NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,200 reports176,000 miles · Nov 21, 2011
Electrical System
TL* THE CONTACT OWNS A 1998 HONDA ACCORD EX. THE CONTACT WAS DRIVING 45-55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND THEY CONFIRMED THAT THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 02V120000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) APPLIED TO THE VEHICLE B…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD EX. THE CONTACT WAS DRIVING 45-55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND THEY CONFIRMED THAT THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 02V120000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) APPLIED TO THE VEHICLE BUT THE RECALL HAD SINCE EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 176,000 AND THE CURRENT MILEAGE WAS 176,100.
NHTSA ODI #10436540
95,874 miles · Nov 10, 2011
Structure
THE FRONT SUBFRAME OF MY 1998 HONDA ACCORD LX HAS RUSTED THROUGH DUE TO SALT ACCUMULATION AT ONLY ~95K MILES MAKING IT A SAFETY HAZARD. THIS IS THE ONLY RUSTING ON THE CAR, EITHER THAN THAT SPOT THE CAR IS RUST FREE. *TR
NHTSA ODI #10435166
139,750 miles · Oct 18, 2011
Electrical SystemCrash
MY CAR UNDERWENT THE IGNITION SWITCH INTERLOCK RECALL IN 2002. BUT THIS IGNITION SWITCH WAS FAULTY AND AGAIN IN 2011, THE SWITCH FAILED. MY CAR STALLED A FEW TIMES ON THE FREEWAY AND I WAS IN GREAT DANGER OF BEING IN A ACCIDENT. THE SYSTEM WAS WHILE DRIVING THE CAR, IT WOULD IMMEDIATELY CUT OFF THE ENGINE AND IF I PUT IT BACK IN…
Read full complaint
MY CAR UNDERWENT THE IGNITION SWITCH INTERLOCK RECALL IN 2002. BUT THIS IGNITION SWITCH WAS FAULTY AND AGAIN IN 2011, THE SWITCH FAILED. MY CAR STALLED A FEW TIMES ON THE FREEWAY AND I WAS IN GREAT DANGER OF BEING IN A ACCIDENT. THE SYSTEM WAS WHILE DRIVING THE CAR, IT WOULD IMMEDIATELY CUT OFF THE ENGINE AND IF I PUT IT BACK IN NEUTRAL AND RESTART IT WOULD START FINE. HONDA KNEW ABOUT THE FAULTY SWITCH REPLACED AND NOW IS RECOMMENDING A NEW AND IMPROVED VERSION AT THE OWNERS COST. I HAD TO TOW THE CAR AT MY EXPENSE TO A NEARBY MECHANIC AND SPEND MY MONEY TO FIX THIS ISSUE INSTEAD OF HONDA FIXING THE FAULTY COMPONENT. *TR
NHTSA ODI #10430678
149,000 miles · Sep 26, 2011
Power Train
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED AN EXCESSIVE VIBRATION IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. AFTER THE REPAIR THE FAILURE CONTINUED. THE TRANSMISSION WAS REP…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED AN EXCESSIVE VIBRATION IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. AFTER THE REPAIR THE FAILURE CONTINUED. THE TRANSMISSION WAS REPLACED SEVEN TIMES TO NO AVAIL. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. UPDATED 11/22/11*LJ UPDATED 06/13/2012 *JS
NHTSA ODI #10427248
Mileage unknown · Sep 18, 2011
Electrical SystemEngine And Engine CoolingUnknown Or Other
WHEN I STOP OR SLOW DOWN THE CAR SHUTS OFF. I HAVE NO STEERING AND NO BRAKES AND NO HAZARD LIGHTS. CAR SHUTS DOWN WHILE DRIVING. *TT
NHTSA ODI #10425929
63,050 miles · Sep 8, 2011
Electrical System
WHILE BRAKING, CAR JUST DIED (INCLUDING DASHBOARD ELECTRIC) AND THEN DIFFICULT TO RESTART. AFTER CAR STARTED NO FURTHER INCIDENT FOR A FEW DAYS. NEXT, WHILE TRAVELLING ON HIGHWAY ~50MPH AT NIGHT, CAR UNEXPECTEDLY DIED (NO BRAKING INVOLVED) AND MOST, NOT ALL ELECTRIC DIED (EMERGENCY FLASHERS WORKED). NO "CHECK ENGINE LIGHT" EV…
Read full complaint
WHILE BRAKING, CAR JUST DIED (INCLUDING DASHBOARD ELECTRIC) AND THEN DIFFICULT TO RESTART. AFTER CAR STARTED NO FURTHER INCIDENT FOR A FEW DAYS. NEXT, WHILE TRAVELLING ON HIGHWAY ~50MPH AT NIGHT, CAR UNEXPECTEDLY DIED (NO BRAKING INVOLVED) AND MOST, NOT ALL ELECTRIC DIED (EMERGENCY FLASHERS WORKED). NO "CHECK ENGINE LIGHT" EVER CAME ON, BEFORE DASHBOARD BLANKED OUT. IGNITION SWITCH REPLACED IN 2002 WITH NATIONAL RECALL. MECHANIC AT A LOSS. HONDA HEADQUARTERS INITIALLY DENIED A PROBLEM EXISTED. CAR AGAIN STALLED A FEW TIMES WHILE BRAKING TO SLOW DOWN OR COME TO A STOP, BUT ASSUMED IT MIGHT BE "BAD GAS". EVENING OF 8/3/2011 TRAVELLING AT ~50MPH, CAR LOST ALL ELECTRIC 3 TIMES (DASHBOARD BLANKED OUT, BUT HEADLIGHTS WORKED), BUT IMMEDIATELY CAME BACK ON (AS THOUGH IT "BLINKED OFF"), WITHOUT HAVING TO RESTART IT. AFTER PARKING CAR, TOOK KEY OUT OF IGNITION- IT WAS "BURNING HOT". THIS TIME WHEN I CALLED HONDA HEADQUARTERS THEY SAID IT "MIGHT" BE PART OF A "SECOND RECALL", BUT CAR HAD TO BE CHECKED BY HONDA DEALER SERVICE STAFF. IF IT WAS THE IGNITION SWITCH, IT WOULD BE REPLACED FREE. IT WAS EXPLAINED TO ME THAT THIS WAS NOT PART OF A NATIONWIDE RECALL. RESULT- IGNITION SWITCH WAS BAD AND WAS REPLACED FREE. I WAS LUCKY I WASN'T KILLED OR SERIOUSLY INJURED IN A BAD CRASH. PLEASE ORDER A NATIONWIDE RECALL- IT COULD SAVE A LIFE OR LIVES.
NHTSA ODI #10424909
90,285 miles · Sep 1, 2011
Structure
DURING A RECENT OIL CHANGE AND VEHICLE INSPECTION, THE HONDA DEALER FOUND THAT THE RIGHT FRONT SUB-FRAME HAD RUSTED THROUGH. THE DRIVER SIDE HAD NO SIGNS OF RUST DAMAGE. THE TECHNICIAN JUDGED THE CAR AS UNSAFE TO DRIVE SINCE TOTAL FAILURE OF THE FRAME COULD OCCUR AT ANYTIME. THE TECHNICIAN SAID HE HAD PREVIOUSLY SEEN THIS FAI…
Read full complaint
DURING A RECENT OIL CHANGE AND VEHICLE INSPECTION, THE HONDA DEALER FOUND THAT THE RIGHT FRONT SUB-FRAME HAD RUSTED THROUGH. THE DRIVER SIDE HAD NO SIGNS OF RUST DAMAGE. THE TECHNICIAN JUDGED THE CAR AS UNSAFE TO DRIVE SINCE TOTAL FAILURE OF THE FRAME COULD OCCUR AT ANYTIME. THE TECHNICIAN SAID HE HAD PREVIOUSLY SEEN THIS FAILURE ON THE 1998 ACCORD LX SEDANS. THE ESTIMATED REPAIR COST IS $2,200.00. *TR
NHTSA ODI #10422840
130,000 miles · Aug 26, 2011
Electrical System
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED THE VEHICLE STALLED WITHOUT WARNING. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V120000 ( ELECTRICAL SYSTEM:IGNITION:SWITCH). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MEC…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED THE VEHICLE STALLED WITHOUT WARNING. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V120000 ( ELECTRICAL SYSTEM:IGNITION:SWITCH). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC AND WAS AWAITING DIAGNOSIS. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 130,000. THE VIN WAS UNAVAILABLE. UPDATED 01/04/12*LJ UPDATED 01/09/12
NHTSA ODI #10421597
140,000 miles · Aug 23, 2011
Electrical System
1998 HONDA ACCORD WOULD STALL WITHOUT WARNING WHILE RUNNING. THE FAILURE HAPPENED AT LEAST TWO OR THREE TIMES A WEEK FOR A 2 MONTH PERIOD. BROUGHT THE CAR TO TWO MECHANICS WHO WEREN'T SURE WHAT THE PROBLEM WAS. LOCATED INFORMATION ONLINE ABOUT A RECALL IN 2002 FOR THE IGNITION SWITCH. CAR WAS FIX DURING FOR THE RECALL. BROUGHT C…
Read full complaint
1998 HONDA ACCORD WOULD STALL WITHOUT WARNING WHILE RUNNING. THE FAILURE HAPPENED AT LEAST TWO OR THREE TIMES A WEEK FOR A 2 MONTH PERIOD. BROUGHT THE CAR TO TWO MECHANICS WHO WEREN'T SURE WHAT THE PROBLEM WAS. LOCATED INFORMATION ONLINE ABOUT A RECALL IN 2002 FOR THE IGNITION SWITCH. CAR WAS FIX DURING FOR THE RECALL. BROUGHT CAR TO THE DEALER AND DISCOVERED IT WAS THE IGNITION SWITCH AGAIN! COST $100 TO REPLACE THE SECOND TIME. *TR
NHTSA ODI #10421161
250,876 miles · Jun 23, 2011
Engine And Engine CoolingSuspensionCrashInjury
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND THE FRONT SUSPENSION COLLAPSED. AS A RESULT, THE VEHICLE CRASHED INTO THE GROUND. A POLICE REPORT WAS NOT FILED, BUT THE CONTACT SUFFERED INJURIES FROM THE CRASH. THE VEHICLE WAS TOWED TO AN INDEPENDENT R…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND THE FRONT SUSPENSION COLLAPSED. AS A RESULT, THE VEHICLE CRASHED INTO THE GROUND. A POLICE REPORT WAS NOT FILED, BUT THE CONTACT SUFFERED INJURIES FROM THE CRASH. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THE BODY DAMAGE AND LOWER BALL JOINTS WERE REPAIRED. THE FAILURE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 250,876.
NHTSA ODI #10408637
Official recalls
6Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 10, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES WERE MANUFACTURED WITH BALL JOINTS THAT CAN PREMATURELY WEAR OUT AND, IN THE WORSE CASE, THE BALL JOINT WOULD SEPARATE CAUSING THE FRONT SUSPENSION TO COLLAPSE.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN VEHICLE DECELERATION AND A SUDDEN LOSS OF POWER. ALSO STEERING CONTROLLABILITY WOULD BE REDUCED.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES (HONDA ACCORD SEDANS MANUFACTURED FROM SEPTEMBER 18, 1997 TO JANUARY 10, 1998; COUPES MANUFACTURED DECEMBER 11, DECEMBER 15, 1997, AND JANUARY 5, 1998; ACURA 2.3CL MANUFACTURED OCTOBER 22, 1997 THROUGH JANUARY 7, 1998). DURING MANUFACTURING, THE CASTING DIE CAUSED AN IRREGULARITY IN THE RIGHT-SIDE TRANSMISSION COVER. THIS IRREGULARITY CAN LIMIT THE MOVEMENT OF THE PARKING PAWL ACTUATION LEVEL AND PREVENT ADEQUATE ENGAGEMENT OF THE PARKING GEAR PAWL. THIS DOES NOT COMPLY WITH FMVS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE VEHICLE TO ROLL DOWN AN INCLINE WHEN THE TRANSMISSION IS LOCKED IN "PARK," INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A COLLAR ON THE TRANSMISSION PARKING PAWL TO ENSURE PROPER MOVEMENT OF THE ACTUATION LEVER.
Dec 16, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT PASSENGER SEAT BELT RETRACTOR MOUNTING BRACKET WAS IMPROPERLY WELDED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRACKET TO SEPARATE FROM THE VEHICLE BODY IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration