NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
57 reportsClear category filter54,000 miles · Jul 31, 2006
Service Brakes, HydraulicSuspension
DT*: THE CONTACT STATED WHILE THE BRAKE PEDAL WAS DEPRESSED, THERE WAS A GROWL AND INTERMITTENT VIBRATION. THE DEALERSHIP ALERTED THE CONTACT THAT THE MANUFACTURER IS TRYING TO DESIGN A BETTER BRAKE PAD. THERE IS ALSO A HEAVY VIBRATION WHILE THE ECONOMY LOAD LIGHT IS ILLUMINATED. THE DEALERSHIP HAS REPLACED THE ENGINE MOUNTS,…
Read full complaint
DT*: THE CONTACT STATED WHILE THE BRAKE PEDAL WAS DEPRESSED, THERE WAS A GROWL AND INTERMITTENT VIBRATION. THE DEALERSHIP ALERTED THE CONTACT THAT THE MANUFACTURER IS TRYING TO DESIGN A BETTER BRAKE PAD. THERE IS ALSO A HEAVY VIBRATION WHILE THE ECONOMY LOAD LIGHT IS ILLUMINATED. THE DEALERSHIP HAS REPLACED THE ENGINE MOUNTS, ROTATED AND BALANCED THE TIRES, BUT THE PROBLEM PERSISTS.
NHTSA ODI #10163977
Mileage unknown · Jul 14, 2006
Service Brakes, HydraulicSuspension
MAY 2005- RIGHT FRONT WHEEL BEARING REPLACED. MAY 2006 LEFT FRONT WHEEL BEARING REPLACED DUE TO COMPLAINT OF EXCESSIVE STEERING WHEEL VIBRATION WHEN BRAKING AND WHEN DRIVING AT HIGHWAY SPEEDS. PROBLEM NOT RESOLVED. JULY 2006 FRONT BRAKE PADS REPLACED AND FRONT ROTORS REPLACED. STEERING WHEEL VIBRATION STILL EXISTS AT HIGHWAY…
Read full complaint
MAY 2005- RIGHT FRONT WHEEL BEARING REPLACED. MAY 2006 LEFT FRONT WHEEL BEARING REPLACED DUE TO COMPLAINT OF EXCESSIVE STEERING WHEEL VIBRATION WHEN BRAKING AND WHEN DRIVING AT HIGHWAY SPEEDS. PROBLEM NOT RESOLVED. JULY 2006 FRONT BRAKE PADS REPLACED AND FRONT ROTORS REPLACED. STEERING WHEEL VIBRATION STILL EXISTS AT HIGHWAY SPEEDS. *JB
NHTSA ODI #10162400
16,000 miles · Jun 16, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED THERE IS A LOUD GRINDING NOISE HEARD WHILE APPLYING THE BRAKES. EXTRA PRESSURE IS NEEDED ON THE BRAKE PEDAL TO SUFFICIENTLY STOP THE VEHICLE. THE DEALERSHIP HAS INSPECTED THE VEHICLE FOUR TIMES AND DETERMINED THE PROBLEM CANNOT BE DUPLICATED.
NHTSA ODI #10160016
Mileage unknown · Jun 6, 2006
Service Brakes, Hydraulic
INTERMITTENT GRINDING NOISE FROM FRONT AND REAR BRAKES, ASSOCIATED WITH DELAYED STOPPING AND BRAKE FEELING "SOFT". DEALER STATED "GRAVEL IN BRAKES". UNABLE TO REPRODUCE AT DEALERS. MULTIPLE TRIPS TO DEALER AND FINALLY REPRODUCED. INFORMED THAT WAS CAUSED BY FAULTY BRAKE PADS AND HONDA NEEDED TO DEVELOP IMPROVED PADS. 9 MONT…
Read full complaint
INTERMITTENT GRINDING NOISE FROM FRONT AND REAR BRAKES, ASSOCIATED WITH DELAYED STOPPING AND BRAKE FEELING "SOFT". DEALER STATED "GRAVEL IN BRAKES". UNABLE TO REPRODUCE AT DEALERS. MULTIPLE TRIPS TO DEALER AND FINALLY REPRODUCED. INFORMED THAT WAS CAUSED BY FAULTY BRAKE PADS AND HONDA NEEDED TO DEVELOP IMPROVED PADS. 9 MONTHS BEFORE DEALER INFORMED ME THAT NEW PADS WERE AVAILABLE, DESPITE MULTIPLE CALLS AND VISITS TO THE DEALER. ALL FOUR PADS AND ROTORS REPLACED. IT FEELS LIKE A NEW BRAKING SYSTEM. *JB
NHTSA ODI #10159081
8,300 miles · Jun 5, 2006
Service Brakes, Hydraulic
GRINDING, PULSATING HARD TO STOP BRAKES AT 8500 MILES. HONDA STATED NOT A SAFETY ISSUE. ISSUE GOT WORSE AND FINALLY AFTER 13 ATTEMPTS THROUGH 2 DEALERS AND THEIR CUSTOMER RELATIONS LINE, I FILED WITH THE BETTER BUSINESS BUREAU. IT WAS DEEMED IN THE ARBITRATION HEARING THAT THESE BRAKES WERE INDEED A SAFETY ISSUE. POOR BRAKE …
Read full complaint
GRINDING, PULSATING HARD TO STOP BRAKES AT 8500 MILES. HONDA STATED NOT A SAFETY ISSUE. ISSUE GOT WORSE AND FINALLY AFTER 13 ATTEMPTS THROUGH 2 DEALERS AND THEIR CUSTOMER RELATIONS LINE, I FILED WITH THE BETTER BUSINESS BUREAU. IT WAS DEEMED IN THE ARBITRATION HEARING THAT THESE BRAKES WERE INDEED A SAFETY ISSUE. POOR BRAKE PADS WHICH CAUSED WARPED ROTORS ARE DANGEROUS. VEHICLE DOES NOT STOP TIMELY. SOMEONE WILL GET KILLED. HONDA IS WELL AWARE THAT THERE IS A PROBLEM WITH THE BRAKING SYSTEM ON THE 2005 AND 2006 ODYSSEY (MY PARENTS HAVE A 2006). WHEN I FIRST REPORTED IN APRIL 05, HONDA SAID THEY NEW OF THE PROBLEM, BUT CONTINUED TO SELL DANGEROUS VEHICLES. SUPPOSEDLY AS OF MARCH 06 THEY HAVE THE NEW PADS. IT SHOULD BE MANDATED THAT THEY NOTIFY EVERY 05 & 06 ODYSSEY OWNER AND ADVISE THEM OF THE POTENTIAL PROBLEM. PLEASE MAKE HONDA DO THIS BECAUSE THEY WON'T ON THEIR OWN. ACCORDING TO HONDA'S OWN WEBSITE "HONDA GENUINE BRAKE PADS YOUR HONDA'S ABILITY TO BRAKE PROPERLY AND RELIABLY IS OBVIOUSLY OF THE UTMOST IMPORTANCE FOR THE SAFETY OF YOU AND YOUR PASSENGERS." THEY ADVERTISE THAT THE VEHICLE IS THE SAFEST, BUT IT IS A DANGEROUS FAMILY VEHICLE. DOES A FAMILY HAVE TO DIE BEFORE HONDA DOES THE RIGHT THING? *NM
NHTSA ODI #10158966
Mileage unknown · May 23, 2006
Power TrainService Brakes, Hydraulic
2005 ODYSSEY HAD A INCREASE IN BRAKING DISTANCE. *TS ***NAR*** THE VEHICLE WOULD STOP FAR SHORT OF THE CONSUMERS INTENDED STOP. WHILE DRIVING 70 MPH, THE VEHICLE WOULD PRODUCE A LOW FREQUENCY NOISE WHILE IN LOW GEAR. *JB
NHTSA ODI #10158417
4,050 miles · May 5, 2006
Service Brakes, HydraulicStructureSuspension
DT*: THE CONTACT STATED WHILE MAKING U-TURNS, AT 5 MPH, A NOISE WAS HEARD COMING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE BRAKE CLIP ON THE PASSENGER FRONT WAS REPLACED. THE NOISE PERSISTED AND THE DEALER REPLACED THE STEERING PUMP ON A SECOND VISIT. THE REPLACEMENT OF THE STEERING PUMP DID …
Read full complaint
DT*: THE CONTACT STATED WHILE MAKING U-TURNS, AT 5 MPH, A NOISE WAS HEARD COMING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE BRAKE CLIP ON THE PASSENGER FRONT WAS REPLACED. THE NOISE PERSISTED AND THE DEALER REPLACED THE STEERING PUMP ON A SECOND VISIT. THE REPLACEMENT OF THE STEERING PUMP DID NOT REMEDY THE PROBLEM AND THE VEHICLE HAS NOT BEEN RETURNED TO THE DEALER FOR FURTHER INSPECTION. THE DRIVER SIDE DOOR DID NOT CLOSE PROPERLY, THE RIGHT SIDE DOOR SEAL WAS BROKE. UPDATED 05/23/06. *JB
NHTSA ODI #10156875
14,830 miles · Apr 27, 2006
Service Brakes, Hydraulic
UPDATE TO CASE #10155801: SINCE VEHICLE HAD BEEN SITTING FOR OVER TWO MONTHS AND HONDA DID NOT WANT TO FACE THAT VEHICLE HAS SAFETY ISSUES - I DECIDED TO HAVE VEHICLE TOWED TO THE OTHER SHOP IN TOWN FOR A SECOND OPINION. I DROPPED VEHICLE OFF TO HAVE BRAKES DONE W/ OTHER WARRANTY ISSUES AND 9 DAY LATER I PICKED UP VEHICLE AN…
Read full complaint
UPDATE TO CASE #10155801: SINCE VEHICLE HAD BEEN SITTING FOR OVER TWO MONTHS AND HONDA DID NOT WANT TO FACE THAT VEHICLE HAS SAFETY ISSUES - I DECIDED TO HAVE VEHICLE TOWED TO THE OTHER SHOP IN TOWN FOR A SECOND OPINION. I DROPPED VEHICLE OFF TO HAVE BRAKES DONE W/ OTHER WARRANTY ISSUES AND 9 DAY LATER I PICKED UP VEHICLE AND THEY INSTALLED THE 1ST DESIGN BRAKE PADS. THE ONES WE HAD GRINDING, PULSATING, LOSS OF PRESSURE AND BRAKES THAT WOULD LOCKED UP. I CAN NOT WAIT - GIVE IT A FEW THOUSAND MORE MILES AND HERE I GO AGAIN -- THE FIRST BRAKE PROBLEMS ALL OVER AGAIN. PLEASE INVESTIGATE THE BRAKE ISSUES BEFORE SOMEONE GETS HURT OR EVEN KILLED. *NM
NHTSA ODI #10156200
5,600 miles · Apr 21, 2006
Service Brakes, HydraulicCrash
CONTINUOUS BRAKE PROBLEMS! 1ST PROBLEM STARTED IN JUNE 05' @5600 MILES - GRINDING NOISE, PULSATING AND HARD TO STOP VEHICLE. TOOK VEHICLE TO DEALERSHIP AND WAS UNABLE TO DUPLICATE. SERVICE WRITER EXPLAINED THAT --BRAKE DUST-- WAS THE PROBLEM. 2ND MAJOR PROBLEM - IN SEPTEMBER BRAKES WERE MAKING THE LOUD GRINDING NOISE - WHEN APP…
Read full complaint
CONTINUOUS BRAKE PROBLEMS! 1ST PROBLEM STARTED IN JUNE 05' @5600 MILES - GRINDING NOISE, PULSATING AND HARD TO STOP VEHICLE. TOOK VEHICLE TO DEALERSHIP AND WAS UNABLE TO DUPLICATE. SERVICE WRITER EXPLAINED THAT --BRAKE DUST-- WAS THE PROBLEM. 2ND MAJOR PROBLEM - IN SEPTEMBER BRAKES WERE MAKING THE LOUD GRINDING NOISE - WHEN APPLYING BRAKES MODERATELY - LT. FRONT BRAKE LOCKED UP AND SKIDDED 78 FEET. VEHICLE WAS TAKEN IN @ 8600 MILES AND 1ST DESIGN BRAKE PADS WERE RE-INSTALLED. 3RD PROBLEM - TWO WEEKS LATER - BRAKES WERE GRINDING NON-STOP. TOOK VEHICLE BACK IN SHOP AND THEY REPLACED AGAIN WITH 1ST DESIGN BRAKE PADS AND ROTORS.. -- 2ND DESIGN TO BE PRODUCED IN LATE OCTOBER-- 4TH PROBLEM - BRAKES PROGRESSIVELY GOT WORSE DURING THE MONTH OF OCTOBER 05 @11,000 MILES - TOOK VEHICLE BACK INTO SHOP FOR THE 2ND DESIGN BRAKE PADS AND NEW ROTORS. -- WAS TOLD THAT NEW DESIGN WAS A -- SOFTER -- BRAKE PAD. -- WHEN DRIVING HOME - PULLED UP TO GARAGE DOOR AND VEHICLE ALMOST DID NOT STOP - ** HARD BREAK PEDAL WHEN DRIVING AT SLOW SPEEDS ** SEEM TO NOTICE EVEN MORE WHEN TURNING. 5TH PROBLEM - TOOK VEHICLE BACK TO SHOP A WEEK LATER, TO CHECK OUT BRAKE SYSTEM - UNABLE TO DUPLICATE. 6TH PROBLEM- TOOK VEHICLE BACK INTO SHOP IN DECEMBER 05 - BRAKE WERE INTERMITTENT NOT STOPPING VEHICLE - NUMEROUS TIME I HAVE ALMOST REAR ENDED VEHICLES IN STOP AND GO TRAFFIC. -- SHOP WAS UNABLE TO DUPLICATE. 7TH PROBLEM - TOOK VEHICLE BACK AGAIN IN LATE DECEMBER WITH 14,000 MILES - SHOP STILL UNABLE TO DUPLICATE PROBLEM. TWO WEEKS LATER WHILE DRIVING THROUGH A PHARMACY DRIVE THROUGH - MY WIFE AND I EXPERIENCED BRAKE FAILURE AGAIN - THIS TIME MY WIFE HAD TO RUN OVER CURB TO AVOID HITTING VEHICLE IN FRONT OF HER. ** DAMAGED THE FRONT BUMPER ** AND MY WIFE REFUSES TO DRIVE VEHICLE WITH THE --SAFETY-- ISSUES THAT IT DOES HAVE.. THIS IS A SAFETY ISSUE -- -- VEHICLE HAS BEEN SITTING NOW FOR OVER TWO MONTHS -- NOT DRIVEN -- AND STILL MAKING CAR PAYMENTS. *NM
NHTSA ODI #10155801
Mileage unknown · Apr 14, 2006
Service Brakes, Hydraulic
2005 HONDA ODYSSEY: GROANING AND GRINDING NOISE WHEN BREAKING ESP WHEN DRIVEN FOR A LONG TRIP. BREAK STOPPING DISTANCE INCREASE. COMPLAINED TO HONDA BUT HONDA SAID ITS NOT A SAFETY ISSUE. WHEN BREAKING AND NOT STOPPING IS NOT A SAFETY ISSUE PLEASE INVESTIGATE. *NM
NHTSA ODI #10155365
Official recalls
8Mar 14, 2014
American Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.
Consequence & remedy
Consequence: A fuel leak increases the risk of a fire.
Remedy: Parts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover will get a replacement, original cover. All vehicles, including those receiving the interim repair, will get an improved cover when they are available. Owners may contact Honda at 1-800-999-1009. The recall numbers associated with this campaign are JD9 (inspection and/or preliminary part replacement) and JE0 (final parts replacement).
Oct 22, 2010
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2007 ODYSSEY AND ACURA RL VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS A LUBRICANT FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER SEAL FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Feb 23, 2010
HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.
Consequence & remedy
Consequence: INJURY MAY RESULT FROM A POWER LIFTGATE CLOSING UNEXPECTEDLY WHEN A PERSON IS WITHIN THE CLOSING PATH OF THE LIFTGATE.
Remedy: DEALERS WILL INSPECT THE GAS LIFTGATE STRUTS AND REPLACE IF WITHIN THE RECALL POPULATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE CAMPAIGN BEGAN ON MARCH 26, 2010. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Additional source detail variants (2)
Structure:body:hatchback/liftgate:support Device/strut
HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.
Consequence: INJURY MAY RESULT FROM A POWER LIFTGATE CLOSING UNEXPECTEDLY WHEN A PERSON IS WITHIN THE CLOSING PATH OF THE LIFTGATE.
Remedy: DEALERS WILL INSPECT THE GAS LIFTGATE STRUTS AND REPLACE IF WITHIN THE RECALL POPULATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE CAMPAIGN BEGAN ON MARCH 26, 2010. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Structure:body:hatchback/liftgate
HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.
Consequence: INJURY MAY RESULT FROM A POWER LIFTGATE CLOSING UNEXPECTEDLY WHEN A PERSON IS WITHIN THE CLOSING PATH OF THE LIFTGATE.
Remedy: DEALERS WILL INSPECT THE GAS LIFTGATE STRUTS AND REPLACE IF WITHIN THE RECALL POPULATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE CAMPAIGN BEGAN ON MARCH 26, 2010. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Mar 14, 2007
ON CERTAIN VEHICLES, A COIL WIRE INSIDE THE FUEL PUMP RELAY MAY BREAK, CAUSING THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
Consequence & remedy
Consequence: IF THE FUEL PUMP LOSES POWER WHILE DRIVING, THE ENGINE COULD STALL WITHOUT WARNING, AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT AND REPLACE THE FUEL PUMP RELAY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Aug 1, 2005
THE FRONTAL AIR BAG SYSTEM HAS TWO EXTERNAL IMPACT SENSORS. ON CERTAIN MINI VANS,SOME SENSORS WERE INSUFFICIENTLY SEALED DURING MANUFACTURING. IF WATER ENTERS A SENSOR, CORROSION CAN OCCUR. CORRODED SENSORS COULD SHORT CIRCUIT INTERNALLY. IF SENSORS FAIL, THE SRS WARNING LAMP ON THE INSTRUMENT PANEL WILL TURN ON AND REMAIN ILLUMINATED.
Consequence & remedy
Consequence: FRONT IMPACT SENSOR FAILURE COULD CAUSE A DELAY IN, OR LOSS OF, FRONTAL AIR BAG DEPLOYMENT, WHICH CAN INCREASE THE RISK OF INJURY IN A FRONTAL CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT IMPACT SENSORS. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Apr 5, 2005
ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
Consequence & remedy
Consequence: IF THE FUEL PUMP LOSES POWER WHILE DRIVING THE ENGINE COULD STALL WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ENTIRE FUSE BOX FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HONDA AT 800-999-1009 OR ACURA AT 1-800-382-2238.
Feb 3, 2005
ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.
Consequence & remedy
Consequence: LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.
Remedy: OWNERS WERE NOTIFIED BY TELEPHONE ON JANUARY 25, 2005, AND ARRANGEMENTS WERE MADE TO HAVE THEIR VEHICLES TOWED TO THEIR DEALERS AND HAVE THE REPAIRS PERFORMED. THE RECALL BEGAN ON JANUARY 25, 2005.
Nov 15, 2004
ON CERTAIN MINIVANS, THE ANTI-LOCK BRAKE SYSTEM (ABS) USES A SENSOR ON EACH WHEEL TO DETECT WHEEL SPEED. SOME SENSORS ON THE REAR WHEELS WERE INSTALLED INCORRECTLY, WHICH MEANS THE SENSOR MAY REPORT THE WRONG WHEEL SPEED TO THE ABS CONTROL UNIT.
Consequence & remedy
Consequence: THE DRIVER COULD EXPERIENCE A LOSS OF BRAKE FORCE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL SPEED SENSORS. IF AN INCORRECT GAP IS DETECTED, THE SENSOR WILL BE REMOVED AND THE KNUCKLE CHECKED FOR CROSS THREADING DAMAGE. IF DAMAGE IS FOUND, THE KNUCKLE WILL BE REPLACED. IF NO DAMAGE IS FOUND, THE SENSOR WILL BE REINSTALLED CORRECTLY. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08015 · Unexpected Closing Of Power Liftgate
Opened Aug 8, 2008 · Closed Apr 12, 2010
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:support Device/strut
Honda will replace the liftgate struts in approximately 21,776 model year 2005 Honda Odyssey Touring vehicles equipped with power liftgates that were built before a manufacturing change of the liftgate strut assembly on July 16, 2005 (NHTSA Recall No. 10V-055).Vehicles built after the change experience significantly lower failure rates.The recall will inform consumers of the dangers of the existing struts and provide the opportunity for vehicle owners to obtain new struts that are more robust.Based on Honda's action, the agency has decided to close the investigation.While Honda has not made a decision that the recalled vehicles contain a safety-related defect, in view of the recall, further use of the agency's resources does not appear to be warranted.The agency reserves the right to take further action if warranted by the circumstances.Additional information can be found in the attached Engineering Analysis Report.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Honda will replace the liftgate struts in approximately 21,776 model year 2005 Honda Odyssey Touring vehicles equipped with power liftgates that were built before a manufacturing change of the liftgate strut assembly on July 16, 2005 (NHTSA Recall No. 10V-055).Vehicles built after the change experience significantly lower failure rates.The recall will inform consumers of the dangers of the existing struts and provide the opportunity for vehicle owners to obtain new struts that are more robust.Based on Honda's action, the agency has decided to close the investigation.While Honda has not made a decision that the recalled vehicles contain a safety-related defect, in view of the recall, further use of the agency's resources does not appear to be warranted.The agency reserves the right to take further action if warranted by the circumstances.Additional information can be found in the attached Engineering Analysis Report.
Structure:body:hatchback/liftgate:support Device/strut
Honda will replace the liftgate struts in approximately 21,776 model year 2005 Honda Odyssey Touring vehicles equipped with power liftgates that were built before a manufacturing change of the liftgate strut assembly on July 16, 2005 (NHTSA Recall No. 10V-055).Vehicles built after the change experience significantly lower failure rates.The recall will inform consumers of the dangers of the existing struts and provide the opportunity for vehicle owners to obtain new struts that are more robust.Based on Honda's action, the agency has decided to close the investigation.While Honda has not made a decision that the recalled vehicles contain a safety-related defect, in view of the recall, further use of the agency's resources does not appear to be warranted.The agency reserves the right to take further action if warranted by the circumstances.Additional information can be found in the attached Engineering Analysis Report.
PE08026 · Unexpected Closing Of Power Liftgate
Opened Apr 10, 2008 · Closed Aug 8, 2008
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:support Device/strut
THE LIFTGATE GAS STRUTS FOR THE SUBJECT VEHICLES MAY HAVE DAMAGED GAS SEALS THAT ALLOW THE LIFTGATE TO CLOSE UNEXPECTEDLY.AT THE COMPLETION OF A POWER-OPEN COMMAND, THE POWER LIFTGATE MAY EITHER CLOSE WITHOUT POWER ACTUATION (I.E., DESCEND UNASSISTED UNDER THE FORCE OF GRAVITY) OR AUTOMATICALLY POWER-CLOSE WITHOUT INPUT FROM THE OPERATOR.SOME OWNERS ARE CAUGHT UNAWARE OF THE UNINTENDED CLOSING OF THE LIFTGATE WHILE UNDER THE REAR LIFTGATE DOOR.THERE HAVE BEEN TEN REPORTED INJURIES RELATED TO THE ALLEGED PROBLEM ON THE SUBJECT VEHICLES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-015).
Additional source detail variants (2)
Structure:body:hatchback/liftgate
THE LIFTGATE GAS STRUTS FOR THE SUBJECT VEHICLES MAY HAVE DAMAGED GAS SEALS THAT ALLOW THE LIFTGATE TO CLOSE UNEXPECTEDLY.AT THE COMPLETION OF A POWER-OPEN COMMAND, THE POWER LIFTGATE MAY EITHER CLOSE WITHOUT POWER ACTUATION (I.E., DESCEND UNASSISTED UNDER THE FORCE OF GRAVITY) OR AUTOMATICALLY POWER-CLOSE WITHOUT INPUT FROM THE OPERATOR.SOME OWNERS ARE CAUGHT UNAWARE OF THE UNINTENDED CLOSING OF THE LIFTGATE WHILE UNDER THE REAR LIFTGATE DOOR.THERE HAVE BEEN TEN REPORTED INJURIES RELATED TO THE ALLEGED PROBLEM ON THE SUBJECT VEHICLES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-015).
Structure:body:hatchback/liftgate:support Device/strut
THE LIFTGATE GAS STRUTS FOR THE SUBJECT VEHICLES MAY HAVE DAMAGED GAS SEALS THAT ALLOW THE LIFTGATE TO CLOSE UNEXPECTEDLY.AT THE COMPLETION OF A POWER-OPEN COMMAND, THE POWER LIFTGATE MAY EITHER CLOSE WITHOUT POWER ACTUATION (I.E., DESCEND UNASSISTED UNDER THE FORCE OF GRAVITY) OR AUTOMATICALLY POWER-CLOSE WITHOUT INPUT FROM THE OPERATOR.SOME OWNERS ARE CAUGHT UNAWARE OF THE UNINTENDED CLOSING OF THE LIFTGATE WHILE UNDER THE REAR LIFTGATE DOOR.THERE HAVE BEEN TEN REPORTED INJURIES RELATED TO THE ALLEGED PROBLEM ON THE SUBJECT VEHICLES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-015).
Illustration