NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
71 reportsClear category filter41,618 miles · Mar 15, 2010
Engine And Engine Cooling
AN OBJECT, MOST LIKELY ROAD DEBRIS LIKE ROCKS OR PEBBLES, IMPACTED THE A/C CONDENSER CAUSING THE A/C TO LEAK RENDERING THE SYSTEM INOPERABLE. DUE TO HONDA'S DESIGN OF THE FRONT BUMPER, THE A/C CONDENSER IS COMPLETELY EXPOSED TO DEBRIS. IN ORDER TO FIX THE PROBLEM THE CONDENSER MUST BE REPLACED WHICH WOULD COST AN ESTIMATED BIL…
Read full complaint
AN OBJECT, MOST LIKELY ROAD DEBRIS LIKE ROCKS OR PEBBLES, IMPACTED THE A/C CONDENSER CAUSING THE A/C TO LEAK RENDERING THE SYSTEM INOPERABLE. DUE TO HONDA'S DESIGN OF THE FRONT BUMPER, THE A/C CONDENSER IS COMPLETELY EXPOSED TO DEBRIS. IN ORDER TO FIX THE PROBLEM THE CONDENSER MUST BE REPLACED WHICH WOULD COST AN ESTIMATED BILL OF CLOSE TO $1000 IN PARTS AND LABOR. EVEN AFTER THE FIX, THE CONDENSER STILL REMAINS EXPOSED AND THE LIKELIHOOD OF THIS EVENT HAPPENING AGAIN REMAINS HIGH DUE TO THE DESIGN OF THE FRONT BUMPER. THIS PROBLEM WAS OBVIOUSLY FIXED BY HONDA IN THE 2008 YEAR BY INSTALLING A "HONEYCOMB" TYPE GRILLE TO COVER THIS AREA TO REDUCE THE CHANCE OF DEBRIS IMPACTING THE CONDENSER. *TR
NHTSA ODI #10320050
35,000 miles · Mar 15, 2010
Electrical SystemEngine And Engine CoolingFire
MY WIFE LEFT WORK AND DROVE HOME, APPROXIMATELY 2MILES, AND ADVISED SHE SMELLED/SAW SMOKE COMING FROM THE REAR OF THE VEHICLE. SHE EXITED THE VEHICLE AND ADVISE THE VEHICLE WAS ON FIRE. FIRE DEPARTMENT RESPONDED AND PUT OUT THE FIRE, HOWEVER THE VEHICLE WAS A TOTAL LOSS. LOCAL FIRE INSPECTOR INVESTIGATED AND ADVISE THE SOURC…
Read full complaint
MY WIFE LEFT WORK AND DROVE HOME, APPROXIMATELY 2MILES, AND ADVISED SHE SMELLED/SAW SMOKE COMING FROM THE REAR OF THE VEHICLE. SHE EXITED THE VEHICLE AND ADVISE THE VEHICLE WAS ON FIRE. FIRE DEPARTMENT RESPONDED AND PUT OUT THE FIRE, HOWEVER THE VEHICLE WAS A TOTAL LOSS. LOCAL FIRE INSPECTOR INVESTIGATED AND ADVISE THE SOURCE OF IGNITION WAS IN THE RIGHT REAR OF THE VEHICLE IN THE AREA OF THE REAR A/C UNIT AND PBC. I CONTACTED THE MANUFACTURER'S CUSTOMER SERVICE AND THEY RESPONDED THAT "IF YOUR INSURANCE COMPANY DOES NOT SUBROGATE, THERE IS NOTHING THEY CAN DO." THE RECENT SERVICE ON THE VEHICLE WAS AN OIL CHANGE AND NEW TIRES APPROXIMATELY ONE MONTH PRIOR. *TR
NHTSA ODI #10320041
12,000 miles · Oct 19, 2009
Engine And Engine Cooling
DEBRIS MUST HAVE HIT MY AIR CONDITIONER CONDENSER AND PUT A HOLE IN IT. ONLY 12,150 MILES ON IT AND JUST OUT OF WARRANTY BY 2 MONTHS. COST ME $1334 TO HAVE IT REPLACED. *TR
NHTSA ODI #10288974
59,400 miles · Sep 9, 2009
Engine And Engine Cooling
2006 HONDA ODYSSEY VEHICLE WAS SMOKING UPON ARRIVING AT DESTINATION. THE SMOKE WAS COMING FROM THE RIGHT FRONT OF VAN, ODOR PRESENT. TWO DAYS LATER, AIR CONDITIONING WAS NOT WORKING. TOOK VAN TO DEALERSHIP. THEY SAID THAT A ROCK MUST HAVE HIT THE CONDENSER. THEY SAID THIS IS NOT COVERED BY MY 60,000 MILE HONDA CARE WA…
Read full complaint
2006 HONDA ODYSSEY VEHICLE WAS SMOKING UPON ARRIVING AT DESTINATION. THE SMOKE WAS COMING FROM THE RIGHT FRONT OF VAN, ODOR PRESENT. TWO DAYS LATER, AIR CONDITIONING WAS NOT WORKING. TOOK VAN TO DEALERSHIP. THEY SAID THAT A ROCK MUST HAVE HIT THE CONDENSER. THEY SAID THIS IS NOT COVERED BY MY 60,000 MILE HONDA CARE WARRANTY BECAUSE IT WASN'T MECHANICAL. THERE ARE PLENTY OF COMPLAINTS ABOUT THIS, EVEN THE DEALER SAID THIS IS VERY COMMON WITH THE ODYSSEY. SOUNDS LIKE A DESIGN FLAW & A RECALL IS DUE. *TR
NHTSA ODI #10283416
51,900 miles · Jul 31, 2009
Engine And Engine Cooling
AIR CONDITIONING FAILED AT 51,900 MILES. DEBRIS POKED A HOLE IN THE CONDENSER. $1000 TO FIX. NOT UNDER WARRANTY. IT COULD HAPPEN AGAIN SO I TRADED IT IN FOR A 2009 MODEL! *TR
NHTSA ODI #10278956
55,000 miles · Jul 23, 2009
Engine And Engine Cooling
I OWN A 2006 ODYSSEY AND AIR CONDITIONING CONDENSER FAILED " DUE SMALL ROCK PUNCTURING HOLE". INTERNET SEARCH SHOWED JUST HOW COMMON THIS PROBLEM IS WITH THE ODYSSEY. THIS PROBLEM IS NOT COVERED UNDER WARRANTY BECAUSE THEY STATE IT IS AN "ACT OF NATURE". I WAS TOLD I COULD TRY TO HAVE IT COVERED UNDER MY CAR INSURANCE JUST LIKE…
Read full complaint
I OWN A 2006 ODYSSEY AND AIR CONDITIONING CONDENSER FAILED " DUE SMALL ROCK PUNCTURING HOLE". INTERNET SEARCH SHOWED JUST HOW COMMON THIS PROBLEM IS WITH THE ODYSSEY. THIS PROBLEM IS NOT COVERED UNDER WARRANTY BECAUSE THEY STATE IT IS AN "ACT OF NATURE". I WAS TOLD I COULD TRY TO HAVE IT COVERED UNDER MY CAR INSURANCE JUST LIKE A ROCK HITS A WINDSHIELD AND IT GETS REPLACED. ( WHY SHOULD THE INSURANCE INDUSTRY PAY FOR WHAT IS OBVIOUSLY A DESIGN FLAW!) THE ADVERTISEMENT OF LOW COST OF OWNERSHIP IS FALSE, BECAUSE JUST THIS REPLACEMENT IS GOING TO COST $750 IN LESS THAN 3 YEARS OF OWNERSHIP. *TR
NHTSA ODI #10278062
50,000 miles · Jun 27, 2009
Engine And Engine Cooling
A/C CONDENSER WENT OUT DUE TO "ROCK HITTING IT". *TR
NHTSA ODI #10275111
Mileage unknown · Jun 21, 2009
Engine And Engine CoolingEquipment
I HAVE A 2006 HONDA ODYSSEY AND THE AC SUDDENLY STOP BLOWING COLD AIR. I LATER FOUND OUT THAT THE CONDENSER WAS DAMAGED BY THE ROCK HITTING IT WHILE DRIVING ON A HIGHWAY. I NOTICED THAT THERE ARE A LOT OF PEOPLE WHO OWN AN ODYSSEY ALSO EXPERIENCE A SIMILAR PROBLEM. THIS IS CONSIDER AS A DESIGN PROBLEM FROM HONDA NOT HAVING ANY P…
Read full complaint
I HAVE A 2006 HONDA ODYSSEY AND THE AC SUDDENLY STOP BLOWING COLD AIR. I LATER FOUND OUT THAT THE CONDENSER WAS DAMAGED BY THE ROCK HITTING IT WHILE DRIVING ON A HIGHWAY. I NOTICED THAT THERE ARE A LOT OF PEOPLE WHO OWN AN ODYSSEY ALSO EXPERIENCE A SIMILAR PROBLEM. THIS IS CONSIDER AS A DESIGN PROBLEM FROM HONDA NOT HAVING ANY PROTECTION TO THE CONDENSER AS ROCKS CAN HIT THE CONDENSER FROM THE HIGHWAY AND DAMAGE IT. THIS COST ME ALMOST $800 TO FIX. I HAVE 2 SMALL CHILDREN AND EVENTHOUGH I GOT IT FIXED, THE CONDENSER CAN GET DAMAGED ANYTIME AS THERE IS NOTHING PROTECTING IT. *TR
NHTSA ODI #10274532
36,000 miles · Jun 2, 2009
Engine And Engine Cooling
1. UNKNOWN - RESEARCH SUGGESTS BAD DESIGN, ROCKS FLY UP INTO LOWER GRILL AND PUNCTURE CONDENSER. NO PROTECTION OF A/C CONDENSER. 2. ONCE - AIR CONDITIONING FAILED 3. HONDA DEALERSHIP REPLACED CONDENSER AT A CHARGE OF $870. DEALERSHIP REFUSED TO FIX FREE OF CHARGE OR REDUCE FEE. *TR
NHTSA ODI #10272612
37,000 miles · May 22, 2009
Engine And Engine Cooling
A/C PROBLEMS YEARLY, AC CONDENSER NEEDS TO BE REPLACED DUE TO HOLE, DESIGN FLAW FROM HONDA MAKES THIS A RECURRING PROBLEM, NOT COVERED UNDER WARRANTY. *TR
NHTSA ODI #10269708
Official recalls
3Mar 14, 2014
American Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.
Consequence & remedy
Consequence: A fuel leak increases the risk of a fire.
Remedy: Parts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover will get a replacement, original cover. All vehicles, including those receiving the interim repair, will get an improved cover when they are available. Owners may contact Honda at 1-800-999-1009. The recall numbers associated with this campaign are JD9 (inspection and/or preliminary part replacement) and JE0 (final parts replacement).
Oct 22, 2010
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2007 ODYSSEY AND ACURA RL VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS A LUBRICANT FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER SEAL FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Jul 26, 2006
ON CERTAIN PASSENGER VEHICLES AND MOTORCYCLES, THE OWNER'S MANUALS CONTAIN INCORRECT CONTACT INFORMATION FOR THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S (NHTSA) VEHICLE SAFETY HOTLINE.
Consequence & remedy
Consequence: THE LANGUAGE IN THE OWNER'S MANUALS IS NOT IN ACCORDANCE WITH THE CURRENT MANDATORY REQUIREMENTS.
Remedy: HONDA WILL SEND A POSTCARD TO DEALERS AND OWNERS WITH THE CORRECT NHTSA VEHICLE SAFETY HOTLINE INFORMATION AND WITH INSTRUCTIONS TO INSERT THE CARD INTO THE "REPORTING SAFETY DEFECTS" SECTION OF THE OWNER'S MANUAL. THE RECALL BEGAN ON AUGUST 2, 2006. OWNERS MAY CONTACT HONDA AT 1-800-999-1009, ACURA AT 1-800-382-2238 OR HONDA MOTORCYCLES AT 1-866-784-1870.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE09024 · Air In Brake System
Opened May 13, 2009 · Closed Oct 19, 2009
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS RECEIVED 69 COMPLAINTS, AND HONDA HAS RECEIVED 613 COMPLAINTS AND FIELD REPORTS, ALLEGING LOW/SOFT/SPONGY BRAKE PEDAL TRAVEL IN MODEL YEAR (MY) 2006 THROUGH 2008 HONDA ODYSSEY MINIVANS.TWENTY-SIX ODI COMPLAINTS WERE ALSO REPORTED TO HONDA, RESULTING IN A TOTAL COMPLAINT COUNT OF 656.SOME COMPLAINTS ALLEGE THAT THE CONDITION RESULTED IN EXTENDED STOPPING DISTANCES, INCLUDING SOME REPORTS OF ROLLING PAST STOP SIGNS OR TRAFFIC LIGHTS.THERE ARE 14 ALLEGED CRASHES IN THE SUBJECT VEHICLE POPULATION RELATED TO LOW/SOFT PEDALS. IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PRELIMINARY EVALUATION PE09-024, HONDA INDICATED THAT SMALL AMOUNTS OF AIR MAY ENTER THE BRAKE SYSTEM DURING INITIAL DIAGNOSTICS OF THE VEHICLE STABILITY ASSIST (VSA) MODULATOR WHILE THE PUMP IS BRIEFLY ACTUATED FOR SYSTEM DIAGNOSTICS AFTER THE ENGINE IS STARTED.THE AMOUNT OF AIR GRADUALLY INCREASES WITH EACH SUCCESSIVE ENGINE START CYCLE, RESULTING IN PROGRESSIVELY INCREASING BRAKE PEDAL STROKE.ACCORDING TO HONDA, THE CONDITION DOES NOT PRESENT A SIGNIFICANT RISK TO MOTOR VEHICLE SAFETY BECAUSE THE PEDAL STROKE GRADUALLY INCREASES, PROVIDING THE DRIVER WITH INFORMATION THAT THE BRAKE PEDAL HEIGHT IS CHANGING AND REQUIRES ATTENTION.HONDA HAS FURTHER INDICATED THAT THERE IS NO DETERIORATION OF BRAKING PERFORMANCE CAUSED BY THE SUBJECT CONDITION, EVEN THOUGH THE PEDAL HEIGHT AND FEEL ARE DIFFERENT, UNTIL PEDAL STROKE HAS REACHED THE END OF TRAVEL AND THE DRIVER CANNOT PRODUCE ANY ADDITIONAL BRAKE LINE PRESSURE.HONDA STATES THAT IT IS UNAWARE OF ANY VEHICLES THAT HAVE REACHED SUCH A CONDITION AND HONDA TESTING USING A LEAKING FIELD RETURN MODULATOR INDICATES THAT IT WOULD TAKE OVER A YEAR BEFORE THE PEDAL TRAVEL WOULD REACH ITS LIMIT DURING HARD STOPS WITH 200 N (45 LBF) OF PEDAL EFFORT - THE NOMINAL FORCE REQUIRED TO REACH ABS BRAKING MODE. ODI'S ANALYSIS OF WARRANTY DATA INDICATES THAT THE MY 2007-08 ODYSSEY VEHICLES HAVE EXPERIENCED THE ALLEGED DEFECT AT A RATE OF 0.67%.THE MY 2006 ODYSSEY VEHICLES HAVE EXPERIENCED THE ALLEGED DEFECT AT A SIGNIFICANTLY LOWER RATE (0.04%) THAN THE MY 2007-08 ODYSSEY.HONDA IMPLEMENTED A DESIGN CHANGE IN THE MY 2007 VEHICLES TO CHANGE THE VSA DIAGNOSTIC PROGRAM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-014) FOR THE MY 2007-08 ODYSSEY VEHICLES TO CONTINUE TO INVESTIGATE THE SCOPE, FREQUENCY, AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
Illustration