NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,183 reports112,000 miles · Dec 20, 2012
Structure
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO THE DEALER FOR ROUTINE SERVICE WHEN HE WAS ADVISED THAT THE REAR AND FRONT OF THE SUB-FRAME WAS COMPLETELY RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO THE DEALER FOR ROUTINE SERVICE WHEN HE WAS ADVISED THAT THE REAR AND FRONT OF THE SUB-FRAME WAS COMPLETELY RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000. THE CURRENT MILEAGE WAS APPROXIMATELY 115,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10489396
129,000 miles · Dec 18, 2012
Power Train
EXPERIENCING TRANSMISSION PROBLEM WHICH HONDA IS REFUSING TO REPAIR/REPLACE. HONDA IS AWARE OF THIS PROBLEM AND HAS EXTENDED THE WARRANTY TO 7 YEAR 7 MONTHS OR 109K MILES BUT MY CAR HAPPENS TO FAIL JUST OUTSIDE OF THE WARRANTY. THE ON TIME SCHEDULED MAINTENANCE AND PROPER TREATMENT IS PROBABLY TO BLAME. CONSIDER THIS AS MY FO…
Read full complaint
EXPERIENCING TRANSMISSION PROBLEM WHICH HONDA IS REFUSING TO REPAIR/REPLACE. HONDA IS AWARE OF THIS PROBLEM AND HAS EXTENDED THE WARRANTY TO 7 YEAR 7 MONTHS OR 109K MILES BUT MY CAR HAPPENS TO FAIL JUST OUTSIDE OF THE WARRANTY. THE ON TIME SCHEDULED MAINTENANCE AND PROPER TREATMENT IS PROBABLY TO BLAME. CONSIDER THIS AS MY FORMAL COMPLAINT AGAINST HONDA FOR NOT STANDING BEHIND THEIR PRODUCT AND INADEQUATE CUSTOMER SERVICE. *TR
NHTSA ODI #10489134
148,000 miles · Dec 18, 2012
Power Train
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE WOULD SPORADICALLY BECOME STUCK IN SECOND GEAR. WHEN THE VEHICLE INDEPENDENTLY SHIFTED OUT OF SECOND GEAR, IT WOULD CAUSE A VIOLENT JERKING MOTION. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS TOLD THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE WOULD SPORADICALLY BECOME STUCK IN SECOND GEAR. WHEN THE VEHICLE INDEPENDENTLY SHIFTED OUT OF SECOND GEAR, IT WOULD CAUSE A VIOLENT JERKING MOTION. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS TOLD THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE FAILURE WOULD RECUR MOSTLY IN COLDER WEATHER. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 148,000 AND THE CURRENT MILEAGE WAS 168,000.
NHTSA ODI #10489104
151,700 miles · Dec 15, 2012
Air BagsFuel/propulsion SystemStructureCrash
I WAS PULLING INTO THE PARKING SPACE AFTER DRIVING THE VEHICLE FOR 45 MINS (APPROX. 20 MILES). WHEN I WAS READY PARK THE CAR AND SWITCH OFF THE IGNITION, THE CAR SUDDENLY ACCELERATED WAY TOO FAST AND HIT THE BUILDING IN FRONT. I WAS DRIVING INTO THE PARKING SPACE AT LESS THAN AROUND 10 MPH AS I HAD TO MAKE 3 TURNS WITHIN 100 FEE…
Read full complaint
I WAS PULLING INTO THE PARKING SPACE AFTER DRIVING THE VEHICLE FOR 45 MINS (APPROX. 20 MILES). WHEN I WAS READY PARK THE CAR AND SWITCH OFF THE IGNITION, THE CAR SUDDENLY ACCELERATED WAY TOO FAST AND HIT THE BUILDING IN FRONT. I WAS DRIVING INTO THE PARKING SPACE AT LESS THAN AROUND 10 MPH AS I HAD TO MAKE 3 TURNS WITHIN 100 FEET BEFORE COMING INTO VACANT PARKING SPACE. MY LEG WAS ALSO IN THE BREAK PEDAL AS I MADE THOSE TURNS AFTER GETTING INTO THE PRIVATE PROPERTY FROM IL RTE 83. I CAN DEFINITELY CONFIRM THAT MY LEG WAS NOT IN GAS PEDAL AS MY RIGHT LEG WAS ON THE BREAK PEDAL TO MAKE THOSE TURNS AND STOP THE CAR IN THE PARKING SPACE. IT ALL HAPPENED IN THE MATTER OF FEW SECONDS AND THERE WAS NO TIME TO REACT. THE CAR CAME TO HALT ONLY AFTER HITTING THE BUILDING. BOTH AIR BAGS DEPLOYED AS SOON AS THE CAR HIT THE BUILDING AND THERE WAS HEAVE SMOKE INSIDE THE CAR. IT WAS REALLY SCARY BECAUSE BY LOOKING AT THE DAMAGE THE SPEED AT THE TIME OF ACCIDENT LOOKS TO BE AROUND 50 MPH. IT WAS A RELATIVELY HIGHER CURB IN FRONT AND THE BUILDING WAS JUST 6 - 8 FEET AWAY FROM THE CURB, I WAS ALSO DRIVING INTO THE PARKING SPACE AT LESS THAN 10 MPH. I AM REALLY SHOCKED TO SEE THIS KIND OF UNINTENDED/SUDDEN ACCELERATION HAPPEN WITH HONDA ACCORD CARS WHICH COULD PROVE TO BE FATAL FOR THE DRIVER, PASSENGER AND PEDESTRIAN ALIKE. *TR
NHTSA ODI #10488888
100,000 miles · Dec 12, 2012
Air BagsElectrical System
THE SRS LIGHT CAME ON. HONDA TELLS US THAT THE COMPONENT THAT REGULATES THE AIRBAGS (A MINI-COMPUTER IN THE DASH?) HAS FAILED AND MUST BE REPLACED. HONDA ADVISES THAT, UNTIL REPLACED, THE AIRBAGS WILL NOT WORK. BASED ON THE INTERNET RESEARCH I HAVE DONE, THIS APPEARS TO BE A FAIRLY COMMON PROBLEM. HONDA WANTS TO CHARGE $1000 …
Read full complaint
THE SRS LIGHT CAME ON. HONDA TELLS US THAT THE COMPONENT THAT REGULATES THE AIRBAGS (A MINI-COMPUTER IN THE DASH?) HAS FAILED AND MUST BE REPLACED. HONDA ADVISES THAT, UNTIL REPLACED, THE AIRBAGS WILL NOT WORK. BASED ON THE INTERNET RESEARCH I HAVE DONE, THIS APPEARS TO BE A FAIRLY COMMON PROBLEM. HONDA WANTS TO CHARGE $1000 TO REPLACE THE UNIT, ALTHOUGH IT APPEARS THAT THE COMPONENT IS AVAILABLE ONLINE FOR ABOUT $325, AND REQUIRES ABOUT AN HOUR OF LABOR TO INSTALL. THIS SEEMS TO US TO BE A PRETTY FUNDAMENTAL SAFETY ISSUE, AND THIS COMPONENT SHOULD BE ENGINEERED TO LAST WELL BEYOND THE ANTICIPATED LIFETIME OF THE VEHICLE. *TR
NHTSA ODI #10488119
66,200 miles · Dec 4, 2012
Air Bags
ON NOVEMBER 26, 2012 MY SRS LIGHT CAME ON AND HAS STAYED ON SINCE. THIS VEHICLE THOUGH IT IS A 2000 HONDA ACCORD HAS ONLY 66,200 ORIGINAL MILES WILL COST ABOUT $800-$900 TO REPAIR. THIS IS AN ISSUE WHICH INVOLVES THE SAFETY OF THE DRIVER AND ANY PASSENGERS. I AM TOLD IT COULD BE A POSSIBLE DANGER IF THE AIRBAG DOES NOT DEPLO…
Read full complaint
ON NOVEMBER 26, 2012 MY SRS LIGHT CAME ON AND HAS STAYED ON SINCE. THIS VEHICLE THOUGH IT IS A 2000 HONDA ACCORD HAS ONLY 66,200 ORIGINAL MILES WILL COST ABOUT $800-$900 TO REPAIR. THIS IS AN ISSUE WHICH INVOLVES THE SAFETY OF THE DRIVER AND ANY PASSENGERS. I AM TOLD IT COULD BE A POSSIBLE DANGER IF THE AIRBAG DOES NOT DEPLOY IN ANY ACCIDENT. I AM NOT SURE OF THE SIGNIFICANCE; I GET DIFFERENT STORIES FROM FOLKS. IT IS MY UNDERSTANDING FROM SOME RESEARCH THAT THIS LIGHT COULD POSSIBLY COME ON AND STAY ON AFTER RECENT TRANSMISSIONS PROBLEMS. MAY 9, 2012 JUST FIVE MONTHS AFTER HAVING MY TRANSMISSION FLUID REPLACED I NEEDED TO HAVE A REBUILT TRANSMISSION AT A COST OF $3757. FOR SEVERAL WEEKS I HAD DISCUSSIONS WITH HONDA CUSTOMER SERVICE DEPARTMENT TO NO AVAIL. I PERSONALLY WILL NEVER BUY ANOTHER HONDA PRODUCT IN MY LIFETIME AND INTEND TO DISCUSS THIS SITUATION WITH ANY PERSON CONSIDERING BUYING THIS PRODUCT. I HAVE BEEN A LOYAL AND FAITHFUL CAR OWNER WITH MY HONDA DEALER SINCE I PURCHASED THE VEHICLE. I RECEIVED ALL SCHEDULED SERVICES EVEN THOUGH I DID NOT HAVE THE RECOMMENDED MILEAGE. THIS IS MY REWARD, A ROTTEN CAR FROM A ROTTEN COMPANY. *TR
NHTSA ODI #10487378
175,000 miles · Dec 4, 2012
Suspension
EXCESSIVE RUST ON PASSENGER SIDE SUB FRAME UNDER AIR CONDITIONER DRAIN. DRIVER SIDE IS OK. *TR
NHTSA ODI #10487303
164,869 miles · Nov 21, 2012
Engine
I FIRST NOTICED THAT WHEN THE CAR WAS IDLING, IT DIDN'T SOUND EXACTLY RIGHT. THEN ABOUT A WEEK LATER WE NOTICED THAT WHEN WE BEGAN TO STOP, THE CAR JUMPED. AFTER THAT WHEN YOU GO TO TAKE OFF FROM BEING STOPPED THE CAR WILL REV UP THE RPMS AND THEN THE MOTOR CATCHES UP AND JERKS INTO GEAR. WHEN WE CALLED AND TALKED TO A MECHAN…
Read full complaint
I FIRST NOTICED THAT WHEN THE CAR WAS IDLING, IT DIDN'T SOUND EXACTLY RIGHT. THEN ABOUT A WEEK LATER WE NOTICED THAT WHEN WE BEGAN TO STOP, THE CAR JUMPED. AFTER THAT WHEN YOU GO TO TAKE OFF FROM BEING STOPPED THE CAR WILL REV UP THE RPMS AND THEN THE MOTOR CATCHES UP AND JERKS INTO GEAR. WHEN WE CALLED AND TALKED TO A MECHANIC (HIGHLY KNOWN FOR TRANSMISSIONS) ABOUT IT, HE TOLD US THAT THEY HAVE BEEN HAVING A LOT OF PROBLEMS WITH THE 1998-2000 MODEL HONDAS, AFTER 100,000 MILES DOING THIS, THAT THE TRANSMISSION IS GOING OUT ON IT, THAT WE NEED TO HAVE IT REPLACED. I WAS EXPECTING TO HAVE THIS CAR FOR A LONG, LONG TIME, AS HONDA IS KNOWN FOR BEING A VERY RELIABLE CAR. *TR
NHTSA ODI #10485399
114,000 miles · Nov 1, 2012
Equipment
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT THE AIR CONDITIONING TUBE FAILED AND AS A RESULT, THE AIR CONDITIONING FLUID LEAKED ONTO THE SUB-FRAME CAUSING THE FRAME TO CORRODE. THE CONTACT STATED THAT DUE TO THE FAILURE THE FUEL TANK AND FUEL LINES NEEDED TO BE REPLACED. THE SUB-FRAME WAS NOT REPAIRED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT THE AIR CONDITIONING TUBE FAILED AND AS A RESULT, THE AIR CONDITIONING FLUID LEAKED ONTO THE SUB-FRAME CAUSING THE FRAME TO CORRODE. THE CONTACT STATED THAT DUE TO THE FAILURE THE FUEL TANK AND FUEL LINES NEEDED TO BE REPLACED. THE SUB-FRAME WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 114,000.
NHTSA ODI #10482856
109,000 miles · Oct 27, 2012
Power Train
TRANSMISSION STARTED SLIPPING JUST OUTSIDE OF THE 100,000 EXTENDED WARRANTY HONDA DID BECAUSE OF MULTIPLE COMPLAINTS ABOUT TRANSMISSION ISSUES. *TR
NHTSA ODI #10482429
Official recalls
8Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 2001-2002 Acura 3.2CL, 2000-2003 Acura 3.5RL, 2000-2001 Acura 3.2TL, Honda CR-V and Honda Odyssey, 2001-2002 Acura MDX and 2000 Accord Coupe, Accord Sedan, Civic Coupe, and Civic Sedan vehicles. These vehicles may have received a replacement driver frontal air bag module as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the air bags in the vehicles, replacing the driver frontal air bag inflator with an inflator of a different design, as necessary, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138.
Jan 28, 2005
ON CERTAIN PASSENGER VEHICLES, THE INTERLOCK OPERATION OF THE IGNITION SWITCH MAY NOT FUNCTION PROPERLY, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO PARK.
Consequence & remedy
Consequence: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT CONFIRMS INTERLOCK FUNCTION. VEHICLES WILL BE UPDATED WITH A REDESIGNED INTERLOCK LEVER FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Jun 7, 2004
ON CERTAIN PASSENGER VEHICLES, THE DIMMER CONTROL FOR THE INSTRUMENT PANEL LIGHTS COULD FAIL DUE TO HEAT BUILDUP.
Consequence & remedy
Consequence: IF THIS OCCURS, THE INSTRUMENT LIGHTS MAY FAIL AND, AT NIGHT, THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES, SUCH AS THE SPEEDOMETER.
Remedy: DEALERS WILL REPLACE A MULTIPLEX CONTROL UNIT FOR THE INSTRUMENT PANEL LIGHTS. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
Mar 14, 2002
ON CERTAIN PASSENGER VEHICLES, A COMPONENT IN THE INFLATOR OF SOME PASSENGER AIR BAG MODULES WAS NOT WELDED PROPERLY.
Consequence & remedy
Consequence: AS A RESULT, THE AFFECTED AIR BAGS MAY NOT DEPLOY CORRECTLY IN A CRASH, INCREASING THE RISK OF INJURY TO A FRONT SEAT PASSENGER.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. OWNER NOTIFICATION BEGAN APRIL 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Feb 8, 2002
CERTAIN SEDANS AND COUPES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." CERTAIN REAR SEAT BELT BUCKLES WERE IMPROPERLY MANUFACTURED.
Consequence & remedy
Consequence: THE REAR SEAT BELTS WILL WORK PROPERLY AND PROVIDE PROTECTION IN A CRASH, BUT THE OWNER MAY EXPERIENCE DIFFICULTY UNFASTENING THE BELT AFTER THE CRASH.
Remedy: IN A PREVIOUS RECALL (01V-380), ONLY RIGHT AND LEFT BUCKLES WERE INSPECTED. THE REAR CENTER BUCKLE SHOULD ALSO BE INSPECTED AND CORRECTED IF NECESSARY. THIS RECALL IS BEING CONDUCTED ONLY FOR THE CENTER BUCKLE. DEALERS WILL INSPECT THE VEHICLES AND REPLACE THE SEAT BELT ASSEMBLIES THAT WERE IMRPOPERLY MANUFACTURED. ONLY BUCKLES THAT ARE MARKED (ON THE BACK SIDE OF THE BUCKLE) WITH AN ASSEMBLY NUMBER BEGINNING WITH 00185, 00186, OR 00187, WILL BE REPLACED. OWNERS SHOULD CONTACT THEIR DEALER FOR THIS REPLACEMENT. OWNER NOTIFICATION BEGAN MARCH 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009.
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN SEDANS AND COUPES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." CERTAIN REAR SEAT BELT BUCKLES WERE IMPROPERLY MANUFACTURED.
Consequence & remedy
Consequence: THE REAR SEAT BELTS WILL WORK PROPERLY AND PROVIDE PROTECTION IN A CRASH, BUT THE OWNER MAY EXPERIENCE DIFFICULTY UNFASTENING THE BELT AFTER THE CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND REPLACE THE SEAT BELT ASSEMBLIES THAT WERE IMPROPERLY MANUFACTURED. ONLY BUCKLES THAT ARE MARKED (ON THE BACK SIDE OF THE BUCKLE) WITH AN ASSEMBLY NUMBER BEGINNING WITH 00185, 00186, OR 00187, WILL BE REPLACED. OWNERS SHOULD CONTACT THEIR DEALER FOR THIS REPLACEMENT. OWNER NOTIFICATION BEGAN JANUARY 22, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009.
Jul 14, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SUSPENSION LOWER ARMS AND/OR CONTROL ARMS COULD BREAK DUE TO IMPROPER WELDING.
Consequence & remedy
Consequence: VEHICLE HANDLING AND CONTROL WOULD BE REDUCED.
Remedy: DEALERS WILL INSPECT AND REPLACE THE REAR SUSPENSION LOWER ARMS OR CONTROL ARMS IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE05043 · Srs Readiness Indicator Illumination
Opened Aug 12, 2005 · Closed Mar 24, 2006
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL INTERFERENCE THAT WOULD RESULT IN THE ILLUMINATION OF THE SRS READINESS INDICATOR.IN THIS CONDITION, OPDS SUPPRESSION WILL NOT FUNCTION, BUT THE SIDE AIRBAG WILL STILL DEPLOY IN THE EVENT OF A SIDE CRASH. HONDA ISSUED A TECHNICAL SERVICE BULLETIN IN APRIL 2004 TO ADDRESS THIS PROBLEM. HOWEVER, THE PROBLEM PERSISTS EVEN AFTER THE WARRANTY PERIOD EXPIRES.AS A RESULT, SOME OWNERS MAY NOT BE OBTAINING THE NECESSARY REMEDIAL SERVICE WORK.CONTINUED ILLUMINATION OF THE SRS INDICATOR CAN MASK THE DETECTION OF OTHER AIRBAG COMPONENT FAULTS IF THEY OCCUR. IN MARCH 2006, HONDA ISSUED A SERVICE BULLETIN (06-009) TO EXTEND THE WARRANTY ON SRS ILLUMINATION AND OPDS ISSUES TO 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST).HONDA WILL SEND NOTIFICATION LETTERS TO OWNERS OF THE SUBJECT VEHICLES AND WILL PROVIDE A NO COST REPLACEMENT OF THE OPDS UNIT AS NEEDED.IN ADDITION, OTHER MY 1999-04 HONDA AND ACURA VEHICLES ARE ALSO COVERED BY THE BULLETIN.THIS ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:frontal:sensor/control MODULE-INACTIVE
THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL INTERFERENCE THAT WOULD RESULT IN THE ILLUMINATION OF THE SRS READINESS INDICATOR.IN THIS CONDITION, OPDS SUPPRESSION WILL NOT FUNCTION, BUT THE SIDE AIRBAG WILL STILL DEPLOY IN THE EVENT OF A SIDE CRASH. HONDA ISSUED A TECHNICAL SERVICE BULLETIN IN APRIL 2004 TO ADDRESS THIS PROBLEM. HOWEVER, THE PROBLEM PERSISTS EVEN AFTER THE WARRANTY PERIOD EXPIRES.AS A RESULT, SOME OWNERS MAY NOT BE OBTAINING THE NECESSARY REMEDIAL SERVICE WORK.CONTINUED ILLUMINATION OF THE SRS INDICATOR CAN MASK THE DETECTION OF OTHER AIRBAG COMPONENT FAULTS IF THEY OCCUR. IN MARCH 2006, HONDA ISSUED A SERVICE BULLETIN (06-009) TO EXTEND THE WARRANTY ON SRS ILLUMINATION AND OPDS ISSUES TO 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST).HONDA WILL SEND NOTIFICATION LETTERS TO OWNERS OF THE SUBJECT VEHICLES AND WILL PROVIDE A NO COST REPLACEMENT OF THE OPDS UNIT AS NEEDED.IN ADDITION, OTHER MY 1999-04 HONDA AND ACURA VEHICLES ARE ALSO COVERED BY THE BULLETIN.THIS ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL INTERFERENCE THAT WOULD RESULT IN THE ILLUMINATION OF THE SRS READINESS INDICATOR.IN THIS CONDITION, OPDS SUPPRESSION WILL NOT FUNCTION, BUT THE SIDE AIRBAG WILL STILL DEPLOY IN THE EVENT OF A SIDE CRASH. HONDA ISSUED A TECHNICAL SERVICE BULLETIN IN APRIL 2004 TO ADDRESS THIS PROBLEM. HOWEVER, THE PROBLEM PERSISTS EVEN AFTER THE WARRANTY PERIOD EXPIRES.AS A RESULT, SOME OWNERS MAY NOT BE OBTAINING THE NECESSARY REMEDIAL SERVICE WORK.CONTINUED ILLUMINATION OF THE SRS INDICATOR CAN MASK THE DETECTION OF OTHER AIRBAG COMPONENT FAULTS IF THEY OCCUR. IN MARCH 2006, HONDA ISSUED A SERVICE BULLETIN (06-009) TO EXTEND THE WARRANTY ON SRS ILLUMINATION AND OPDS ISSUES TO 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST).HONDA WILL SEND NOTIFICATION LETTERS TO OWNERS OF THE SUBJECT VEHICLES AND WILL PROVIDE A NO COST REPLACEMENT OF THE OPDS UNIT AS NEEDED.IN ADDITION, OTHER MY 1999-04 HONDA AND ACURA VEHICLES ARE ALSO COVERED BY THE BULLETIN.THIS ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05002 · IGNITION-PARK Interlock
Opened Jan 13, 2005 · Closed Feb 2, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Additional source detail variants (3)
Electrical System
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
DP04006 · IGNITION-PARK Interlock
Opened Oct 8, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Additional source detail variants (2)
Electrical System:ignition
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration