Service Brakes. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports1 injury reports

Power Train complaints

4 reports

Clear category filter

31,000 miles · Sep 24, 2020

EnginePower Train

WHILE RIDING ON THE FREEWAY AT 65 MPH THE CHECK ENGINE LIGHT CAME ON AND THE BIKE WENT INTO A 'LIMP' MODE ALL OF A SUDDEN AND WOULD NOT GO OVER 15-20 MPH. HAD TO CUT ACROSS TRAFFIC WITHOUT GETTING HIT TO GET TO THE SIDE OF THE ROAD. TURNED OFF BIKE AND IT RESET WAS ABLE TO MAKE IT HOME. RESEARCHED PROBLEM ON LINE AND HAVE SEEMS…

Read full complaint

NHTSA ODI #11361012

25,000 miles · Sep 12, 2017

EnginePower TrainUnknown Or Other

Read full complaint

RIDING MY FLHX THE OTHER DAY AND BIKE STARTED MAKING NOISE FROM MY PRIMARY AND I PULLED OVER AND CHECKED NOISE AND COMFIRMED IT WAS COMING FROM THE LEFT SIDE(PRIMARY). MADE IT HOME SAFE; WASN'T FAR FROM HOME. TOOK OFF THE PRIMARY COVER AND CHECKED OVER THE INNER PRIMARY COMPONENTS. THE COMPENSATOR AND ADJUSTER WERE BAD. DID SOME RESEARCH AND FOUND THAT THE AUTO-ADJUSTED CHAIN TENSIONER TIGHTENS SO BAD OVER TIME THAT IT RATCHETS ALL THE SPROKET PARTS DOWN SO BAD THAT IT STARTES TO CREATE WEAR ON COMPONENTS SO BAD THAT PARTS CAN BREAK LOOSE, LOCK UP, AND THE COMPONENTS IN MY YEAR FLHX ARE SEVERLY UNDER RATED. THIS COMPENSATOR WASN'T SUPPOSED TO BE USED FOR ANYTHING BIGGER THAN AN 80 CUBIC INCH MOTOR; MY BIKE CAME STOCK WITH A 96 CUBIC INCH MOTOR. FLHX IS PAST ANY WARRANTY, BUT THIS IS AN INCREASING PROBLEM THAT HARLEY SHOULD BE HELD ACCOUNTABLE FOR AND BE MADE TO CORRECT IT. REPAIR IS GOING TO COST OVER $1000.00 FOR REPAIR FOR SOMETHING THAT SHOULD HAVE BEEN MADE RIGHT IN THE FIRST PLACE, ESPECIALLY FOR A MOTORCYCLE THAT IS SO POPULAR AND VASTLY SOLD ACCROSSED THE COUNTRY. IF THESE PARTS WERE TO LOCK UP WHILE RIDING, IT COULD CAUSE SEVER INJURY OR DEATH TO RIDER AND ANYONE AROUND THE BIKE DURING THE TIME.

NHTSA ODI #11022936

35,000 miles · Mar 18, 2015

Power Train

THE COMPENSATOR IS AN ISSUE WITH HARLEY THAT NEEDS TO BE ADDRESSED ON 2007 AND 2008 TWIN CAM BIKES. *TR

NHTSA ODI #10695057

37,000 miles · Jan 12, 2015

Power Train

Read full complaint

WHAT WE HAVE DISCOVERED IS THE COMPENSATOR SPROCKET HAS EITHER WORKED LOOSE OR IS CRACKED, THIS IS WITHIN THE SHAFT ASSEMBLY WHERE THE CLUTCH ASSEMBLY AND PRIMARY FINAL DRIVE IS LOCATED, HARLEY KNOWS THEY HAVE A PROBLEM WITH THIS, AND IT COULD RESULT IN THE DRIVE TRAIN LOCKING UP IF THE ASSEMBLY LOCKS UP OR SOMETHING COMES LOOSE AND CAUSES SUCH AN EVENT IT COULD LOCK UP THE REAR WHEEL AND CAUSE A CRASH I KNOW OF A FEW PEOPLE THAT ARE HAVING THIS SAME ISSUE, AND ALSO JUST FROM RESEARCH ONLINE THERE ARE A LOT OF MOTORCYCLES WITH THE SAME PROBLEM. *TR

NHTSA ODI #10671869

Official recalls

18V076000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:fluid

Jan 29, 2018

Harley-Davidson Motor Company (Harley-Davidson) is recalling all 2008-2011 Touring, CVO Touring and VSRC motorcycles equipped with anti-lock brakes (ABS), including Road King (FLHR), Road King Police (EFI) (FLHP), Road King Police (EFI) (FLHPE), Electra Glide Standard Police (EFI) (FLHTP), Electra Glide Classic (EFI) (FLHTC), Electra Glide Ultra Classic (EFI) (FLHTCU) and Street Glide (EFI) (FLHX), 2008 VROD (VRSCAWA), CVO Road King 4 (FLHRSE4), Night Rod (VRSCDA), CVO Ultra Classic 3 (FLHTCUSE3), Night Rod Special (VRSCDXA), 2008-2010 Road King Classic (EFI) (FLHRC), 2008-2009 Road Glide (EFI) (FLTR) and Electra Glide Standard (EFI) (FLHT), 2009-2010 V-Rod (VRSCAW), 2009 CVO Ultra Classic (FLHTCUSE4) and CVO Road Glide 3 (FLTRSE3), 2009-2011 Night Rod Special (VRSCDX) and V-Rod Muscle (VRSCF), 2010 CVO Ultra Classic 5 (FLHTCUSE5) and CVO Street Glide (FLHXSE), 2010-2011 Electra Glide Ultra Limited (FLHTK) and Road Glide Custom (FLTRX), 2011 Road Glide Ultra 103 (FLTRU103), Street Glide 103 (FLHX103), Road King Classic 103 (FLHRC103), CVO Ultra Classic 6 (FLHTCUSE6), CVO Road Glide Ultra (FLTRUSE), Road Glide Custom 103 (FLTRX103), and CVO Street Glide 2 (FLHXSE2) motorcycles. Deposits may form on components within the brake system if the DOT 4 brake fluid is not replaced for a prolonged period of time beyond the 2-year maintenance schedule specified in the Owners Manual.

Consequence & remedy

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.

Additional source detail variants (2)

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.

Service Brakes, Hydraulic:fluid

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

08V357000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Jul 30, 2008

HARLEY DAVIDSON IS RECALLING 47,579 MY 2008 FLHP, FLHPE, FLHR, FLHRC, FLHRSE4, FLHT, FLHTC, FLHTCU, FLHTCUSE3, FLHTP, FLHX, AND FLTR MOTORCYCLES. THESE MOTORCYCLES MAY EXPERIENCE A CRACKING OF THE FUEL FILTER SHELL LEADING TO LOSS OF FUEL PRESSURE. THIS LOSS OF FUEL PRESSURE CAN CAUSE DIMINISHED PERFORMANCE AND, IN SOME CASES, MAY CAUSE AN ENGINE STALL OR A NO-START CONDITION.

Consequence & remedy

Consequence: THIS CONDITION COULD LEAD TO A CRASH WHICH COULD CAUSE INJURY OR DEATH TO THE RIDER.

Remedy: DEALERS WILL REPLACE THE FUEL FILTER SHELL FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2008. OWNERS MAY CONTACT HARLEY DAVIDSON AT 1-414-343-4056.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE16009 · Sudden Brake Failure - Motorcycle

Opened Jul 6, 2016 · Closed Apr 23, 2018

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) opened this investigation in July 2016 based on forty-three (43) Vehicle Owner Questionnaires (VOQ).During the course of this investigation ODI received a total of 145 VOQs related to the alleged defect on the subject motorcycles.Owners allege they experience a sudden and complete loss of brakes on one or both wheels.To better understand the cause of the braking issue on the subject motorcycles, ODI requested NHTSA's Vehicle Research and Test Center (VRTC) conduct inspections and testing of affected vehicle braking systems.Through its work, VRTC determined that deposits were forming on the valves in the Hydraulic Control Unit (HCU) of the Antilock Braking System (ABS). These deposits could prevent the proper function of the HCU and render the brakes ineffective.To understand why deposits were forming in the HCU, Harley Davidson completed an analysis of the Dow 460 brake fluid used as original equipment on the subject motorcycles and determined that it had stability issues if left in the brake system for an extended period of time.Harley Davidson found that if a brake fluid flush was not conducted as outlined in the owner?s manual for the motorcycles, and was left in the system for a period of time beyond their recommendation; deposits could form in the HCU.Through further testing, Harley Davidson identified an alternate, commercially available, brake fluid that did not have the same stability issues as the original fluid and could stop the proliferation of any current brake system deposits.ODI sent Information Request (IR) letters to Harley Davidson and Dow Chemical (the supplier of the brake fluid on the subject motorcycles) to collect information about the subject bikes and the alleged defect.Harley Davidson responded in full on Sept 30, 2016 and Dow responded with a confidential submission on October 25, 2017.ODI analyzed the information contained in both IR responses and concluded that motorcycles manufactured during Model Years (MY) 2008, 2009, 2010, and 2011 were failing at a rate greater than their peers.Based on this analysis and the brake fluid study conducted by Harley Davidson, a group of motorcycles was identified that were potentially affected by the instability of the original brake fluid.2008 marked the introduction of ABS on Harley Davidson motorcycles and a change in the Dow 460 brake fluid used in the 2012 MY vehicles provided the bases for the scope of the affected population.With recall action 18V-076 taken by Harley Davidson this investigation is closed as further use of agency resources does not appear to be warranted.The ODI reports cited above can be reviewed at: https://www.nhtsa.gov/ using the complaint identification numbers attached to this resume.

PE08043 · Motorcycle Stalling

Opened Jul 17, 2008 · Closed Aug 8, 2008

Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery

THE SUBJECT FUEL FILTER HOUSING (P/N 62229-08) CRACKS, RESULTING IN SUDDEN ENGINE STALL DUE TO UNREGULATED FUEL PRESSURE.HARLEY-DAVIDSON HAS MODIFIED THE HOUSING WITH A NEW PART NUMBER 62229-08A.SHORTLY AFTER OPENING THIS PE, ODI RECEIVED HARLEY'S DEFECT NOTIFICATION INDICATING THAT THE SUBJECT VEHICLES WERE BEING RECALLED TO INSTALL THE NEW FUEL FILTER HOUSING.WITH THAT RECALL, RECEIVED PRIOR TO RELEASE OF OUR INFORMATION REQUEST, THIS INVESTIGATION IS CONCLUDED.

Additional source detail variants (2)

Fuel System, Gasoline:delivery

Fuel System, Gasoline