CONSUMER WAS INJURED WHEN THE GREAT DANE TRAILER HIS TRACTOR RIG WAS PULLING FAILED. *MR WHILE DRIVING THE TRAILER ON THE VEHICLE LOST IT'S REAR AXLES. THE AXLES WENT ACROSS THE ROAD AND COLLIDED WITH THE GUARDRAIL. THE TRAILERS LOAD SHIFTED WHICH CAUSED THE TRAILER TO ROLL ONTO IT'S RIGHT SIDE AND SLIDE ALONG THE EMBANKMENT.…
Read full complaint
CONSUMER WAS INJURED WHEN THE GREAT DANE TRAILER HIS TRACTOR RIG WAS PULLING FAILED. *MR WHILE DRIVING THE TRAILER ON THE VEHICLE LOST IT'S REAR AXLES. THE AXLES WENT ACROSS THE ROAD AND COLLIDED WITH THE GUARDRAIL. THE TRAILERS LOAD SHIFTED WHICH CAUSED THE TRAILER TO ROLL ONTO IT'S RIGHT SIDE AND SLIDE ALONG THE EMBANKMENT. THE TRACTOR'S FRONT END COLLIDED INTO THE EMBANKMENT. THE TRACTORS AIR BAGS DID NOT DEPLOY. THE DRIVER WAS INJURED ((STATE OF COLORADO TRAFFIC ACCIDENT REPORT). *NM
NHTSA ODI #10073779
Mileage unknown · Jul 30, 2002
Power Train
WHILE DRIVING, THE FRONT AXLE ON THE LEFT SIDE OF THE TRAILER BROKE, THE ALUMINUM HOUSING WHICH COVERS THE WHEEL BEARING CAME OFF OF THE AXLE.(OHIO TRAFFIC REPORT, 10-91-274)*JB
ON CERTAIN TRAILERS EQUIPPED WITH SPRING BRAKE CONTROL VALVE ASSEMBLIES, THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING. THE RECESSED AREA ALLOWS ACCUMULATION OF WATER, DIRT, AND/OR CHEMICALS TO BUILD UP BEHIND THE SNAP RING TO THE POINT WHERE IT WILL NO LONGER CONTAIN THE GUIDE PIN RESULTING IN A FAILURE OF THE AIR VALVE.
Consequence & remedy
Consequence: FAILURE OF THE VALVE IN AN EMPTY OR LIGHTLY LOADED TRAILER WHILE THE VEHICLE IS IN MOTION COULD RESULT IN A HARD APPLICATION OF THE SPRING BRAKES, POSSIBLY LOCKING UP THE TRAILER WHEELS AND RESULTING IN A VEHICLE CRASH.
Remedy: SEALCO WILL PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS TO ITS CUSTOMERS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SEALCO AT 602-253-1007 OR GREAT DANE AT 912-644-2100.
CERTAIN TRAILERS EQUIPPED WITH PINTLE HOOK ASSEMBLIES MAY HAVE UNACCEPTABLE WELD ATTACHMENTS TO THE TRAILERS.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL CORRECT THE WELDS AND ALSO ADD A REINFORCEMENT PACKAGE. OWNER NOTIFICATION BEGAN MARCH 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.
VEHICLE DESCRIPTION: TRAILERS. THESE TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THESE TRAILERS FAIL TO PROVIDE PRIMARY CONTINUOUS POWER TO THE REAR PINTLE HOOK ELECTRICAL CONNECTOR FOR THE ANTI-LOCK BRAKING SYSTEM AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: A NON-FUNCTIONING TRAILER ABS COULD ALLOW THE TRAILER TO SKID, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL ADD A WIRING HARNESS WHICH WILL BE RUN FROM THE FRONT NOSE ELECTRICAL CONNECTOR TO THE PINTLE HOOK ELECTRICAL CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN JULY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GREAT DANE AT 1-912-644-2100.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 Great Dane Trailer Problems, Complaints & Recalls | Skip That Year
Illustration