NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,135 reports165,000 miles · Dec 29, 2014
Suspension
I HEARD A KNOCK IN THE FRONT SUSPENSION AND TOOK THE ACCORD INTO AN AUTO SHOP THAT WAS OPEN ON SUNDAY. THEY PUT IT ON THE LIFT AND FOUND THE ENGINE SUBFRAME WAS RUSTED THROUGH ON THE PASSENGER SIDE. THEY SAID THE CAR WAS UNSAFE TO DRIVE AND WOULD REQUIRE A NEW SUBFRAME. IT'S THE ONLY RUST ON THE CAR. RESEARCH ONLINE FOUND THAT I…
Read full complaint
I HEARD A KNOCK IN THE FRONT SUSPENSION AND TOOK THE ACCORD INTO AN AUTO SHOP THAT WAS OPEN ON SUNDAY. THEY PUT IT ON THE LIFT AND FOUND THE ENGINE SUBFRAME WAS RUSTED THROUGH ON THE PASSENGER SIDE. THEY SAID THE CAR WAS UNSAFE TO DRIVE AND WOULD REQUIRE A NEW SUBFRAME. IT'S THE ONLY RUST ON THE CAR. RESEARCH ONLINE FOUND THAT IN 2012 THE CENTER FOR AUTOMOTIVE SAFETY IDENTIFIED THIS AS A PERSISTENT PROBLEM WITH ACCORDS, AS HONDA DESIGNED THE AC TO VENT CONDENSATION DIRECTLY ONTO THE SUBFRAME. THEY ASKED HONDA TO DO A VOLUNTARY RECALL, AS BOTH TOYOTA AND FORD DID WITH SIMILAR ISSUES FOR SIMILAR YEARS. HONDA'S CUSTOMER SERVICE SAID THAT THEY HAVE NO KNOWLEDGE OF THIS BEING A PROBLEM, AND DENIED THE RECALL. *TR
NHTSA ODI #10668705
62,451 miles · Dec 12, 2014
Power Train
MY TRANSMISSION FAILED BECAUSE I WAS TOLD THE TORQUE CONVERTER SHOULD HAVE BEEN REPLACED BY THE MANUFACTURER HONDA IMMEDIATELY AFTER HONDA REALIZED THE 199 HONDA ACCORD TORQUE CONVERTERS WERE FAULTY. I PURCHASED MY CAR NEW AND WAS NOT TOLD ABOUT THE SITUATION UNTIL THE TRANSMISSION FAILED DUE TO THE FAULTY TORQUE CONVERTER. HO…
Read full complaint
MY TRANSMISSION FAILED BECAUSE I WAS TOLD THE TORQUE CONVERTER SHOULD HAVE BEEN REPLACED BY THE MANUFACTURER HONDA IMMEDIATELY AFTER HONDA REALIZED THE 199 HONDA ACCORD TORQUE CONVERTERS WERE FAULTY. I PURCHASED MY CAR NEW AND WAS NOT TOLD ABOUT THE SITUATION UNTIL THE TRANSMISSION FAILED DUE TO THE FAULTY TORQUE CONVERTER. HONDA DID NOT SET UP A RECALL OR NOTIFY 199 HONDA ACCORD OWNERS. THEY PAID FOR THE REPAIRS WHEN THE TRANSMISSIONS FAILED FOR A FEW YEARS. I HAVE ONLY 62,45A MILES ON MY CAR AND NOW HAVE A $3007.00 BILL TO REPLACE MY TRANSMISSION. THIS WOULD NOT HAVE OCCURRED IF I WAS TOLD TO REPLACE THE TORQUE CONVERTER BY HONDA AS SOON AS THEY WERE AWARE OF THE PROBLEM. I SHOULD BE REIMBURSED BY HONDA. THEY REFUSE TO DO SO. *TR
NHTSA ODI #10663945
Mileage unknown · Dec 10, 2014
Electrical SystemEngine
I WANTED TO COMPLAIN BECAUSE THIS IS THE 2ND TIME WITHIN 5 YEARS THAT I'M HAVING TO HAVE MY EGR PORT CLEANED AGAIN WHICH IS COSTLY. ALSO I THE SAME THING WITH THE IGNITION SWITCH WIRES, WHICH WERE RECALLED AND REPLACED 5 YEARS LATER ALSO TRYING TO SPARK A FIRE. I AM STILL THE ORIGINAL OWNER OF MY HONDA AND HAVING THE SAME PROBL…
Read full complaint
I WANTED TO COMPLAIN BECAUSE THIS IS THE 2ND TIME WITHIN 5 YEARS THAT I'M HAVING TO HAVE MY EGR PORT CLEANED AGAIN WHICH IS COSTLY. ALSO I THE SAME THING WITH THE IGNITION SWITCH WIRES, WHICH WERE RECALLED AND REPLACED 5 YEARS LATER ALSO TRYING TO SPARK A FIRE. I AM STILL THE ORIGINAL OWNER OF MY HONDA AND HAVING THE SAME PROBLEM ONCE AGAIN ABOUT MY EGR AFTER I PAID LOTS OF $$$$$$$$$$.I THINK SOMEBODY NEED TO INVESTIGATE IF THE PARTS ONLY LAST FOR 5 YEARS AT A TIME. *TR
NHTSA ODI #10663360
Mileage unknown · Dec 3, 2014
Structure
THE CLEAR COAT/PAINT IS PEELING/WEARING OFF OF MY 1999 HONDA ACCORD. IT IS CAUSING THE VEHICLE TO LOOK HORRIBLE. THOUSANDS OF OTHER HONDA OWNERS HAVE THE SAME PROBLEM, YOU SEE THE SAME CAR WITH SAME COLOR (GREEN) ON THE ROAD. IF I HAVE THE CAR REPAINTED, IT WILL COST OVER $1000. THIS IS UNACCEPTABLE AND HONDA SHOULD BE HELD ACC…
Read full complaint
THE CLEAR COAT/PAINT IS PEELING/WEARING OFF OF MY 1999 HONDA ACCORD. IT IS CAUSING THE VEHICLE TO LOOK HORRIBLE. THOUSANDS OF OTHER HONDA OWNERS HAVE THE SAME PROBLEM, YOU SEE THE SAME CAR WITH SAME COLOR (GREEN) ON THE ROAD. IF I HAVE THE CAR REPAINTED, IT WILL COST OVER $1000. THIS IS UNACCEPTABLE AND HONDA SHOULD BE HELD ACCOUNTABLE FOR THIS DEFECT AND THE PAINT BE RECALLED. [XXX] [XXX] LAKE JUNALUSKA NC [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS
NHTSA ODI #10661951
105,200 miles · Nov 22, 2014
Structure
MY CAR HAS BEEN MAKING CLUNKING NOISE FROM THE BOTTOM FOR ABOUT 2-3 WEEKS AND HAS BEEN GETTING WORSE. I TOOK IT TO A MECHANIC, HE SHOWED ME THE CRADLE/SUBFRAME ON THE PASSENGER SIDE RUSTED HEAVILY AND ALMOST BREAKING OFF. IN RESEARCHING ON THE INTERNET I SEE THIS IS A COMMON PROBLEM WITH 1999-2002 ACCORDS, DUE TO WATER LEAKING F…
Read full complaint
MY CAR HAS BEEN MAKING CLUNKING NOISE FROM THE BOTTOM FOR ABOUT 2-3 WEEKS AND HAS BEEN GETTING WORSE. I TOOK IT TO A MECHANIC, HE SHOWED ME THE CRADLE/SUBFRAME ON THE PASSENGER SIDE RUSTED HEAVILY AND ALMOST BREAKING OFF. IN RESEARCHING ON THE INTERNET I SEE THIS IS A COMMON PROBLEM WITH 1999-2002 ACCORDS, DUE TO WATER LEAKING FROM AC CONDENSATION. THIS HAS BEEN REPORTED AS A SERIOUS MECHANICAL/FRAME ISSUE WITH POSSIBILITY OF BECOMING CATASTROPHIC. MY MECHANIC IS LOOKING TO ORDER THE SUBFRAME FROM AN HONDA DEALER BUT I THINK THIS IS A SERIOUS DESIGN PROBLEM. THESE VEHICLES SHOULD BE RECALLED AND FIXED BY HONDA. *TR
NHTSA ODI #10660283
Mileage unknown · Nov 11, 2014
Structure
THE CAR'S CLEAR COAT IS PEELING AND HAS BEEN SINCE ABOUT 2005 WHEN I BROUGHT IT TO THEIR ATTENTION AND ALSO EXPLAINED THERE ARE MANY OTHER OF THE SAME CARS HAVING THE SAME PROBLEM I WAS TOLD IT WAS PARKING UNDER A TREE, OR BIRD POOP, OR SUN DAMAGE BUT I HAVE A FRIEND YOU DOES ALL OR THE ABOVE WITH THEIR CAR AND THERE IS NO PROBL…
Read full complaint
THE CAR'S CLEAR COAT IS PEELING AND HAS BEEN SINCE ABOUT 2005 WHEN I BROUGHT IT TO THEIR ATTENTION AND ALSO EXPLAINED THERE ARE MANY OTHER OF THE SAME CARS HAVING THE SAME PROBLEM I WAS TOLD IT WAS PARKING UNDER A TREE, OR BIRD POOP, OR SUN DAMAGE BUT I HAVE A FRIEND YOU DOES ALL OR THE ABOVE WITH THEIR CAR AND THERE IS NO PROBLEMS AND I DO NOT HAVE ANY OF THOSE PROBLEMS (YES A FEW BIRD POOPS BUT NOT EXTREME, AS WITH SUN). I EXPLAINED THAT I WENT TO A PROFESSIONAL PAINT PLACE AND THEY EXPLAINED THAT IT WAS EITHER THE WAY IT APPLIED OR THE BATCH(LOT) WAS A BAD BATCH AND YOU CAN TYPICALLY ISOLATE IT TO A AREA OR MANUFACTURE - NO I HAVE NOT HAD MY CAR REPAINTED I FEEL AS A CERTIFIED HONDA VEHICLE THEY SHOULD REPAINT IT ON THERE DIME. YES I HAVE HAD THE CAR FOR 11 YEARS BUT STILL I SHOULD HAVE BEEN ENTITLED TO NOT HAVING THE EMBARRASSMENT WHEN I TOOK GUESS OUT AND WITH MY NEIGHBORS THINKING I DON'T TAKE CARE OF MY CAR AS WITH FELLOW EMPLOYEES. SHAME FIRMS CAN'T STAND BEHIND "OH THERE AWARD WINNING" PRODUCT. I ALSO HAD SEVERAL ISSUES WITH THE TRANSMISSION THE SECOND YEAR AND IT TOOK 3 YEARS TO GET THAT RESOLVES, THEN THERE WAS A RECALL WITH A IGNITION PARTS THAT THEY FIXED AFTER THE CAR ROLLED INTO THE ROAD TWICE, AND IF YOU WANT TO CHANGE THE ODOMETER LIGHT YOU HAVE TO PAY TO HAVE THE DASH REMOVED - SAD. *TR
NHTSA ODI #10654173
Mileage unknown · Nov 9, 2014
Engine
TOOK MY CAR TO GET TIRES AND NOTICE SOMETHING HANGING! DROVE RIGHT TO AUTO SHOP FROM THERE ! PUT THE CAR UP AND RIGHT AWAY HE SAW THE PROBLEM! SUB FRAME WAS RUSTED COMPLETELY THROUGH! I DRIVE BACK IN FROTH FROM MICHIGAN TO OHIO TWICE A WEEK,HAVING KNOW IDEA THAT AT ANYTIME MY ENGINE MIGHT FALL OUT AND KILL ME! *TR
NHTSA ODI #10653682
300,030 miles · Nov 5, 2014
Engine
TL* THE CONTACT OWNS 1999 HONDA ACCORD LX. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 300,030.
NHTSA ODI #10652848
87,000 miles · Oct 29, 2014
Seat BeltsCrashInjury
DURING LATE NIGHT DRIVE IN CLEAR WEATHER AT ABOUT 30 MPH, AUTO VEERED INTO UTILITY POLE HITTING ON DRIVER'S SIDE FRONT. THE HONDA ACCORD COUPE HAS SEAT BELT WHOSE HEIGHT WHERE MOUNTED TO SIDE BODY OF CAR IS NOT ADJUSTABLE. THE SEAT BELT WORN CORRECTLY BY DRIVER, CUT ACROSS THE NECK OF THE 5'3" DRIVER AND ABOVE HER RIGHT BREAST…
Read full complaint
DURING LATE NIGHT DRIVE IN CLEAR WEATHER AT ABOUT 30 MPH, AUTO VEERED INTO UTILITY POLE HITTING ON DRIVER'S SIDE FRONT. THE HONDA ACCORD COUPE HAS SEAT BELT WHOSE HEIGHT WHERE MOUNTED TO SIDE BODY OF CAR IS NOT ADJUSTABLE. THE SEAT BELT WORN CORRECTLY BY DRIVER, CUT ACROSS THE NECK OF THE 5'3" DRIVER AND ABOVE HER RIGHT BREAST. DRIVER WAS TRANSPORTED BY AMBULANCE TO TWO HOSPITALS (THE FIRST DIDN'T FEEL IT COULD HANDLE THE INJURY). THE ONLY MAJOR INJURY WAS C2 CERVICAL FRACTURE REQUIRING (SO FAR) THE WEARING OF A RIGID MIAMI J NECK BRACE. FOLLOWUP WITH NEUROSURGEON WILL DETERMINE WHETHER THE INJURED NECK IS HEALING PROPERLY OR WILL REQUIRE SURGERY. *TR
NHTSA ODI #10651001
77,000 miles · Oct 20, 2014
Structure
THE SUBFRAME OF MY 1999 HONDA ACCORD EX HAS ROTTED THROUGH. THIS IS LOCATED ON THE FRONT PASSENGER SIDE NEAR THE STRUT ASSEMBLY, PRESUMABLY BENEATH THE AIR CONDITIONER DRAIN, AS NOTED BY OTHERS ON POSTINGS ON THE WORLD WIDE WEB. THE VEHICLE IS IN EXCELLENT CONDITION OTHERWISE, ESPECIALLY WITH VERY LOW MILES (77,000 MILES) I CO…
Read full complaint
THE SUBFRAME OF MY 1999 HONDA ACCORD EX HAS ROTTED THROUGH. THIS IS LOCATED ON THE FRONT PASSENGER SIDE NEAR THE STRUT ASSEMBLY, PRESUMABLY BENEATH THE AIR CONDITIONER DRAIN, AS NOTED BY OTHERS ON POSTINGS ON THE WORLD WIDE WEB. THE VEHICLE IS IN EXCELLENT CONDITION OTHERWISE, ESPECIALLY WITH VERY LOW MILES (77,000 MILES) I CONTACTED HONDA OF AMERICA AND THEY STATE THAT THE ROT IS NOT COVERED BY THEM. THIS WILL COST ME $1800 TO REPAIR. THERE IS NO OTHER ROT ON THE VEHICLE AND THE VEHICLE ONLY HAS 77,000 MILES. MY MECHANIC SAYS IT IS UNSAFE TO DRIVE. IT APPEARS TO BE THE RESULT OF A DESIGN FLAW RELATING TO THE LOCATION OF THE AIR CONDITIONER DRAIN. HONDA SHOULD BE MADE TO REPAIR THIS UNSAFE SITUATION. *TR
NHTSA ODI #10648843
Official recalls
4Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Jan 28, 2005
ON CERTAIN PASSENGER VEHICLES, THE INTERLOCK OPERATION OF THE IGNITION SWITCH MAY NOT FUNCTION PROPERLY, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO PARK.
Consequence & remedy
Consequence: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT CONFIRMS INTERLOCK FUNCTION. VEHICLES WILL BE UPDATED WITH A REDESIGNED INTERLOCK LEVER FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE05002 · IGNITION-PARK Interlock
Opened Jan 13, 2005 · Closed Feb 2, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Additional source detail variants (3)
Electrical System
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
DP04006 · IGNITION-PARK Interlock
Opened Oct 8, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Additional source detail variants (2)
Electrical System:ignition
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration