NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
26 reportsClear category filter148,000 miles · May 21, 2013
Engine And Engine CoolingPower TrainSteering
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 148,000. ..UPDATED 07-17-13 *BF THE BALL JOINTS, EXHAUST, TIE ROD END, ENGINE GASKETS, SWAY BAR LINKS AND TIMING BELT ALL NEEDED TO BE REPLACED.
NHTSA ODI #10513029
154,000 miles · Mar 4, 2013
EnginePower TrainSuspension
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE REAR SUSPENSION LOWER LINK BRACKET WAS FRACTURED DUE TO EXCESSIVE CORROSION. IN ADDI…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE REAR SUSPENSION LOWER LINK BRACKET WAS FRACTURED DUE TO EXCESSIVE CORROSION. IN ADDITION, THE MECHANIC STATED THAT THE VEHICLE WAS NOT REPAIRABLE BECAUSE THE FRAME WAS ALSO CORRODED AND THE BRACKET COULD NOT BE WELDED BACK ONTO THE FRAME. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 154,000. ..UPDATED 04/18/13 *BF THE CONSUMER STATED HE FINALLY FOUND A FRAME RESTORATION SHOP. THEY CUT OUT ALL OF THE RUSTED FRAME AREAS ON THE REAR DRIVER SIDE AND MADE A NEW END FOR THE LOWER LINK BRACKET. THE CONSUMER ALSO STATED THE CATALYTIC CONVERTER BECAME CLOGGED AND RUINED THE ENGINE. THE FRONT AXLES WERE REPLACED TWICE. THE VEHICLE HAD AN OIL LEAK AND TRANSMISSION LEAK. UPDATED 04/23/13
NHTSA ODI #10501262
222,138 miles · Dec 31, 2010
Fuel System, OtherPower TrainSuspension
NOTICED THAT FUEL GAUGE IS NOT WORKING PROPERLY BECAUSE IT WENT EMPTY EVEN THOUGH I HAVE A TANK FULL OF GAS. I DID SOME INTERNET RESEARCH AND FOUND OUT THAT THIS IS RELATED TO A DEFECTIVE 'FUEL SENDING UNIT'. IT AFFECTS HONDA PASSPORTS AND ISUZU RODEO VEHICLES . MY SUV HONDA PASSPORT FUEL GAUGE IS NOT WORKING DUE TO BAD FLOAT CH…
Read full complaint
NOTICED THAT FUEL GAUGE IS NOT WORKING PROPERLY BECAUSE IT WENT EMPTY EVEN THOUGH I HAVE A TANK FULL OF GAS. I DID SOME INTERNET RESEARCH AND FOUND OUT THAT THIS IS RELATED TO A DEFECTIVE 'FUEL SENDING UNIT'. IT AFFECTS HONDA PASSPORTS AND ISUZU RODEO VEHICLES . MY SUV HONDA PASSPORT FUEL GAUGE IS NOT WORKING DUE TO BAD FLOAT CHAMBER ON THE PUMP COMPONENT HAS MANUFACTURING DEFECTS. MY FUEL GAUGE HAS STARTED FLUCTUATING WILDLY. THE MOST COMMON THING THOUGH, IS THAT IT READS OUT OF GAS SHORTLY AFTER A FILL UP. THIS IS THE SAME MODEL AS AN ISUZU RODEO AND THE PROBLEMS ARE DUPLICATED THERE. I WANT TO MAKE SURE A RECALL HAPPENS AND THAT IT COVERS THE HONDAS AS WELL. *TR
NHTSA ODI #10373658
Mileage unknown · Nov 22, 2005
Power Train
I HAVE OWNED THE 1999 HONDA PASSPORT FOR 3 YEARS. AT ABOUT 50,000 MILES, THE SUV WOULD SHIFT HARD FORM THE LOWER GEAR TO FIRST. SO HARD IF FACT, THAT OTHERS IN CARS NEARBY NOTICED. RECENTLY, THE SUV WAS HAVING PROBLEMS SHIFTING DURING ACCELERATION. AT FIRST IT WAS SLIP, BUT QUICKLY WORSENED. UPON ACCELERATING FROM A STOPPED POSI…
Read full complaint
I HAVE OWNED THE 1999 HONDA PASSPORT FOR 3 YEARS. AT ABOUT 50,000 MILES, THE SUV WOULD SHIFT HARD FORM THE LOWER GEAR TO FIRST. SO HARD IF FACT, THAT OTHERS IN CARS NEARBY NOTICED. RECENTLY, THE SUV WAS HAVING PROBLEMS SHIFTING DURING ACCELERATION. AT FIRST IT WAS SLIP, BUT QUICKLY WORSENED. UPON ACCELERATING FROM A STOPPED POSITION OR WHEN SHIFTING FROM A HIGHER GEAR DOWN (ESPECIALLY ON TURNS) THE GEAR SEEMS TO SLIP AND THERE IS A JOLT. I TOOK THE SUV TO BE DIAGNOSED. ON TWO SEPARATE OCCASIONS, IT HAS TAKEN SEVERAL DAYS FOR DIAGNOSIS. FIRST DIAGNOSIS WAS THE DRIVE SHAFT, PROBLEM DID NOT GO AWAY. THEN IT WAS THE TYPE OF OIL IN THE DIFFERENTIAL. WENT AWAY FOR A DAY, THEN RETURNED. FINALLY, HAD THE TRANSMISSION REBUILT. PROBLEM WENT AWAY. I SPENT OVER $4000 ON THESE REPAIRS AND BELIEVE THAT THIS IS A SIGNIFICANT ISSUE WITH THIS VEHICLE. *JB
NHTSA ODI #10143510
83,600 miles · Nov 9, 2004
Power Train
IN MY SECOND YEAR OF OWNING MY 1999 HONDA PASSPORT, I BEGAN TO EXPERIENCE A JARRING JOLT WHEN TAKING OFF FROM A STOP IMTERMITTANTLY. NOW, ABOUT A YEAR LATER, THIS HAS GROWN TO A VIOLENT BANGING JOLT WHEN ACCELERATING, AND A FULL SLIPPING BETWEEN GEARS AS I PROCEED. THIS GREW WORSE VERY FAST, AND NOW I NEED TO REPLACE THE TRANSMI…
Read full complaint
IN MY SECOND YEAR OF OWNING MY 1999 HONDA PASSPORT, I BEGAN TO EXPERIENCE A JARRING JOLT WHEN TAKING OFF FROM A STOP IMTERMITTANTLY. NOW, ABOUT A YEAR LATER, THIS HAS GROWN TO A VIOLENT BANGING JOLT WHEN ACCELERATING, AND A FULL SLIPPING BETWEEN GEARS AS I PROCEED. THIS GREW WORSE VERY FAST, AND NOW I NEED TO REPLACE THE TRANSMISSION, AT A COST OF OVER $4,000.00, ACCORDING TO BELL ROAD HONDA IN PHOENIX. I'M AT A LOSS, AND NEED HELP.*AK
NHTSA ODI #10098544
50,000 miles · Aug 23, 2004
Power Train
THIS PASSPORT HAVE BEEN HAVING (AUTOMATIC) TRANSMISSION PROBLEMS AT AROUND 15 TO 20 MILES AND AT 25 TO 30 MILES. THE MILEAGE ON THIS CAR NOW IS ABOUT 50,200 MILES. WHEN I TAKE TO THE DEALER THE PROBLEM IS GONE AND THEY CANNOT DIAGNOSE THE PROBLEM. THE GEARS SLAMS OR JERKS WHEN IT SHIFTS AND IT ALSO DOES WHEN YOU SLOW DOWN. T…
Read full complaint
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
NHTSA ODI #10088402
114,000 miles · Jul 6, 2004
Power Train
VEHICLE JERKS & SHIFTS HARD AT VARIOUS SPEEDS DURING GEAR CHANGES. VEHICLE WAS TAKEN TO DEALERSHIP 1 YR BEFORE THE JERKS BECAME VIOLENT DUE TO DECREASE IN SMOOTHNESS OF GEAR CHANGES. THE DEALER INFORMED ME THAT IT WAS NORMAL IN THE PASSPORT/ISUZU & THAT IT WOULDN'T GET ANY WORSE. IT HAS! *NM
NHTSA ODI #10080401
46,000 miles · Jan 15, 2004
Fuel System, GasolinePower Train
WHEN THE PASSPORT WAS PURCHASED IN MAY OF 2002, THE FUEL LIGHT INTERMITTENTLY BLINKED. THE PROBLEM WAS DIAGNOSED BY HONDA CARS OF CONCORD (NC) AS A "FUEL SENDING UNIT." ESTIMATED COST, INCLUDING LABOR WAS $500. I DECIDED TO KEEP TRACK OF FUEL BY CALCULATING THE MILEAGE BECAUSE THIS "WASN'T A WARRANTY PROBLEM" BEC…
Read full complaint
WHEN THE PASSPORT WAS PURCHASED IN MAY OF 2002, THE FUEL LIGHT INTERMITTENTLY BLINKED. THE PROBLEM WAS DIAGNOSED BY HONDA CARS OF CONCORD (NC) AS A "FUEL SENDING UNIT." ESTIMATED COST, INCLUDING LABOR WAS $500. I DECIDED TO KEEP TRACK OF FUEL BY CALCULATING THE MILEAGE BECAUSE THIS "WASN'T A WARRANTY PROBLEM" BECAUSE I BOUGHT IT "PRE-OWNED." THAT PROBLEM WAS MINOR COMPARED TO WHAT CAME NEXT. I NOTICED THE TRANSMISSION ACTING FUNNY BY SKIPPING AND REVVING HARD. WHEN I TOOK IT IN FOR THE DEALERSHIP TO CHECK THE TRANSMISSION FLUID, (BECAUSE YOU CAN'T DO THIS YOURSELF), THEY INFORMED ME THAT THE TRANSMISSION NEEDED TO BE REPLACED. I COULDN'T BELIEVE IT. THIS VEHICLE HAS JUST UNDER 47,000 MILES ! AFTER FURTHER INVESTIGATION, I SEE WHERE SCORES OF OTHERS HAVE THE IDENTICAL PROBLEM AROUND THE SAME AMOUNT OF MILES. NO RECALL ??? SINCE THE CAR IS NOW VALUED AT LESS THAN THE PAYOFF BECAUSE OF THE TRANSMISSION PROBLEM (NEGATIVE EQUITY) I AM FORCED TO PAY FOR A VEHICLE THAT HAS A SHORT LIFE LEFT AND VERY LITTLE MILEAGE. PLEASE HELP ME ! THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10069803
45,000 miles · Nov 23, 2003
Power Train
MY 1999 HONDA PASSPORT IS CONTINUING TO HAVE PROBLEMS WITH THE AUTO TRANSMISSION. FROM A COLD START THE SUV WILL INTERMITTENTLY SHIFT HARD INTO 2ND GEAR. I HAVE TAKEN TO THE POWER COSTA MESA HONDA DEALER TO HAVE THEM DIAGNOSE 5 TIMES. THEY HAD NO WAY OF DIAGNOSING THE PROBLEM AS THE SUV WOULD DO THIS EVERY ONCE IN A WHILE. FINAL…
Read full complaint
MY 1999 HONDA PASSPORT IS CONTINUING TO HAVE PROBLEMS WITH THE AUTO TRANSMISSION. FROM A COLD START THE SUV WILL INTERMITTENTLY SHIFT HARD INTO 2ND GEAR. I HAVE TAKEN TO THE POWER COSTA MESA HONDA DEALER TO HAVE THEM DIAGNOSE 5 TIMES. THEY HAD NO WAY OF DIAGNOSING THE PROBLEM AS THE SUV WOULD DO THIS EVERY ONCE IN A WHILE. FINALLY, AFTER ONE DAY OF DRIVING IN TRAFFIC I FOUND A WAY TO DUPLICATE THE PROBLEM. I HAD PLACED IT INTO 1ST GEAR (LOW) THE SUV SHIFTED INTO 2ND! I AM NO MECHANIC BUT I DO KNOW THAT IT IS NOT SUPPOSED TO HAPPEN. I WAS DRIVING IN 2ND WHEN ALL OF A SUDDEN IT REALIZED OH I NEED TO BE IN 1ST! SO I TOOK THE SUV BACK TO HAVE THEM DIAGNOSE THE ISSUE. THEY REPLACED A FAA MOTOR IN THE TRANSMISSION. PART NUMBER: 8-96041-156-0, THE PART WAS 400 DOLLARS AND ABOUT 200 LABOR. THE ISSUE WAS FIXED FOR A MONTH NOW CONTINUES TO HAVE THE PROBLEM BUT IT WILL NOT SHIFT FROM LOW TO SECOND. NOW THEY WANT ME TO REPLACE THE RANGE SELECTOR SWITCH PART NUMBER: 8-96017-511-0 FOR $147.32 (PART ONLY). *LA
NHTSA ODI #10047429
Mileage unknown · Oct 19, 2003
Power Train
WHEN ACCELERATING FROM A COMPLETE STOP, AS SOON AS AUTO TRANSMISSION SHIFTS TO 1ST GEAR AT 30 MPH, I EXPERIENCE SUCH A VIOLENT, HARD JERK THAT IT IS ACTUALLY SEEN BY PEOPLE IN OTHER VEHICLES. THIS JERK CREATES A LOUD MECHANICAL NOISE ALSO THAT CAN BE HEARD BY PEOPLE NOT IN THE CAR WITH ME. THIS SAME JERKING IS EXPERIENCED WHEN…
Read full complaint
WHEN ACCELERATING FROM A COMPLETE STOP, AS SOON AS AUTO TRANSMISSION SHIFTS TO 1ST GEAR AT 30 MPH, I EXPERIENCE SUCH A VIOLENT, HARD JERK THAT IT IS ACTUALLY SEEN BY PEOPLE IN OTHER VEHICLES. THIS JERK CREATES A LOUD MECHANICAL NOISE ALSO THAT CAN BE HEARD BY PEOPLE NOT IN THE CAR WITH ME. THIS SAME JERKING IS EXPERIENCED WHEN DECREASING SPEED TO COME TO A STOP, AT APPROXIMATELY 15 MILES PER HOUR WHEN TRANSMISSION IS SHIFTING DOWN. THIS PROBLEM HAS JUST STARTED, I ONLY HAVE 29600 MILES VEHICLE. THIS PROBLEM DOES NOT HAPPEN EVERY TIME I DRIVE THE VEHICLE. HONDA COULD NOT DUPLICATE PROBLEM, THEREFORE DID NOTHING. IT SCARES ME, AND MY CHILD BECAUSE IT IS SUCH A JOLTING VIOLENT MOVEMENT. *LA
NHTSA ODI #10043184
Official recalls
2Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
Illustration