Engine failed to start when turning the key in the ignition. Occurred three separate occasions within 30 days @ 18,000. Engine light and electronic steering system lights remained on. Vehicle started after waiting one hour. On the third occasion, the car was towed to the dealer, and a service advisor experienced the same iss…
Read full complaint
Engine failed to start when turning the key in the ignition. Occurred three separate occasions within 30 days @ 18,000. Engine light and electronic steering system lights remained on. Vehicle started after waiting one hour. On the third occasion, the car was towed to the dealer, and a service advisor experienced the same issue. However, 30 minutes later, a mechanic was able to start the engine at every attempt. There were no warning lights, other than the lights remaining on the dashboard when attempting to turn the key. (I have video of the experience - please see photo). I am submitting this notice because on all 3 occasions, Honda dealer performed diagnostics, but could not find an issue that caused the failed start. I was reluctant to keep a car with a problem that statistically would reoccur in the future, or perhaps might experience an even worse electrical problem. The dealer "bought" the car back, and sold me a 2024 - same model. There were some additional costs and of course the interest rate was higher. I agreed to all of the conditions for the new purchase, and I believe the dealer did right by me with the purchase of the newer model. HOWEVER, 3 days after I purchased the 2024 HR-V, the dealer put the 2022 HR-V on the lot and is attempting to resell it. I find this wrong and possibly a risk to the new owner. I have every reason to believe the issue for the faulty electrical system was not discovered over the short time (3 days) from when I turned in the car, and when I saw it on the lot for resell. Other than the electrical issue, the vehicle was very reliable and I took very good care with it. If not for anticipating the problem would reoccur when I was driving or wouldn't start in an emergency, or perhaps reoccur after the warranty expired, I traded it in to the dealer and purchased a new 2024 model. Thank you.
NHTSA ODI #11546739
4,309 miles · Aug 17, 2023
EngineService Brakes
The contact owns a 2022 Honda HR-V. The contact stated while driving approximately 65 MPH, the check engine warning light illuminated. Additionally, the "Electric Emergency Brake Unavailable - See Dealer" message was displayed. The contact stated that the vehicle stalled and lost power steering and braking functionality. The con…
Read full complaint
The contact owns a 2022 Honda HR-V. The contact stated while driving approximately 65 MPH, the check engine warning light illuminated. Additionally, the "Electric Emergency Brake Unavailable - See Dealer" message was displayed. The contact stated that the vehicle stalled and lost power steering and braking functionality. The contact stated that after several attempts, the vehicle was able to be restarted. The contact stated that she had experienced the same failure with the vehicle stalling and stopped driving the vehicle out of fear of stalling on a busy road. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed and had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was 4,309.
NHTSA ODI #11539098
Mileage unknown · May 20, 2023
Electrical SystemEngineService Brakes
I purchased the vehicle on 2/17/22 and shortly afterwards started noticing problems starting with acceleration car wouldn’t go past 45 mph or lower. The car radio system has static can’t get reception; the battery died requiring a jump. On 9/21/22 and January 10, 2023 I took car to dealer about these problems and other concerns …
Read full complaint
I purchased the vehicle on 2/17/22 and shortly afterwards started noticing problems starting with acceleration car wouldn’t go past 45 mph or lower. The car radio system has static can’t get reception; the battery died requiring a jump. On 9/21/22 and January 10, 2023 I took car to dealer about these problems and other concerns and they said couldn’t verify my concerns. On 5/9/23 I set out for my first long distance trip from Vallejo CA, to Las Vegas NV after driving approximately 200-300 miles the dashboard light up light a Christmas tree with several system problem warnings as follow: Power Steering System (EPS) problem, Road Departure Mitigation, Vehicle Stability Assist (VSA) problem, Emissions System problem, All Wheel Drive System problem, Brake System problem, Brake Hold system problem, Hill Start Assist problem, Tire Pressure Monitoring System, Electronic Brake Distribution (EBD) continuously flashing, Hold Brake light, Oil light flashing and the Drivers and Front Passenger Airbag light flashing. I had to stop in Los Angeles CA, Honda service center and they couldn’t do a diagnostic test that day and warning lights went off after technician disabled the Road departure mitigation system and was told it was safe to continue on to Vegas. However, all warning light as mentioned came back on and remained on. I took the car to Honda West in Vegas on 5/11/23 and was told car had a misfiring code. Diagnostic test performed and multiple repair codes were detected but they couldn’t duplicate concerns, took fuel sample test and it passed, cleared DTCs performed final test verified no DTCs returned or currently present/stored and they returned car to me. On 5/15/23 left Vegas and the same system warning lights came back on, stopped in Los Angeles again and stayed overnight and the lights were off the next morning. I took vehicle to Avery Green Honda after speaking to Sales Manager Sean Shahid where the car remains to date for further diagnostic testing.
NHTSA ODI #11523038
Mileage unknown · Feb 7, 2023
Electrical SystemEngineUnknown Or Other
The vehicle started to encounter mechanical issues 10 days after delivery. The vehicle's radio, Apple Carplay, Bluetooth, and anti-theft system/radio unit started to encounter electrical issues, stating it had lost power. The issues were not as common at first but, grew to be persistent as the vehicle continued to be driven. Th…
Read full complaint
The vehicle started to encounter mechanical issues 10 days after delivery. The vehicle's radio, Apple Carplay, Bluetooth, and anti-theft system/radio unit started to encounter electrical issues, stating it had lost power. The issues were not as common at first but, grew to be persistent as the vehicle continued to be driven. The vehicle was in for service approximately 1-2 weeks ago from today's date and all the issues have started again. The issues that persist are the vehicle not being able to start multiple times in a week (does not depend if the vehicle is hot or cold, and/or if the vehicle has been recently driven or sitting), Apple Carplay consistently disconnecting, the anti-theft system/radio unit continually losing power and needing to acquire GPS satellites. The dealership did conclude that the battery was at fault for the no-start issues and replaced the battery, unfortunately, that did not solve the issues and they continue to arise on a consistent basis thereafter. The other issues could not be replicated and were recommended that the phones connected via Apple Carplay be updated & repaired, the phones that were connected were already up to date in the IOS version, and the Hondailink version, and were using Apple oem cables. These issues were not solved as well, and could not be replicated by the dealership. Most recently, the vehicle had a hard time starting and refused to accelerate above 40 mph.
NHTSA ODI #11506070
Mileage unknown · Jan 3, 2023
EngineFuel/propulsion SystemService Brakes
While driving multiple warning lights came on stating braking system failure, collision system failure, check engine lights , Emissions system problem, brake hold system failure etc. There were no lights prior. I was at highway speeds when all of this took place which could have turned out to be rather disasterous. The Vehicle w…
Read full complaint
While driving multiple warning lights came on stating braking system failure, collision system failure, check engine lights , Emissions system problem, brake hold system failure etc. There were no lights prior. I was at highway speeds when all of this took place which could have turned out to be rather disasterous. The Vehicle was taken to the dealer who stated that this was caused by the drain of sunroof being clogged from the elements. The drainage system backed up and water entered front cabin. Dealer states this is not covered under warranty. Even though this is a near brand new car.
NHTSA ODI #11500028
17,000 miles · Jul 28, 2022
Engine
The contact owns a 2022 Honda HR-V. The contact stated while driving approximately 40 MPH and attempting to accelerate the vehicle failed to respond. The contact stated that the vehicle failed to shift into gear before stalling. The contact stated that the brakes, check engine, and several unknown warning lights were illuminated…
Read full complaint
The contact owns a 2022 Honda HR-V. The contact stated while driving approximately 40 MPH and attempting to accelerate the vehicle failed to respond. The contact stated that the vehicle failed to shift into gear before stalling. The contact stated that the brakes, check engine, and several unknown warning lights were illuminated. The vehicle was towed to the dealer and diagnosed for the fourth time. The vehicle had received unknown repairs three times before; however, the failure reoccurred. The dealer reset the software. The manufacturer was not notified of the failure. The approximate failure mileage was 17,000.
NHTSA ODI #11476349
Mileage unknown · May 13, 2022
EnginePower TrainVehicle Speed Control
This is a continuation of NHTSA ID Number: 11463644. Secondary issue is minimal acceleration output when entering the freeways. At times, it can take between 20-30 seconds to get 0-60 mph - creating a very dangerous environment with the vehicles behind me braking hard to avoid crashing into my 2022 Honda HR-V Sport. America…
Read full complaint
This is a continuation of NHTSA ID Number: 11463644. Secondary issue is minimal acceleration output when entering the freeways. At times, it can take between 20-30 seconds to get 0-60 mph - creating a very dangerous environment with the vehicles behind me braking hard to avoid crashing into my 2022 Honda HR-V Sport. American Honda denied my claim to replace ECU and repair body damage to the vehicle after examination.
NHTSA ODI #11464442
Mileage unknown · Dec 24, 2021
EnginePower TrainVehicle Speed Control
The SUV decelerated rapidly while driving uphill on the grapevine in Los Angeles. I was driving 70 mph and then the SUV's speed just started to drop and I was pressing down hard on the accelerator. This may haven been an issue with the engine or the transmission. My daughter and I could have been seriously injured or killed s…
Read full complaint
The SUV decelerated rapidly while driving uphill on the grapevine in Los Angeles. I was driving 70 mph and then the SUV's speed just started to drop and I was pressing down hard on the accelerator. This may haven been an issue with the engine or the transmission. My daughter and I could have been seriously injured or killed since we were surrounded by cars going 70+ mph and no one could have expected our SUV to decelerate so quickly on this stretch of highway. We really could not figure out what to do. The dealer said they could not replicate it, but I have had this happen more than once. I told them how serious this was, but they said they could not help me. I have read online of others complaining about the same issue for both the CRV and the HRV (www.thedrive.com) and I read that this issue has been reported to the NHTSA before so I wonder how the Honda dealer has never heard about this before. The SUV has not been inspected by anyone but the dealer. The SUV also intermittently shakes on the highway as it picks up speed. This also appears to be an issue others have experienced. No warning lamps, messages or other symptoms appeared for either issue. Both issues present safety concerns.
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Additional source detail variants (2)
Back Over Prevention:software
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Back Over Prevention:display Function
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Additional source detail variants (2)
Back Over Prevention:display Function
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE22011 · Rear Differential Seizure
Opened Nov 28, 2022 · Closed Jul 22, 2024
Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Additional source detail variants (6)
Power Train:axle Assembly:axle Shaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly:axle Shaft:seal
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:differential Unit
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
2022 Honda HR-V Problems, Complaints & Recalls | Skip That Year
Illustration