NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
26 reportsClear category filterMileage unknown · Dec 16, 2025
EngineFuel/propulsion System
After driving for 2 hrs in single digit temperatures I entered the on ramp to interstate freeway. I lost power, couldn’t accelerate further and the Check engine light was flashing. I pulled over on the 4 lane interstate, turned off my car and restarted. CEL went away. This is the 2nd time in 2 Winters this has occurred during co…
Read full complaint
After driving for 2 hrs in single digit temperatures I entered the on ramp to interstate freeway. I lost power, couldn’t accelerate further and the Check engine light was flashing. I pulled over on the 4 lane interstate, turned off my car and restarted. CEL went away. This is the 2nd time in 2 Winters this has occurred during cold weather. Both on exit/entrance ramps when trying to accelerate after turning with traffic behind me. This can only be reproduced in specific situations and diagnostics are not stored. Honda has a service bulletin on this issue 24-085. I feel it should be covered on all vehicles, regardless of warranty status due to the safety risk.
NHTSA ODI #11705252
Mileage unknown · Sep 9, 2025
EngineUnknown Or Other
When attempting to restart from the autostop function (i.e. the fuel economy function), the vehicle fails to restart successfully. This has happened on multiple occasions. It is not a battery problem and I have had the battery tested and even replaced (by Honda) and the problem has continued. The vehicle will stutter, stall or e…
Read full complaint
When attempting to restart from the autostop function (i.e. the fuel economy function), the vehicle fails to restart successfully. This has happened on multiple occasions. It is not a battery problem and I have had the battery tested and even replaced (by Honda) and the problem has continued. The vehicle will stutter, stall or even completely shut down. This has happened when I have been at intersections and on busier roads or even in traffic on the highway. Its very concerning to me and seems extremely unsafe. No warning signs come in this scenario until the vehicle shuts down and the regular dash light engages indicating the engine is inoperable. I have today's date below but this has been happening consistently the last several months.
NHTSA ODI #11686132
Mileage unknown · Aug 27, 2025
Electrical SystemEngineSuspension
Can has been making a popping noise that can be felt in the steering wheel for 2 years. Honda has told me nothing was wrong after taking it in 4 times. Now my car keeps stalling at lights, sometimes it takes a while to get it to restart, and they can not figure out why. They keep saying the battery is fine and diagnostics finds …
Read full complaint
Can has been making a popping noise that can be felt in the steering wheel for 2 years. Honda has told me nothing was wrong after taking it in 4 times. Now my car keeps stalling at lights, sometimes it takes a while to get it to restart, and they can not figure out why. They keep saying the battery is fine and diagnostics finds nothing.
NHTSA ODI #11683344
Mileage unknown · Aug 20, 2025
Engine
While stopped at a stop light at an intersection in our 2021 Hond Odyssey, the idle auto off feature kicked in, and then as we let off the brake and went to hit the gas to move forward the car shut off completely. The car had to be restarted by applying the brake and pressing the start/stop ignition button. This is not the first…
Read full complaint
While stopped at a stop light at an intersection in our 2021 Hond Odyssey, the idle auto off feature kicked in, and then as we let off the brake and went to hit the gas to move forward the car shut off completely. The car had to be restarted by applying the brake and pressing the start/stop ignition button. This is not the first time this has happened with this vehicle. This also happened a series of times in 2023 and Honda performed a series of software updates, replaced the battery, and replaced a sensor on the battery. However, now two years later the idle auto off issue occured again.
NHTSA ODI #11681925
Mileage unknown · Jun 30, 2025
Electrical SystemEngine
2021 Odyssey EXL shuts off completely in traffic stop and go conditions. Happened three times in a 2 week period. Twice in city roads at traffic stop light and once in highway when the cars are in stop / go mode due to heavy traffic. Engine switches off completely and puts itself in "P" mode, all light comes on as if in accessor…
Read full complaint
2021 Odyssey EXL shuts off completely in traffic stop and go conditions. Happened three times in a 2 week period. Twice in city roads at traffic stop light and once in highway when the cars are in stop / go mode due to heavy traffic. Engine switches off completely and puts itself in "P" mode, all light comes on as if in accessory mode, radio switches off, all doors unlocked. To get going, the driver had to press brake pedal and start the car again (via Engine Start /Stop button). This issue started in the car at 43K miles. Never had any issue with mine before that. But it is scary especially the engine switch off in highway and traffic stop light.
NHTSA ODI #11670208
Mileage unknown · Jun 30, 2025
Electrical SystemEngineForward Collision Avoidance
2021 Odyssey EXL the Electric parking brake 'issue' warning comes on while driving and collision mitigation warning / lane assist switches off and flashes in console; when this happens the car continues to run but the dashboard warning lights comes up for Parking brake / Collision Warning and or Lane assist. It gets cleared afte…
Read full complaint
2021 Odyssey EXL the Electric parking brake 'issue' warning comes on while driving and collision mitigation warning / lane assist switches off and flashes in console; when this happens the car continues to run but the dashboard warning lights comes up for Parking brake / Collision Warning and or Lane assist. It gets cleared after I turn on/off the car couple of times and drive for approximately 5 miles. Those features had to be turned on manually, once the car is in parked mode, again. The issue started in the car at around 48K miles. Never had any issue with it before that.
NHTSA ODI #11670202
Mileage unknown · Apr 7, 2025
Engine
In stop and go highway traffic. Engine cut off when at a stop during "Ecoboost." Had to turn off car and restart. Was able to restart with no problem. Full tank of gas. Fresh oil. No error messages before and after
NHTSA ODI #11653192
Mileage unknown · Feb 2, 2025
Electrical SystemEngine
This happened twice to us. While stopped at the red light the car suddenly shuts off and won’t start. We had to press and hold the start button for 5 seconds for the van to start. It appears that on both times the car just stalled.
NHTSA ODI #11640161
Mileage unknown · Oct 25, 2024
EngineFuel/propulsion SystemUnknown Or Other
After having the Honda Dealership perform an oil change and software update 23-008 (updating the Auto Idle Stop Software) last week, my engine stalled while at a busy intersection (PA turnpike/70 junction) during a road trip. At the long stop light the auto idle function engaged and the engine turned off. When the stop light tur…
Read full complaint
After having the Honda Dealership perform an oil change and software update 23-008 (updating the Auto Idle Stop Software) last week, my engine stalled while at a busy intersection (PA turnpike/70 junction) during a road trip. At the long stop light the auto idle function engaged and the engine turned off. When the stop light turned green and I lifted my foot off the brake and pressed the gas the engine shut down and automatically went into Park. I had to press the start/stop button to fully turn off then turn back on the car to get the engine to restart. This is with a giant semitruck honking right behind me. The auto idle feature does not work. It sounds terrible every time the engine restarts after it has been engaged. There really should be an option to allow users to permanently disable it, and not have to remember to turn it off every time they start the car--terrible user experience.
NHTSA ODI #11621957
Mileage unknown · Sep 18, 2024
Engine
My Honda Odyssey is experiencing an issue where it intermittently fails to restart automatically after coming to a stop and engaging the idle stop feature. Despite following Honda's recommendations, which included applying Service Bulletin 23-008 (updating the PGM-FI Idle Stop Software) and replacing the battery, the problem per…
Read full complaint
My Honda Odyssey is experiencing an issue where it intermittently fails to restart automatically after coming to a stop and engaging the idle stop feature. Despite following Honda's recommendations, which included applying Service Bulletin 23-008 (updating the PGM-FI Idle Stop Software) and replacing the battery, the problem persists. I've also had the vehicle inspected at two different dealerships, with no resolution. I discovered Service Bulletin 23-009 on your website, which directly addresses this exact issue and extends the warranty for the Ridgeline, Pilot, and Passport models. Given that my Odyssey shares the same engine, it's concerning that it's not included in this bulletin. I believe it's unfair that I'm being forced to pay dealership fees to diagnose and fix a safety issue that Honda has already acknowledged and addressed for other vehicles with the same engine. I urge you to reconsider the exclusion of the Odyssey from Service Bulletin 23-009 and provide a solution that doesn't burden owners with unnecessary costs.
NHTSA ODI #11615252
Official recalls
8May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Apr 9, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2022 Odyssey vehicles. A software programming error can cause the side and side curtain air bags to deploy unexpectedly.
Consequence & remedy
Consequence: Air bags that deploy unexpectedly can increase the risk of injury.
Remedy: Dealers will reprogram the supplemental restraint system (SRS) electronic control unit (ECU) software or replace the ECU, as necessary, free of charge. Owner notification letters were mailed May 27, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is UNW. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning April 16, 2026. The information in your report suggests that Honda (American Honda Motor Co.) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.
Dec 17, 2025
Vantage Mobility, LLC (VM) is recalling certain 2021-2026 Honda Odyssey, 2021-2025 Chrysler Pacifica, and Toyota Sienna vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Dealers will inspect and replace the retractors, free of charge. Owner notification letters was mailed January 27, 2026. Owners may contact Vantage Mobility customer service at 1-800-488-9082.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Jan 14, 2021
Braun Corporation (Braun) is recalling certain 2018-2021 Braun-modified Honda Odyssey vehicles. The fuel tank assembly installed by Braun may be susceptible to the fuel tank overfilling into the charcoal canister. If the charcoal canister fills with a sufficient amount of fuel, fuel may leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of fire.
Remedy: Braun will notify owners, and dealers will inspect vehicles. If evidence of a fuel leak is present, a new fuel tank assembly and a new Honda charcoal canister will be installed, free of charge. The recall began February 22, 2021. Owners may contact Braun customer service at 1-800-488-0359.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE25018 · Inadvertent Deployment Of Side Air Bags
Opened Oct 28, 2025 · Closed Jun 25, 2026
Status: closed (inferred from source dates) · Air Bags; Air Bags:sensor:side Impact; Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Air Bags
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:sensor:side Impact
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Air Bags:side/window
On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag deployment. In the recall filing, the company stated that “[a]s of April 2, 2026, Honda has had 130 warranty claims, 25 reports of an injury, and no reports of death related to this issue from January 24, 2017 – April 2, 2026.” Honda states that the Supplemental Restraint System (SRS) Electronic Control Unit (ECU) contains incorrect deployment parameters for the side thorax and side curtain air bags, which may cause inadvertent deployment when the vehicle encounters strong road impacts, such as driving over potholes, speed bumps, or road debris. Honda stated that the SRS control logic for the second and third rows of seating contained an insufficient deployment threshold margin, allowing signal inputs to be misinterpreted as side impacts and causing inadvertent deployment of the side thorax and side curtain air bags. Recall 26V227 states that dealers will reprogram or replace the SRS ECU with improved air bag deployment parameters. Consumers received notice of this recall in late May 2026. In view of the recall being conducted by Honda, ODI is closing this Preliminary Evaluation (PE). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration