NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
767 reportsClear category filter60,000 miles · Nov 2, 2020
Electrical SystemEngine
MY CAR DIED ON ME AT A STOP SIGN WITH THE IDLE START/STOP FEATURE WITH 50K MILES ON IT ON 12/3/2019. (ONE WEEK PRIOR, THE 'EMISSIONS SYSTEM PROBLEM' POPPED UP.) I CAME TO A STOP AT A VERY BUSY INTERSECTION. THE IDLE START/STOP KICKED IN. WHEN I WENT TO TAKE MY FOOT OFF THE BRAKE TO HIT THE GAS, MY PILOT COMPLETELY DIED ON ME. IT…
Read full complaint
MY CAR DIED ON ME AT A STOP SIGN WITH THE IDLE START/STOP FEATURE WITH 50K MILES ON IT ON 12/3/2019. (ONE WEEK PRIOR, THE 'EMISSIONS SYSTEM PROBLEM' POPPED UP.) I CAME TO A STOP AT A VERY BUSY INTERSECTION. THE IDLE START/STOP KICKED IN. WHEN I WENT TO TAKE MY FOOT OFF THE BRAKE TO HIT THE GAS, MY PILOT COMPLETELY DIED ON ME. IT WOULDN'T RESTART. MY DASH LOOKED LIKE A CHRISTMAS TREE WITH ALL THE DIFFERENT LIGHTS/WARNINGS POPPING UP EVERY TIME I WOULD TRY TO START IT. MY FRIEND CAME TO JUMP IT & IT WOULD NOT START. AFTER OVER 2.5 HOURS BLOCKING TRAFFIC & 2 POLICE OFFICERS HAVING TO DIRECT TRAFFIC, WHILE WAITING FOR A TOW TRUCK, I FINALLY GOT MY CAR TO THE DEALERSHIP. FIRST DAY THEY SAID THEY HAD NO CLUE WHAT WAS WRONG WITH IT. 2ND DAY THEY CALLED & SAID THE PROBLEM WAS JUST A SOFTWARE UPDATE FOR THE IDLE START/STOP. THEY SAID IT'S A KNOWN ISSUE & THERE IS NO RECALL & THEY ARE FIXING THEM ONLY AS THE ISSUE PRESENTS ITSELF. FORWARD TO 2/21/2020. 'EMISSIONS SYSTEM PROBLEM' POPS UP AGAIN. I DROP MY PILOT OFF AT THE DEALERSHIP AGAIN ON 2/24/2020. THIS TIME THEY SAY ALL MY FUEL INJECTORS NEED TO BE REPLACED. THE NEXT DAY THEY CALL ME AGAIN TO SAY WHEN THEY GOT IN THERE, MY SEALS WERE BAD & THEY NEEDED TO REPLACE THOSE TOO. AFTER 3 DAYS, I GOT MY PILOT BACK. EVER SINCE I HAVE HAD IT BACK, MY IDLE START/STOP HAS ACTED LIKE IT WASN'T GOING TO COME BACK ON EVERY TIME I DRIVE IT & I TRY TO REMEMBER TO TURN IT OFF WHEN I GET IN MY CAR. I GO FROM THE BRAKE TO THE GAS & IT DINGS & THEN 'COLLISION MITIGATION SYSTEM PROBLEM' POPS UP & THEN GOES AWAY. 10/31/2020 DIED ON ME STOPPED AT A RED LIGHT AGAIN WITH THE IDLE START/STOP FEATURE ON. I HAD TO CALL 911 & HAVE IT TOWED TO THE DEALERSHIP AGAIN.
NHTSA ODI #11372622
60,000 miles · Oct 26, 2020
EngineVehicle Speed Control
HONDA PILOT AWD 2016 HAS RPM VARIATION / HESITATION DURING NORMAL DRIVING FROM REV RANGE 1500 TO 2500RPM. IT IS A CONTINUAL HESITATION OR SPLUTTERING OF REVS. IF ACCELERARTING EXTREMELY HARD IT IS NOT AS EVIDENT BUT IS ALWAYS THERE. APPEARED OUT OF NOWHERE, CAR HAS NO OTHER ISSUES, SERVICED PROFESSIONALLY AS NEEDED/SCHEDULED. HO…
Read full complaint
HONDA PILOT AWD 2016 HAS RPM VARIATION / HESITATION DURING NORMAL DRIVING FROM REV RANGE 1500 TO 2500RPM. IT IS A CONTINUAL HESITATION OR SPLUTTERING OF REVS. IF ACCELERARTING EXTREMELY HARD IT IS NOT AS EVIDENT BUT IS ALWAYS THERE. APPEARED OUT OF NOWHERE, CAR HAS NO OTHER ISSUES, SERVICED PROFESSIONALLY AS NEEDED/SCHEDULED. HORRIBLE COMFORT/ SAFETY ISSUE - NEEDS TO BE ADDRESSED HAS 75K MILES, HAS BEEN OCCURRING FOR LAST 10K DOESNT SEEM TO DO IT UNDER NO LOAD (NEUTRAL) BUT ALWAYS UNDER NORMAL DRIVING. ECO MODE ON OR OFF DOESNT MATTER - NO DIFFERENCE
NHTSA ODI #11366432
55,000 miles · Oct 17, 2020
EngineFuel/propulsion SystemPower Train
MY CAR WILL DIE AFTER BEING STOPPED (EX. AT A RED LIGHT, STOP SIGN) AND WILL NOT RESTART RIGHT AWAY. SOMETIMES IT DOESN'T DIE COMPLETELY. WHEN IT DOES YOU ARE UNABLE TO PUT THE CAR INTO PARK OR ENGAGE THE EMERGENCY LIGHTS. THIS HAS HAPPENED WHERE WE WERE STOPPED AT A RED-LIGHT AND THE CAR DIED AND WOULD NOT RESTART. A CAR BEHIND…
Read full complaint
MY CAR WILL DIE AFTER BEING STOPPED (EX. AT A RED LIGHT, STOP SIGN) AND WILL NOT RESTART RIGHT AWAY. SOMETIMES IT DOESN'T DIE COMPLETELY. WHEN IT DOES YOU ARE UNABLE TO PUT THE CAR INTO PARK OR ENGAGE THE EMERGENCY LIGHTS. THIS HAS HAPPENED WHERE WE WERE STOPPED AT A RED-LIGHT AND THE CAR DIED AND WOULD NOT RESTART. A CAR BEHIND US WAS APPROACHING THE LIGHT AND SAW THAT IT WAS GREEN, QUICKLY CAME UP BEHIND US HONKING THEIR HORN AND LUCKY WAS ABLE TO MOVE TO THE OTHER LANE TO AVOID HITTING US. THIS SEAMS TO HAPPEN WHEN WE FORGET TO TURN OFF THE AUTO IDLE STOP. THIS IS SOMETHING YOU HAVE TO PUSH EVERYONE YOU START THE CAR. I TOOK THE CAR TO THE DEALER THEY PUT IN A NEW TRANSMISSION AND CHANGED THE TIMING BELT. PREVIOUSLY I HAD THE CARS FUEL INJECTORS REPLACED. AFTER ALL THIS WORK THE CAR IS STILL DYING AND IT IS HAPPENING MORE FREQUENTLY. THE DEALERSHIP SAYS THEY HAVE HEARD OF THIS PROBLEM BUT DON'T KNOW OF A FIX YET.
NHTSA ODI #11364808
60,000 miles · Oct 16, 2020
Electrical SystemEngine
AFTER AUTOMATIC IDLE ENGINE STOP/START ENGAGES AND SHUT OFF VEHICLE AT STOP LIGHT, VEHICLE OCCASIONALLY WILL NOT RESTART AUTOMATICALLY. RESULTS IN BEING STOPPED AND STALLED OUT IN TRAFFIC FOR SEVERAL MINUTES AFTER WHICH IT WILL RESTART VIA MANUAL PROCESS.
NHTSA ODI #11364625
82,000 miles · Sep 28, 2020
Electrical SystemEngineUnknown Or Other
CHECK ENGINE LIGHT IS ILLUMINATED ALONG WITH AWD, KEYLESS START SYSTEM, EMISSIONS SYSTEM, UPHILL START, TRAILER ASSISTANCE, ETC. HAVE HAD TWO ENGINE COILS REPLACED AND A SOFTWARE UPGRADE. THE LIGHTS GO OFF FOR A COUPLE OF DAYS AND THEN RETURN. HAVE SPENT $250 IN DIAGNOSTICS AND NOTHING IS FIXED. REPLACED BATTERIES IN BOTH KEY FO…
Read full complaint
CHECK ENGINE LIGHT IS ILLUMINATED ALONG WITH AWD, KEYLESS START SYSTEM, EMISSIONS SYSTEM, UPHILL START, TRAILER ASSISTANCE, ETC. HAVE HAD TWO ENGINE COILS REPLACED AND A SOFTWARE UPGRADE. THE LIGHTS GO OFF FOR A COUPLE OF DAYS AND THEN RETURN. HAVE SPENT $250 IN DIAGNOSTICS AND NOTHING IS FIXED. REPLACED BATTERIES IN BOTH KEY FOBS. I WAS TOLD BY DEALERSHIP TO REPLACE THE START/STOP BUTTON FOR $375. DEALERSHIP ALSO RECOMMENDED REPLACING FUEL INJECTORS FOR $1600.NO GUARANTEE THAT THIS WILL FIX ANY OF THE ISSUES.
NHTSA ODI #11361626
63,750 miles · Sep 27, 2020
Electrical SystemEngine
THE CAR ENGINE/BATTERY SHUTS OFF AT STOP LIGHTS AND RED LIGHTS WHEN YOU TAKE YOUR FOOT OFF THE BREAK PEDAL. THIS SAME ISSUE OCCURRED A YEAR AGO. HONDA INITIALLY TOLD US THAT THERE WAS NO ISSUE WITH THE VEHICLE AND UNTIL WE PRESSED ABOUT FINDING A KNOWN ISSUE REPORTED ONLINE THEY SAID THERE WAS NOTHING WRONG. EVENTUALLY A REGION…
Read full complaint
THE CAR ENGINE/BATTERY SHUTS OFF AT STOP LIGHTS AND RED LIGHTS WHEN YOU TAKE YOUR FOOT OFF THE BREAK PEDAL. THIS SAME ISSUE OCCURRED A YEAR AGO. HONDA INITIALLY TOLD US THAT THERE WAS NO ISSUE WITH THE VEHICLE AND UNTIL WE PRESSED ABOUT FINDING A KNOWN ISSUE REPORTED ONLINE THEY SAID THERE WAS NOTHING WRONG. EVENTUALLY A REGIONAL SERVICE REP WAS INVOLVED WHO SAID THE ISSUE WAS KNOWN AND WAS WITH THE BATTERY. THE BATTERY WAS REPLACED AND FOR ONE YEAR HAD BEEN OKAY UNTIL TWO WEEKS AGO WHEN SAME ISSUE BEGAN OCCURRING AGAIN. THIS IS A MAJOR SAFETY ISSUE WITH THE VEHICLE TURNING OFF. I HAVE TWO YOUNG CHILDREN I HAVE TO DRIVE AROUND AND DO NOT FEEL SAFE IN THE VEHICLE WHILE THIS IS HAPPENING. I AM NOW WAITING ON A REPEAT SERVICE VISIT ON OCTOBER 8, 2020 TO ADDRESS THE ISSUE THIS YEAR.
NHTSA ODI #11361413
65,000 miles · Sep 10, 2020
Electrical SystemEngine
THE KEYLESS START SYSTEM PROBLEM LIGHT HAS COME ON AND THE DEALERSHIP FINDS NO CODES TO RESOLVE THE ISSUE. THE AUTO ENGINE SHUTOFF TO CONSERVE GAS WHEN THE BAKE IS DEPRESSED WILL COMPLETELY SHUT OFF THE CAR AND I AM NOT ABLE TO START THE CAR AGAIN. THIS HAS HAPPENED MANY TIME FROM DRIVING ON THE HIGHWAY AND STOPPING IN TRAFFIC T…
Read full complaint
THE KEYLESS START SYSTEM PROBLEM LIGHT HAS COME ON AND THE DEALERSHIP FINDS NO CODES TO RESOLVE THE ISSUE. THE AUTO ENGINE SHUTOFF TO CONSERVE GAS WHEN THE BAKE IS DEPRESSED WILL COMPLETELY SHUT OFF THE CAR AND I AM NOT ABLE TO START THE CAR AGAIN. THIS HAS HAPPENED MANY TIME FROM DRIVING ON THE HIGHWAY AND STOPPING IN TRAFFIC TO BEING IN THE CITY STOPPING AT A RED LIGHT. IT CAN TAKE UP TO A MINUTE OR MORE TO GET THE CAR TO START AGAIN. THE ONLY WAY TO DISABLE THIS FROM HAPPENING IS TO MANUALLY SHUT OFF THIS FEATURE EVERY TIME I START THE VEHICLE.
NHTSA ODI #11354112
75,000 miles · Sep 8, 2020
EnginePower Train
MY TIMING BELT FAILED AT UNDER 80K MILE AND AT LESS THAN 4 YEARS OLD. I WAS DRIVING AND COULD HAVE BEEN SERIOUSLY INJURED AS MY CAR DIED IN THE MIDDLE OF THE ROAD. THE BELT THEN DESTROYED MY ENTIRE ENGINE.
NHTSA ODI #11353631
78,000 miles · Sep 3, 2020
EnginePower Train
I WAS DRIVING THE CAR AND SUDDENLY EVER SINGLE WARNING LIGHT WENT ON, I HEARD A LOUD NOISE AND THE VEHICLE STOPPED RUNNING AND WOULD NOT START BACK UP. I WAS TOLD I HAD A TIMING BELT FAILURE AND THAT MY ENGINE THREW PISTONS AND WAS DESTROYED. THIS VEHICLE HAD 78K AND HAD EVERY OIL CHANGE REQUIRED.
NHTSA ODI #11353021
75,000 miles · Aug 27, 2020
Engine
BEGINNING IN SEPTEMBER OF 2019, THE PILOT HAS COMPLETELY SHUT OFF AT LEAST 8 TIMES WHEN THE AUTO START/STOP FEATURE IS ON. WHAT SHOULD HAPPEN IS THE ENGINE AUTO SHUTS OFF BUT THE ELECTRICAL SYSTEM AND ALL OTHER SYSTEMS STAY ACTIVE. WHAT IS HAPPENING IS THE ENTIRE SYSTEM HAS SHUT DOWN AND WE NEED TO RESTART THE PILOT. IT TYPIC…
Read full complaint
BEGINNING IN SEPTEMBER OF 2019, THE PILOT HAS COMPLETELY SHUT OFF AT LEAST 8 TIMES WHEN THE AUTO START/STOP FEATURE IS ON. WHAT SHOULD HAPPEN IS THE ENGINE AUTO SHUTS OFF BUT THE ELECTRICAL SYSTEM AND ALL OTHER SYSTEMS STAY ACTIVE. WHAT IS HAPPENING IS THE ENTIRE SYSTEM HAS SHUT DOWN AND WE NEED TO RESTART THE PILOT. IT TYPICALLY HAPPENS AT A STOP LIGHT BUT THE LAST TIME IT HAPPENED WHEN MY WIFE WAS TURNING LEFT OUT OF STOP LIGHT AND THERE WAS ONCOMING TRAFFIC. WE HAVE TAKEN IT TO OUR LOCAL HONDA DEALER AND THEY HAVE NO IDEA WHAT IS WRONG. OTHER IN THE HONDA PILOTEERS AUTO FORUM HAVE ALSO HAD THE SAME ISSUE BASED ON MY RESEARCH.
NHTSA ODI #11351507
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Jun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Oct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
Consequence & remedy
Consequence: If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Remedy: Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Jul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
Consequence & remedy
Consequence: If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
PE22005 · No Restart After Auto Start/stop Engages
Opened Jun 3, 2022 · Closed Mar 26, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration