2024 Honda Civic

I am filing this complaint regarding an unresolved steering issue involving my vehicle and the handling of NHTSA Recall 24V-744. My vehicle was subject to Recall 24V-744, which involved a steering-related safety issue. I brought the vehicle to the dealer for the recall repair. The dealer applied grease as part of the recall service and represented that the issue had been addressed. However, the steering problem did not go away. I subsequently returned to the dealer because I was still experiencing the same steering issue. Instead of treating the continuing problem as related to the recall repair, the dealer charged me a diagnostic fee and is refusing to cover the cost of the steering rack. I am concerned because the vehicle continues to have a steering-related problem after the recall repair was performed. The fact that the dealer’s initial recall repair did not resolve the issue raises concerns about whether the recall condition was properly diagnosed or repaired, or whether a related component has failed as a result of the same underlying problem. I do not believe I should be responsible for paying a diagnostic fee or the cost of a steering rack if the problem is related to the recalled steering condition or the attempted recall repair. I am requesting that NHTSA investigate whether the dealer properly performed the recall repair, whether the continuing steering problem is related to Recall 24V-744, and whether additional corrective action is necessary. I am particularly concerned about the safety implications of continuing to operate a vehicle with an unresolved steering problem. I would like the manufacturer/dealer to properly diagnose and correct the underlying steering issue and address the costs I have incurred as a result of the unsuccessful recall repair. Even the mechanic said that it was a internal steering issue. Please see reported attached.

1. Component Failed & Inspection Availability:The Electronic Power Steering (EPS) Gearbox and Rack Assembly malfunctioned and failed. The component is currently installed on the vehicle and is fully available for inspection upon request.2. Safety Risks:The steering wheel physically binds, catches, and sticks when traveling at highway speeds (between 45–70 mph). Controlling the vehicle requires increased steering effort to break through the physical stickiness, causing the vehicle to suddenly jerk. This poses an immediate crash hazard as it makes maintaining a straight line or making minor lane corrections incredibly dangerous for myself and other drivers on the road.3. Dealer/Independent Confirmation:The vehicle was previously taken to an authorized Honda dealership for NHTSA Campaign 24V-744. The dealership performed a temporary grease/spring intervention and marked the recall as "Completed" or removed on my VIN. The mechanical failure has now returned and worsened at 76,000 miles. A secondary local dealership has verbally confirmed the steering rack requires full replacement but is refusing to formally diagnose or inspect the failed safety component without an out-of-pocket $210 diagnostic fee.4. Entity Inspection:The component was previously inspected and serviced only by an authorized Honda dealership during the initial recall rollout. It has not been inspected by police or insurance.5. Warning Lamps & Prior Symptoms:There are currently intermittent "Steering System Problem" and "Lane Keeping Assist / ADAS Failure" warning messages appearing on the dashboard. The primary symptom is a distinct "sticky" or "notchy" resistance when turning the wheel. These symptoms first appeared gradually over the last several thousand miles following the failure of the initial dealership recall remedy.

Numerous defects in my 2024 Honda Civic Sport. I leased this vehicle in January 2024 for 36 months (with a $4,675 down payment and $284.62 monthly payments). From early in the lease, the car has been plagued with serious problems. Below is a chronological list of the issues my vehicle has experienced: Gearbox replacement – Feb 3, 2025 (12,792 miles): The vehicle’s transmission/gearbox failed catastrophically and was replaced under warranty. Axle boots replacement – Feb 19, 2025 (13,384 miles): Soon after, the front axle boots were found to be defective (leaking) and were replaced. Climate control panel failure (moisture damage) – Mar 6, 2025 (13,892 miles): The climate control and infotainment panel stopped functioning due to moisture intrusion and had to be replaced. Refusal to diagnose vibration issue – June 27, 2025 (18,116 miles): I reported a persistent and concerning vibration during driving (which could indicate an unresolved powertrain or suspension issue), but the dealership refused to perform a diagnostic or address it, returning the car to me without resolution. Steering wheel damage & falsified report – June 30, 2025: During a service visit, dealership personnel damaged the steering wheel and then provided a false report that inaccurately stated the damage was pre-existing, instead of taking responsibility. Ongoing audio system malfunctions – (continuing issue): The car’s audio system suffers from frequent USB/Bluetooth disconnections, which have persisted despite multiple service visits. The car's lane assist is triggered at random during drives almost causing several auto accidents. Every one of these issues is documented through repair orders and correspondence. I have maintained a file with all relevant service records, emails with the dealer (Honda of Van Nuys), and photographic evidence (such as photos of the steering wheel after the damage on June 30, 2025). These docs are available