NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
767 reportsClear category filter60,000 miles · Jan 21, 2020
Engine
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE RPM INCREASED TO HIGH AND VEHICLE ACCELERATED SPONTANEOUSLY. THE VEHICLE WENT INTO LIMP MODE. ADDITIONALLY, THE VEHICLE SHIFTED ROUGHLY FROM FIRST TO SECOND AND THIRD TO FOURTH GEARS. THE EMISSION, TRANSMISSION, LANE ASSIST, TOWING AND POWER S…
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE RPM INCREASED TO HIGH AND VEHICLE ACCELERATED SPONTANEOUSLY. THE VEHICLE WENT INTO LIMP MODE. ADDITIONALLY, THE VEHICLE SHIFTED ROUGHLY FROM FIRST TO SECOND AND THIRD TO FOURTH GEARS. THE EMISSION, TRANSMISSION, LANE ASSIST, TOWING AND POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO HOLM AUTOMOTIVE CENTER (2005 N BUCKEYE AVE, ABILENE, KS 67410 (785) 263-4000) WHERE THE CODES WERE RESET BUT NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TAKEN TO LITTLE APPLE TOYOTA (3002, 2828 AMHERST AVE A, MANHATTAN, KS 66502(785) 539-7441) WHERE IT WAS INFORMED THAT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED THE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #11300755
30,000 miles · Jan 15, 2020
Electrical SystemEngineExterior LightingFire
ON JANUARY 13TH, I LEFT MY HOME TO PICK UP MY SON, JULIAN, 3 YEARS OLD, AT PRESCHOOL. HIS PRESCHOOL IS APPROXIMATELY 3 MILES FROM OUR HOME. I PICKED HIM UP, AND DROVE THE SAME DISTANCE BACK TO OUR HOUSE, ARRIVING HOME AROUND 4:45PM. I HAD NO UNUSUAL WARNING NOTIFICATIONS OR ANY UNUSUAL EXPERIENCE DRIVING TO AND FROM THE PRESCHOO…
Read full complaint
ON JANUARY 13TH, I LEFT MY HOME TO PICK UP MY SON, JULIAN, 3 YEARS OLD, AT PRESCHOOL. HIS PRESCHOOL IS APPROXIMATELY 3 MILES FROM OUR HOME. I PICKED HIM UP, AND DROVE THE SAME DISTANCE BACK TO OUR HOUSE, ARRIVING HOME AROUND 4:45PM. I HAD NO UNUSUAL WARNING NOTIFICATIONS OR ANY UNUSUAL EXPERIENCE DRIVING TO AND FROM THE PRESCHOOL. I PARKED THE CAR IN OUR DRIVEWAY. JULIAN AND I EXITED THE VEHICLE, AND WALKED TO OUR FRONT DOOR. AS WE APPROACHED THE FRONT DOOR I SMELLED SMOKE, AND LOOKED BACK AT THE CAR. I NOTICED A SMALL FLICKER IN THE PASSENGER SIDE LOWER HEADLIGHT. UPON CLOSER LOOK, I REALIZED THIS WAS IN FACT A FLAME. JULIAN AND I LEFT OUR BAGS ON THE PORCH, STEPPED OFF OF OUR FRONT PORCH, AND MOVED AWAY FROM THE HOUSE AND CAR, AND CALLED 911. AS WE WAITED FOR THE FIRE DEPARTMENT, WE WATCHED THIS SMALL FLAME GROW TO FULL FLAMES, ENGULFING THE ENGINE, FRONT HOOD, AND FRONT OF THE CAR. THE POLICE AND FIRE DEPARTMENT ARRIVED, AND PUT OUT THE FIRE. THE CAR WAS TOWED OUT OF OUR DRIVEWAY. A POLICE REPORT WAS FILED WITH THE MONTCLAIR POLICE DEPT. OFFICER ANTHONY SWAN #232 PATROL DIVISION MONTCLAIR POLICE HEADQUARTERS, 647 BLOOMFIELD AVE., MONTCLAIR NJ 07042 ASWAN@MONTCLAIRNJUSA.ORG REPORT # 20-005325 I THEN CALLED OUR INSURANCE PROVIDER, USAA, FOLLOWING THE INCIDENT. THEY HAVE TAKEN THE CAR INTO THEIR POSSESSION AND INITIATED AN ORIGIN & CAUSE INVESTIGATION. WE PURCHASED THE CAR NEW. WE HAVE NOT BEEN IN A COLLISION. THE CAR HAS BEEN SERVICED TWICE ANNUALLY. IT WAS SERVICED LAST WEEK. IT HAS ~30,000 MILES ON IT. THE DEALER THAT SOLD US THE CAR, PAUL MILLER HONDA, IN NJ, HAS BEEN UNRESPONSIVE, TELLING US TO REACH OUT THE THE NATIONAL HONDA OFFICE. I HAVE FILED A CASE WITH HONDA, AND HAVE BEEN TOLD SOMEONE WILL REACH OUT TO ME. THAT HAS NOT HAPPENED.
NHTSA ODI #11299501
12,000 miles · Jan 15, 2020
Electrical SystemEngineUnknown Or Other
WE HAVE HAD SEVERAL ISSUES BUT THE MOST PRESSING IS THAT THE CAR WILL SUDDENLY STOP RESPONDING UNDER ACCELERATION. THIS HAS HAPPENED 3 TIMES ONCE VERY NEARLY CAUSED A VERY BAD ACCIDENT WITH A BIG RIG WHILST WE WERE ENTERING A FREEWAY. THE CAR WILL SUDDENLY NOT RESPOND TO THROTTLE THE GAUGES SEEM TO RESET AND THEN THE CAR WILL GO…
Read full complaint
WE HAVE HAD SEVERAL ISSUES BUT THE MOST PRESSING IS THAT THE CAR WILL SUDDENLY STOP RESPONDING UNDER ACCELERATION. THIS HAS HAPPENED 3 TIMES ONCE VERY NEARLY CAUSED A VERY BAD ACCIDENT WITH A BIG RIG WHILST WE WERE ENTERING A FREEWAY. THE CAR WILL SUDDENLY NOT RESPOND TO THROTTLE THE GAUGES SEEM TO RESET AND THEN THE CAR WILL GO. SIMILAR TO HOW THE AUTO STOP IDLE FUNCTION WORKS EXCEPT WE WERE NOT STOPPED WE WERE UNDER ACCELERATION. WE HAVE ALSO HAD SEVERAL INSTANCES WHERE THE VEHICLE WILL NOT START AFTER THE IDLE STOP HAS ACTIVATED AT A TRAFFIC LIGHT FORCING US TO TURN OFF THE VEHICLE AND THEN RESTART IT. WE HAVE TAKE THE CAR TO THE DEALER SEVERAL TIMES BUT THEY HAVE BEEN UNABLE TO RECREATE THE ISSUE AND ASSURE US THAT THERE IS NOTHING WRONG WITH THE VEHICLE... BEYOND THE PROBLEMS LISTED ABOVE THE CAR FREQUENTLY HAS ELECTRICAL SAFETY ISSUES WITH THE AUTO BRAKE AND COLLISION DETECTION, I CANT EVEN COUNT THE NUMBER OF TIMES THAT THE CAR HAS SUDDENLY BRAKED OUT OF NO WHERE, NO OBSTACLES OR ANYTHING TO TRIGGER IT, JUST DECIDES WE NEED TO BRAKE. THESE "SAFETY FEATURES" SHOULD REALLY BE REVIEWED AND TESTED BETTER BEFORE BEING PUT INTO A PRODUCTION VEHICLE.
NHTSA ODI #11299470
86,000 miles · Dec 26, 2019
Engine
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO HEATHER CANNON HONDA (3415 N 14TH ST., PONCA CITY, OK) WHERE IT WAS DIAGNOSED THAT AN EMISSIONS SYSTEM UPGRADE WAS NEEDED AND FIVE OF THE SIX FUEL INJECTORS WERE FAULTY AND NEEDED TO BE …
Read full complaint
TL* THE CONTACT OWNS A 2016 HONDA PILOT. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO HEATHER CANNON HONDA (3415 N 14TH ST., PONCA CITY, OK) WHERE IT WAS DIAGNOSED THAT AN EMISSIONS SYSTEM UPGRADE WAS NEEDED AND FIVE OF THE SIX FUEL INJECTORS WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 86,000.
NHTSA ODI #11291269
Mileage unknown · Dec 23, 2019
EngineFuel/propulsion SystemUnknown Or Other
I'VE HAD MULTIPLE ISSUES INCLUDING FAULTY FUEL INJECTORS, FAULTY COLLISION MITIGATION SYSTEM, FAULTY HOMELINK TRANSMITTER, AUDIO BLUETOOTH THAT RESETS ON ITS OWN AND NOW THE LATEST ONE IS A KEYLESS START SYSTEM PROBLEM. IN ADDITION, I CONTINUE TO HAVE THIS ISSUE THAT WHEN I AM DRIVING THE CAR SENSE SOMETHING IN FRONT (WHERE THER…
Read full complaint
I'VE HAD MULTIPLE ISSUES INCLUDING FAULTY FUEL INJECTORS, FAULTY COLLISION MITIGATION SYSTEM, FAULTY HOMELINK TRANSMITTER, AUDIO BLUETOOTH THAT RESETS ON ITS OWN AND NOW THE LATEST ONE IS A KEYLESS START SYSTEM PROBLEM. IN ADDITION, I CONTINUE TO HAVE THIS ISSUE THAT WHEN I AM DRIVING THE CAR SENSE SOMETHING IN FRONT (WHERE THERE IS NOTHING) AND IT BREAKS, ALSO DRIVING IN HIGHWAY OR ABOVE 50 AND TRY TO PRESS BREAKS, THE STEERING WHEEL SHAKES. MY CAR HAS A LITTLE OVER 36K MILES AND ALL THESE THINGS HAVE HAPPENED SINCE 34K MILES.
NHTSA ODI #11290844
50,000 miles · Nov 21, 2019
Electrical SystemElectronic Stability Control (esc)Engine
CAR BRAKES BY ITSELF, SHAKES THE STEERING WHEEL AND SHUTS OFF AND LOSES POWER RANGING IN SPEEDS FROM 20 -60MPH. ON DOUBLE LANE ROADS TO INTERSTATES IN THE RAIN AND SUNNY DRY DAYS.
NHTSA ODI #11281633
45,000 miles · Nov 17, 2019
Electrical SystemEngine
MY HONDA PILOT WILL STALL OUT WHEN COMING OUT OF THE AUTO START/STOP FEATURE AT AN INTERSECTION. THIS PROBLEM STARTED HAPPENING IN JULY 2019 AFTER HAVING THE TRANSMISSION DOUBLE REPLACED. THIS PROBLEM HAS NOW HAPPENED FOUR DIFFERENT TIMES AND EXTREMELY DANGEROUS FOR MY WIFE AND KIDS WHO ARE LEFT STRANDED AT AN INTERSECTION. MY …
Read full complaint
MY HONDA PILOT WILL STALL OUT WHEN COMING OUT OF THE AUTO START/STOP FEATURE AT AN INTERSECTION. THIS PROBLEM STARTED HAPPENING IN JULY 2019 AFTER HAVING THE TRANSMISSION DOUBLE REPLACED. THIS PROBLEM HAS NOW HAPPENED FOUR DIFFERENT TIMES AND EXTREMELY DANGEROUS FOR MY WIFE AND KIDS WHO ARE LEFT STRANDED AT AN INTERSECTION. MY WIFE HAS TO ATTEMPT TO RECYCLE THE POWER TO THE PILOT BY HOLDING DOWN THE POWER BUTTON TO THE PILOT. MY WIFE HAS CAPTURED MULTIPLE VIDEOS OF THE DASH WITH ALL THE ERROR MESSAGES POPPING UP AFTER IT HAS DIED.
NHTSA ODI #11280570
67,000 miles · Nov 7, 2019
Electrical SystemEngineUnknown Or Other
PREVIOUS COMPLAINT NHTSA ID 11111894 SUBMITTED 7/17/18. FOR CAR STALLING AFTER ENTERING INTO AUTO IDLE STOP. REPLACED BATTERY IN AUGUST 2018 AND DIDN'T HAVE ANY PROBLEMS UNTIL NOW. HAS HAPPENED AT LEAST 3 TIMES NOW IN SEPT. AND OCT 2019.. AT FIRST, RADIO OR DVD PLAYER WOULD CUT OUT BUT HAS PROGRESSED TO FULL ON STALLING AFTER…
Read full complaint
PREVIOUS COMPLAINT NHTSA ID 11111894 SUBMITTED 7/17/18. FOR CAR STALLING AFTER ENTERING INTO AUTO IDLE STOP. REPLACED BATTERY IN AUGUST 2018 AND DIDN'T HAVE ANY PROBLEMS UNTIL NOW. HAS HAPPENED AT LEAST 3 TIMES NOW IN SEPT. AND OCT 2019.. AT FIRST, RADIO OR DVD PLAYER WOULD CUT OUT BUT HAS PROGRESSED TO FULL ON STALLING AFTER ENTERING AUTO IDLE STOP. SAME PROBLEM AS BEFORE AND ALL OTHER COMPLAINTS. AFTER CAR GOES INTO IDLE STOP, IT DOES NOT RESTART AFTER TAKE FOOT OFF BRAKE. HAVE TO PUT CAR IN PARK, PRESS BRAKE, AND PUSH START BUTTON TO GET IT TO RESTART. CAN TAKE SEVERAL TRIES AND SEVERAL MINUTES.
NHTSA ODI #11278720
44,000 miles · Oct 28, 2019
EngineUnknown Or OtherVehicle Speed Control
ON OCTOBER 24, 2019 AT APPROXIMATELY 10:00 AM CST. ENGINE COMPLETELY LOST POWER WHILE DRIVING AT APPROXIMATELY 65 MPH ON INTERSTATE I-80. WAS IN THE LEFT LANE PASSING VEHICLE IN RIGHT LANE. ANOTHER VEHICLE WAS AHEAD OF MINE. TAPPED THE BRAKES TO SLOW A BIT AS VEHICLE IN FRONT WAS MERGING RIGHT AFTER PASSING. HIT THE GAS PEDAL AN…
Read full complaint
ON OCTOBER 24, 2019 AT APPROXIMATELY 10:00 AM CST. ENGINE COMPLETELY LOST POWER WHILE DRIVING AT APPROXIMATELY 65 MPH ON INTERSTATE I-80. WAS IN THE LEFT LANE PASSING VEHICLE IN RIGHT LANE. ANOTHER VEHICLE WAS AHEAD OF MINE. TAPPED THE BRAKES TO SLOW A BIT AS VEHICLE IN FRONT WAS MERGING RIGHT AFTER PASSING. HIT THE GAS PEDAL AND ALL POWER TO THE ENGINE WAS LOST FOR ABOUT 1.5 - 2 SECONDS. TACHOMETER DROPPED TO 0. TOOK MY FOOT OFF THE GAS AND THEN RE-ENGAGED. POWER TO ENGINE CAME BACK ON AND WAS ABLE TO RESUME NORMAL VEHICLE OPERATIONS. AUTO ENGINE ON/OFF FEATURE WAS DISABLED. REGULAR CRUISE CONTROL WAS ON, HAD BEEN SET BUT WASN'T CURRENTLY ENGAGED. PARKING SENSORS WERE ON. LANE DEPARTURE WAS OFF. FORWARD COLLISION WARNING ON. NO OTHER ISSUES FOR THE REST OF THE 1300 MILE (ROUND) TRIP. WE HAVE HAD THIS VEHICLE FOR ABOUT 1 YEAR AND THIS IS THE SECOND TIME THIS HAS HAPPENED. FIRST TIME WAS NOT REPORTED OR DOCUMENTED. IF ENGINE/POWER HADN'T BEEN RESTORED, THERE COULD HAVE BEEN A SERIOUS ACCIDENT. THIS CANNOT BE NORMAL VEHICLE OPERATION. PLEASE LOOK INTO THIS HONDA AND NHTSA.
NHTSA ODI #11271594
88,000 miles · Oct 25, 2019
Electrical SystemEngine
TWICE NOW MY 2016 HONDA PILOT ELITE WITH AUTO IDLING STOP FEATURE HAS STALLED AT INTERSECTION LIGHTS. WHILE STOPPED AT THE RED LIGHT THE ENGINE GOES OFF AND NORMALLY WHEN I LIFT MY FOOT OFF THE BRAKE IT RESTARTS AND ACCELERATES WHEN I PUSH THE GAS PEDAL. HOWEVER, IN THESE INSTANCES WHEN I LIFTED MY FOOT OFF THE BRAKE AND WENT …
Read full complaint
TWICE NOW MY 2016 HONDA PILOT ELITE WITH AUTO IDLING STOP FEATURE HAS STALLED AT INTERSECTION LIGHTS. WHILE STOPPED AT THE RED LIGHT THE ENGINE GOES OFF AND NORMALLY WHEN I LIFT MY FOOT OFF THE BRAKE IT RESTARTS AND ACCELERATES WHEN I PUSH THE GAS PEDAL. HOWEVER, IN THESE INSTANCES WHEN I LIFTED MY FOOT OFF THE BRAKE AND WENT TO ACCELERATE, THE ENGINE COMPLETELY STALLED. A COUPLE OF WARNING LIGHTS CAME ON, UNFORTUNATELY I DIDN'T READ WHICH ONES BECAUSE I WAS AT BUSY INTERSECTIONS. THE CAR WOULD NOT START EVEN AFTER PUTTING IT INTO PARK. IT TOOK ABOUT 2 MINUTES BEFORE THE ENGINE WOULD START. OTHER DRIVERS WERE TRYING TO GET AROUND ME, HONKING. THE 2ND TIME, I WAS GOING TO MAKE A LEFT TURN AND JUST HAD TO WAIT UNTIL I COULD START IT, WATCHING IN MY REAR VIEW MIRROR HOPING I WOULDN'T GET REAR-ENDED. I DRIVE 75+ MILES TO WORK ON A VERY BUSY AND SLOW MOVING CALIFORNIA FREEWAY WITH LOTS OF STOP AND GO TRAFFIC. I AM VERY CONCERNED ABOUT OUR SAFETY IF THIS WERE TO HAPPEN ON A BUSY FREEWAY WHERE DRIVERS DON'T REALIZE I AM DEAD IN THE WATER. I CALLED AMERICAN HONDA AND THEY ADVISED ME TO GET IT INTO A DEALER RIGHT AWAY. I GOT AN APPOINTMENT FOR THIS AM AT 0700 BUT AS OF NOW (11:30AM) HAVEN'T HEARD A WORD. THEY ARE CHARGING ME $125 JUST TO RUN DIAGNOSTICS DESPITE THE FACT I HAVE AN EXTENDED WARRANTY. THE SERVICE PERSON HAD A DEFINITE "COULD CARE LESS ATTITUDE". AFTER READING ON THIS WEBSITE AND OTHERS, THIS IS HAPPENING A LOT AND HONDA DOESN'T SEEM TO HAVE AN ANSWER. THIS IS THE 2ND MAJOR ISSUE WITH THIS CAR. THE LAST ISSUE INVOLVED MY CAR BASICALLY SHUTTING DOWN ON THE FREEWAY AT 70MPH, GOING INTO A LOWER GEAR, EVERY POSSIBLE WARNING LIGHT ON THE DASH LIT UP. HAD TO DRIVE ONE MILE ON THE SHOULDER TO GET IT OFF THE FREEWAY. THIS HAPPENED TWICE TO ME AND A "COMPUTER PATCH WAS DONE". IT SEEMS FIXED BUT NOW I AM NOT SURE AT ALL WHAT IS GOING ON WITH THIS CAR.
NHTSA ODI #11271053
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration