NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
64 reportsClear category filterMileage unknown · Apr 2, 2007
Latches/locks/linkagesStructure
HONDA 2001 ODYSSEY EX. 1. DOOR WOULD BUZZ AND NOT SHUT COMPLETELY. BOTH POWER SLIDING DOORS OF MINIVAN. 2. HAD CHILDREN WHO WERE TRAPPED AND HAD TO CLIMB OUT OF THE FRONT PASSENGER SEAT TO GET OUT OF THE VAN. ALSO, HAD TO DRIVE DOWN THE ROAD WITH THE DOOR PARTIALLY AJAR. 3. FUSE #13 WAS PULLED, DOORS WERE LUBRICATED. HOND…
Read full complaint
HONDA 2001 ODYSSEY EX. 1. DOOR WOULD BUZZ AND NOT SHUT COMPLETELY. BOTH POWER SLIDING DOORS OF MINIVAN. 2. HAD CHILDREN WHO WERE TRAPPED AND HAD TO CLIMB OUT OF THE FRONT PASSENGER SEAT TO GET OUT OF THE VAN. ALSO, HAD TO DRIVE DOWN THE ROAD WITH THE DOOR PARTIALLY AJAR. 3. FUSE #13 WAS PULLED, DOORS WERE LUBRICATED. HONDA THEN TOLD ME IT WAS THE MOTOR. THEN A DAY LATER WHEN BOTH DOORS WOULDN'T WORK THEY SAID IT'S THE CONTACT PINS THAT NEED TO BE REPLACED. *JB
NHTSA ODI #10186746
100,000 miles · Mar 4, 2007
Latches/locks/linkagesStructure
AUTOMATIC, SLIDING DOORS ON 2001 HONDA ODYSSEY DO NOT CLOSE COMPLETELY AND LATCH. *JB
NHTSA ODI #10184155
Mileage unknown · Nov 6, 2006
Structure
THE SLIDING DOORS ON THE VAN SEAL SHUT AFTER RAIN, SNOW OR CAR WASHES. I HAVE TO CLIMB INSIDE THE VEHICLE AND PUSH THE DOORS OUT WHILE SOMEONE YANKS FROM THE OUTSIDE ON THE HANDLE. THE SEALS HAVE BEEN REPLACED AND LUBRICATED OVER AND OVER, BUT TO NO AVAIL. I FEAR THAT IN AN ACCIDENT AN EMERGENCY RESPONDER WOULD NOT BE ABLE TO…
Read full complaint
THE SLIDING DOORS ON THE VAN SEAL SHUT AFTER RAIN, SNOW OR CAR WASHES. I HAVE TO CLIMB INSIDE THE VEHICLE AND PUSH THE DOORS OUT WHILE SOMEONE YANKS FROM THE OUTSIDE ON THE HANDLE. THE SEALS HAVE BEEN REPLACED AND LUBRICATED OVER AND OVER, BUT TO NO AVAIL. I FEAR THAT IN AN ACCIDENT AN EMERGENCY RESPONDER WOULD NOT BE ABLE TO GET INTO THE VAN TO HELP MY CHILDREN. *NM
NHTSA ODI #10172748
91,470 miles · Sep 24, 2006
Structure
MY AIR CONDITIONER IN MY 2001 HONDA ODYSSEY STOPPED BLOWING COOL AIR, SO I TOOK MY VAN IN TO MY DEALERSHIP. I THOUGHT IT WOULD BE SOMETHING SIMPLE. BUT, APPARENTLY A ROCK MUST HAD HIT MY CONDENSER AND CAUSED A LEAK. MY CONDENSER HAD TO BE REPLACED WHICH ENDED UP COSTING $750. THIS WAS A 5 HOUR JOB. I BELIEVE THAT THIS IS A …
Read full complaint
MY AIR CONDITIONER IN MY 2001 HONDA ODYSSEY STOPPED BLOWING COOL AIR, SO I TOOK MY VAN IN TO MY DEALERSHIP. I THOUGHT IT WOULD BE SOMETHING SIMPLE. BUT, APPARENTLY A ROCK MUST HAD HIT MY CONDENSER AND CAUSED A LEAK. MY CONDENSER HAD TO BE REPLACED WHICH ENDED UP COSTING $750. THIS WAS A 5 HOUR JOB. I BELIEVE THAT THIS IS A MANUFACTURE DEFECT AND HAVE RESEARCHED THIS ISSUE. THERE ARE ALOT OF OTHER HONDA ODYSSEYS THAT HAVE HAD THIS PROBLEM. *NM
NHTSA ODI #10169156
116,000 miles · Aug 21, 2006
Structure
DT*: THE CONTACT STATED THE DRIVER'S SIDE SLIDING DOOR DID NOT CLOSE ALL OF THE WAY. THE DOOR HAD TO BE CLOSED MANUALLY. THE DEALERSHIP DETERMINED THE CENTRAL ROLLER NEEDED TO BE REPLACED. OVER THE YEARS, THE CONTACT HAD TROUBLE WITH BOTH THE DRIVER'S AND PASSENGER'S SLIDING DOORS IN COLD WEATHER.
NHTSA ODI #10166117
Mileage unknown · Jul 21, 2006
Structure
POWER SLIDING DOORS FAIL TO FUNCTION PROPERLY REQUIRING COSTLY REPAIRS. SERVICE DEPT. AT DEALERSHIP INFORMS ME THAT THIS IS A FREQUENT PROBLEM REQUIRING CORRECTION WITH THESE VEHICLES (PARTICULARLY THIS MODEL YEAR).
NHTSA ODI #10163082
35,000 miles · Jun 11, 2006
Electrical SystemStructure
THE AUTOMATIC SLIDING DOORS BOTH STOPPED FUNCTIONING. I LEARNED THAT THEY COULD BE RESET BY REMOVING FUSE #13 FOR A FEW SECONDS AND REPLACING IT. THIS WORKED UNTIL IT HAPPENED AGAIN SEVERAL MONTHS LATER. THIS TIME IT DIDN'T HELP. NOW ONE DOOR WORKS BUT BECAUSE THE OTHER DOESN'T I HAVE TO TURN OFF THE AUTO-DOOR SWITCH BECAUSE IT …
Read full complaint
THE AUTOMATIC SLIDING DOORS BOTH STOPPED FUNCTIONING. I LEARNED THAT THEY COULD BE RESET BY REMOVING FUSE #13 FOR A FEW SECONDS AND REPLACING IT. THIS WORKED UNTIL IT HAPPENED AGAIN SEVERAL MONTHS LATER. THIS TIME IT DIDN'T HELP. NOW ONE DOOR WORKS BUT BECAUSE THE OTHER DOESN'T I HAVE TO TURN OFF THE AUTO-DOOR SWITCH BECAUSE IT BUZZES CONSTANTLY. I HAVE ALSO HAD THE CLOCK LIGHT BURN OUT AND MY HONDA MECHANIC (WHO SPECIALIZES IN HONDAS) CANNOT REMOVE THE COVER TO REPLACE IT. I HAVE HAD SEVERAL OTHER WARNING LIGHT INCIDENTS THAT MAY OR MAY NOT BE ELECTRICAL PROBLEMS. *NM
NHTSA ODI #10159538
Mileage unknown · May 16, 2006
Power TrainService Brakes, HydraulicStructure
2001 HONDA ODYSSEY STALLED WHILE DRIVING. *TS THE TRANSMISSION FAILED WHILE THE CONSUMER WAS DRIVING ON THE INTERSTATE. IT WAS THE SECOND TIME THE TRANSMISSION HAD BEEN REPLACED. THE CONSUMER HAS ALSO EXPERIENCED PROBLEMS WITH THE BRAKES AND SLIDING DOORS. *JB
NHTSA ODI #10158387
105,000 miles · May 12, 2006
Structure
DT*: THE CONTACT STATED WHILE PULLING INTO A PARKING LOT THE SHIELD UNDERNEATH THE BUMPER OF THE VEHICLE HIT THE CEMENT BARRIER CAUSING DAMAGE TO THE RADIATOR AND THE AIR CONDITIONER. THE VEHICLE BEGAN LOSING COOLANT AND THE AIR CONDITIONER WOULD NOT OPERATE CORRECTLY. THE CONTACT BELIEVES THIS IS A DESIGN FLAW. THE DEALERSHI…
Read full complaint
DT*: THE CONTACT STATED WHILE PULLING INTO A PARKING LOT THE SHIELD UNDERNEATH THE BUMPER OF THE VEHICLE HIT THE CEMENT BARRIER CAUSING DAMAGE TO THE RADIATOR AND THE AIR CONDITIONER. THE VEHICLE BEGAN LOSING COOLANT AND THE AIR CONDITIONER WOULD NOT OPERATE CORRECTLY. THE CONTACT BELIEVES THIS IS A DESIGN FLAW. THE DEALERSHIP HAS BEEN ALERTED.
NHTSA ODI #10157437
Mileage unknown · Feb 25, 2006
Structure
REAR MANUAL SLIDING DOORS STICK CLOSED. IF THERE IS AN ACCIDENT OR EMERGENCY, IT IS NOT POSSIBLE FOR PASSENGERS TO OPEN THE DOORS FROM THE INSIDE TO GET OUT OF THE VEHICLE. IT IS NOT POSSIBLE TO OPEN THE DOORS FROM THE OUTSIDE FOR RESCUE. TOOK TO DEALER TWICE. THE FIRST TIME THEY PUT TAPE ON THE DOOR SEALS. THIS WAS NOT EFF…
Read full complaint
REAR MANUAL SLIDING DOORS STICK CLOSED. IF THERE IS AN ACCIDENT OR EMERGENCY, IT IS NOT POSSIBLE FOR PASSENGERS TO OPEN THE DOORS FROM THE INSIDE TO GET OUT OF THE VEHICLE. IT IS NOT POSSIBLE TO OPEN THE DOORS FROM THE OUTSIDE FOR RESCUE. TOOK TO DEALER TWICE. THE FIRST TIME THEY PUT TAPE ON THE DOOR SEALS. THIS WAS NOT EFFECTIVE. THE SECOND TIME THEY PUT GREASE ON THE DOOR SEALS. THIS WAS EFFECTIVE FOR A SHORT TIME. *JB
NHTSA ODI #10151199
NHTSA investigations
1PE06007 · Front Coil Spring Fracture
Opened Jan 24, 2006 · Closed May 24, 2006
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
THE POPULATION OF 116,000 VEHICLES IS AN ESTIMATE BASED ON AMERICAN HONDA MOTOR COMPANY (AHM) DATA IDENTIFYING ORIGINAL STATE OF SALE OR DELIVERY.THE SUBJECT VEHICLES (SV) UTILIZE LIGHT WEIGHT COIL SPRINGS MANUFACTURED FROM HIGH STRENGTH STEEL (HSS).IF THE COATING MATERIAL OF A HSS SPRING IS BREACHED, CORROSIVE ELEMENTS (SALT) MAY ATTACK THE SPRING.SPRING CORROSION RESULTS IN A STRESS RISER AND MAY CAUSE A FRACTURE.DEPENDING ON THE LOCATION WHERE THE SPRING BREAKS, THE JAGGED EDGE MAY PIERCE THE TIRE; A RAPID DEFLATION OF THE TIRE MAY OCCUR AND CAN RESULT IN A LOSS OF CONTROL OR CRASH.SV SPRING FAILURE MECHANICS AND TIRE CONTACT LIKELIHOOD ARE DISCUSSED IN AN AHM PRESENTATION TO ODI DATED APRIL 20TH, 2006 (AVAILABLE ON ODI?S WEB SITE; WWW-ODI.NHTSA.DOT.GOV).AHM?S PRESENTATION IDENTIFIED TWO MECHANISMS WHICH CAUSE THE SPRING COATING TO BECOME BREACHED; 1) CONTACT WITH THE LOWER SPRING SEAT, AND 2) ENTRAPMENT OF ABRASIVE MATERIALS BETWEEN THE SILENCER TUBE AND SPRING.THE PRESENTATION COMPARED SV SPRING FRACTURE RATES TO THE HONDA MDX MODEL, A SISTER VEHICLE RECALLED FOR FRONT SPRING FRACTURE UNDER NHTSA RECALL 05V385, AND TO OTHER VEHICLES INVESTIGATED AND OR RECALLED FOR FRONT SPRING FRACTURE.THE SPRING FRACTURE RATE FOR THE SV, WHICH IS ABOUT HALF THE RATE OF THE MDX MODEL EVEN THOUGH THE SV'S HAVE ONE YEAR LONGER IN SERVICE, IS COMPARABLE TO RATES OBSERVED IN PRIOR SPRING FRACTURE INVESTIGATIONS THAT WERE CLOSED WITH NO RECALL AND LOW IN COMPARISON TO INVESTIGATIONS THAT HAVE RESULTED IN A SAFETY RECALL.OF THE 7 REPORTS ODI IDENTIFIED ALLEGING TIRE DAMAGE DUE TO SPRING FRACTURE, 6 INVOLVED SPRING-TIRE CONTACT WHICH RESULTED IN SLOW OR NO LOSS OF AIR PRESSURE; ODI WAS UNABLE TO VERIFY THE ONE REPORT ALLEGING A PUNCTURE OCCURRED.ODI NOTES THAT THE SV FRONT SPRING DIFFERS FROM THE MDX SPRING IN THAT IT HAS A SINGLE SILENCER TUBE (UPPER ONLY, AS OPPOSED TO UPPER AND LOWER ON THE MDX) WHICH IS, ACCORDING TO AHM, LOCATED IN AN AREA LESS LIKELY TO RESULT IN A TIRE PUNCTURE SHOULD A FRACTURE OCCUR.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration