IllustrationTHE CLUTCH, PRESSURE PLATE AND THROW OUT BEARING, FAILED. ALSO, THERE WERE STRESS CRACKS IN THE TRANSMISSION CASING. *AK
1994 Honda Passport
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Honda Passport do not stand out strongly from the model-year median of 60.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 36 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports0 fire reports9 injury reports
Power Train complaints
2 reportsI HAD BOTH DRIVERS AND PASSENGERS SIDE REAR AXLE SEALS REPLACED ONCE AND NOW I NEED ANOTHER PASSENGER SIDE REPLACED IN THE NEAR FUTURE. I READ THAT THE 1995 AND 1996 MODELS HAVE THIS PROBLEM. I DO NOT ABUSE THE TRUCK AND MY BELIEF IT IS A MANUFACTORING DEFECT.*AK
Official recalls
402V281000 · Seat Belts:front:buckle Assembly
Oct 15, 2002
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MID-DECEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
97V034002 · Electrical System:alternator/generator/regulator
Jan 1, 1997
AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.
Consequence & remedy
Consequence: THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.
96V170003 · Seat Belts:front:anchorage
Sep 17, 1996
THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.
94V132000 · Engine And Engine Cooling:engine
Jul 19, 1994
CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.
Consequence & remedy
Consequence: THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.
Remedy: DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ02009 · Seat Belt Latch Failures
Opened Apr 11, 2002 · Closed Dec 17, 2002
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts:front:buckle Assembly
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.
Seat Belts
TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.