NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
35 reportsClear category filter164,835 miles · Oct 29, 2010
Structure
TL*THE CONTACT OWNS A 1998 HONDA PASSPORT. WHILE THE VEHICLE WAS BEING ROUTINELY SERVICED, THE MECHANIC INFORMED THE CONTACT THAT THE REAR FRAME WAS CORRODED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THERE WERE NO RELATED RECALLS AND THEY WOULD NOT ASSIST. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 164…
Read full complaint
TL*THE CONTACT OWNS A 1998 HONDA PASSPORT. WHILE THE VEHICLE WAS BEING ROUTINELY SERVICED, THE MECHANIC INFORMED THE CONTACT THAT THE REAR FRAME WAS CORRODED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THERE WERE NO RELATED RECALLS AND THEY WOULD NOT ASSIST. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 164,835 AND THE CURRENT MILEAGE WAS 167,523.
NHTSA ODI #10362894
141,709 miles · Oct 8, 2010
Fuel System, GasolineStructure
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT MECHANIC FOR UNRELATED ISSUES, THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS LEAKING ABNORMALLY. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE FAILURE WAS CONFIRMED AND THE CONTACT WAS ADVISED THAT THE FAILURE COULD…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT MECHANIC FOR UNRELATED ISSUES, THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS LEAKING ABNORMALLY. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE FAILURE WAS CONFIRMED AND THE CONTACT WAS ADVISED THAT THE FAILURE COULD NOT BE REPAIRED. IN ADDITION, THE DEALER ALSO ADVISED THAT THE UNDER FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 141,709.
NHTSA ODI #10359627
98,000 miles · Oct 4, 2010
Structure
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE EXHIBITED AN UNUSUALLY LOUD BANG AND THE CONTACT IMMEDIATELY NOTICED THAT THE SUSPENSION DID NOT FEEL NORMAL. THE CONTACT DISCOVERED EXCESSIVE FRAME RUST AND THE SHOCKS WERE BEING HELD UP BY THE BODY OF THE VEHICLE. THE CONTACT TOOK THE…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE EXHIBITED AN UNUSUALLY LOUD BANG AND THE CONTACT IMMEDIATELY NOTICED THAT THE SUSPENSION DID NOT FEEL NORMAL. THE CONTACT DISCOVERED EXCESSIVE FRAME RUST AND THE SHOCKS WERE BEING HELD UP BY THE BODY OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC AND MECHANIC STATED THE VEHICLE WAS BEYOND REPAIR. THE CONTACT THEN TOOK THE VEHICLE TO AN AUTHORIZED DEALER WHERE THE DEALER INFORMED THE CONTACT THAT THE FRAME WAS DAMAGED BEYOND REPAIR AND SHOULD NOT BE DRIVEN. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY WOULD NOT ASSIST WITH REPAIRS DUE TO THE RUST ISSUE. THE CONTACT STATED THAT HE NOTICED SEVERAL COMPLAINTS VIA THE INTERNET REGARDING EXCESSIVE FRAME RUST FOR HIS YEAR, MAKE AND MODEL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000. UPDATED 01/19/11 *BF UPDATED 01/31/11. *JB
NHTSA ODI #10359164
123,000 miles · Aug 28, 2010
Structure
1998 HONDA PASSPORT WITH SEVERE FRAME ROT, ALMOST CAUSED ACCIDENT WHEN LOWER CONTROL ARM RUSTED OFF AND BROKE, THANK GOD MY KIDS WEREN'T IN THE CAR WITH ME! HAD TO GET WELDED AND NOW THE UPPER CONTROL ARMS ARE ROTTING OFF. *TR
NHTSA ODI #10352465
140,000 miles · Jul 22, 2010
Structure
OUR FAMILY OWNS A 1998 HONDA PASSPORT WITH SERIOUS FRAME RUSTING AND FRAME ROT. WE HAVE MAINTAINED AND SERVICED THE VEHICLE REGULARLY AND HAVE HAD IT SERVICED NUMEROUS TIMES. OUR INCIDENT OCCURRED WHEN WE NOTICED THAT THE VEHICLE STARTED TO DRIVE LIKE A TANK. IN OTHER WORDS IT BECAME HARD TO TURN AND YOU COULD FEEL EVERY BUMP IN…
Read full complaint
OUR FAMILY OWNS A 1998 HONDA PASSPORT WITH SERIOUS FRAME RUSTING AND FRAME ROT. WE HAVE MAINTAINED AND SERVICED THE VEHICLE REGULARLY AND HAVE HAD IT SERVICED NUMEROUS TIMES. OUR INCIDENT OCCURRED WHEN WE NOTICED THAT THE VEHICLE STARTED TO DRIVE LIKE A TANK. IN OTHER WORDS IT BECAME HARD TO TURN AND YOU COULD FEEL EVERY BUMP IN THE ROAD. UPON INSPECTION OF THE CAR I FOUND THAT THE REAR SUSPENSION OF THE CAR HAD COMPLETELY RUSTED THROUGH. ALLOWING THE REAR AXLE SPRINGS TO RIDE DIRECTLY ONTO THE CAR BODY. ALSO THE FRAME STABILIZER BAR MOUNT WAS RUSTED THROUGH AND BREAKING OFF. THE REAR FRAME SUPPORT BAR THAT CONNECTS THE REAR END OF THE FRAME TOGETHER WAS COMPLETELY RUSTED THROUGH. THIS FRAME IS SO RUSTED THOUGHT THAT YOU CAN POKE HOLES IN IT WITH YOUR FINGERS!!!!! THE ENTIRE FRAME IS COMPLETELY ROTTED THROUGH. *TR
NHTSA ODI #10344664
11,500 miles · Jun 2, 2010
Structure
TL*THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT STATED THAT THE ENTIRE UNDERBODY OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNABLE TO BE REPAIRED AND IT WAS UNSAFE TO DRIVE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 11,500. …
Read full complaint
TL*THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT STATED THAT THE ENTIRE UNDERBODY OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNABLE TO BE REPAIRED AND IT WAS UNSAFE TO DRIVE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 11,500.
NHTSA ODI #10334285
117,000 miles · May 13, 2010
EquipmentStructure
I OWN A 1998 HONDA PASSPORT, I BOUGHT IT IN 2008, AND WAS UNAWARE OF THE RUSTING PROBLEM. I WAS TOLD THAT IT WILL NOT PASS INSPECTION AT ALL BECAUSE OF THE RUST ON THE FRAME, AND THE AXLES. THAT THE TRUCK IS NOT AT ALL SAFE TO DRIVE BECAUSE OF THE RUST OF THE FRAME. I WAS ALSO TOLD THAT THE GAS TANK IS ALSO ROTTING OUT, BECAUS…
Read full complaint
I OWN A 1998 HONDA PASSPORT, I BOUGHT IT IN 2008, AND WAS UNAWARE OF THE RUSTING PROBLEM. I WAS TOLD THAT IT WILL NOT PASS INSPECTION AT ALL BECAUSE OF THE RUST ON THE FRAME, AND THE AXLES. THAT THE TRUCK IS NOT AT ALL SAFE TO DRIVE BECAUSE OF THE RUST OF THE FRAME. I WAS ALSO TOLD THAT THE GAS TANK IS ALSO ROTTING OUT, BECAUSE THERE IS SO MUCH RUST UNDERNEATH THE TRUCK ON THE FRAME. I DID PAY A MECHANIC TO FIX SOME OF THE FRAME,AND AXLE TO WELD SOME NEW METAL ONTO THE FRAME, BUT THAT DIDN'T HELP IN THE INSPECTION PROCESS, THE TRUCK STILL FAILED TO PAS INSPECTION. THIS TRUCK HAS BEEN SITTING IN MY DRIVEWAY FOR OVER A YEAR NOW AND I HAVE NO WAY TO FIX IT, OR DRIVE IT. *TR
NHTSA ODI #10330330
200,000 miles · May 8, 2010
StructureCrash
REAR FRAME ON MY 1998 HONDA PASSPORT BROKE AND DRIVER REAR CONTROL BAR BROKE OFF FRAME. *TR
NHTSA ODI #10329415
153,492 miles · May 7, 2010
Structure
THE FRAME OF MY 1998 HONDA PASSPORT RUSTED AND BROKE IN OCT 09 WHILE AT SCHOOL. IT COST ME OVER $1500.00 TO HAVE IT WELDED (REPAIRED), SO I COULD DRIVE IT HOME. WHEN I GOT IT HOME IN MAY I HAD MY GARAGE CHECK THE CAR'S REPAIR JOB AND CONDITION. THE WELD JOB ON THE LEFT MID-FRAME HELD, BUT THE REAR OF THE FRAME WAS IN BAD SH…
Read full complaint
THE FRAME OF MY 1998 HONDA PASSPORT RUSTED AND BROKE IN OCT 09 WHILE AT SCHOOL. IT COST ME OVER $1500.00 TO HAVE IT WELDED (REPAIRED), SO I COULD DRIVE IT HOME. WHEN I GOT IT HOME IN MAY I HAD MY GARAGE CHECK THE CAR'S REPAIR JOB AND CONDITION. THE WELD JOB ON THE LEFT MID-FRAME HELD, BUT THE REAR OF THE FRAME WAS IN BAD SHAPE. THE REAR OF THE FRAME AND COIL SPRINGS ETC. HAD TOTALLY RUSTED AND DETERIORATED TO THE POINT THAT THE CAR WAS SAGGING AND UNSTABLE AND UNSAFE TO OPERATE. THE BODY, ENGINE, AND TRANSMISSION ARE FINE. THE FRAME ACTUALLY HAS HOLES RUSTED THROUGH IT AND CRUMBLES IN YOUR HANDS. THE CAR IS ECONOMICALLY UNREPAIRABLE AND I HAVE TO JUNK THE CAR. I HAVE LEASED ANOTHER VEHICLE TO GET TO WORK. *TR
NHTSA ODI #10329304
96,000 miles · May 6, 2010
Structure
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) 1998 HONDA PASSPORT WITH ALMOST TOTAL FRAME ROT OUT VIN NUMBER IS [XXX] I NOTICE THIS WHEN UP ON A LIFT AT MY MECHANICS GARAGE THEN I SEE ALL THE COMPLAINT ON THE WEB ABOUT THE FRAME ROT. MY TRUCK IS IN PERFECT SHAPE OTHERWISE AND …
Read full complaint
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) 1998 HONDA PASSPORT WITH ALMOST TOTAL FRAME ROT OUT VIN NUMBER IS [XXX] I NOTICE THIS WHEN UP ON A LIFT AT MY MECHANICS GARAGE THEN I SEE ALL THE COMPLAINT ON THE WEB ABOUT THE FRAME ROT. MY TRUCK IS IN PERFECT SHAPE OTHERWISE AND , WAS TOLD IT CAN NOT BE FIX.. I AM LOW INCOME AND CANNOT AFFORD A NEW TRUCK AND HAVE JUST PUT IN 800 + DOLLARS OF ENGINE WORK.. I M AM HOPING SOMETHING CN BE DONE , BEFORE ME OR A FAMILY GET HURT OR KILLED THANK GOD I ONLY TRAVEL 6 MILES A DAY TO AND FROM WORK I PRAY EVERY DAY THAT IT DOES NOT LET GO AND HOPE WE CAN GET THE BALL ROLLING ON THESE COMPANIES HONDA AND ISUZU YOU MAY CONTACT ME AT [XXX] *TR
NHTSA ODI #10329181
Official recalls
5Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: HONDA IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98053 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration