NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
26 reportsClear category filterMileage unknown · Dec 3, 2025
Electrical SystemEngine
Vehicle has been having AIS issues for a couple of years, requiring new batteries, new starter/relays and countless internal computer updates (none of which have helped btw...). This morning she had the AIS engaged, went to turn left at a green light and when she released the brake the vehicle threw itself into Neutral and flash…
Read full complaint
Vehicle has been having AIS issues for a couple of years, requiring new batteries, new starter/relays and countless internal computer updates (none of which have helped btw...). This morning she had the AIS engaged, went to turn left at a green light and when she released the brake the vehicle threw itself into Neutral and flashed a "Auto Idle Stop System Problem" message on the dash. She put it into park and tried to restart, which failed, she then had to turn the vehicle off completely and restart from there. As I mentioned, none of the computer updates Honda has done for this vehicle have helped and it's my understanding there is a block of vehicles in this age range (all Passports, Ridgelines and Pilots) that continue to have problems with the AIS as well. Honda needs to disable this "feature" on any vehicles they cannot fix via computer updates IMMEDIATELY before they get someone killed. Not to mention, we are sick and tired of having to replace the battery and/or starter every couple of years. Honda should not be putting tax breaks above their customers safety and satisfaction. You know it's bad when their 30+ year techs go out of their way to buy a used Honda just to avoid the AIS because they don't know what to do with it at this point either.
NHTSA ODI #11702714
Mileage unknown · Oct 7, 2025
Electrical SystemEngineUnknown Or Other
To preface: All of these issues only occur when the engine idle feature is on. I have not experienced any of these problems when the feature is off. Question #1: When I release the brake with the engine idle on, the vehicle will sometimes completely shut off. When this happens, the steering wheel and brakes lock up, and I am un…
Read full complaint
To preface: All of these issues only occur when the engine idle feature is on. I have not experienced any of these problems when the feature is off. Question #1: When I release the brake with the engine idle on, the vehicle will sometimes completely shut off. When this happens, the steering wheel and brakes lock up, and I am unable to restart the vehicle for at least 60 seconds. Question #2: On one occasion, my wife, our 8-month-old child, and I were stuck at a green light for about 60 seconds while unable to restart the vehicle. Cars were passing by at over 50 mph, and we were relying on other drivers to notice us in time. This situation has happened multiple times and poses a serious safety risk to both us and others on the road. Question #3: I have not taken the vehicle in for service because the issue is difficult to reproduce consistently. That uncertainty is part of the problem, along with the anxiety of not knowing whether the car will suddenly shut off. Question #4: For the same reason, I have not been able to demonstrate the problem on demand. However, the main concern is that I should not have to worry about my vehicle stalling when I go to accelerate. Question #5: The vehicle has completely shut off four separate times over the past year. On one occasion, after releasing the brake, the engine struggled to reach normal RPMs and the check engine light came on. I pulled over, turned the vehicle off, restarted it, and it seemed fine afterward, although it had noticeably less power while the check engine light was on. Lastly, there have been several instances where the engine did not completely shut off when the idle feature was on, but when I released the brake to accelerate, I heard a clicking sound and the vehicle seemed as though it was about to stall. It then resumed operation normally as the idle system re-engaged. Since this happens intermittently, it has been difficult to recreate during a diagnostic inspection.
NHTSA ODI #11691991
Mileage unknown · Jul 8, 2025
Electrical SystemEngineForward Collision Avoidance
Owned the 2021 Honda Passport for 4 years and have had multiple issues over that time. 1st. Electrical issues. Randomly while driving the center/head unit will continuously restart on a loop until vehicle is turned off and turned back on. 2nd. The speakers make crackling noises randomly while driving. Even when the audio/spea…
Read full complaint
Owned the 2021 Honda Passport for 4 years and have had multiple issues over that time. 1st. Electrical issues. Randomly while driving the center/head unit will continuously restart on a loop until vehicle is turned off and turned back on. 2nd. The speakers make crackling noises randomly while driving. Even when the audio/speakers are turned off the crackling continues. (Very loud and annoying) 3rd. The Passport sometimes shuts off completely when stopped at red lights and has difficultly turning back on / restarting. This showed an error that there was a battery issue, which the battery had just been replaced a month or two earlier. It said something about being in accessory mode. 4th. The sensor that tracks oncoming traffic goes off sporadically. There are times on single lane roads that the car forces the breaks on because it senses cars on the other side. 5th. There has been issues while accelerating that feel like the car is having trouble shifting. It continues to rev but not go, when letting off the gas it almost feels like its doing an engine break to get back down to a certain rpm or something. Had the whole car bouncing, had to pull over and turn off the car to get it to start working properly. *** All of that said, this car has been and continues to feel unsafe to drive for multiple reasons listed above. I'd be more than happy to go into more detail for them if needed. ***
NHTSA ODI #11672023
Mileage unknown · Apr 6, 2025
Engine
Engine Restart failure. Vehicle approached intersection, came to complete start and engine stopped. Vehicle would not restart when I lifted foot off of brake pedal. I had to shut vehicle off, waited a few minutes and restarted it again. Vehicle's Auto Idle Stop system was activate at time. on 12/11/2024 reported incident to…
Read full complaint
Engine Restart failure. Vehicle approached intersection, came to complete start and engine stopped. Vehicle would not restart when I lifted foot off of brake pedal. I had to shut vehicle off, waited a few minutes and restarted it again. Vehicle's Auto Idle Stop system was activate at time. on 12/11/2024 reported incident to NuCar Honda, Norwood, MA. They were unable to duplicate issue.
NHTSA ODI #11653020
Mileage unknown · Apr 1, 2025
Engine
While at a stop light, there was an engine start failure that caused the vehicle not to restart. It took me approximately 5 minutes to get it to start again.
NHTSA ODI #11651961
Mileage unknown · Mar 10, 2025
Electrical SystemEnginePower Train
Vehicle engine keeps stopping while in drive and puts itself in neutral and turn offs, metal flying around the engine, vehicle jumps and makes loud rattling noise, vehicle electrical issue all components turned themselves off, Catalyst converter and several other vehicle issues alarm safety , vehicle gets stuck on hill
NHTSA ODI #11647468
Mileage unknown · Mar 1, 2025
Engine
I purchased a 2021 Passport this week with 22k miles. Test drive was great, but the next day I noticed a knocking sound coming from the engine at low rpm on a warm engine. I took back to the dealer twice and they told me it was normal… I took it to another Honda and they diagnosed crank bearing knock. I just purchased this car w…
Read full complaint
I purchased a 2021 Passport this week with 22k miles. Test drive was great, but the next day I noticed a knocking sound coming from the engine at low rpm on a warm engine. I took back to the dealer twice and they told me it was normal… I took it to another Honda and they diagnosed crank bearing knock. I just purchased this car with low miles and it has engine problems which is very scary. Maintenance records are great. I’ve been reading forums and this problem is very common with these engines. A lot of people have been told it was normal, but it is not. It’s very scary and dangerous to find out I bought a defective engine. I have a video of the knocking sound.
NHTSA ODI #11645702
Mileage unknown · Sep 15, 2024
Engine
Engine knocking noise that related to recent Honda crankshaft recalls of certain V6 engines. with 22k miles Honda did replace on main crankshaft bearing to to premature wear on my multiple complains on engine knocking noise that clearly audible between 11 to 17 k RPM. After main bearing replacement the noise is audible so the pa…
Read full complaint
Engine knocking noise that related to recent Honda crankshaft recalls of certain V6 engines. with 22k miles Honda did replace on main crankshaft bearing to to premature wear on my multiple complains on engine knocking noise that clearly audible between 11 to 17 k RPM. After main bearing replacement the noise is audible so the parts that cause it are still working in this engine. It is super unsafe to have catastrophic failure of an engine on highway or in the mountains with no cellular connection.
NHTSA ODI #11614723
Mileage unknown · Jul 18, 2023
Electrical SystemEngine
My car is equipped to cut off when you come to a stop. It has failed to restart after taking your foot off the brake a couple of times, and it has been slow to restart many times.
NHTSA ODI #11533062
Mileage unknown · Jun 21, 2023
Electrical SystemEngine
The auto engine idle is failing to properly restart the vehicle. After coming to a complete stop the vehicle will not restart on its own. I have to put the vehicle in park, wait a few minutes and then push the start button to restart the vehicle. The vehicle will be available for inspection upon request. My safety and the safety…
Read full complaint
The auto engine idle is failing to properly restart the vehicle. After coming to a complete stop the vehicle will not restart on its own. I have to put the vehicle in park, wait a few minutes and then push the start button to restart the vehicle. The vehicle will be available for inspection upon request. My safety and the safety of others has been put at risk numerous times. The vehicle has failed to restart mid-intersection in heavy traffic., on the highway during stop and go traffic, and at stop lights. The problem has not been reproduced or confirmed by a dealer or service center. The vehicle has not been inspected by the manufacturer, police or insurance company. No prior warning signs, messages or lamps have appeared before the problem.
NHTSA ODI #11528172
Official recalls
7Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 29, 2023
Honda (American Honda Motor Co.) is recalling certain 2020-2021 Civic, 2020-2023 Ridgeline, 2021-2023 Passport, 2021-2022 Pilot, and 2020 Acura MDX vehicles. The tie rod fastener that connects the brake booster and the brake master cylinder may have been improperly assembled during manufacturing, which can cause the brake master cylinder to separate from the booster assembly.
Consequence & remedy
Consequence: Brake master cylinder separation can cause a loss of brake function and increase the risk of a crash.
Remedy: Dealers will inspect and repair the brake booster assembly as necessary, free of charge. Owner notification letters were mailed August 7, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are VEU, AEV, and ZET.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25002 · Inadvertent Automatic Emergency Braking
Opened Jan 17, 2025 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the investigation is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24008 · Inadvertent Automatic Emergency Braking
Opened Mar 7, 2024 · Closed Jan 17, 2025
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration