NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
276 reportsMileage unknown · Jan 22, 2025
EngineForward Collision Avoidance
The Idle-Stop system engages as expected when the vehicle comes to a stop, but the engine fails to restart when I release the brake pedal. This leaves me stranded in traffic and vulnerable to collisions, especially in high-traffic areas like intersections. The car has completely stalled and remains frozen for at least 3 minutes…
Read full complaint
The Idle-Stop system engages as expected when the vehicle comes to a stop, but the engine fails to restart when I release the brake pedal. This leaves me stranded in traffic and vulnerable to collisions, especially in high-traffic areas like intersections. The car has completely stalled and remains frozen for at least 3 minutes. Instrument panel lights up and says to depress pedal fully and press the start button. Another message says something about being in neutral and then to put it in park. I'm doing what it says and I cannot get the car to start. I have a green light and I'm stuck in an intersection where opposing traffic has a green light as well. People are honking at me and nervous because of the unpredictibilty of my car. - Frequency: This occurs at least 1x/month for the past 65 months (lifetime of the vehicle) - Conditions: Occurs during normal driving conditions, typically in stop-and-go traffic. - Impact: This issue has resulted in significant delays and near-misses with other vehicles, posing a clear safety hazard. The vehicle has been evaluated by a Honda dealer regarding Idle-Stop system malfunction specifically on the following dates October 1st, 2020, February 2nd 2023, March 16th, 2023 May 11th 2023, November 7th 2024 and January 9th 2025. The vehicle was found to be in normal working order and multiple times I was told to disengage the auto idle stop (press the button) to prevent that from happening. There was a recall for idle-stop software update which failed to repair the issue. This has been a persistent problem and the above dates by no means reflects the only times that the engine fails to restart after auto-stopping.
NHTSA ODI #11637721
31,000 miles · Jan 22, 2025
Fuel System, Gasoline
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while his wife was at a complete stop on two different occasions, the vehicle stalled. A message pertainin…
Read full complaint
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while his wife was at a complete stop on two different occasions, the vehicle stalled. A message pertaining to the engine was displayed. The contact's wife was able to restart the vehicle. The vehicle was taken to the dealer to be diagnosed, but the dealer informed the contact that no failure was found. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,000. Parts distribution disconnect.
NHTSA ODI #11637708
Mileage unknown · Jan 16, 2025
Fuel System, Gasoline
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall r…
Read full complaint
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11636335
Mileage unknown · Jan 7, 2025
Unknown Or Other
Unknown component failure on 2019 Honda Passport. While operating the vehicle, the engine shut off and automatically placed the vehicle in neutral. The battery light appeared on the dashboard, and instructed, "To start engine: Brake + Push". The vehicle would not allow me to press the start button unless placed in park, however,…
Read full complaint
Unknown component failure on 2019 Honda Passport. While operating the vehicle, the engine shut off and automatically placed the vehicle in neutral. The battery light appeared on the dashboard, and instructed, "To start engine: Brake + Push". The vehicle would not allow me to press the start button unless placed in park, however, the vehicle would not allow me to select park while the engine was off. After a few minutes, I was able to place the vehicle in park, but the engine would not immediately start upon pressing the start button. I then had to manually reset the vehicle by pressing the start button three times before the engine would turn on again. This issue has occurred three times over a span of three months. Once while I was parked. Once while I was operating on the highway, thus posing a risk being rear-ended at a high speed. And once while I was operating through an intersection on the main road, again posing a risk of being rear-ended or T-boned. During these times, the vehicle was rendered inoperable until it was eventually restarted. There were no warning messages or other symptoms of the problem prior to the times of failure. It is noted the issue seems to present itself while the speed of the vehicle is decreasing. For instance, while slowing in traffic on the highway and on the main road. The issue was brought to the attention of the Honda Service Center on two separate occasions. Both times Honda was unable to replicate the issue or identify the component at fault. Honda stated that the vehicle diagnostics and computer system presented no codes or record of the malfunction. The issue remains unresolved.
NHTSA ODI #11634692
Mileage unknown · Jan 1, 2025
Engine
The 3.5 engine is ticking (knocking hard from 1-2 rpm same engine that is in all the recall on pilots and other Honda cars! My car has 65k miles on it . Honda has it for a week they can’t figure it out and say it’s normal. I know my car and a loud tick is not normal! Honda knows these engine have issue and don’t want to fix it. …
Read full complaint
The 3.5 engine is ticking (knocking hard from 1-2 rpm same engine that is in all the recall on pilots and other Honda cars! My car has 65k miles on it . Honda has it for a week they can’t figure it out and say it’s normal. I know my car and a loud tick is not normal! Honda knows these engine have issue and don’t want to fix it. I’m now out of warranty and they don’t want to do anything basically they want me to get stranded when it breaks down or I’m in an accident if my engine breaks.
NHTSA ODI #11633540
Mileage unknown · Dec 30, 2024
Fuel System, Gasoline
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel system, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall r…
Read full complaint
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel system, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11633226
Mileage unknown · Dec 27, 2024
Fuel System, Gasoline
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the iss…
Read full complaint
The contact owns a 2019 Honda Passport. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11632615
56,000 miles · Dec 23, 2024
Fuel System, Gasoline
The contact owns a 2019 Honda Passport. The contact stated that while driving at an undisclosed speed, the vehicle stalled with no warning light illuminated. The vehicle was able to restart however, the failure recurred. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the pa…
Read full complaint
The contact owns a 2019 Honda Passport. The contact stated that while driving at an undisclosed speed, the vehicle stalled with no warning light illuminated. The vehicle was able to restart however, the failure recurred. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to repair was unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact was informed by the dealer that the parts were not available The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact to confirm when the parts were available for the recall. The approximate failure mileage was 56,000. Parts distribution disconnect.
NHTSA ODI #11632149
Mileage unknown · Dec 19, 2024
Forward Collision AvoidanceService Brakes
The automatic braking system will activate at various times shaking the wheel and applying the brakes. This happens when there is nothing in front of the vehicle.
NHTSA ODI #11631606
Mileage unknown · Dec 18, 2024
Forward Collision AvoidanceLane Departure
Adaptive Cruise Control; Automatic Emergency Braking; Blind Spot Warning Lane Departure Warning; Lane Keeping Assistance; Parking Collision Warning
NHTSA ODI #11631475
Official recalls
10Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Mar 11, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Passport and Pilot vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Overcured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation, which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash or injury.
Remedy: Honda will notify owners, and dealers will inspect all four tires and replace them as necessary, free of charge. The recall began April 22, 2021. Owners may contact American Honda Motor Co. customer service at 1-888-234-2138. Honda's number for this recall is UA2.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence & remedy
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Oct 31, 2019
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Pilot and 2019 Passport vehicles. The front frame left and right side upper members may not have been welded completely to the unibody. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 219, "Windshield Zone Intrusion."
Consequence & remedy
Consequence: In the event of a crash, incomplete body welding may provide inadequate protection to occupants, increasing the risk of an injury.
Remedy: Honda will notify owners, and dealers will inspect the vehicle for missing welds, free of charge. If the vehicle is identified as missing welds, the dealer will offer to repurchase the vehicle or provide a similar replacement vehicle. Owner notification began November 6 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is X6J.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25002 · Inadvertent Automatic Emergency Braking
Opened Jan 17, 2025 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the investigation is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24008 · Inadvertent Automatic Emergency Braking
Opened Mar 7, 2024 · Closed Jan 17, 2025
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration