Service Brakes. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports1 fire reports0 injury reports

What owners actually said

70 reports

Mileage unknown · Mar 17, 2026

Service Brakes

Read full complaint

While riding my 2009 ultra classic cvc Harley davidson motorcycle the front brake level became stiff and eventually did not compress, no front brakes, while attempting to stop. The rear brake still operated normally. In an emergency, this could cause serious injury or death with front brake failing and possible rear brake failure at same time. a local repair shop inspected the brakes and attempted to bleed system and determined the ABS mudule failed. there were no warning lamp indications of ABS failure. When ABS module fails on HD motorcycles, brakes can also fail. This is a major safety issue with the braking system that shoud still operate to stop motorcycle when ABS module fails.

NHTSA ODI #11725017

Mileage unknown · Jun 5, 2025

Service Brakes

ABS Module failure. Brake pedal solid when depressed with no brakes available. I will request the bad module from the dealer. No brakes is an extremely dangerous condition. The motorcycle is in a Harley Davidson getting the module replaced. This catastrophic failure happened with no warnings or symptoms.

NHTSA ODI #11665136

Mileage unknown · Jun 29, 2022

EnginePower TrainUnknown Or Other

The guard/spring housing locater on the rotor behind the drive sprocket developed a fatigue crack, it propagated approximately half way around the circumference before separating and then being pulled thru between the drive chain and sprocket . this caused the drive train to seize up locking up the engine and rear wheel and d…

Read full complaint

NHTSA ODI #11471559

Mileage unknown · Nov 21, 2021

Service Brakes

When approaching an intersection I went to apply brakes and could not because lever was frozen this resulted in my bike to coast into the intersection I was fortunate the vehicle coming was able to stop.I was told my abs system had failed and would need replaced! The issue was blamed on fluid and lack of flushing and replacemen…

Read full complaint

NHTSA ODI #11441177

43,176 miles · Dec 3, 2018

Service Brakes

Read full complaint

TL* THE CONTACT OWNS A 2009 HARLEY-DAVIDSON FLHTCU. WHILE OPERATING THE VEHICLE, THE FRONT BRAKES MALFUNCTIONED AND THE FRONT BRAKE LEVER COULD NOT BE PRESSED TO STOP THE MOTORCYCLE. THE MOTORCYCLE WAS TAKEN TO HARLEY-DAVIDSON EASTGATE (699 CINCINNATI POTAVIA PIKE, CINCINNATI, OH) WHERE IT WAS DIAGNOSED THAT THE VALVE IN THE ABS MODULE MALFUNCTIONED AND THE MODULE NEEDED TO BE REPLACED. THE FAILURE WAS REPAIRED. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 18V076000(SERVICE BRAKES) IN JULY OF 2018, BUT THE PARTS FOR THE REPAIR WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 43,176.

NHTSA ODI #11155634

Mileage unknown · Sep 18, 2018

Service Brakes

Read full complaint

TL* THE CONTACT OWNS A 2009 HARLEY-DAVIDSON FLHTCU. THE CONTACT STATED THAT THE FRONT BRAKES FAILED TO FULLY ENGAGE AND FUNCTION PROPERLY. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 18V076000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT SCHEDULED AN APPOINTMENT WITH WAR HORSE HARLEY-DAVIDSON (5331 N US HWY 441, OCALA, FL 34475, 1-(352) 732-2488) AND WAS PROVIDED WITH A REMEDY FOR THE RECALL REPAIR FROM THE MANUFACTURER; HOWEVER, THE FAILURE RECURRED. THE DEALER REFUSED TO TEST DRIVE THE VEHICLE, INDICATING THAT IT WAS NOT SAFE. THE MANUFACTURER WAS CONTACTED. THE VEHICLE REMAINED PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ODI #11130210

35,000 miles · May 4, 2018

Service Brakes

Read full complaint

ABS HCU SUDDENLY FAILED CAUSING FRONT BRAKE LEVER TO BECOME SO HARD IT IS ALMOST UNSQUEEZABLE. LUCKILY THIS HAPPENED WHILE STATIONARY IN MY GARAGE ON INITIAL IGNITION ON CYCLE. I UNDERSTAND THINGS FAIL BUT FOR ABS TO FAIL IN A WAY TO LOOSE ALL BRAKING WITHOUT WARNING IS REDICULOUS. HOW COULD NHTSA LET HARLEY DAVIDSON BLAME THIS ON FLUID OR CONSUMER? ARE YOU IMPLYING THAT HARLEY TOURING OWNERS OF 2008-11 ARE THE ONLY ONES WHO DIDNT FLUSH BRAKE FLUID? MY FLUID WAS ALWAYS FLUSHED. ITS A DEFECTIVE MODULE. COME ON NHTSA WAKE UP!

NHTSA ODI #11091997

12,800 miles · Apr 23, 2018

Service Brakes

Read full complaint

REAR BRAKES FAILED TO OPERATE. THE REAR BRAKE PEDAL WOULD NOT MOVE WHEN PRESSURE IS APPLIED WITH FOOT. THE HARLEY RECALL ONLY CHANGES THE BRAKE FLUID WHICH IS NOT THE CAUSE OF THE PROBLEM. THE ROOT CAUSE OF THE MALFUNCTION IS THE ABS MODULE IS A DEFECTIVE DESIGN. HARLEY CLAIMS A LACK OF FLUID CHANGE IS THE CAUSE. THIS A COVER UP BY HARLEY TO KEEP FROM HAVING TO REPLACE ALL OF THE ABS MODULES ON THEIR DANGEROUS MOTORCYCLES ON THE ROAD. THIS IS THE ONLY VEHICLE THAT I HAVE EVER HEARD OF THAT MUST HAVE THE BRAKE FLUID CHANGED EVERY TWO YEARS ( JUST A COVER UP BY HARLEY) THIS IS A SERIOUS DEFECT THAT IS VERY DANGEROUS AND COULD COST LIVES ON THE ROAD.

NHTSA ODI #11089758

59,720 miles · Mar 10, 2018

Service Brakes

WHEN TRYING TO MOVE THE BRAKE LEVER FOR FRONT BRAKE THE LEVER WAS FROZEN AND UNABLE TO MOVE. *JS

NHTSA ODI #11078519

88,000 miles · Feb 24, 2018

Service BrakesCrash

FRONT BRAKES FAILED UNEXPECTEDLY WHILE ON HIGHWAY. BRAKE LEVER IS LOCKED OPEN AND WILL NOT MOVE. LATER THAT DAY, THE BRAKES LOCKED OPEN AGAIN WHILE IN PARKING LOT CAUSING ME TO WRECK INTO CURB AND DAMAGE FRONT FENDER.

NHTSA ODI #11074665

Official recalls

18V076000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:fluid

Jan 29, 2018

Harley-Davidson Motor Company (Harley-Davidson) is recalling all 2008-2011 Touring, CVO Touring and VSRC motorcycles equipped with anti-lock brakes (ABS), including Road King (FLHR), Road King Police (EFI) (FLHP), Road King Police (EFI) (FLHPE), Electra Glide Standard Police (EFI) (FLHTP), Electra Glide Classic (EFI) (FLHTC), Electra Glide Ultra Classic (EFI) (FLHTCU) and Street Glide (EFI) (FLHX), 2008 VROD (VRSCAWA), CVO Road King 4 (FLHRSE4), Night Rod (VRSCDA), CVO Ultra Classic 3 (FLHTCUSE3), Night Rod Special (VRSCDXA), 2008-2010 Road King Classic (EFI) (FLHRC), 2008-2009 Road Glide (EFI) (FLTR) and Electra Glide Standard (EFI) (FLHT), 2009-2010 V-Rod (VRSCAW), 2009 CVO Ultra Classic (FLHTCUSE4) and CVO Road Glide 3 (FLTRSE3), 2009-2011 Night Rod Special (VRSCDX) and V-Rod Muscle (VRSCF), 2010 CVO Ultra Classic 5 (FLHTCUSE5) and CVO Street Glide (FLHXSE), 2010-2011 Electra Glide Ultra Limited (FLHTK) and Road Glide Custom (FLTRX), 2011 Road Glide Ultra 103 (FLTRU103), Street Glide 103 (FLHX103), Road King Classic 103 (FLHRC103), CVO Ultra Classic 6 (FLHTCUSE6), CVO Road Glide Ultra (FLTRUSE), Road Glide Custom 103 (FLTRX103), and CVO Street Glide 2 (FLHXSE2) motorcycles. Deposits may form on components within the brake system if the DOT 4 brake fluid is not replaced for a prolonged period of time beyond the 2-year maintenance schedule specified in the Owners Manual.

Consequence & remedy

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.

Additional source detail variants (2)

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

Remedy: Harley-Davidson will notify owners, and dealers will flush the entire brake system with new Platinum Label DOT 4 brake fluid, free of charge. The recall began on February 14, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0171.

Service Brakes, Hydraulic:fluid

Consequence: These deposits may cause a valve within the ABS Hydraulic Control Unit to stick, reducing braking ability and increasing the risk of a crash.

11V506000 · Exterior Lighting:brake Lights:switch

Oct 19, 2011

HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009-2012 TOURING, CVO TOURING AND TRIKE VEHICLES MANUFACTURED FROM JUNE 6, 2008, THROUGH SEPTEMBER 16, 2011. SEE THE ABOVE LIST FOR THE MODELS INCLUDED IN THE RECALL. THE REAR BRAKE LIGHT SWITCH MAY BE EXPOSED TO EXCESSIVE HEAT FROM THE EXHAUST SYSTEM.

Consequence & remedy

Consequence: THE EXCESSIVE HEAT MAY CAUSE THE SWITCH TO NOT ACTIVATE THE BRAKE LAMP OR ACTIVATE THE BRAKE LAMP WHEN NO BRAKE IS APPLIED AND/OR CAUSE A BRAKE FLUID LEAK AT THE BRAKE LIGHT SWITCH, AFFECTING REAR BRAKE PERFORMANCE. EITHER CONDITION MAY INCREASE THE RISK OF A CRASH.

Remedy: HARLEY-DAVIDSON WILL NOTIFY OWNERS, AND DEALERS WILL A INSTALL A REAR BRAKE LIGHT SWITCH KIT, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 31, 2011. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

09V457000 · Fuel System, Gasoline:storage:tank Assembly:mounting

Dec 1, 2009

HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 TOURING FAMILY MOTORCYCLES, INCLUDING CVO TOURING AND TRIKE PRODUCTS, MANUFACTURED FROM JUNE 6, 2008 THROUGH NOVEMBER 19, 2009. THE FRONT FUEL TANK MOUNTS MAY DISTORT IN REACTION TO SEVERE FRAME DAMAGE FROM A FRONTAL COLLISION. THIS CONDITION MAY CAUSE A FUEL LEAK AT THE WELD OF THE FRONT BRACKET TO THE TUNNEL.

Consequence & remedy

Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE, WHICH COULD LEAD TO INJURY OR DEATH TO THE RIDER.

Remedy: DEALERS WILL INSTALL A LEFT AND RIGHT BRACE, WHICH ARE INTENDED TO REDUCE FRONT MOUNT DISTORTION DURING CERTAIN CRASH CONDITIONS. THIS REPAIR WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE16009 · Sudden Brake Failure - Motorcycle

Opened Jul 6, 2016 · Closed Apr 23, 2018

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) opened this investigation in July 2016 based on forty-three (43) Vehicle Owner Questionnaires (VOQ).During the course of this investigation ODI received a total of 145 VOQs related to the alleged defect on the subject motorcycles.Owners allege they experience a sudden and complete loss of brakes on one or both wheels.To better understand the cause of the braking issue on the subject motorcycles, ODI requested NHTSA's Vehicle Research and Test Center (VRTC) conduct inspections and testing of affected vehicle braking systems.Through its work, VRTC determined that deposits were forming on the valves in the Hydraulic Control Unit (HCU) of the Antilock Braking System (ABS). These deposits could prevent the proper function of the HCU and render the brakes ineffective.To understand why deposits were forming in the HCU, Harley Davidson completed an analysis of the Dow 460 brake fluid used as original equipment on the subject motorcycles and determined that it had stability issues if left in the brake system for an extended period of time.Harley Davidson found that if a brake fluid flush was not conducted as outlined in the owner?s manual for the motorcycles, and was left in the system for a period of time beyond their recommendation; deposits could form in the HCU.Through further testing, Harley Davidson identified an alternate, commercially available, brake fluid that did not have the same stability issues as the original fluid and could stop the proliferation of any current brake system deposits.ODI sent Information Request (IR) letters to Harley Davidson and Dow Chemical (the supplier of the brake fluid on the subject motorcycles) to collect information about the subject bikes and the alleged defect.Harley Davidson responded in full on Sept 30, 2016 and Dow responded with a confidential submission on October 25, 2017.ODI analyzed the information contained in both IR responses and concluded that motorcycles manufactured during Model Years (MY) 2008, 2009, 2010, and 2011 were failing at a rate greater than their peers.Based on this analysis and the brake fluid study conducted by Harley Davidson, a group of motorcycles was identified that were potentially affected by the instability of the original brake fluid.2008 marked the introduction of ABS on Harley Davidson motorcycles and a change in the Dow 460 brake fluid used in the 2012 MY vehicles provided the bases for the scope of the affected population.With recall action 18V-076 taken by Harley Davidson this investigation is closed as further use of agency resources does not appear to be warranted.The ODI reports cited above can be reviewed at: https://www.nhtsa.gov/ using the complaint identification numbers attached to this resume.