019
Engine
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER WHEN THE BRAKE PEDAL WAS DEPRESSED. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT RESTARTED THE VEHICLE AND WAS ABLE TO DRIVE HOME. THE FAILURE DID NOT OCCUR WHILE THE VEHICLE WAS IDLING. THE VEHICLE WAS TAKEN TO GALPIN HONDA…
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER WHEN THE BRAKE PEDAL WAS DEPRESSED. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT RESTARTED THE VEHICLE AND WAS ABLE TO DRIVE HOME. THE FAILURE DID NOT OCCUR WHILE THE VEHICLE WAS IDLING. THE VEHICLE WAS TAKEN TO GALPIN HONDA (11151 LAUREL CANYON BLVD, SAN FERNANDO, CA 91340) TO BE DIAGNOSED, BUT NO FAILURE WAS FOUND. THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED A CASE NUMBER. THE MANUFACTURER ADVISED THE CONTACT TO WORK WITH THE DEALER. THE FAILURE MILEAGE WAS 27,817.
NHTSA ODI #11219314
42,000 miles · Jun 6, 2019
Engine
AUTO IDLE STOP DOESN'T RESTART. IT STALLS OFTEN DEPENDING ON THE LENGTH OF THE IDLE. IT HAS BEEN SLOWING PROGRESSING TO UNRELIABLE. IT STOPS ENTIRELY, OFTEN IN TRAFFIC AND THEN YOU HAVE TO PUT CAR IN PARK, RESTART ENGINE AND THEN PUT IN DRIVE AND GO AGAIN. BY THIS TIME TRAFFIC IS ALREADY MOVING AROUND YOU. VERY DANGEROUS AN…
Read full complaint
AUTO IDLE STOP DOESN'T RESTART. IT STALLS OFTEN DEPENDING ON THE LENGTH OF THE IDLE. IT HAS BEEN SLOWING PROGRESSING TO UNRELIABLE. IT STOPS ENTIRELY, OFTEN IN TRAFFIC AND THEN YOU HAVE TO PUT CAR IN PARK, RESTART ENGINE AND THEN PUT IN DRIVE AND GO AGAIN. BY THIS TIME TRAFFIC IS ALREADY MOVING AROUND YOU. VERY DANGEROUS AND SCARY ON FREEWAY AND AT INTERSECTIONS. HAD THE BATTERY CHECKED AT AUTO STORE, TAKE IN FOR REGULAR MAINTENANCE - IT TESTED STRONG BUT NEEDED A "CHARGE" SHOULD BE RECHARGING WHEN RUNNING AND ON FREEWAY.
NHTSA ODI #11218355
83,000 miles · May 28, 2019
EngineStructureInjury
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE DRIVING 70 MPH, THE VEHICLE LUNGED FORWARD AND THE CONTACT SMELLED FUMES. ALSO, THE VEHICLE STALLED WHILE DRIVING VARIOUS SPEEDS. THE CONTACT PULLED OVER AND IT TOOK NUMEROUS ATTEMPTS TO RESTART THE VEHICLE. WHILE DRIVING VARIOUS SPEEDS, A PIECE OF THE FENDER ON THE FRONT DRIVER AN…
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE DRIVING 70 MPH, THE VEHICLE LUNGED FORWARD AND THE CONTACT SMELLED FUMES. ALSO, THE VEHICLE STALLED WHILE DRIVING VARIOUS SPEEDS. THE CONTACT PULLED OVER AND IT TOOK NUMEROUS ATTEMPTS TO RESTART THE VEHICLE. WHILE DRIVING VARIOUS SPEEDS, A PIECE OF THE FENDER ON THE FRONT DRIVER AND PASSENGER SIDES FRACTURED AND STRUCK A PERSON IN THE HEAD. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS DIAGNOSED AND REPAIRED BY MULTIPLE UNKNOWN DEALERS AND INDEPENDENT MECHANICS AND THE CATALYTIC CONVERTER WAS REPLACED FOUR TIMES AND TWO INJECTORS WERE INSTALLED; HOWEVER, THE FAILURES CONTINUED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 83,000. THE VIN WAS INVALID.
NHTSA ODI #11210322
120 miles · May 24, 2019
Engine
THE ENGINE FULLY STOPPED WHILE DRIVING ON THE HWY WHILE DRIVING ALMOS GOT REAR ENDED. I WAS MOVING TAPPED THE BREAK AND THE ENGINE STOPPED ( LIKE IN IDLE) I QUICKLY PUSHED ON THE GAS AND AFTER SECONDS OF NO RESPONSE IT CAME BACK. ON 9/2/2018 THIS HAPPENED WHEN I WAS GOING TJRU PAYING TOLL I TOUCHED THE BREAK TRYING TO SLOW DOW…
Read full complaint
THE ENGINE FULLY STOPPED WHILE DRIVING ON THE HWY WHILE DRIVING ALMOS GOT REAR ENDED. I WAS MOVING TAPPED THE BREAK AND THE ENGINE STOPPED ( LIKE IN IDLE) I QUICKLY PUSHED ON THE GAS AND AFTER SECONDS OF NO RESPONSE IT CAME BACK. ON 9/2/2018 THIS HAPPENED WHEN I WAS GOING TJRU PAYING TOLL I TOUCHED THE BREAK TRYING TO SLOW DOWN IT COMPLETLY DIED, TRIED TO PUSH GAS NO RESPONSE DIED AND WENT IN N. HAD TO TURN IT ON AMD DRIVE AGAIN. AT THAT TIME WENT TO DEALER AMD THEY DID NOT SEE AN ISSUE. IT IS HAPPENENING MORE NOW. IT IS FRIGHTENING TO BE UNDER THE MERCEY OF TJE PERAON BEHIND U TO SLOW DOWN IN TIME. THIS IS HORROBLE VERY SCARY AND CAN KILL A FAMILY!
NHTSA ODI #11209757
39,000 miles · May 21, 2019
Electrical SystemEngine
I HAVE A 2016 TOURING PILOT WITH JUST OVER 38,000 MILES. SINCE ABOUT 25,000 MILES I HAVE FELT THAT THERE WAS AN ODD HESITATION WITH THE AUTO-OFF FEATURE THAT I'D NOT NOTICED DURING THE INITIAL PERIOD OF OWNERSHIP. THE ISSUE ESCALATED TO THE POINT WHICH IT WOULD ACTUALLY STALL OUT AT AN INTERSECTION AND THE VEHICLE WOULD NOT TUR…
Read full complaint
I HAVE A 2016 TOURING PILOT WITH JUST OVER 38,000 MILES. SINCE ABOUT 25,000 MILES I HAVE FELT THAT THERE WAS AN ODD HESITATION WITH THE AUTO-OFF FEATURE THAT I'D NOT NOTICED DURING THE INITIAL PERIOD OF OWNERSHIP. THE ISSUE ESCALATED TO THE POINT WHICH IT WOULD ACTUALLY STALL OUT AT AN INTERSECTION AND THE VEHICLE WOULD NOT TURN BACK ON FOR A FEW MINUTES. THE DEALERSHIP REPLACED THE BATTERY AND SAID THAT THEY COULD SEE THE ERROR AND THAT THERE WAS AN ISSUE CAUSED BY THE BATTERY. A FEW MONTHS LATER THE ISSUE STARTED TO HAPPEN AGAIN AND STALLED FOR MY WIFE AGAIN WITH OUR KIDS IN THE CAR AT A BUSY INTERSECTION. THE CAR WENT BACK INTO THE DEALERSHIP AND THEY HAVE NOW HAD IT FOR CLOSE TO 6 WEEKS WITH LITTLE TO NO UPDATE AS TO WHAT IS GOING ON. THIS IS A HORRIBLY UNSAFE ISSUE AND I KNOW FOR A FACT THAT MANY PEOPLE ARE HAVING THE SAME ISSUE AS REFERENCED IN THIS BLOG: HTTPS://WWW.PILOTEERS.ORG/FORUMS/114-2016-THIRD-GENERATION-PILOT/157005-ELITE-SHUTS-OFF-STOP-LIGHT-5.HTML THE FACT THAT HONDA CAN NOT COME UP WITH A FIX FOR THE ISSUE IS A VERY SCARY THOUGHT. WE AS CONSUMERS NEED SOMEONE TO HELP HOLD HONDA ACCOUNTABLE TO PROVIDE A SAFE DRIVING EXPERIENCE FOR OUR FAMILIES.
NHTSA ODI #11208938
5,000 miles · Apr 29, 2019
Electrical SystemEnginePower Train
WE HAVE HAD MULTIPLE, ONGOING PROBLEMS WITH OUR 2016 HONDA PILOT ELITE SINCE EARLY ON IN OUR OWNERSHIP. WHEN I TRY TO GO AFTER COMING TO A STOP, THE CAR TRIES TO STALL AND HAS STALLED SEVERAL TIMES IN THE MIDDLE OF THE ROAD. WHEN IT STALLS, IT HAS SWITCHED ITSELF TO NEUTRAL AND FOR SEVERAL MINUTES, IT WILL NOT LET ME DO ANYTHING…
Read full complaint
WE HAVE HAD MULTIPLE, ONGOING PROBLEMS WITH OUR 2016 HONDA PILOT ELITE SINCE EARLY ON IN OUR OWNERSHIP. WHEN I TRY TO GO AFTER COMING TO A STOP, THE CAR TRIES TO STALL AND HAS STALLED SEVERAL TIMES IN THE MIDDLE OF THE ROAD. WHEN IT STALLS, IT HAS SWITCHED ITSELF TO NEUTRAL AND FOR SEVERAL MINUTES, IT WILL NOT LET ME DO ANYTHING TO TRY TO GET THE CAR GOING AGAIN SUCH AS CHANGE GEARS, START THE CAR, ETC. AS I TRY TO GET IT GOING, IT WILL TELL ME THAT I NEED TO START THE ENGINE TO CHANGE THE GEAR BACK TO DRIVE BUT WILL NOT DO ANYTHING WHEN I PRESS THE START BUTTON. FURTHER, THERE ARE SEVERAL ISSUES WITH THE INFOTAINMENT SYSTEM: THE BACK UP CAMERA GOES BLACK, THE ENTIRE SYSTEM REBOOTS WHILE DRIVING, THE AUDIO SCREEN FREEZES AND AUDIO CEASES WHILE DRIVING, THE ENTIRE SCREEN GOES BLACK EXCEPT THE TIME LINE ON TOP WHILE DRIVING, AND THE NAVIGATION SCREEN BLACKS OUT WHILE DRIVING. DESPITE PROVIDING VIDEO AND PHOTOGRAPHIC EVIDENCE OF THE ISSUES, HONDA KEPT SAYING THEY COULDN'T REPLICATE IT AND THUS COULDN'T TEST IT, BUT WHEN I WAS ABLE TO BRING IT TO THEM WITH THE SCREEN FROZEN, THEY SAID THERE WERE NO TESTS THEY COULD RUN. THEY FINALLY TRIED REPLACING THE INFOTAINMENT SYSTEM, BUT THE ISSUES RETURNED. THESE ISSUES ARE ON TOP OF THE FACT THAT THEY REPLACED THE DVD PLAYER BECAUSE IT WAS LOOPING. WE FEEL WE HAVE RECEIVED A LEMON AND THAT THESE ISSUES CAUSE A HAZARD DURING WHAT SHOULD BE NORMAL OPERATION OF OUR VEHICLE.
NHTSA ODI #11204402
Mileage unknown · Apr 24, 2019
Electrical SystemEngineUnknown Or Other
WHEN TRYING TO START VEHICLE YOU RECEIVE 'KEYLESS START SYSTEM PROBLEM'. TAKEN TO THE DEALER TWICE AND NOT ABLE TO DIAGNOSE THE ISSUE. VEHICLE HAS 49000 MILES TODAY AND HAVE HAD THIS INTERMITTENT ISSUE SINCE 42000 MILES. FOB BATTERIES HAVE BOTH BEEN REPLACED AND SUPPOSEDLY REPROGRAMMED. STILL UNABLE TO RESOLVE. LET ME KNOW IF A…
Read full complaint
WHEN TRYING TO START VEHICLE YOU RECEIVE 'KEYLESS START SYSTEM PROBLEM'. TAKEN TO THE DEALER TWICE AND NOT ABLE TO DIAGNOSE THE ISSUE. VEHICLE HAS 49000 MILES TODAY AND HAVE HAD THIS INTERMITTENT ISSUE SINCE 42000 MILES. FOB BATTERIES HAVE BOTH BEEN REPLACED AND SUPPOSEDLY REPROGRAMMED. STILL UNABLE TO RESOLVE. LET ME KNOW IF AND HOW YOU WERE ABLE TO RESOLVE THE ISSUE.
NHTSA ODI #11203510
29,000 miles · Apr 3, 2019
Electrical SystemEngine
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE OPERATING THE VEHICLE AND WHILE AT A STOP LIGHT, THE AUTO IDLE STOP FEATURE ACTIVATED NORMALLY, BUT THE VEHICLE WOULD NOT IMMEDIATELY RESTART WHEN THE DRIVER RELEASED THE BRAKE PEDAL AND DEPRESSED THE ACCELERATOR PEDAL. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. DURING THE FAILURE, …
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE OPERATING THE VEHICLE AND WHILE AT A STOP LIGHT, THE AUTO IDLE STOP FEATURE ACTIVATED NORMALLY, BUT THE VEHICLE WOULD NOT IMMEDIATELY RESTART WHEN THE DRIVER RELEASED THE BRAKE PEDAL AND DEPRESSED THE ACCELERATOR PEDAL. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. DURING THE FAILURE, SEVERAL INSTRUCTIONAL PROMPTS APPEARED, EXPLAINING HOW TO RESTART THE VEHICLE. ON ONE OCCASION, THE VEHICLE COULD NOT BE RESTARTED AND WAS TOWED TO STERLING MCCALL HONDA (22575 HWY 59 NORTH, KINGWOOD, TX 77339). WHILE AT THE DEALER, THE VEHICLE OPERATED NORMALLY AND THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000.
NHTSA ODI #11193598
Mileage unknown · Mar 26, 2019
EngineFuel/propulsion SystemUnknown Or Other
THERE IS A GASOLINE SMELL INSIDE THE CAR AND OUTSIDE I DONT SEE ANY LEAKING BUT THE SMELL IS MAKING ME WORRY
NHTSA ODI #11191739
48,000 miles · Mar 26, 2019
Electrical SystemEngineSeats
MY VEHICLE HAS MULTIPLE SYSTEM ERROR MESSAGES THAT HAVE COME ON AND OFF WHEN TURNING ON THE CAR AND SOME HAVE BECAME MUCH MORE FREQUENT AND REMAIN ON WHILE DRIVING. 1. KEYLESS STARTING SYSTEM ERROR- HAPPENS FREQUENTLY WHEN VEHICLE IS TURNED ON AND REMAINS ON WHILE DRIVING. 2. ANTILOCK BRAKE SYSTEM ERROR- WHEN VEHICLE IS P…
Read full complaint
MY VEHICLE HAS MULTIPLE SYSTEM ERROR MESSAGES THAT HAVE COME ON AND OFF WHEN TURNING ON THE CAR AND SOME HAVE BECAME MUCH MORE FREQUENT AND REMAIN ON WHILE DRIVING. 1. KEYLESS STARTING SYSTEM ERROR- HAPPENS FREQUENTLY WHEN VEHICLE IS TURNED ON AND REMAINS ON WHILE DRIVING. 2. ANTILOCK BRAKE SYSTEM ERROR- WHEN VEHICLE IS POWERED ON AND REMAINS ON FOR ABOUT 20 MINS AFTER DRIVING VEHICLE AND RETURNS WHEN CAR IS POWERED ON. 3. CHARGING SYSTEM ERROR- WAS COMING ON OCCASIONALLY AND AS OF TODAY HAS CAME ON EVERY TIME THE VEHICLE IS POWERED ON AND REMAINS ON WHILE DRIVING. 4. BRAKE SYSTEM PROBLEM- OCCASIONALLY COMES ON WHEN CAR IS POWERED ON AND COMES OFF AFTER DRIVING VEHICLE. ALSO, THE MOST RECENT ISSUES I'VE HAD WAS THE DRIVER SEAT DOES NOT WARM UP WHEN SEAT WARMER IS TURNED ON AND WHILE DRIVING THE VEHICLE AT APPROXIMATELY 30MPH VEHICLE BEGINS TO JERK AS IF IT IS STRUGGLING TO DRIVE. THESE PROBLEMS HAVE BECOME MUCH MORE FREQUENT AND HAVE BECOME A SAFETY CONCERN FOR ME AND MY CHILDREN.
NHTSA ODI #11191666
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration