NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
767 reportsClear category filter37,000 miles · Sep 16, 2019
Electrical SystemEngine
OUR HONDA PILOT SHUTS DOWN WHILE BEING OPERATED, TYPICALLY WHILE ATTEMPTING TO RESUME DRIVING AFTER HAVING BEEN STOPPED AT INTERSECTIONS, MAKING TURNS, RED LIGHTS, ETC. ALL ELECTRICAL COMPONENTS BECOME UNRESPONSIVE, INCLUDING STARTER, SHIFT CONTROLLER, HAZARD LIGHTS, ETC. TYPICALLY TAKES TO 5 MINUTES TO RESTART, LEAVING US STRAN…
Read full complaint
OUR HONDA PILOT SHUTS DOWN WHILE BEING OPERATED, TYPICALLY WHILE ATTEMPTING TO RESUME DRIVING AFTER HAVING BEEN STOPPED AT INTERSECTIONS, MAKING TURNS, RED LIGHTS, ETC. ALL ELECTRICAL COMPONENTS BECOME UNRESPONSIVE, INCLUDING STARTER, SHIFT CONTROLLER, HAZARD LIGHTS, ETC. TYPICALLY TAKES TO 5 MINUTES TO RESTART, LEAVING US STRANDED IN TRAFFIC; AN INCREDIBLY DANGEROUS SITUATION. THIS HAS OCCURRED (5 TIMES SO FAR) WITH THE "AUTO ENGINE IDLE STOP" ENGAGED AND IS SUSPECT. 1ST ATTEMPT BY DEALER TO DIAGNOSE & REPAIR INVOLVED REPLACING THE BATTERY DESPITE TESTING "GOOD". SHUTDOWNS CONTINUED; THE LAST OCCURRED IN A 5-LANE HIGHWAY WITH MY WIFE AND 3-YEAR OLD CHILD ON BOARD. 2ND ATTEMPT TO DIAGNOSE & REPAIR, TOOK 4 WEEKS AND A SUGGESTED REPAIR OF REPLACING THE BATTERY (PREVIOUS BATTERY LESS THAN A YEAR OLD) AND A NEW STARTER @ $1,600; EVEN THOUGH THE TECHNICIAN STATED BOTH WERE "GOOD". CONVERSATIONS WITH THE DEALERSHIP/TECHNICIANS ACKNOWLEDGE THE SUSPECTED PROBLEM ELECTRICAL/COMPUTER BASED BUT THE ON-BOARD COMPUTER DOES NOT RECORD THESE EVENTS. THE DEALERSHIP/TECHNICIANS STATE THEY REPORTED AND RESEARCHED THIS ISSUE VIA THEIR IN-HOUSE TECH SITE BUT WE WERE TOLD THIS ISSUE IS UNKNOWN AND ISOLATED TO OUR CAR. OUR SOLUTION BEING A MUTUALLY ACKNOWLEDGE, UNNECESSARY REPAIR. I DEBATED THEIR $1,600 "SOLUTION" AND QUESTIONED WARRANTY COVERAGE AND WAS INFORMED IF NOT DONE, WOULD BE RECORDED AS "CUSTOMER REFUSES REPAIR". WHEN I ASKED IF THE $1,600 WOULD BE REFUNDED WHEN THE ISSUE RESUMED (SINCE WELL AGREED THE SUGGESTED REPAIR WAS NOT THE SOLUTION), I WAS INFORMED "NO". WE HAVE NOT DONE THE REPAIR. A SIMPLE INTERNET SEARCH SHOWS THIS IS NOT AN ISOLATED PROBLEM AS WE WERE TOLD AND IS EVEN RECORDED HERE ON THE NHTSA WEBSITE NUMEROUS TIMES, VERBATIM TO OUR EXPERIENCE.
NHTSA ODI #11255719
37,500 miles · Aug 29, 2019
Electrical SystemEngine
WHEN DRIVING IN ECO MODE THE CAR SHUTS PARTIALLY DOWN AT RED LIGHTS AND OTHER STOPS AS IS EXPECTED, BUT LIGHTS, RADIO, AC., ETC STILL FUNCTION. EVERY 5 OR 6TH TIME MY CAR NOW SHUTS OFF COMPLETELY AND REQUIRES ME TO RESTART IT.
NHTSA ODI #11252277
38,000 miles · Aug 29, 2019
Electrical SystemEngine
CAR TURNS OFF COMPLETELY WHILE DRIVING, DOES NOT RESPOND TO ATTEMPTS TO RESTART RIGHT AWAY
NHTSA ODI #11252274
30,000 miles · Aug 19, 2019
Electrical SystemEngine
THE HONDA PILOT HAS A FEATURE CALLED AUTO ENGINE IDLE STOP. TO MEET EMISSION STANDARDS, THIS FEATURE PUTS THE ENGINE INTO A STOP/OFF MODE WHEN YOU BRAKE FOR MORE THAN 3 SECONDS. HOWEVER, THIS FEATURE SOMETIMES CAUSES THE CAR BATTERY TO FAIL AND THE CAR TO STALL. THIS COULD HAPPEN WHEN STOPPED AT A TRAFFIC LIGHT OR ON A HIGHWA…
Read full complaint
THE HONDA PILOT HAS A FEATURE CALLED AUTO ENGINE IDLE STOP. TO MEET EMISSION STANDARDS, THIS FEATURE PUTS THE ENGINE INTO A STOP/OFF MODE WHEN YOU BRAKE FOR MORE THAN 3 SECONDS. HOWEVER, THIS FEATURE SOMETIMES CAUSES THE CAR BATTERY TO FAIL AND THE CAR TO STALL. THIS COULD HAPPEN WHEN STOPPED AT A TRAFFIC LIGHT OR ON A HIGHWAY STOPPED IN TRAFFIC. IF THE BATTERY HASN'T HAD ENOUGH TIME TO RECHARGE, THE CAR MIGHT STALL AND NEED TO BE COMPLETELY SHUTDOWN, WAIT A WHILE AND MAYBE WILL RESTART. WE BOUGHT OUR CAR IN LATE 2015. THE ISSUE PRESENTED ITSELF BY 2016/2017, MOSTLY AS BRIEF BLIPS AND THE CAR WOULD RESTART. IN SUMMER 2018, AFTER REPEATED VISITS TO HONDA AND NUMEROUS TIMES OF THE CAR COMPLETELY STALLING AT TRAFFIC LIGHTS, WE CHOSE TO REPLACE THE BATTERY. OUR HONDA SERVICE CENTERS KEPT TELLING US THAT THE BATTERY TESTS SHOWED IT WAS FINE AND THAT THE FEATURE ISN'T SUPPOSE TO ENGAGE IF THE BATTERY DOESN'T HAVE "ENOUGH JUICE" TO RESTART. BUT CLEARLY, THAT DOESN'T WORK, BECAUSE MY CAR WOULD INDEED COMPLETELY STALL AND NEED TO TRY TO RESTART. I ONCE HAD TO WAIT FIVE MINUTES STUCK AT A LIGHT IN THE MIDDLE OF A 3 LANE ROAD, AND MY CAR FINALLY RESTARTED. BUT ONCE WE PAID TO REPLACE THE BATTERY (THAT SUPPOSEDLY WAS FINE), THE CAR DIDN'T BLIP OR STALL. BUT ONE YEAR LATER, IT STARTED HAPPENING AGAIN. SOMETIMES THE CAR WILL JUST BLIP, WHERE ALL THE LIGHTS, RADIO AND AIR CONDITIONING WILL BRIEFLY CUT OUT AND THEN COME BACK ON AS THE FEATURE RE-ENGAGES THE ENGINE. BUT SOMETIMES, IT JUST WON'T RESTART. THERE IS A BUTTON YOU CAN HIT TO DISABLE THE AUTO ENGINE IDLE STOP FEATURE. BUT YOU MUST REMEMBER TO HIT EVERY TIME YOU START THE CAR. IF YOU FORGET, ALL IT TAKES IS STOPPING AT ONE TRAFFIC LIGHT AND THE CAR COULD STALL. THERE ARE NUMEROUS ONLINE REPORTS OF SIMILAR ISSUES WITH THIS FEATURE.
NHTSA ODI #11245132
50,000 miles · Aug 15, 2019
EngineFuel/propulsion System
SEEING AN ISSUE WITH FUEL INJECTORS ASSOCIATED WITH THIS AND I THINK THERE SHOULD BE A RECALL ISSUED FOR IT.
NHTSA ODI #11244104
37,541 miles · Aug 13, 2019
Electrical SystemEngine
WHEN ENGINE AUTO IDLE IS ENGAGED, INSTEAD OF RE-ENGAGING WHEN FOOT REMOVED FROM BRAKE, THE CAR STALLS IN ONE OF THREE WAYS. GRADE 1, THE FAN AND RADIO SHUT OFF BUT THE ENGINE ENGAGES ONCE GAS IS APPLIED. GRADE 2, THE FAN, RADIO AND ENGINE SHUT OFF BUT RESTART ONCE GAS IS APPLIED. VARIOUS WARNING LIGHTS THEN APPEAR ON THE DASH.…
Read full complaint
WHEN ENGINE AUTO IDLE IS ENGAGED, INSTEAD OF RE-ENGAGING WHEN FOOT REMOVED FROM BRAKE, THE CAR STALLS IN ONE OF THREE WAYS. GRADE 1, THE FAN AND RADIO SHUT OFF BUT THE ENGINE ENGAGES ONCE GAS IS APPLIED. GRADE 2, THE FAN, RADIO AND ENGINE SHUT OFF BUT RESTART ONCE GAS IS APPLIED. VARIOUS WARNING LIGHTS THEN APPEAR ON THE DASH. GRADE 3, EVERYTHING SHUTS OFF AND THE CAR WILL NOT RESTART UNTIL YOU SHIFT INTO PARK AND PRESS THE START BUTTON SEVERAL TIMES. THIS IS VERY DANGEROUS AS IT HAPPENS AT INTERSECTIONS WHEN CARS EXPECT YOU TO BE MOVING AND YOU'RE STALLED OUT. I HAVE VIDEO OF THESE INCIDENTS AND HAVE PROVIDED THEM TO THE HONDA DEALER.
NHTSA ODI #11243724
36,000 miles · Aug 9, 2019
Electrical SystemEngine
VEHICLE RANDOMLY DOES NOT AUTOMATICALLY RESTART AFTER AUTO IDLE STOP ENGAGES WHEN IN STOP-GO TRAFFIC ON FREEWAY OR WHEN STOPPED AT INTERSECTION, RESULTING IN A STALLED VEHICLE IN THE MIDDLE OF FREEWAY OR INTERSECTION. ATTEMPTS TO MANUALLY RESTART THE VEHICLE GENERALLY SUCCESSFUL AFTER FRANTICALLY (OR SLOWLY!) PUSHING THE START-…
Read full complaint
VEHICLE RANDOMLY DOES NOT AUTOMATICALLY RESTART AFTER AUTO IDLE STOP ENGAGES WHEN IN STOP-GO TRAFFIC ON FREEWAY OR WHEN STOPPED AT INTERSECTION, RESULTING IN A STALLED VEHICLE IN THE MIDDLE OF FREEWAY OR INTERSECTION. ATTEMPTS TO MANUALLY RESTART THE VEHICLE GENERALLY SUCCESSFUL AFTER FRANTICALLY (OR SLOWLY!) PUSHING THE START-STOP BUTTON SEVERAL TIMES. VIDEO DOCUMENTING ISSUE AVAILABLE AT HTTPS://1DRV.MS/V/S!AQY6PDPSAKNNNN5FXRZ2NGSTMND0CG (ADDITIONAL VIDEOS AVAILABLE). ISSUE ONGOING SINCE ~ OCTOBER 2018. DEALER HAS REPLACED BATTERY & ENGINE START-STOP BUTTON TO NO AVAIL.
NHTSA ODI #11242912
36,500 miles · Jul 30, 2019
EngineStructureUnknown Or OtherCrash
I BOUGHT THIS VEHICLE AS A "CERTIFIED PRE OWNED BY HONDA" AND FOUR DAYS AFTER THE PURCHASE THE CAR WAS PARKED IN MY DRIVEWAY, IN "PARK" WHEN I HIT THE START/STOP ENGINE BUTTON AND THE VEHICLE DIDN'T START. ALARMS STARTED TO GO OFF SO I ASSUMED IT WAS THE KEY WAS STILL INSIDE THE HOUSE. AS I WENT INSIDE TO CHECK, MAYBE A FEW SECO…
Read full complaint
I BOUGHT THIS VEHICLE AS A "CERTIFIED PRE OWNED BY HONDA" AND FOUR DAYS AFTER THE PURCHASE THE CAR WAS PARKED IN MY DRIVEWAY, IN "PARK" WHEN I HIT THE START/STOP ENGINE BUTTON AND THE VEHICLE DIDN'T START. ALARMS STARTED TO GO OFF SO I ASSUMED IT WAS THE KEY WAS STILL INSIDE THE HOUSE. AS I WENT INSIDE TO CHECK, MAYBE A FEW SECONDS, WHEN I WENT BACK OUTSIDE THE VEHICLE WAS GONE. I FOUND IT IN MY FRONT YARD. IT HAD ROLLED OFF WHILE IN PARK WITHOUT ENGINE ON. AFTER GETTING IT TOWED TO HONDA, DAYS LATER I WAS INFORMED THAT THERE WAS A PROBLEM WITH THE START/STOP ENGINE SYSTEM AND THAT IT ALSO NEEDED THE ENTIRE A/C SYSTEM REPLACED. ATTACHED YOU WILL FIND THE PHOTO I TOOK OF THE VEHICLE STILL IN PARK WHEN I FOUND IT IN MY FRONT YARD.
NHTSA ODI #11240689
67,851 miles · Jul 19, 2019
EngineExterior LightingService Brakes
IT ENGINE IS IDLE ALL THE TIME WHEN THE AC IS ON
NHTSA ODI #11233411
63,000 miles · Jul 12, 2019
Electrical SystemEnginePower Train
WHILE STOPPED AT A TRAFFIC LIGHT THE CAR PUT ITSELF INTO PARK WITHOUT MY (THE DRIVER) KNOWLEDGE. WHEN THE LIGHT TURNED GREEN I ATTEMPTED TO ACCELERATE HOWEVER THE CAR WAS IN PARK. I ATTEMPTED TO SHIFT THE CAR INTO DRIVE AND IT WOULD NOT DO SO. I HAD TO TURN THE CAR OFF AND THEN BACK ON IN ORDER TO PLACE THE CAR INTO DRIVE AN…
Read full complaint
WHILE STOPPED AT A TRAFFIC LIGHT THE CAR PUT ITSELF INTO PARK WITHOUT MY (THE DRIVER) KNOWLEDGE. WHEN THE LIGHT TURNED GREEN I ATTEMPTED TO ACCELERATE HOWEVER THE CAR WAS IN PARK. I ATTEMPTED TO SHIFT THE CAR INTO DRIVE AND IT WOULD NOT DO SO. I HAD TO TURN THE CAR OFF AND THEN BACK ON IN ORDER TO PLACE THE CAR INTO DRIVE AND PROCEED THROUGH THE INTERSECTION.
NHTSA ODI #11231392
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration