NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
27 reportsClear category filter148,000 miles · May 21, 2013
Engine And Engine CoolingPower TrainSteering
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 148,000. ..UPDATED 07-17-13 *BF THE BALL JOINTS, EXHAUST, TIE ROD END, ENGINE GASKETS, SWAY BAR LINKS AND TIMING BELT ALL NEEDED TO BE REPLACED.
NHTSA ODI #10513029
65,000 miles · Jan 21, 2005
Engine And Engine Cooling
AFTER A YEAR OF OWNING THIS VEHICLE, STARTED STALLING OUT EVEN WHILE DRIVING (AUTOMATIC TRANS). CHECK ENGINE LIGHT CAME ON, AND WAS TOLD BY DEALER THAT THE MANIFOLD GASKET NEEDS TO BE REPLACED. WANTS OVER $600 TO DO SO. I CAN'T AFFORD IT YET, SO I'M DEALING WITH THE STALLING UNTIL I CAN PAY TO HAVE IT FIXED, BUT I'M WARY OF I…
Read full complaint
AFTER A YEAR OF OWNING THIS VEHICLE, STARTED STALLING OUT EVEN WHILE DRIVING (AUTOMATIC TRANS). CHECK ENGINE LIGHT CAME ON, AND WAS TOLD BY DEALER THAT THE MANIFOLD GASKET NEEDS TO BE REPLACED. WANTS OVER $600 TO DO SO. I CAN'T AFFORD IT YET, SO I'M DEALING WITH THE STALLING UNTIL I CAN PAY TO HAVE IT FIXED, BUT I'M WARY OF IT BECAUSE I'VE RESEARCHED THE PROBLEM AND FOUND THE DEFECT IS REPETITIVE IN THIS VEHICLE. *NM
NHTSA ODI #10107698
32,000 miles · Jan 21, 2005
Engine And Engine Cooling
THIS CAR BURNS OIL AT A VERY FAST RATE, WITH NO SIGN OF LEAKS, ETC. TOOK TO DEALER AND THEY CAN'T FIND SOURCE. I HAVE TO CHECK OIL LEVEL AND USUALLY REPLACE EACH WEEK - I DRIVE ABOUT 150 MILES WEEKLY. SEEMS VERY EXCESSIVE TO ME, ESPECIALLY W/ NO SUGGESTION ON HOW TO FIX. *NM
NHTSA ODI #10107697
59,000 miles · Jul 13, 2004
Engine And Engine Cooling
THE ENGINE COUGHED AND CHOKED, AND THE VEHICLE STALLED. I AT FIRST THOUGHT IT WASN'T WARMED UP ENOUGH BEFORE I STARTED DRIVING IT, SO I WARMED IT UP IN THE MORNING FOR ABOUT 5 MIN. THE PROBLEM DIDN'T OCCUR FOR A SHORT WHILE, THEN CAME BACK. I BROUGHT IT TO A HONDA DEALERSHIP. THEY TESTED IT AND ADVISED ME THAT THE HEAD CYLIN…
Read full complaint
THE ENGINE COUGHED AND CHOKED, AND THE VEHICLE STALLED. I AT FIRST THOUGHT IT WASN'T WARMED UP ENOUGH BEFORE I STARTED DRIVING IT, SO I WARMED IT UP IN THE MORNING FOR ABOUT 5 MIN. THE PROBLEM DIDN'T OCCUR FOR A SHORT WHILE, THEN CAME BACK. I BROUGHT IT TO A HONDA DEALERSHIP. THEY TESTED IT AND ADVISED ME THAT THE HEAD CYLINDER GASKET WAS BLOWN, CAUSING COOLANT TO LEAK INTO THE COMBUSTION CHAMBER. ALSO ONE CYLINDER HEAD IS CRACKED AND HAD TO BE REPLACED. THE OTHER CYLINDER HEAD HAD TO BE MACHINED. IT TOOK ABOUT A MONTH TO GET IT FIXED. I FOUND IT VERY UNUSUAL THAT A MAJOR ENGINE WORK HAD TO BE DONE WITH LESS THAN 60,000 MILES. *LA
NHTSA ODI #10080919
77,000 miles · Jul 11, 2004
Engine And Engine Cooling
VEHICLE STALLED WITHOUT WARNING. I HAD VEHICLE TOWED TO DEALER. THE DEALER INFORMED ME THAT THEY WERE NOT SURE WHAT WAS WRONG, BUT THEY BELIEVED THE ENGINE NEEDED TO BE REPLACED.*AK
NHTSA ODI #10080795
77,000 miles · Apr 16, 2004
Engine And Engine Cooling
WHILE DRIVING BETWEEN 15 TO 20 MPH VEHICLE STALLED. CONSUMER PULLED OFF THE ROAD. VEHICLE WAS TOWED TO THE DEALER. DEALERSHIP TECHNICIAN DETERMINED ENGINE NEEDED TO B EREPLACED. *AK
NHTSA ODI #10067254
61,000 miles · Mar 16, 2004
Engine And Engine Cooling
TWO PROBLEMS. ONE IS THAT THE ENGINE STARTED KNOCKING. STARTED OUT LIGHT AND AT ONLY WHEN THE ENGINE REACHED OVER 2000 RPM. CALLED TAYLOR HONDA SERVICE AS SOON AS THE NOISE STARTED AND THEY TOLD ME THE FIRST THEY COULD LOOK AT IT WAS ONE WEEK LATER. EVENTUALLY, THE KNOCK BECAME AN OBVIOUS BREAK OF SOMETHING IN THE ENGINE. I…
Read full complaint
TWO PROBLEMS. ONE IS THAT THE ENGINE STARTED KNOCKING. STARTED OUT LIGHT AND AT ONLY WHEN THE ENGINE REACHED OVER 2000 RPM. CALLED TAYLOR HONDA SERVICE AS SOON AS THE NOISE STARTED AND THEY TOLD ME THE FIRST THEY COULD LOOK AT IT WAS ONE WEEK LATER. EVENTUALLY, THE KNOCK BECAME AN OBVIOUS BREAK OF SOMETHING IN THE ENGINE. I STOPPED DRIVING THE VEHICLE AND HAD IT TOWED TO DEALERSHIP. THIS PROBLEM HAS OCCURRED FOR NUMEROUS OWNERS JUDGING FROM INTERNET REPORTS. THE DEALER HAS NOT DIAGNOSED THE PROBLEM YET. I AM EXPECTING A CATASTROPHIC PROBLEM. THE FUEL GAUGE HAS ALSO BEEN REGISTERING EMPTY FOR OVER TWO MONTHS. *JB
NHTSA ODI #10062292
77,000 miles · Jan 17, 2004
Engine And Engine Cooling
WHILE DRIVING MY 1999 HONDA PASSPORT, THE VEHICLE TURNED OFF AND I PULLED OVER TO THE SIDE OF THE ROAD. I HAD THE VEHICLE TOWED TO GRAND HONDA IN ELMHURST ILLINOIS ON NOVEMBER 10, 2003. THE VEHICLE REMAINED AT THE DEALER FOR SEVERAL WEEKS AND THEN WAS TOLD THAT THEY DID NOT KNOW WHAT WAS WRONG WITH THE VEHICLE BUT THEY THOUGH…
Read full complaint
WHILE DRIVING MY 1999 HONDA PASSPORT, THE VEHICLE TURNED OFF AND I PULLED OVER TO THE SIDE OF THE ROAD. I HAD THE VEHICLE TOWED TO GRAND HONDA IN ELMHURST ILLINOIS ON NOVEMBER 10, 2003. THE VEHICLE REMAINED AT THE DEALER FOR SEVERAL WEEKS AND THEN WAS TOLD THAT THEY DID NOT KNOW WHAT WAS WRONG WITH THE VEHICLE BUT THEY THOUGHT THE ENGINE NEEDED TO BE REPLACED. I ASKED WHAT HAPPENED TO THE ENGINE AND THEY SAID THEY WERE UNSURE, BUT THOUGHT THAT I NEEDED TO HAVE MINE REPLACED. I AGREED AND THEY LATER TOLD ME THEY WERE NOT ABLE TO FIND A REASONABLY PRICED ENGINE AND THAT IT WOULD BE CHEAPER FOR ME TO TAKE MY SUV SOMEWHERE ELSE. I CONTACTED HONDA CORPORATE AND WAS TOLD THE SAME. HONDA DID NOT STAND BEHIND THEIR VEHICLE. THE HONDA DEALER TOLD ME TO HAVE MY VEHICLE PICKED UP. I ARRANGED FOR A TOW TRUCK TO PICK UP MY VEHICLE AND DELIVER IT TO MY HOME. WHEN THE VEHICLE ARRIVED AT MY HOME HONDA HAD NOT EVEN PUT THE VEHICLE BACK TOGETHER. I PAID THEM $290 TO TELL ME THAT THEY COULD NOT REPAIR MY VEHICLE. I CONTACTED BOTH THE DEALER AND THE CORPORATE OFFICE AND WAS TOLD THAT THE $290 WAS ONLY TO TAKE THE VEHICLE APART NOT PUT IT BACK TOGETHER. I BELIEVE THAT MY ENGINE IS DEFECTIVE. *CB
NHTSA ODI #10054351
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
I PURCHASED A 99 HONDA PASSPORT FROM MAZDA OF KNOXVILLE LOCATED IN KNOXVILLE TN. THE VEHICLE HAD 49000 MI. 3 DAYS LATER IT STARTED MAKING NOISE IN THE ENGINE, AND ALSO THE FUEL GAUGE STOPPED WORKING AS WELL AS THE AIR CONDITIONER. I CALLED THEM BACK, THEY TOLD ME TO BRING IT BACK TO THEM. THEY KEPT IT A WEEK AND A HALF. I PICKED…
Read full complaint
I PURCHASED A 99 HONDA PASSPORT FROM MAZDA OF KNOXVILLE LOCATED IN KNOXVILLE TN. THE VEHICLE HAD 49000 MI. 3 DAYS LATER IT STARTED MAKING NOISE IN THE ENGINE, AND ALSO THE FUEL GAUGE STOPPED WORKING AS WELL AS THE AIR CONDITIONER. I CALLED THEM BACK, THEY TOLD ME TO BRING IT BACK TO THEM. THEY KEPT IT A WEEK AND A HALF. I PICKED IT UP AND BROUGHT IT HOME. THEY CLAIMED TO HAVE DONE 3700 DOLLARS WORTH OF WORK TO IT TO FIX IT. I RETURNED HOME AND 2 DAYS LATER AND HAD THE OIL CHANGED, THE PEOPLE CHANGING MY OIL ASKED ME IF THE VEHICLE HAD BEEN UNDER WATER BEFORE, I SAID I DIDN? KNOW. WHEN I HAD THE OIL CHANGED IT STARTED MAKING NOISES AGAIN. I CALLED THEM BACK AND THEY SAID THE NOISE WAS NOTHING TO WORRY ABOUT, IT IS NORMAL SO THIS TIME THEY OFFERED NO HELP. SAID IT WAS MY PROBLEM. I CONTINUED TO DRIVE THE VEHICLE AND NOW NOT ONLY IS IT MAKING NOISE BUT IT ISN?T RUNNING RIGHT. IT WILL NOT IDLE SOMETIMES AND OTHER TIMES IT WILL IDLE AT 4000 RPM TO THE POINT IT SOUNDS LIKE IT IS GOING TO EXPLODE. IT HAS DIED ON ME A NUMBER OF TIMES IN BUSY INTERSECTIONS AND IS ONLY GETTING WORSE.
NHTSA ODI #10070233
130,841 miles · Jan 15, 2004
Engine And Engine Cooling
WHILE DRIVING 80 MPH, THE VEHICLE STALLED WITHOUT WARNING. *AK WHEN THE CONSUMER PULLED OVER, HE NOTICED ALL THE FLUIDS WERE POURING OUT OF THE VEHICLE, TRANSMISSION FLUID, OIL, RADIATOR ETC. THE VEHICLE WAS TOWED TO THE DEALER AND THE CONSUMER WAS TOLD THE VEHICLE NEEDED A NEW ENGINE. *JB *NM
NHTSA ODI #10048176
Official recalls
2Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
Illustration