NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
28 reportsClear category filterMileage unknown · Mar 18, 2026
Electrical SystemEnginePower Train
On 3/3/2026 during the night-time hours, I was traveling on the freeway in my 2023 GMC Yukon at over 65 MPH when I received a notice from the instrument cluster stating that the battery was low and oil pressure was low. Before I could pull over to a safe location, the Yukon turned off while in motion. My wife and two children we…
Read full complaint
On 3/3/2026 during the night-time hours, I was traveling on the freeway in my 2023 GMC Yukon at over 65 MPH when I received a notice from the instrument cluster stating that the battery was low and oil pressure was low. Before I could pull over to a safe location, the Yukon turned off while in motion. My wife and two children were in the vehicle. The Yukon stalled in the number one lane of the off-ramp. I had to remove my children and wife from the vehicle while in the roadway on busy throughfares and in darkness. I attempted to jumpstart the Yukon, but efforts were unsuccessful. The Yukon was towed to the dealership where I purchased it purchased from. The Yukon was returned to my custody on 3/10/2026 stating it was an issue with the battery. While driving the Yukon home it began to bog down and stalled out in-front of my residence as it was being driven by my wife. After arriving home (night-time), I went to check the Yukon, and it started with no issues. I drove the Yukon to see if the errors would occur again. While driving the Yukon on the freeway, the Yukon RMPs indicated close to redline and I received a notification from the instrument cluster stating to turn the vehicle off (traveling at about 70-75 MPH). Once again, I was unable to pull off to a safe location before the Yukon turned off on its own while still in motion; I attempted to jumpstart the Yukon but attempts were unsuccessful. The Yukon was towed again to dealership. On 3/11/2026 I was advised that the engine had seized and on 3/13/2026 I was advised by GMC the engine needed to be replaced (this was covered under powertrain warranty). The approximate milage of the vehicle is at about 42,200.
NHTSA ODI #11725410
Mileage unknown · Feb 10, 2026
Electrical System
Rear camera for in cabin rear view is improperly sealed for cold weather and constantly fogs which renders the camera worthless. I was also sent brand new side lights from gm that were improperly sealed and built condensation them after a month or two.
NHTSA ODI #11716954
Mileage unknown · Jan 30, 2026
Electrical System
Full system error codes displayed on dashboard, Drive Train Error, Steering Colume error, brake system error, "Car will not operate a speed greater than 40 mph, happened 3 times dealership on first inspection advise it was an interface with the factory installed Lojack system and disconnected, Last same sincerio (note..no Lojack…
Read full complaint
Full system error codes displayed on dashboard, Drive Train Error, Steering Colume error, brake system error, "Car will not operate a speed greater than 40 mph, happened 3 times dealership on first inspection advise it was an interface with the factory installed Lojack system and disconnected, Last same sincerio (note..no Lojack connected) same as above the new diagnosis is the battery low voltage to system and throwing everything off.
NHTSA ODI #11714481
Mileage unknown · Jan 23, 2026
Electrical SystemService Brakes
While driving approximately 63 mph on a busy roadway, my 2023 GMC Yukon experienced a sudden failure of the brake system, including loss of normal braking capability along with failures of the Electronic Stability Control (ESC) and ABS systems. The vehicle displayed warning messages stating “Brake System Failure” and “Service ES…
Read full complaint
While driving approximately 63 mph on a busy roadway, my 2023 GMC Yukon experienced a sudden failure of the brake system, including loss of normal braking capability along with failures of the Electronic Stability Control (ESC) and ABS systems. The vehicle displayed warning messages stating “Brake System Failure” and “Service ESC” and entered a reduced-speed mode. Prior to this incident, there were no warning lights, messages, or symptoms indicating a problem. During the failure, the brakes became largely unresponsive, placing me, my two minor children who were passengers in the vehicle, and surrounding motorists at serious risk of a high-speed collision. After extended deceleration, a minimal amount of braking power partially returned, allowing the vehicle to eventually come to a stop. The vehicle has not yet been inspected by a dealer, manufacturer, police, or insurance representatives, and the issue has not yet been reproduced or confirmed by a service center. The vehicle remains available for inspection upon request and has not been repaired. This incident occurred without prior warning and involved a sudden and dangerous loss of braking capability at highway speed.
NHTSA ODI #11712998
Mileage unknown · Jan 3, 2026
Electrical System
My vehicle experienced a sudden and complete loss of OnStar and telematics functionality during or immediately following a routing/software update. I had taken my vehicle in for my engine recall and noted another software update was required and specifically was told by multiple service members over the phone that the onstar s…
Read full complaint
My vehicle experienced a sudden and complete loss of OnStar and telematics functionality during or immediately following a routing/software update. I had taken my vehicle in for my engine recall and noted another software update was required and specifically was told by multiple service members over the phone that the onstar services/telematics module was impacted and this update should resolve it. After some initial research it appears this is related to N212331730, which impacts OnStar and telematics services. I brought the vehicle to an authorized GMC dealer for the recall. After inspection, the dealer informed me that the telematics control module has failed and must be replaced. This failure resulted in the loss of all OnStar safety-related services, including emergency response and vehicle communication features. The failure appears directly related to the recall condition or software update process, yet I am being told the module replacement is not covered. This creates a safety concern because emergency communication systems required for crash response and roadside assistance are nonfunctional. I am concerned that the recall remedy may be causing or accelerating telematics module failures and that affected vehicles may be left without critical safety systems unless owners pay out of pocket.
NHTSA ODI #11708547
Mileage unknown · Oct 20, 2025
Electrical SystemVehicle Speed Control
Purchased 2023 GMC Yukon on August 21, 2025 and after starting the vehicle on October 2, 2025 the whole instrument panel cluster malfunctioned, failed to turn on, currently does not work and is available for inspection upon request. The instrument panel cluster is all black, it shows glitching flashing white lines on the right s…
Read full complaint
Purchased 2023 GMC Yukon on August 21, 2025 and after starting the vehicle on October 2, 2025 the whole instrument panel cluster malfunctioned, failed to turn on, currently does not work and is available for inspection upon request. The instrument panel cluster is all black, it shows glitching flashing white lines on the right side of it therefore being unable to read the speedometer, fuel gauges, tire pressure, oil life, engine temperature, etc.. Prior to the instrument panel cluster malfunction, there were no warning indicators. Being unable to view the instrument cluster, makes the vehicle hazardous & risky to utilize for me and my family. This vehicle has not been confirmed or inspected at this time.
NHTSA ODI #11694475
Mileage unknown · Oct 18, 2025
Electrical System
Onstar module bad
NHTSA ODI #11694252
Mileage unknown · Aug 29, 2025
Electrical System
we brought my 2023 gmc yukon into Parks GMC in greenville sc on july 26, 2025 for the engine recall that we received a letter from. We left it as we were going on vacation for the week and picked it up the following saturday august 2nd. the next week my engine light started lighting up and my husband contacted the dealership and…
Read full complaint
we brought my 2023 gmc yukon into Parks GMC in greenville sc on july 26, 2025 for the engine recall that we received a letter from. We left it as we were going on vacation for the week and picked it up the following saturday august 2nd. the next week my engine light started lighting up and my husband contacted the dealership and we were asked to bring it back in. We did and were told that we now had a bad Telematics Communication Interface Control Module that was causing my engine light to come on and that we were going to have to pay $600.00 out of our pocket to have this repaired. After researching we found that this is a VERY common and widespread problem with a lot of owners right after they bring their vehicles in to be serviced. We declined the repair, one because they did not have the part in stock as that apparently is also a big problem of not being able to get the part in stock and two because we feel like we should not have to pay to have this part replaced as it appears to be a widespread issue that is happening. The dealership also charged me $182 for diagnostic charges that I once again feel like we should not have had ton pay. Please advise us asap. our contact info is [XXX] [XXX] & [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11683839
11,000 miles · Jul 2, 2025
Electrical System
The contact owns a 2023 GMC Yukon. The contact stated that on several occasions, the vehicle failed to immediately start. During the failure, the contact received a message that the battery power was low. The contact stated that the vehicle was jumpstarted. The battery was replaced, but the failure persisted. The vehicle was tak…
Read full complaint
The contact owns a 2023 GMC Yukon. The contact stated that on several occasions, the vehicle failed to immediately start. During the failure, the contact received a message that the battery power was low. The contact stated that the vehicle was jumpstarted. The battery was replaced, but the failure persisted. The vehicle was taken to the local dealer on several occasions, but the cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 11,000.
NHTSA ODI #11670779
Mileage unknown · May 12, 2025
Back Over PreventionElectrical SystemVisibility/wiper
I am experiencing ongoing issues with the infotainment system in my vehicle, which has remained unresolved despite multiple service visits. The system frequently blacks out, reboots while driving, and fails to function entirely at times, for days at a time. This is more than an inconvenience — it presents several serious safety…
Read full complaint
I am experiencing ongoing issues with the infotainment system in my vehicle, which has remained unresolved despite multiple service visits. The system frequently blacks out, reboots while driving, and fails to function entirely at times, for days at a time. This is more than an inconvenience — it presents several serious safety concerns, including: •Loss of the rearview camera and parking assist features, making reversing hazardous. •Inability to access hands-free calling and navigation, increasing the risk of driver distraction and noncompliance with hands-free driving laws. •Disruption of access to climate controls and safety alerts that are routed through the infotainment system. •Frequent system crashes while driving, which divert my attention from the road. These issues compromise both the safety and usability of the vehicle, and I am requesting immediate action to resolve the problem under warranty.
NHTSA ODI #11660485
Official recalls
4Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Sep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration