← New search

2023 GMC Yukon

Owner reports · Recalls · Investigations

More warning signs than most Yukon years

Owner complaints for the 2023 GMC Yukon are substantially higher than the model-year median of 103.

About this comparison →

When problems were reported

Mileage at the reported incident

Limited mileage data: 28 of 234 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports1 injury reports

Unknown Or Other complaints

18 reports
Clear category filter
Mileage unknown · Jun 2, 2025
EngineUnknown Or Other

I was driving on the highway going about 50 mph and the engine just stopped. It was very dangerous, and I couldn't get to a completely safe spot. I was stuck for 45 minutes there until police could get to my Yukon and help provide safety. I had 2 other passengers in the car. All of us were put at great risk and the surrounding t…

Read full complaint

I was driving on the highway going about 50 mph and the engine just stopped. It was very dangerous, and I couldn't get to a completely safe spot. I was stuck for 45 minutes there until police could get to my Yukon and help provide safety. I had 2 other passengers in the car. All of us were put at great risk and the surrounding traffic was also at risk. The Triple A towing took over an hour to get the vehicle on a flatbed because they couldn't get the Yukon in Neutral. There were absolutely no warning lights or any weird noises, the car shifted out of drive and would not go back into any gear. I am waiting for the dealership to decide what to do. My main reason for writing this complaint is this is a BIG HAZARD, not only for people who drive/ride in these vehicles but for every vehicle on the roads around them. When they stop with no warning, accidents and I'm sure some with fatalities will happen. This is a critical situation, and these vehicles should all be off the road. My Yukon was in my dealership service for an oil change about 1 week prior to this incident and I had a long conversation about the recall. They said my Yukon looked great and nothing was needed unless I had any problems. Since there have been so many others with the failed engine, ALL vehicles with this recall should be off the road to prevent totally innocent people from being in these dangerous situations. This is preventable if these cars are forbidden on the roads!!! GM must take responsibility before lives are lost due to this negligent reaction of issuing a recall but saying it is safe to keep driving unless there is a problem. If the first sign of a problem is failure with resulting catastrophic outcomes, then just issuing a recall is not enough. This must be addressed, PLEASE. This was a terrifying experience for me and my riders. I have no idea if the police filed the report but they spent alot of time trying to keep everything safe due to this issue.

NHTSA ODI #11664433

Mileage unknown · May 13, 2025
EngineUnknown Or Other

I own a 2023 GMC Yukon Denali with the 6.2L V8 engine. A safety recall was recently issued for this vehicle due to a potential engine defect that could result in sudden and severe failure. However, GM has not provided a remedy, and dealerships are unable to offer any repair or trade-in options while the recall remains open and u…

Read full complaint

I own a 2023 GMC Yukon Denali with the 6.2L V8 engine. A safety recall was recently issued for this vehicle due to a potential engine defect that could result in sudden and severe failure. However, GM has not provided a remedy, and dealerships are unable to offer any repair or trade-in options while the recall remains open and unresolved. I live in a rural area with limited cell service and long distances between towns. This makes the potential for sudden engine failure even more dangerous. Out of serious concern for my family’s safety, I no longer feel comfortable allowing my wife or our [XXX] child to ride in or use the vehicle. The risk of being stranded—or worse, getting into an accident due to engine failure—is too great given our location and the nature of this defect. I attempted to trade in the vehicle at a GMC dealership to get into a safer and unaffected vehicle, but the dealer refused to accept it because of the recall. This leaves me stuck with a vehicle that has a known safety issue and no solution in sight, limiting both my transportation options and peace of mind. There were no warning lights or prior symptoms before the recall. The issue was disclosed by the manufacturer. A dealer has confirmed the recall is active, but no fix exists. This situation is unacceptable and has real-world safety and financial consequences for families like mine. I urge the NHTSA to hold GM accountable and ensure a remedy is made available immediately to protect consumers who are left in limbo by this unresolved and serious safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11660576

Mileage unknown · Apr 22, 2025
Electrical SystemUnknown Or Other

Liftgate Opening without pushing the button, it just randomly opens.

NHTSA ODI #11656001

Mileage unknown · Apr 12, 2025
Unknown Or Other

The Onstar module becomes inoperable due to a fault with the onstar module. This is a known issue on many forums and GM has yet to issue a fix with mass reported Onstar module failures. This fault renders useless the safety systems.

NHTSA ODI #11654285

Mileage unknown · Mar 5, 2025
EngineUnknown Or Other

My vehicle started making a terrible noise. I had it towed to the nearest GM service center. It was determined that the vehicle, a 2023 Yukon Denali (less than 26000 miles) needed a new engine due to thrust bearing failure causing the engine block to be scored and contamination of debris internally.

NHTSA ODI #11646582

Mileage unknown · Jan 27, 2025
Service BrakesUnknown Or Other

I took my SUV (Yukon SLT 2023) to the GMC Dealership 4/5 months ago because of 2 recalls, Failed Brake Fluid Leak Detection and Serial Data Gateway Model. The car was repaired according to the dealership. About 2 weeks ago, I entered my garage to auto start my vehicle and my SUV would not auto start. I waited a few minutes and t…

Read full complaint

I took my SUV (Yukon SLT 2023) to the GMC Dealership 4/5 months ago because of 2 recalls, Failed Brake Fluid Leak Detection and Serial Data Gateway Model. The car was repaired according to the dealership. About 2 weeks ago, I entered my garage to auto start my vehicle and my SUV would not auto start. I waited a few minutes and tried to start it again from inside the vehicle and it started. When it started, the engine light was on and on the dashboard, brake system failure was displaying. It was very strange. So, I let my vehicle idle for a couple of minutes and tried to move the car in the garage. The car started jerking when I put it in drive and a message displayed on the dashboard telling me not to drive my SUV over 40 mph. The brake system failure and engine light were still on. It was very strange. I parked my SUV and let it sit. I'm taking my SUV back to the dealership on Thursday. I'm thankful I wasn't on the highway traveling to work, who knows what could have happened. There are massive problems with these vehicles, brakes, engine, computer systems, etc. I do not feel safe driving my SUV. I drive 41 miles each way for work and I don't feel safe driving this vehicle now with all the recalls, including the engine.

NHTSA ODI #11638837

Mileage unknown · Jul 2, 2024
Electrical SystemUnknown Or Other

Problem Synopsis: Camera Issues in 2023 Yukon Denali Vehicle Information: Model: 2023 Yukon Denali Issue Description: The vehicle's camera system exhibits malfunctioning behavior after the vehicle gets wet, such as following intense rain. Problem Details: Initial Trigger: The problem begins when the vehicle is put into rever…

Read full complaint

Problem Synopsis: Camera Issues in 2023 Yukon Denali Vehicle Information: Model: 2023 Yukon Denali Issue Description: The vehicle's camera system exhibits malfunctioning behavior after the vehicle gets wet, such as following intense rain. Problem Details: Initial Trigger: The problem begins when the vehicle is put into reverse after being exposed to water, particularly following heavy rainfall. Observed Malfunctions: The driver's side camera ceases to function immediately upon engaging reverse. Abrupt braking while in reverse leads to additional failures: The passenger side and forward-facing cameras also go black. Temporary Recovery: The cameras intermittently resume operation based on the vehicle's movement: Stepping on the brakes causes all cameras to go black. The cameras come back online one by one when the car rocks back, likely indicating water displacement around electrical connectors or modules. Hypothesis: The issues are likely caused by water affecting the electrical connections or modules associated with the camera system. This hypothesis is supported by the cameras' behavior correlating with changes in the vehicle's position and the presence of water. Recommendation: A thorough inspection of the camera system's connectors and modules is recommended, with particular attention to waterproofing and potential areas where water might collect and impact electrical components. Attached Evidence: The attached document contains pictures illustrating the camera issues as observed during the malfunction. These images were taken immediately after the intense rain when the vehicle was put into reverse and during the subsequent camera failures. [XXX] [XXX] [XXX] Solon, Ohio [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11598356

Mileage unknown · May 22, 2024
StructureUnknown Or Other

Faulty Sunroof flooded interior while driving. Dealers and mechanics say it is a known problem. Dangerous to drive while water is running down the driver and passengers. No warnings prior.

NHTSA ODI #11590238

Official recalls

4

25V274000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Apr 24, 2025

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Consequence & remedy

Consequence: Engine failure increases the risk of a crash.

Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

24V674000 · Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp; Service Brakes, Hydraulic:power Assist:electric:control Module:software

Sep 12, 2024

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Consequence & remedy

Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

Additional source detail variants (2)

Service Brakes, Hydraulic:power Assist:electric:control Module:software

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

23V642000 · Suspension:rear

Sep 20, 2023

General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

Consequence & remedy

Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.

22V903000 · Exterior Lighting:lighting Control Module:software

Dec 8, 2022

General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy

Opened Aug 20, 2026 · No close date supplied

Status: open (inferred from source dates) · Engine

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy

Opened Jan 16, 2026 · Closed Aug 20, 2026

Status: closed (inferred from source dates) · Engine

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

EA25007 · Loss Of Motive Power Due To Engine Failure

Opened Oct 23, 2025 · No close date supplied

Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001).  GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274.  This presents a potential safety risk that warrants further investigation.  ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001).  GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274.  This presents a potential safety risk that warrants further investigation.  ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001).  GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274.  This presents a potential safety risk that warrants further investigation.  ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

PE25001 · Loss Of Motive Power Due To Engine Failure

Opened Jan 16, 2025 · Closed Oct 23, 2025

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024.  GM cited the root cause as a supplier manufacturing and quality issues. GM’s  recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024.  GM cited the root cause as a supplier manufacturing and quality issues. GM’s  recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024.  GM cited the root cause as a supplier manufacturing and quality issues. GM’s  recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.