NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
229 reports30 miles · Jan 15, 2004
EquipmentFuel System, Gasoline
THIS LETTER IS TO COMPLAIN ABOUT THE LACK OF SERVICE I RECENTLY RECEIVED WHEN SPEAKING TO A CUSTOMER SERVICE REPRESENTATIVE. I PURCHASED MY PASSPORT IN AUGUST OF 1998. SINCE IT WAS PURCHASED, MY REAR BEVERAGE HOLDER FAILED TO STAY CLOSED. THE DEALER STATED THAT, ?IT IS JUST THE WAY IT WAS DESIGNED. THE STRIKE PLATE SEEMS TO FA…
Read full complaint
THIS LETTER IS TO COMPLAIN ABOUT THE LACK OF SERVICE I RECENTLY RECEIVED WHEN SPEAKING TO A CUSTOMER SERVICE REPRESENTATIVE. I PURCHASED MY PASSPORT IN AUGUST OF 1998. SINCE IT WAS PURCHASED, MY REAR BEVERAGE HOLDER FAILED TO STAY CLOSED. THE DEALER STATED THAT, ?IT IS JUST THE WAY IT WAS DESIGNED. THE STRIKE PLATE SEEMS TO FAIL TO MAKE PROPER CONTACT WITH THE MAGNET. ON NUMEROUS OCCASIONS, MY THREE-YEAR OLD DAUGHTER HAS TRIPPED UPON THIS BEVERAGE HOLDER. LAST YEAR, MY FUEL GAUGE STARTED TO WORK INTERMITTENTLY, NOT READING FULL WHEN FULL, DROPPING TO EMPTY WHEN THE TANK WAS FULL, AND FINALLY, NOT MOVING OFF OF EMPTY. AS A MATTER OF FACT, I BROUGHT MY CAR INTO MY LOCAL DEALER TO HAVE MY AIR CONDITIONING SYSTEM CHECKED AND THE TECHNICIAN MENTIONED TO ME THAT HE COULDN?T TAKE MY CAR FOR AS LONG OF A TEST DRIVE AS INTENDED BECAUSE MY TANK WAS EMPTY. I TOLD THE TECHNICIAN AHEAD OF TIME THAT THE FUEL GAUGE DIDN?T WORK. I CAME ACROSS TWO HONDA TECHNICAL SERVICE BULLETINS THAT COVER THESE PROBLEMS. THE FIRST, BULLETIN 98-027 WAS ISSUED ON MAY 11, 1999 AND COVERS ALL 1998 PASSPORTS. IT DESCRIBES THE SYMPTOM THAT I AM EXPERIENCING ONE OR BOTH OF THE MAGNETIC LATCHES DO NOT HOLD THE REAR BEVERAGE HOLDER CLOSED. IN ADDITION, IT DESCRIBES THE CORRECTIVE ACTION AS REPLACING THE REAR CONSOLE COVER. IF DISCOVERED DURING THE WARRANTY PERIOD, THE BULLETIN ALLOWS THE REPAIR TO BE MADE FOR FREE. IF DISCOVERED OUTSIDE OF WARRANTY, THE BULLETIN REQUIRES THE DISTRICT SERVICE MANAGER OR ZONE OFFICE TO GIVE CONSIDERATION BEFORE WORK IS TO BEGIN. THE SECOND, TECHNICAL SERVICE BULLETIN 99-004, WAS ISSUED ON SEPTEMBER 14, 1999 AND COVERS CARS THROUGH VIN NUMBER [XXX] MY VIN NUMBER IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10070734
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingCrash
LAST FEBRUARY, MY INTAKE GASKET FAILED, AND MY MECHANIC WAS TOLD BY THE HONDA PARTS MANAGER THAT THIS WAS A COMMON PROBLEM WITH MY YEAR PASSPORT. THE GASKETS WERE FAULTY. I WROTE A LETTER TO HONDA AND WAS DISMISSED BECAUSE MY WARRANTY HAD EXPIRED. THIS FEBRUARY, I WAS LOSING OIL AND ANTIFREEZE. I TOOK MY PASSPORT TO MY MECHA…
Read full complaint
LAST FEBRUARY, MY INTAKE GASKET FAILED, AND MY MECHANIC WAS TOLD BY THE HONDA PARTS MANAGER THAT THIS WAS A COMMON PROBLEM WITH MY YEAR PASSPORT. THE GASKETS WERE FAULTY. I WROTE A LETTER TO HONDA AND WAS DISMISSED BECAUSE MY WARRANTY HAD EXPIRED. THIS FEBRUARY, I WAS LOSING OIL AND ANTIFREEZE. I TOOK MY PASSPORT TO MY MECHANIC AND FOUND THAT, ALTHOUGH I REGULARLY CHANGED MY OIL AND THE ENGINE IS EXTREMELY CLEAN, THE HEAD IS CRACKED AND THE VALVES ARE WORN OUT. AGAIN, MY MECHANIC TALKS TO THE PARTS MANAGER AND FINDS OUT THAT THEY HAVE HAD 5 PASSPORTS WITH THE SAME PROBLEM IN THE LAST 6 MONTHS. THIS REPAIR IS GOING TO COST ME $3000. A 1998 VEHICLE SHOULD NOT BE HAVING THESE KIND OF PROBLEMS. THESE VEHICLES ARE BAD AND HONDA SHOULD BE HELD RESPONSIBLE.
NHTSA ODI #10069990
101,960 miles · Jan 4, 2004
Electrical System
IDLING FOR A LONG TIME, OR DRIVING AT VERY LOW SPEEDS FOR A LONG TIME (STOP-AND-GO IN A SEVERE TRAFFIC JAM) ALSO HAVING MOST OF THE VEHICLE'S ELECTRICAL EQUIPMENT TURNED WILL CAUSE THE BATTERY TO GO DEAD BECAUSE THE ALTERNATOR DOES NOT ADEQUATELY CHARGE. THIS MAY BE A SAFETY PROBLEM BECAUSE DRIVING IN THE MOUNTAINS DURING SEVER…
Read full complaint
IDLING FOR A LONG TIME, OR DRIVING AT VERY LOW SPEEDS FOR A LONG TIME (STOP-AND-GO IN A SEVERE TRAFFIC JAM) ALSO HAVING MOST OF THE VEHICLE'S ELECTRICAL EQUIPMENT TURNED WILL CAUSE THE BATTERY TO GO DEAD BECAUSE THE ALTERNATOR DOES NOT ADEQUATELY CHARGE. THIS MAY BE A SAFETY PROBLEM BECAUSE DRIVING IN THE MOUNTAINS DURING SEVERE TRAFFIC MAY CAUSE THE BATTERY TO DISCHARGE AND THE ENGINE TO STALL; NOT ALLOWING THE ABILITY TO MOVE TO SAFE POSITION. *LA
NHTSA ODI #10052368
Mileage unknown · Nov 24, 2003
Service Brakes, HydraulicCrash
PROBLEMS WITH BRAKE EQUIPMENT ON 1998 HONDA PASSPORT.*MR PRIOR TO RECALL NOTIFICATION, WHEN THE CONSUMER ATTEMPTED TO BRAKE, THE VEHICLE DID NOT RESPOND AND THEREFORE THE CONSUMER WAS UNABLE TO STOP THE VEHICLE IN TIME TO AVOID A COLLISION WITH ANOTHER VEHICLE. THE BRAKES FAILED TO RESPOND ON A SECOND OCCASION WHILE DRIVING ON …
Read full complaint
PROBLEMS WITH BRAKE EQUIPMENT ON 1998 HONDA PASSPORT.*MR PRIOR TO RECALL NOTIFICATION, WHEN THE CONSUMER ATTEMPTED TO BRAKE, THE VEHICLE DID NOT RESPOND AND THEREFORE THE CONSUMER WAS UNABLE TO STOP THE VEHICLE IN TIME TO AVOID A COLLISION WITH ANOTHER VEHICLE. THE BRAKES FAILED TO RESPOND ON A SECOND OCCASION WHILE DRIVING ON A ROUGH BUMPY PAVEMENT, AGAIN THE CONSUMER COLLIDED WITH ANOTHER VEHICLE. *JB *NM
NHTSA ODI #10048734
70,000 miles · Nov 4, 2003
Engine And Engine Cooling
I AM COMPLAINING ABOUT A PROBLEM WITH MY HONDA PASSPORT. THIS ENGINE ALSO HAS AN EXCESSIVE AMOUNT OF OIL CONSUMPTION. OIL CONSUMPTION IS SPORADIC, BUT CAN EXCEED MORE THAN TWO QUARTS PER 1000 MILES DRIVEN. OIL CONSUMPTION OCCURS REGARDLESS OF DRIVING CONDITIONS OR LOAD ON VEHICLE. IN COMBINATION WITH NO DASH WARNING, THE OIL CO…
Read full complaint
I AM COMPLAINING ABOUT A PROBLEM WITH MY HONDA PASSPORT. THIS ENGINE ALSO HAS AN EXCESSIVE AMOUNT OF OIL CONSUMPTION. OIL CONSUMPTION IS SPORADIC, BUT CAN EXCEED MORE THAN TWO QUARTS PER 1000 MILES DRIVEN. OIL CONSUMPTION OCCURS REGARDLESS OF DRIVING CONDITIONS OR LOAD ON VEHICLE. IN COMBINATION WITH NO DASH WARNING, THE OIL CONSUMPTION CAN LEAD TO ENGINE FAILURE WITHIN THE REGULAR OIL CHANGE INTERVAL, WHICH I HAD LEARNED THE HARD WAY. NOW HAVING TO REPLACE THE ENGINE.*AK
NHTSA ODI #10045398
Mileage unknown · Sep 12, 2003
Service Brakes, Air
CONSUMER RECEIVED A RECALL NOTICE FROM THE MANUFACTURER NHTSA#02-I-000-001. RECALL FAILED. PLEASE PROVIDE FURTHER INFORMATION. *PH
NHTSA ODI #10039880
Mileage unknown · Sep 12, 2003
Service Brakes, Hydraulic
DEALERSHIP DID NOT HAVE THE PARTS AVAILABLE TO PERFORM RECALL 02 I 002 00I CONCERNING ABS BRAKES. *AK *SCC *JB
NHTSA ODI #10031959
1,417 miles · Sep 10, 2003
Electrical SystemService Brakes, HydraulicSuspension
NAR 9-10-03. CONSUMER COMPLAINT ON A DEFECTIVE 1998 HONDA PASSPORT PURSUANT TO MARYLAND'S LEMON LAW. BATTERY CABLES REPLACED, BRAKE WARNING LIGHT ILLUMINATES, REAR SUSPENSION DEFECTIVE, AND BRAKES PEDAL INOPERABLE. *CB
NHTSA ODI #10039844
Mileage unknown · Sep 10, 2003
Service Brakes, Hydraulic
WHEN THE CONSUMER ATTEMPTED TO APPLY THE BRAKES, THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. *JB
NHTSA ODI #10038598
Mileage unknown · Sep 9, 2003
Suspension
WHILE DRIVING AT HIGHWAY SPEEDS VEHICLE SHAKES, CAUSING IT TO SWERVE. *AK
NHTSA ODI #10038514
Official recalls
5Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: HONDA IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98053 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration