The contact owns a 2023 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact pulled over to the shoulder of the roadway, where the vehicle was able to be restarted. The contact became aware that the vehicle had entered LIMP Mode. No warning lights were…
Read full complaint
The contact owns a 2023 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact pulled over to the shoulder of the roadway, where the vehicle was able to be restarted. The contact became aware that the vehicle had entered LIMP Mode. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 44,000.
NHTSA ODI #11647976
Mileage unknown · Mar 12, 2025
Engine
I was traveling on the highway when my 2023 Yukon Denali engine shut off and switched to the neutral gear with any warnings. The dashboard display read "press start again" as I coasted to the shoulder of the highway. I was able to put the vehicle in "park" and re-start the engine after a couple of tries. I got a couple miles dow…
Read full complaint
I was traveling on the highway when my 2023 Yukon Denali engine shut off and switched to the neutral gear with any warnings. The dashboard display read "press start again" as I coasted to the shoulder of the highway. I was able to put the vehicle in "park" and re-start the engine after a couple of tries. I got a couple miles down the road, got off on an exit ramp then it shut off again and I again coasted to the shoulder of the highway. Again the display read "press start again", but this time the vehicle would NOT restart at all. I had full electrical power in the vehicle during both engine failures. I had the vehicle towed to my local GMC dealership. The dealership told me that I needed a new engine after assessing the vehicle.
NHTSA ODI #11647972
Mileage unknown · Mar 9, 2025
Engine
Engine had catastrophic failure, engine shut down with no warning while driving at highway speed. Huge vehicle safety concern.
NHTSA ODI #11647252
Mileage unknown · Mar 6, 2025
Engine
i was with my entire family 3 hours from home on a ski trip loaded with gear and the motor decided to go. i had to pull into an abandoned lot, leave my family in a car with no heat, walk 6 miles up a mountain to get another vehicle and pick up the family. Then i had to call a local tow company to drive out pick up the vehicle an…
Read full complaint
i was with my entire family 3 hours from home on a ski trip loaded with gear and the motor decided to go. i had to pull into an abandoned lot, leave my family in a car with no heat, walk 6 miles up a mountain to get another vehicle and pick up the family. Then i had to call a local tow company to drive out pick up the vehicle and myself and drive 3 hours home drop the vehicle at the dealer and then myself at home. The vehicle was not even pulled in for 2 weeks to be looked at (no other vehicle was available) and then they told us the motor was shot - lifters cam and other things and that the head gasket was on back order indefinitly. This happened the beginning of February its now March 6, the vehicle is in pieces at the dealer with no time frame of when we can get it back. Meanwhile its costing me 1670$/ mo plus insurance. For a 100k$ vehicle to go with 30k miles is wildly unacceptable. I have had no luck getting a return call from a representative with GM which is why i am filing this complaint now.
NHTSA ODI #11646772
Mileage unknown · Mar 5, 2025
EngineUnknown Or Other
My vehicle started making a terrible noise. I had it towed to the nearest GM service center. It was determined that the vehicle, a 2023 Yukon Denali (less than 26000 miles) needed a new engine due to thrust bearing failure causing the engine block to be scored and contamination of debris internally.
NHTSA ODI #11646582
34,000 miles · Mar 4, 2025
Engine
The contact owns a 2023 GMC Yukon. The contact stated while her husband was driving at 75 MPH, the vehicle independently accelerated without depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the transmission started to downshift, and the vehicle started losing motive power.…
Read full complaint
The contact owns a 2023 GMC Yukon. The contact stated while her husband was driving at 75 MPH, the vehicle independently accelerated without depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the transmission started to downshift, and the vehicle started losing motive power. The contact's husband merged to the side of the road and turned off the vehicle. While the vehicle was off, the message to press enter to start the vehicle was displayed; however, the vehicle failed to restart. The vehicle was then towed to a dealer and diagnosed with total engine failure. The local dealer was contacted; however, the vehicle was not repaired because the vehicle was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,000.
NHTSA ODI #11646222
Mileage unknown · Mar 4, 2025
Engine
Engine failed on interstate causing total stoppage. 18,000 miles on the vehicle and GM had to replace the engine completely which took 3 months. ZERO warning lights prior to the failure, no check engine light once failure occurred.
NHTSA ODI #11646165
Mileage unknown · Mar 3, 2025
Engine
Vehicle stopped working on a major road almost in the intersection in Lake Charles, Louisiana. The Vehicle is not able to be put in neutral to safely push it away to safer area. Had to be towed back to Texas at my expense of $400 and Service department says it is due to a blown 6.2l motor.
NHTSA ODI #11646024
Mileage unknown · Mar 3, 2025
Engine
On Friday 2/21/25, while driving on the Interstate at Highway speeds, the dashboard said to idle the engine. The engine then stalled and thankfully I had enough speed and there was a shoulder available to pull off on. The dashboard then gave many messages including voltage, overheating, high oil temperature, idle engine, etc... …
Read full complaint
On Friday 2/21/25, while driving on the Interstate at Highway speeds, the dashboard said to idle the engine. The engine then stalled and thankfully I had enough speed and there was a shoulder available to pull off on. The dashboard then gave many messages including voltage, overheating, high oil temperature, idle engine, etc... I was unable to restart the vehicle on the side of the interstate. I was towed to the dealer who advised the engine would have to be replaced. This vehicle has a 6.2L gas engine with 39,223 (approx) miles.
NHTSA ODI #11645952
Mileage unknown · Mar 1, 2025
Engine
I was driving home from work at around 60 mph. Very sunddly their was a rattling metal sounds and then vehicle struggled to maintain speed. Before pulling off the highway at the next exit. On the exit ramp the engine turned off and would not turn back on. The vehicle was also stuck in neutral and not able to shift out…
Read full complaint
I was driving home from work at around 60 mph. Very sunddly their was a rattling metal sounds and then vehicle struggled to maintain speed. Before pulling off the highway at the next exit. On the exit ramp the engine turned off and would not turn back on. The vehicle was also stuck in neutral and not able to shift out of neutral for towing. There was no worning lamps or messages even after the noise and reduced power. Vehicle was towed to local dealership on Tuesday evening, as this was not scheduled it took them to diagnosis the issue as engine failure and recommending to replace the engine. The vehicle is a 6.2L GMC Yukon Denali with 23k miles. All service has been done at the dealer with no outstanding work prior to the engine failure. Where it gets more disappointing is the lack of information for time to fix. The replacement engine was ordered by the dealer on February 14th. As of February 28th they did not have any information....So i called GMC on that 1800 number listed on GM Document DCS6866 referencing customer satisfaction program N232413430. The first agent disconnected without filing a case. The second agent had to restart the process and was told that there was nothing they would do for 14 days after the case was opened before it would be elevated. When talking to the agent they denied any information related to the GM Customer Satisfaction Program or any knowledge of what seems to be a wide spread defect on 6.2L engines. The service and support for a $90k vehicle from, in fairness they have provided access to rental vehicle from a local auto shop. The vehicle is far smaller and different from our vehicle we purchased. The vehicle is still sitting at the dealership service center and is not functional until the engine is repalced.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 GMC Yukon Problems, Complaints & Recalls | Skip That Year
Illustration