NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
13 reportsClear category filterMileage unknown · Aug 20, 2026
Power Train
While on the highway vehicles warning light illuminated and the vehicle immediately slowed down and would not go over 20 miles per hour. Prior to the warning lights illuminating there were no warning lights already illuminated and no drivability issues. You could hear a griding noise when driving at low speeds and the vehicle wo…
Read full complaint
While on the highway vehicles warning light illuminated and the vehicle immediately slowed down and would not go over 20 miles per hour. Prior to the warning lights illuminating there were no warning lights already illuminated and no drivability issues. You could hear a griding noise when driving at low speeds and the vehicle would not go above 20 miles per hour. Ended up pulling over and towing the vehicle to the dealership. The dealership mentioned after diagnosis the transmission internally failed and needed to be replaced. They did find metal debris from the transmission belt when draining the fluid and found the fluid to be clean. Found the TSB - Warranty extension from NHSTA website showing all 2016-2020 model year Honda HR-V's with 2WD and AWD included in this warranty extension but when reaching out to Honda Customer Service they denied the warranty extension and called it a goodwill denial and were careful to not mention the warranty extension submitted to NHTSA. The cost would be over $10,000 to replace the transmission with a remanufactured one quote by the dealership. The TSB - Warranty Extension number is 21-047.
NHTSA ODI #11758260
Mileage unknown · Mar 29, 2026
Power Train
On 3/15/26 the CVT transmission on my 2020 HRV EX-L failed while driving on I-95 near Fairfield, CT. My dashboard lit up like a Christmas tree and the car decelerated and would not go past 20 miles per hour. My safety was put at risk because this happened suddenly doing 60 mph highway. There was no indication of an issue with t…
Read full complaint
On 3/15/26 the CVT transmission on my 2020 HRV EX-L failed while driving on I-95 near Fairfield, CT. My dashboard lit up like a Christmas tree and the car decelerated and would not go past 20 miles per hour. My safety was put at risk because this happened suddenly doing 60 mph highway. There was no indication of an issue with the transmission when I visited the Honda Service center on Friday, 3/13 to repair a lose panel. They saw no issues. There were two Service Bulletins 21-046 dated 4/27/21 and o6/1/21, respectively that listed certain HRV VIN numbers that had the warranty extended to cover the full replacement cost of the CVT transmission. My VIN is not included. Many of the steps taken by the dealer to determine the transmission failure came from those service bulletins. I would like the NHTSA to look into this issue and contact Honda in order to extend the warranty in order to have the full replacement cost of the transmission covered.
NHTSA ODI #11727834
Mileage unknown · Mar 24, 2026
Power Train
•What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission failed and yes it’s available upon request. •How was your safety or the safety of others put at risk? My car stop in the middle of the street. No warning or anything. •Has the problem been reproduced …
Read full complaint
•What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission failed and yes it’s available upon request. •How was your safety or the safety of others put at risk? My car stop in the middle of the street. No warning or anything. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Manufacturer •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, everything happened on 03-09-26. L
NHTSA ODI #11726648
122,700 miles · Mar 18, 2026
Power Train
The contact owns a 2020 Honda HR-V. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle bucked, and several warning lights illuminated. The vehicle was taken to the dealer, where it was diagn…
Read full complaint
The contact owns a 2020 Honda HR-V. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle bucked, and several warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed with CVT failure. The contact was informed that the CVT needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced an unknown recall; however, the VIN was not under recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 122,700.
NHTSA ODI #11725279
Mileage unknown · Feb 27, 2026
Electrical SystemEnginePower Train
While stopped at a traffic signal, the vehicle failed to restart when the light turned green. On another occasion, the vehicle stalled during operation and would not start. The engine would crank but there was no ignition. This created a safety risk because the vehicle was disabled in traffic and unable to move out of the roadwa…
Read full complaint
While stopped at a traffic signal, the vehicle failed to restart when the light turned green. On another occasion, the vehicle stalled during operation and would not start. The engine would crank but there was no ignition. This created a safety risk because the vehicle was disabled in traffic and unable to move out of the roadway, increasing the risk of a rear-end collision or other crash. The vehicle was towed to a dealership for inspection. The dealer diagnosed a failed Powertrain Control Module (PCM). The diagnosis indicated no spark and that the ignition coils were not receiving signal, although the crank sensor signal was present. The PCM was replaced, and the vehicle started and operated normally after replacement. No additional wiring, fuse, or grounding issues were identified. There were no prior warning lights, dashboard messages, or drivability symptoms before the failure occurred. The failure happened unexpectedly at approximately 52,889 miles. The replaced PCM is available through the servicing dealership if inspection is requested.
NHTSA ODI #11721088
Mileage unknown · Jan 15, 2026
EnginePower Train
The HRV is available for inspection upon request. It was taken to local Honda dealer for inspection based on the below: December 2025 - Highway driving slightly over speed limit posting 70mph when a majority of the lights on the dashboard came on (transmission, abs brake, awd, engine light, almost all lights) and the car immedia…
Read full complaint
The HRV is available for inspection upon request. It was taken to local Honda dealer for inspection based on the below: December 2025 - Highway driving slightly over speed limit posting 70mph when a majority of the lights on the dashboard came on (transmission, abs brake, awd, engine light, almost all lights) and the car immediately lost speed power and had to emergently pull over into safe lane off the highway. RPM revved irradically up to 6000. Tried to accelerate but it would sputter forward and did not want to shift transmission gears. Honda dealer has inspected the care and state that it needs transmission. The tech looked at it and did a magnet test which was positive information for him to tell me that it needed a transmission and AC belt. There is already a safety bulletin on this issue issued in 2021 covering all HRV models 2016-2000. The car has 112k and is 2020. It fits within the guidelines of the bulletin issued by Honda acknowledging that there is an issue with parts and manufacturing. It is bulletin #21-047: [XXX] Honda has stated my vin does not qualify. Online forums discuss that other people have the same problem in which honda corporate has told them the same thing. No notable warning signs. My safety was challenged and at risk when this happened without any warning at all. I was driving in high speed left lane and could have caused a severe accident with the immediate drop of speed by the car automatically. I have always taken great care of Honda cars that I have owned and this should have never happened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11711268
Mileage unknown · Apr 9, 2025
Power TrainCrash
- The transmission had several problems that failed, leading to the car being unable to drive. The car starts, but does not drive in Drive or Reverse. The exact Honda vehicle codes affected are: P0171 and P0793. -My safety was put at risk because the car had previously stalled several times, leading to needing to pull over on t…
Read full complaint
- The transmission had several problems that failed, leading to the car being unable to drive. The car starts, but does not drive in Drive or Reverse. The exact Honda vehicle codes affected are: P0171 and P0793. -My safety was put at risk because the car had previously stalled several times, leading to needing to pull over on the side of the road immediately, even on what is nearly a highway. -The exact problem was not confirmed by a dealer, but by an independent mechanic. Previous problems, such as the stalling, were confirmed by Caliber Collision in Cinnaminson, NJ. -The vehicle was last inspected by a mechanic in Massachusetts. -There were several of the dash cam lights and error sounds, off and on, since [XXX], upon an accident. The car was repaired after by said Caliber Collision in Cinnaminson, NJ, on more than one occasion between January 19th, 2025 and today, April 4th, 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11653707
109,000 miles · Feb 28, 2025
Power Train
The contact owns a 2020 Honda HR-V. The contact stated while driving approximately 75 MPH with the cruise control engaged, there was an abnormal grinding sound coming from the driver’s side front-end of the vehicle. The contact stated that the vehicle was shuddering and occasionally hesitating while driving. The contact stated t…
Read full complaint
The contact owns a 2020 Honda HR-V. The contact stated while driving approximately 75 MPH with the cruise control engaged, there was an abnormal grinding sound coming from the driver’s side front-end of the vehicle. The contact stated that the vehicle was shuddering and occasionally hesitating while driving. The contact stated that the noise and the shuddering were intermittent but were more frequent. There was no warning light illuminated. The contact stated that the vehicle was taken to a dealer twice to be repaired; however, the dealer was unable to duplicate the failure. The contact stated that the noise gradually became louder, with the failure occurring at various speeds. The vehicle was taken back to the dealer where it was diagnosed, and metal fragments were found in the transmission fluid. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was a Warranty Extension for similar vehicles; however, the vehicle was not covered. The failure mileage was approximately 109,000.
NHTSA ODI #11645589
Mileage unknown · Nov 7, 2024
Power Train
The transmission on my 2020 HRV Honda failed at 63,000 miles. We were at risk because we were driving on a freeway with speed limit of 70 mph and we could only go 30 mph. The problem has been identified by American Honda but they would not extend the warranty to 2020 cars. The transmission had to be replaced and the new one is w…
Read full complaint
The transmission on my 2020 HRV Honda failed at 63,000 miles. We were at risk because we were driving on a freeway with speed limit of 70 mph and we could only go 30 mph. The problem has been identified by American Honda but they would not extend the warranty to 2020 cars. The transmission had to be replaced and the new one is working. They were no warning signs of the failure. American Honda is saying that the NHTSB is responsible for issuing all recalls. Please help. This was a huge expense that Honda knows full and well that it was a CVT failure on their HRVs. The case number with American Honda is 14909647.
NHTSA ODI #11623999
Mileage unknown · Feb 12, 2024
Power Train
Driving 65 on freeway, power loss and all the lights came on. pulled over and put it in park, dash said i was still in N and i took my foot off brake and it was rolling. I shut car off and waited so i could get to safer place. was able to start up - with all lights flashing. Poor power, "limped" to the closest parking lot - a…
Read full complaint
Driving 65 on freeway, power loss and all the lights came on. pulled over and put it in park, dash said i was still in N and i took my foot off brake and it was rolling. I shut car off and waited so i could get to safer place. was able to start up - with all lights flashing. Poor power, "limped" to the closest parking lot - about 1/2 mile. dealer said it was the battery and there were shavings in the transmission fluid. said they would check it again at my next oil change, but it was fine. 5 days later it happened again - same scenario. had it towed to closest dealership - and waiting for diagnosis. they suspect it needs a transmission replacement. they are checking with their "Honda TechLine"
NHTSA ODI #11571518
Official recalls
5May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
May 31, 2024
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Additional source detail variants (2)
Back Over Prevention:software
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Back Over Prevention:display Function
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Feb 2, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Additional source detail variants (2)
Back Over Prevention:display Function
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE22011 · Rear Differential Seizure
Opened Nov 28, 2022 · Closed Jul 22, 2024
Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Additional source detail variants (6)
Power Train:axle Assembly:axle Shaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly:axle Shaft:seal
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:differential Unit
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Illustration