Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 28 of 234 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
234 reports
Mileage unknown · Jan 19, 2026
Engine
Car driving down highway at ~70 MPH with wife and our three young kids. Engine spontaneously shut off while driving. Electronic and other systems continued to function (power steering, brakes, lights, screens etc). Dangerous situation but was able to stop car in shoulder. Tried turning car on and off but car would not restart. P…
Read full complaint
Car driving down highway at ~70 MPH with wife and our three young kids. Engine spontaneously shut off while driving. Electronic and other systems continued to function (power steering, brakes, lights, screens etc). Dangerous situation but was able to stop car in shoulder. Tried turning car on and off but car would not restart. Police were notified but did not come. Tow truck came and tuck car to a GMC dealer (GMC Danvers). Next day when techs arrived at dealer, they were able to start and drive car without issue. There were no present or stored fault codes other than a warning pertaining to the battery. Battery has been replaced and GMC is stating car is now safe to drive. Because issue could not be replicated by dealer and car did not store any fault codes despite the engine shut off, we question whether the issue has been correctly identified and repaired. We noted to GMC that the issue experienced was the same issue associated with the recent recall (for which the car was previously serviced). At this time we do not believe the work GMC performed under recall properly addressed the known engine shut off issue. We requested GMC and dealer perform another picoscope test to conform no issues with crank shaft. GMC refused to perform the service, despite us offering to pay for the test out of pocket. GMC is not offering any additional solutions to identify the cause of the engine shut off issue.
NHTSA ODI #11711944
Mileage unknown · Jan 18, 2026
Engine
Engine had a burning smell and cranking sound. It lost propulsion, no indicator lights were illuminated and the car shutdown while driving. This is a recall item. It passed the recall inspection. I also had it inspected prior to leaving for my trip 2000 miles from home. Im currently stranded and awaiting my options. This …
Read full complaint
Engine had a burning smell and cranking sound. It lost propulsion, no indicator lights were illuminated and the car shutdown while driving. This is a recall item. It passed the recall inspection. I also had it inspected prior to leaving for my trip 2000 miles from home. Im currently stranded and awaiting my options. This is very unsafe, the engine failed while I had no service within 50 miles. Freezing temperatures at sunset. Im being told that my towing and rental car may not be covered. GM told the dealership to do the oil repair first. They covered up the failure. I also had an issue with electrical items after the purchase and that issue is why my alert lights never came on even when the vehicle was Inoperable.
NHTSA ODI #11711742
Mileage unknown · Jan 16, 2026
Engine
Engine siezed total engine failure at 31095 miles
NHTSA ODI #11711420
Mileage unknown · Jan 15, 2026
EnginePower TrainVehicle Speed Control
We are located in Henderson, NV and we were driving on the freeway in a construction zone with no emergency lanes when the vehicle lost all power to the engine going the speed limit. The engine had seized up which is a known problem with the 6.2L GMC motors. We have done all the recalls recommended by the manufacturer. The engin…
Read full complaint
We are located in Henderson, NV and we were driving on the freeway in a construction zone with no emergency lanes when the vehicle lost all power to the engine going the speed limit. The engine had seized up which is a known problem with the 6.2L GMC motors. We have done all the recalls recommended by the manufacturer. The engine seizing, locking up , put our family in danger . We were luckily enough to be close to an offramp where people in other vehicles barley let us over so we can pull off the road or we would of been stuck in the middle of the highway with cars flying by us with little kids in the car. This is unacceptable and as much as this happening and GMC not fixing the issues, people are going to get hurt or killed. IT IS A HUGE SAFETY CONCERN! . ThIS is a known issue with these motors and problems and GMC is putting bandaids on the situations when lives are in danger. Our truck is a 2023 GMC Yukon Denali with only 53k miles on it
NHTSA ODI #11711193
Mileage unknown · Jan 3, 2026
Electrical System
My vehicle experienced a sudden and complete loss of OnStar and telematics functionality during or immediately following a routing/software update. I had taken my vehicle in for my engine recall and noted another software update was required and specifically was told by multiple service members over the phone that the onstar s…
Read full complaint
My vehicle experienced a sudden and complete loss of OnStar and telematics functionality during or immediately following a routing/software update. I had taken my vehicle in for my engine recall and noted another software update was required and specifically was told by multiple service members over the phone that the onstar services/telematics module was impacted and this update should resolve it. After some initial research it appears this is related to N212331730, which impacts OnStar and telematics services. I brought the vehicle to an authorized GMC dealer for the recall. After inspection, the dealer informed me that the telematics control module has failed and must be replaced. This failure resulted in the loss of all OnStar safety-related services, including emergency response and vehicle communication features. The failure appears directly related to the recall condition or software update process, yet I am being told the module replacement is not covered. This creates a safety concern because emergency communication systems required for crash response and roadside assistance are nonfunctional. I am concerned that the recall remedy may be causing or accelerating telematics module failures and that affected vehicles may be left without critical safety systems unless owners pay out of pocket.
NHTSA ODI #11708547
Mileage unknown · Dec 30, 2025
Engine
Took my Yukon in for L87 engine recall. Advisor informed me my engine failed. No symptoms, sounds or messages appeared.’
NHTSA ODI #11707693
Mileage unknown · Dec 29, 2025
Engine
My vehicle was apart of the GM L87 recall. I took it to the dealership and it passed the recall and received the remedy which was an oil change. Now about 3 months later, I was driving in the highway at approximately 70 mph when the vehicle lost power and shifted to neutral. I had to attempt to veer off the highway with no accel…
Read full complaint
My vehicle was apart of the GM L87 recall. I took it to the dealership and it passed the recall and received the remedy which was an oil change. Now about 3 months later, I was driving in the highway at approximately 70 mph when the vehicle lost power and shifted to neutral. I had to attempt to veer off the highway with no acceleration. Upon getting it to the side of the highway, it wouldn’t do anything at all and had to be towed. The dealership has deemed it needs a new engine due to the failure the L87s are facing. We had no warning at all prior to the engine failure, and assumed that after passing a recall it had some degree of safety.
NHTSA ODI #11707538
Mileage unknown · Dec 26, 2025
EnginePower Train
The vehicle drove fine had no warning/ check engine lights. My girlfriend came up to a busy intersection and when she proceeded to cross the intersection the vehicles motor locked up stopping the vehicle in the middle of the intersection with traffic coming from both north and south direction. We had poor visibility due to blowi…
Read full complaint
The vehicle drove fine had no warning/ check engine lights. My girlfriend came up to a busy intersection and when she proceeded to cross the intersection the vehicles motor locked up stopping the vehicle in the middle of the intersection with traffic coming from both north and south direction. We had poor visibility due to blowing snow so she had to bail from the vehicle and stand on the side of the road so she would not be harmed if the vehicle was t boned. Vehicle stopped so hard and fast it threw her into the steering wheel. Was unable to get the vehicle restarted and could not get it to shift into neutral so vehicle blocked 1 lane of traffic completely and half of another lane until tow truck arrived to remove from road.
NHTSA ODI #11707179
Mileage unknown · Dec 18, 2025
Engine
In April 2022, I purchased a brand-new 2022 Yukon Denali from Roberts-Robinson Chevrolet GMC in Excelsior Springs, MO. Shortly thereafter, the first engine failure occurred in October 2022. The vehicle was towed to GMC AutoNation in Golden, CO, where it remained until repairs were completed in January 2023. Soon after the vehic…
Read full complaint
In April 2022, I purchased a brand-new 2022 Yukon Denali from Roberts-Robinson Chevrolet GMC in Excelsior Springs, MO. Shortly thereafter, the first engine failure occurred in October 2022. The vehicle was towed to GMC AutoNation in Golden, CO, where it remained until repairs were completed in January 2023. Soon after the vehicle was returned, the second engine failure occurred in February 2023. The vehicle was again towed to GMC AutoNation, and repairs were not completed until April 2023. At that time, given the repeated failures, I worked with GMC and Roberts-Robinson Chevrolet GMC to replace the vehicle entirely. I took delivery of a new 2023 GMC Yukon Denali as a resolution. On October 8, 2025, the engine on the 2023 Yukon Denali also failed, marking the third major engine failure I have experienced across these vehicles. The vehicle was towed again to GMC AutoNation in Golden, CO, where it remained for two months. I picked up the "repaired" vehicle on Tuesday, December 9, 2025. This pattern of failures has caused significant disruption and distress. I have spent countless hours coordinating tows, securing rental vehicles, and seeking reimbursement for out-of-pocket expenses. More importantly, these repeated engine failures, all of which occurred while I was driving 65 MPH on I-70 through the Colorado mountains, have created extremely dangerous situations for me and my loved ones. Navigating heavy traffic during sudden engine failure and waiting on the roadside for assistance has been frightening and unacceptable for a vehicle of this caliber. Overall, this experience has been incredibly stressful and disappointing.
NHTSA ODI #11705913
Mileage unknown · Dec 17, 2025
Forward Collision AvoidanceService BrakesSteering
Vehicle lost steering and brakes suddenly. Many errors on screen such as: Brake System Failure, ABS Failure, ESC Failure, Traction Control Failure, Maximum Vehicle Speed 43mph. Was able to slowly get home with no power assisted brakes. Did not drive it any more until it was taken to dealer 2 days later and the dealer could n…
Read full complaint
Vehicle lost steering and brakes suddenly. Many errors on screen such as: Brake System Failure, ABS Failure, ESC Failure, Traction Control Failure, Maximum Vehicle Speed 43mph. Was able to slowly get home with no power assisted brakes. Did not drive it any more until it was taken to dealer 2 days later and the dealer could not replicate the errors. Dealer was able to see stored error codes; however, they could not verify any errors in any of the modules or computer. Dealer wants us to take it back and wife is scared to drive it due to no fixes or repairs. Loss of brakes and steering is NOT a situation to ask an owner to 'bring back when it happens again"
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 GMC Yukon Problems, Complaints & Recalls | Skip That Year
Illustration