NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
308 reportsClear category filter102,264 miles · Sep 9, 2014
Electrical System
WE WERE CHARGE FOR A RECALL ON THIS ELECTRICAL IGNITION SWITCH. WE HAVE TALKED TO A THE RECALL SERVICE DEPARTMENT AT HONDA AUTOMOBILE CUSTOMER SERVICE. THAT PERSON TOLD US THAT THIS SHOULD HAVE BEEN NO CHARGE TO US. THEY TOLD US TO FILE A COMPLAINT WITH YOU. WE WILL ALSO BE FAXING THE BILL TO THE NUMBER[XXX]. FAXING ON SEPT …
Read full complaint
WE WERE CHARGE FOR A RECALL ON THIS ELECTRICAL IGNITION SWITCH. WE HAVE TALKED TO A THE RECALL SERVICE DEPARTMENT AT HONDA AUTOMOBILE CUSTOMER SERVICE. THAT PERSON TOLD US THAT THIS SHOULD HAVE BEEN NO CHARGE TO US. THEY TOLD US TO FILE A COMPLAINT WITH YOU. WE WILL ALSO BE FAXING THE BILL TO THE NUMBER[XXX]. FAXING ON SEPT 10, 2014, HERE IS THE CASE NO. [XXX]. PLEASE YOUR IMMEDIATE ATTENTION TO THIS MATTER WILL BE GREATLY APPRECIATED. MAY CONTACT US AT[XXX] THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10631898
133,000 miles · Sep 3, 2014
Electrical System
WHEN DRIVING THE CAR, IT SUDDENLY LOSES POWER AND SHUTS OFF. YOU HAVE TO RESTART IT AGAIN, WITH TRAFFIC BEHIND YOU, WHO COULD SUDDENLY REAR-END YOU, WHEN NOT EXPECTING YOUR CAR TO SHUT OFF, IN THE MIDDLE OF THE ROAD! THIS IS AN IGNITION SWITCH PROBLEM THAT WAS A RECALL. HONDA HAS "FIXED" THIS PART THE FIRST TIME, AND REFUSES T…
Read full complaint
WHEN DRIVING THE CAR, IT SUDDENLY LOSES POWER AND SHUTS OFF. YOU HAVE TO RESTART IT AGAIN, WITH TRAFFIC BEHIND YOU, WHO COULD SUDDENLY REAR-END YOU, WHEN NOT EXPECTING YOUR CAR TO SHUT OFF, IN THE MIDDLE OF THE ROAD! THIS IS AN IGNITION SWITCH PROBLEM THAT WAS A RECALL. HONDA HAS "FIXED" THIS PART THE FIRST TIME, AND REFUSES TO PAY FOR THE RECALL THE SECOND TIME. CAN I BE ANY LESS DEAD THE 2ND TIME? HONDA NEEDS TO REIMBURSE FOR EVERY BAD, DEFECTIVE IGNITION SWITCH ISSUE THAT RESULTS IN A CAR THAT SHUTS OFF! APPARENTLY, THEY HAVE NOT FIXED THE PROBLEM AND COULD BE LIFE-THREATENING! *TR
NHTSA ODI #10630477
333,233 miles · Jul 2, 2014
Electrical SystemEngineSuspension
I HAVE A 1998 HONDA ACCORD WHEN I CALL HONDA TO LET THEM KNOW MY CAR IS STALLING WHILE DRIVING THEY TELL ME THIS IS NOT A COVERED RECALL ON MY CERTAIN CAR FOR MY VIN ALSO THE LOWER BALL JOINTS ARE NOT COVERED BUT THEY HAVE A RECALL FOR THE PARTS ON LINE FOR OTHER 1998 CARS BUT IT IS CRAZY NEITHER OF THESE ITEMS ARE COVERED ON MY…
Read full complaint
I HAVE A 1998 HONDA ACCORD WHEN I CALL HONDA TO LET THEM KNOW MY CAR IS STALLING WHILE DRIVING THEY TELL ME THIS IS NOT A COVERED RECALL ON MY CERTAIN CAR FOR MY VIN ALSO THE LOWER BALL JOINTS ARE NOT COVERED BUT THEY HAVE A RECALL FOR THE PARTS ON LINE FOR OTHER 1998 CARS BUT IT IS CRAZY NEITHER OF THESE ITEMS ARE COVERED ON MY CAR. *TR
NHTSA ODI #10607701
10,000 miles · Jun 25, 2014
Electrical SystemSteeringSuspensionCrashInjury
I HAD CAR ACCIDENT AND TWO DAYS AFTER I HAD PICKED UP CAR FROM BODY SHOP I NOTICE THAT A A NOISE . I CALLED THE INSURANCE AND THE REP. SAID TO TAKE CAR BACK TO SHOP. I DID AND FROM WHAT THE INSURANCE AND WE'RE TOLD THE CAR JUST NEEDED AN ALINGMENT., I REMEMBER HEARING A LOUD HEAVY SOUND ON LEFT FRONT END OF CAR ON PASSENGE…
Read full complaint
I HAD CAR ACCIDENT AND TWO DAYS AFTER I HAD PICKED UP CAR FROM BODY SHOP I NOTICE THAT A A NOISE . I CALLED THE INSURANCE AND THE REP. SAID TO TAKE CAR BACK TO SHOP. I DID AND FROM WHAT THE INSURANCE AND WE'RE TOLD THE CAR JUST NEEDED AN ALINGMENT., I REMEMBER HEARING A LOUD HEAVY SOUND ON LEFT FRONT END OF CAR ON PASSENGER SIDE AND ALL OF THE SUDDEN THE CAR LOOSES CONTROL . I REMEMBERD THE VEHICLE WAS ON ITS ROOF I, FELT ARM GETTING BURN BY FIRE . IT SEEMED THAT THE ROOF OF VEHICLE WAS NOT PROTECTED.AND DID NOT SERVER IT PURPOSE . MY SPEED WAS ABOUT 25 30 MPH . THE LEFT FRONT SIDE AND WHEEL WERE STICKING OUT FROM BODY FRAME OF CAR . THE SAME SIDE WHERE SHOP HAD MADE, REPAIRS AND THE ARM AXEL HAD BEEN REPLACED JUST FEW DAYS BEFORE PER INSURANCE REQUEST . THE INSURANCE HAD USED AND AFTER MARKET IN INVOICE . IF WE CHECK ALL OF THE PARTS THE CAR HAD PUT IN AND THE EXTEND OF THE DAMAGE AND THE WHEEL NOT ALIGN WITH BODY OF CAR ALONG WITH THE LOUD SOUND AND JOLT I FELT COULD ONLY SHOW THE NEGLECT AND THE LACK OF SAFETY . *TR
NHTSA ODI #10605805
147,000 miles · Jun 23, 2014
Electrical System
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AND RESUMED NORMAL OPERATION. THE FAILURE OCCURRED NUMEROUS TIMES. AN INDEPENDENT MECHANIC REPLACED THE IGNITION SWITCH. NHTSA CAMPAIGN NUMBER 02V120000 (ELECTRICAL SYSTEM) WAS RELATED TO THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AND RESUMED NORMAL OPERATION. THE FAILURE OCCURRED NUMEROUS TIMES. AN INDEPENDENT MECHANIC REPLACED THE IGNITION SWITCH. NHTSA CAMPAIGN NUMBER 02V120000 (ELECTRICAL SYSTEM) WAS RELATED TO THE FAILURE; HOWEVER, IT HAD EXPIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 147,000. UPDATED 08/18/14*LJ UPDATED 08/23/2017*CT
NHTSA ODI #10605123
260,000 miles · May 5, 2014
Electrical SystemEngine
I HAVE A 98 HONDA ACCORD LX THAT DIES AT RANDOM TIMES WHILE DRIVING. IT TAKES A FEW MINUTES TO GET MY VEHICLE TO RESTART. I'VE CALLED HONDA AND THEY TOLD ME IT WAS THE ELECTRICAL PORTION OF THE IGNITION SWITCH THAT WASN'T COVERED BY THE RECALL AND IS EXPENSIVE FOR LABOR AND THE PART. I'VE DONE SOME RESEARCH ONLINE AND THIS SEEM…
Read full complaint
I HAVE A 98 HONDA ACCORD LX THAT DIES AT RANDOM TIMES WHILE DRIVING. IT TAKES A FEW MINUTES TO GET MY VEHICLE TO RESTART. I'VE CALLED HONDA AND THEY TOLD ME IT WAS THE ELECTRICAL PORTION OF THE IGNITION SWITCH THAT WASN'T COVERED BY THE RECALL AND IS EXPENSIVE FOR LABOR AND THE PART. I'VE DONE SOME RESEARCH ONLINE AND THIS SEEMS TO BE A LOT OF HONDA OWNERS WHO HAS THIS PROBLEM AND THE DEALERSHIP WON'T REPLACE THE PART. *TR
NHTSA ODI #10586662
100,000 miles · May 1, 2014
Electrical System
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE IGNITION SWITCH WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V1…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE IGNITION SWITCH WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V120000 (ELECTRICAL SYSTEM) AND 03V423000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10585985
Mileage unknown · Apr 10, 2014
Electrical System
1998 HONDA ACCORD. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH FAILURE. *SMD THE CONSUMER STATED THE IGNITION SWITCH FAILURE WOULD HAPPEN RANDOMLY WHILE DRIVING ON THE HIGHWAY. THE VEHICLE WOULD CUT OFF WITHOUT WARNING. THE DEALER CONFIRMED, THE IGNITION SWITCH WAS FAULTY. *JB
NHTSA ODI #10578704
170,000 miles · Apr 1, 2014
Electrical System
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE KEY MOVED OUT OF THE ON POSITION CAUSING THE VEHICLE TO SUDDENLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN PERFORMED THE REPAIRS FOR NHTSA RECALL CAMPAIGN NUMBER: 03V423000 (ELECTRICAL SYSTEM) AND DIAGNOSED THAT T…
Read full complaint
TL* THE CONTACT OWNS A 1998 HONDA ACCORD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE KEY MOVED OUT OF THE ON POSITION CAUSING THE VEHICLE TO SUDDENLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN PERFORMED THE REPAIRS FOR NHTSA RECALL CAMPAIGN NUMBER: 03V423000 (ELECTRICAL SYSTEM) AND DIAGNOSED THAT THE IGNITION CYLINDER WAS DEFECTIVE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 180,248.
NHTSA ODI #10576145
285,000 miles · Mar 1, 2014
Electrical System
MY 1998 HONDA ACCORD WOULD RANDOMLY SHUT OFF WHILE DRIVING. INCIDENT WOULD HAPPEN ANYTIME, ANY DAY, WEATHER CONDITION, ON ANY ROAD (HIGHWAY, INTERSTATES, ETC). HAS HAPPENS OVER 100 TIMES. I WASN'T ABLE TO TURN THE STEERING WHEEL, OR EVEN STOP THE BRAKES. EVERYTHING FAILED ON HUGE ROADS AND INTERSECTIONS WHERE MY CAR WOULD SHUT O…
Read full complaint
MY 1998 HONDA ACCORD WOULD RANDOMLY SHUT OFF WHILE DRIVING. INCIDENT WOULD HAPPEN ANYTIME, ANY DAY, WEATHER CONDITION, ON ANY ROAD (HIGHWAY, INTERSTATES, ETC). HAS HAPPENS OVER 100 TIMES. I WASN'T ABLE TO TURN THE STEERING WHEEL, OR EVEN STOP THE BRAKES. EVERYTHING FAILED ON HUGE ROADS AND INTERSECTIONS WHERE MY CAR WOULD SHUT OFF WHILE IN FRONT OF A WHOLE LANE OF TRAFFIC. ENDED UP FINDING OUT THAT THERE WAS RECALL ON THE IGNITION SWITCH. I CALLED A LOCAL HONDA DEALERSHIP TO SEE IF IT HAS BEEN SERVICED. IT "WAS". I REPLACED THE PART MYSELF AND NOW MY CAR HAS HAD A COUPLE GOOD TRIPS. BUT IF I WOULD OF TAKEN IT TO HONDA, THEY WERE GOING TO CHARGE ME WHICH IS RIDICULOUS, EVEN THOUGH THEY COULD OF RECALLED IT TWICE LIKE OTHER PEOPLE I READ ABOUT. *TR
NHTSA ODI #10566626
Official recalls
6Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
May 10, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES WERE MANUFACTURED WITH BALL JOINTS THAT CAN PREMATURELY WEAR OUT AND, IN THE WORSE CASE, THE BALL JOINT WOULD SEPARATE CAUSING THE FRONT SUSPENSION TO COLLAPSE.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN VEHICLE DECELERATION AND A SUDDEN LOSS OF POWER. ALSO STEERING CONTROLLABILITY WOULD BE REDUCED.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES (HONDA ACCORD SEDANS MANUFACTURED FROM SEPTEMBER 18, 1997 TO JANUARY 10, 1998; COUPES MANUFACTURED DECEMBER 11, DECEMBER 15, 1997, AND JANUARY 5, 1998; ACURA 2.3CL MANUFACTURED OCTOBER 22, 1997 THROUGH JANUARY 7, 1998). DURING MANUFACTURING, THE CASTING DIE CAUSED AN IRREGULARITY IN THE RIGHT-SIDE TRANSMISSION COVER. THIS IRREGULARITY CAN LIMIT THE MOVEMENT OF THE PARKING PAWL ACTUATION LEVEL AND PREVENT ADEQUATE ENGAGEMENT OF THE PARKING GEAR PAWL. THIS DOES NOT COMPLY WITH FMVS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE VEHICLE TO ROLL DOWN AN INCLINE WHEN THE TRANSMISSION IS LOCKED IN "PARK," INCREASING THE RISK OF PERSONAL INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A COLLAR ON THE TRANSMISSION PARKING PAWL TO ENSURE PROPER MOVEMENT OF THE ACTUATION LEVER.
Dec 16, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT PASSENGER SEAT BELT RETRACTOR MOUNTING BRACKET WAS IMPROPERLY WELDED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRACKET TO SEPARATE FROM THE VEHICLE BODY IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration