SLIDING DOORS ON HONDA ODYSSEY (VAN) HAVE THE TENDENCY TO STICK AND NOT OPEN WITHOUT REPEATED EFORTS IF NOT USED FOR A DAY OR TWO. IN MANY INSTANCES THE HANDLE OF THE VEHICLE BROKE OFF. IT IS POTENTIALLY DANGEROUS, INCASE OF AN EMERGECY THE CHILDERN IN THE CAR SEAT IN THE REAR OF THE CAR CAN NOT BE EASLY REACHED. THE MANUFACTURE…
Read full complaint
SLIDING DOORS ON HONDA ODYSSEY (VAN) HAVE THE TENDENCY TO STICK AND NOT OPEN WITHOUT REPEATED EFORTS IF NOT USED FOR A DAY OR TWO. IN MANY INSTANCES THE HANDLE OF THE VEHICLE BROKE OFF. IT IS POTENTIALLY DANGEROUS, INCASE OF AN EMERGECY THE CHILDERN IN THE CAR SEAT IN THE REAR OF THE CAR CAN NOT BE EASLY REACHED. THE MANUFACTURER IS WELL INFORMED OF THE PROBLEM BUT DOES NOT GIVEN IT A SERIOUS CONSIDERATION.*AK
NHTSA ODI #10062652
Mileage unknown · Mar 2, 2004
Structure
DOORS DO NOT SLIDE EASILY, THEY STICK AND I NOTICE A LITTLE BUMP PROTRUDING FROM JUST BELOW EACH HANDLE. NOW THE PAINT IS STARTING TO COME OFF WHERE THE BUMPS ARE!!*AK
NHTSA ODI #10060161
15,048 miles · Jan 23, 2004
Engine And Engine CoolingFuel System, GasolineSeat Belts
REAR BUCKET SEAT BUCKLE UNBOLTED FROM ITS STRUCTURE WITHOUT ANY IMPACT OR FORCE BEING APPLIED. *AK THERE WERE PROBLEMS WITH THE TEMPERATURE CONTROL KNOB. (THE ENTIRE HEAT A/C CONTROL PANEL WAS REPLACED), THE FRONT BRAKE PADS HAD TO BE REPLACED AND THE ROTORS HAD TO BE CUT, THE CHECK ENGINE LIGHT HAD COME ON, AND GASOLINE WAS…
Read full complaint
REAR BUCKET SEAT BUCKLE UNBOLTED FROM ITS STRUCTURE WITHOUT ANY IMPACT OR FORCE BEING APPLIED. *AK THERE WERE PROBLEMS WITH THE TEMPERATURE CONTROL KNOB. (THE ENTIRE HEAT A/C CONTROL PANEL WAS REPLACED), THE FRONT BRAKE PADS HAD TO BE REPLACED AND THE ROTORS HAD TO BE CUT, THE CHECK ENGINE LIGHT HAD COME ON, AND GASOLINE WAS SMELLED EACH TIME THE ENGINE WAS SHUT OFF. *SC *JB
NHTSA ODI #10051877
Mileage unknown · Nov 21, 2003
Structure
2000 HONDA ODYSSEY LX MANUAL SLIDING DOORS "STICKING" PROBLEM SOLUTION: A) AFTER ATTEMPTING TO OPEN THE SLIDING DOOR, AND IT ONLY "POPS OPEN" SLIGHTLY AND STICKS; B) FROM INSIDE THE VEHICLE, PUSH OUTWARD ON THE UPPER CORNER (OF THE SLIDING DOOR) WHICH IS CLOSEST TO THE REAR OF THE VEHICLE. IT SHOULD PUSH OUTWARD EASILY, AN…
Read full complaint
2000 HONDA ODYSSEY LX MANUAL SLIDING DOORS "STICKING" PROBLEM SOLUTION: A) AFTER ATTEMPTING TO OPEN THE SLIDING DOOR, AND IT ONLY "POPS OPEN" SLIGHTLY AND STICKS; B) FROM INSIDE THE VEHICLE, PUSH OUTWARD ON THE UPPER CORNER (OF THE SLIDING DOOR) WHICH IS CLOSEST TO THE REAR OF THE VEHICLE. IT SHOULD PUSH OUTWARD EASILY, AND THE DOOR SHOULD SLIDE OPEN FREELY. C) APPLY LUBRICANT TO THE UPPER REAR CORNER OF THE WEATHER STRIPPING RUBBER: TRY SILICON GREASE, OR SILICON SPRAY LUBRICANT, OR GRAPHITE POWDER, OR TALCUM POWDER. PROBLEM SOLVED. NO MORE STICKING WHEN RE-OPENING THE PREVIOUSLY STUCK DOOR. ITS PROBABLY THE PHYSICS OF THE PRESSURE OF THE DOOR AGAINST THE RUBBER CREATING SUFFICIENT FRICTION TO PREVENT THE DOOR FROM "POPPING" COMPLETELY AWAY FROM THE RUBBER WEATHER STRIPPING AND THUS PREVENTING THE DOOR FROM SLIDING OPEN. *LA
NHTSA ODI #10047347
Mileage unknown · Nov 16, 2003
Structure
SINCE DAY ONE OF OWNING OUR 2000 HONDA ODYSSEY LX, BOTH SLIDING DOORS STICK. RECENTLY, THE DRIVER'S SIDE DOOR HANDLE BROKE. DEALER HAS ONLY GREASED THE DOOR, WHICH ONLY PREVENTS THE SEAL OR VACUUM OR WHATEVER FOR A SHORT PERIOD. *LA
NHTSA ODI #10047029
48,000 miles · Oct 24, 2003
Structure
THE CHILD WAS STANDING IN THE MIDDLE OF THE SLIDING DOOR WHEN IT CLOSED WITHOUT THE OWNER PRESSING THE CLOSE BUTTON. THE OWNER TOOK THE VEHICLE TO THE DEALERSHIP. THE MECHANIC HAD NOT RESOLVE THE PROBLEM. *JB
NHTSA ODI #10044701
Mileage unknown · Oct 15, 2003
Structure
PROBLEMS WITH THE SLIDING DOORS GETTING STUCK CLOSED. *MR IT WOULD TAKE TWO ADULTS TO OPEN THE DOOR. THE CONSUMER'S CHILDREN HAD GOTTEN STUCK INSIDE OF THE VEHICLE TOO MANY TIMES. THE DEALER WAS AWARE OF THE PROBLEM. THE VEHICLE HAD BEEN IN THE SHOP MANY TIMES FOR THE PROBLEM WHERE ALL THE PARTS HAD BEEN REPLACED AND ADJU…
Read full complaint
PROBLEMS WITH THE SLIDING DOORS GETTING STUCK CLOSED. *MR IT WOULD TAKE TWO ADULTS TO OPEN THE DOOR. THE CONSUMER'S CHILDREN HAD GOTTEN STUCK INSIDE OF THE VEHICLE TOO MANY TIMES. THE DEALER WAS AWARE OF THE PROBLEM. THE VEHICLE HAD BEEN IN THE SHOP MANY TIMES FOR THE PROBLEM WHERE ALL THE PARTS HAD BEEN REPLACED AND ADJUSTMENTS WERE MADE. *SCC *JB
NHTSA ODI #10044170
Mileage unknown · Sep 26, 2003
Structure
REAR SLIDING DOORS STICK AND WILL NOT OPEN. DEALER HAS GREASED THE SEALS MANY TIMES. THIS FIXES THE PROBLEM SOR ONLY A SHORT TIME. THIS IS A SAFETY HAZARD AS PASSENGERS IN THE REAR CANNOT GET OUT IF THE DOORS ARE STUCK. THIS HAS BEEN A PROBLEM EVER SINCE THE VEHICLE WAS PURCHASED.
NHTSA ODI #10039584
Mileage unknown · May 8, 2003
Structure
THE PASSENGER SLIDING DOOR DID NOT OPEN WHEN THE DOOR WAS UNLOCKED FROM THE INSIDE. *JB
NHTSA ODI #10019445
Mileage unknown · Apr 17, 2003
Structure
THE VEHICLES SLIDING DOOR WAS STUCK WHICH RESULTED IN THE DOOR HANDLE BREAKING. THE DEALER HAS BEEN CONTACTED. *NLM
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Honda (American Honda Motor Co.) is recalling certain 2001-2002 Acura 3.2CL, 2000-2003 Acura 3.5RL, 2000-2001 Acura 3.2TL, Honda CR-V and Honda Odyssey, 2001-2002 Acura MDX and 2000 Accord Coupe, Accord Sedan, Civic Coupe, and Civic Sedan vehicles. These vehicles may have received a replacement driver frontal air bag module as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the air bags in the vehicles, replacing the driver frontal air bag inflator with an inflator of a different design, as necessary, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138.
VEHICLE DESCRIPTION: MINIVAN. THE SLIDING DOORS MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: AN IMPROPERLY LATCHED DOOR COULD OPEN UNEXPECTEDLY WHILE THE VEHICLE IS IN MOTION. UNDER CERTAIN CIRCUMSTANCES, A DOOR COULD OPEN COMPLETELY. AN UNRESTRAINED REAR SEAT PASSENGER COULD FALL OUT OF AN OPEN DOOR OF A MOVING VEHICLE AND BE SERIOUSLY INJURED OR KILLED.
Remedy: DEALERS WILL REPLACE THE DOOR LATCH ASSEMBLY ON ALL ODYSSEY MINVANS BUILT FROM DECEMBER 3, 1999 THROUGH DECEMBER 16, 1999. ALSO INCLUDED IN THIS RECALL ARE APPROXIMATELY 1,612 ODYSSEY MINIVANS THAT HAD THE LATCHES REPLACED UNDER RECALL 99V-158 OR UNDER WARRANTY, THAT MAY NEED TO HAVE THE LATCHES REPLACED AGAIN. OWNERS OF THESE VEHICLES WILL BE NOTIFIED BY HONDA TO BRING THE VEHICLE TO THEIR HONDA DEALER FOR INSPECTION OF THE PREVIOUSLY REPLACED LATCH ASSEMBLY. LATCHES WITH THE SUSPECT DATE CODE WILL BE REPLACED.
VEHICLE DESCRIPTION: MINI VANS. A WIRE HARNESS, LOCATED WITHIN THE ENGINE COMPARTMENT, COULD BE DAMAGED BY CONTACT WITH A METAL PIPE, POSSIBLY RESULTING IN A BLOWN FUSE.
Consequence & remedy
Consequence: IF A FUSE BLOWS, ENGINE POWER, OR OPERATION OF ANY OR ALL ELECTRICAL COMPONENTS, CAN BE LOST, INCLUDING LIGHTS, WINDSHIELD WIPERS, HORN, AND THE ANTI-LOCK FUNCTION OF THE BRAKES. A SUDDEN LOSS OF POWER OR LIGHTING, OR A FAILURE OF THE WINDSHIELD WIPERS OR ANTI-LOCK BRAKE FEATURE IN BAD WEATHER, COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING OVER THE WIRE HARNESS AND METAL PIPE TO PREVENT THIS PROBLEM. IF ANY WIRES ARE DAMAGED, THE DEALER WILL MAKE THE NECESSARY REPAIRS, AND THEN INSTALL THE PROTECTIVE COVERING.
VEHICLE DESCRIPTION: MINIVANS. THE FRONT BODY/FRAME IS MISSING SPOT WELDS.
Consequence & remedy
Consequence: THE MISSING WELDS MIGHT AFFECT THE OCCUPANT PROTECTION PERFORMANCE IN A COLLISION.
Remedy: DEALERS INSPECTED ALL THE VEHICLES AND THEY WERE FOUND TO BE PROPERLY WELDED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE06007 · Front Coil Spring Fracture
Opened Jan 24, 2006 · Closed May 24, 2006
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
THE POPULATION OF 116,000 VEHICLES IS AN ESTIMATE BASED ON AMERICAN HONDA MOTOR COMPANY (AHM) DATA IDENTIFYING ORIGINAL STATE OF SALE OR DELIVERY.THE SUBJECT VEHICLES (SV) UTILIZE LIGHT WEIGHT COIL SPRINGS MANUFACTURED FROM HIGH STRENGTH STEEL (HSS).IF THE COATING MATERIAL OF A HSS SPRING IS BREACHED, CORROSIVE ELEMENTS (SALT) MAY ATTACK THE SPRING.SPRING CORROSION RESULTS IN A STRESS RISER AND MAY CAUSE A FRACTURE.DEPENDING ON THE LOCATION WHERE THE SPRING BREAKS, THE JAGGED EDGE MAY PIERCE THE TIRE; A RAPID DEFLATION OF THE TIRE MAY OCCUR AND CAN RESULT IN A LOSS OF CONTROL OR CRASH.SV SPRING FAILURE MECHANICS AND TIRE CONTACT LIKELIHOOD ARE DISCUSSED IN AN AHM PRESENTATION TO ODI DATED APRIL 20TH, 2006 (AVAILABLE ON ODI?S WEB SITE; WWW-ODI.NHTSA.DOT.GOV).AHM?S PRESENTATION IDENTIFIED TWO MECHANISMS WHICH CAUSE THE SPRING COATING TO BECOME BREACHED; 1) CONTACT WITH THE LOWER SPRING SEAT, AND 2) ENTRAPMENT OF ABRASIVE MATERIALS BETWEEN THE SILENCER TUBE AND SPRING.THE PRESENTATION COMPARED SV SPRING FRACTURE RATES TO THE HONDA MDX MODEL, A SISTER VEHICLE RECALLED FOR FRONT SPRING FRACTURE UNDER NHTSA RECALL 05V385, AND TO OTHER VEHICLES INVESTIGATED AND OR RECALLED FOR FRONT SPRING FRACTURE.THE SPRING FRACTURE RATE FOR THE SV, WHICH IS ABOUT HALF THE RATE OF THE MDX MODEL EVEN THOUGH THE SV'S HAVE ONE YEAR LONGER IN SERVICE, IS COMPARABLE TO RATES OBSERVED IN PRIOR SPRING FRACTURE INVESTIGATIONS THAT WERE CLOSED WITH NO RECALL AND LOW IN COMPARISON TO INVESTIGATIONS THAT HAVE RESULTED IN A SAFETY RECALL.OF THE 7 REPORTS ODI IDENTIFIED ALLEGING TIRE DAMAGE DUE TO SPRING FRACTURE, 6 INVOLVED SPRING-TIRE CONTACT WHICH RESULTED IN SLOW OR NO LOSS OF AIR PRESSURE; ODI WAS UNABLE TO VERIFY THE ONE REPORT ALLEGING A PUNCTURE OCCURRED.ODI NOTES THAT THE SV FRONT SPRING DIFFERS FROM THE MDX SPRING IN THAT IT HAS A SINGLE SILENCER TUBE (UPPER ONLY, AS OPPOSED TO UPPER AND LOWER ON THE MDX) WHICH IS, ACCORDING TO AHM, LOCATED IN AN AREA LESS LIKELY TO RESULT IN A TIRE PUNCTURE SHOULD A FRACTURE OCCUR.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ00014 · Upexpected Opening Of Sliding Door
Opened Jul 28, 2000 · Closed Apr 25, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
2000 Honda Odyssey Problems, Complaints & Recalls | Skip That Year
Illustration