IllustrationThe telematics module aka OnStar, doesn’t not work.
2022 GMC Yukon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2022 GMC Yukon do not stand out strongly from the model-year median of 103.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 30 of 179 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
Unknown Or Other complaints
10 reportsWhen initially turning the vehicle on for the day and turning on the heater, the cabin fills up with exhaust fumes odor. This also happens while the car is idling and not moving. Have taken it to the dealership and they do not know how to proceed or what is wrong with it.
Gateway system module failed during the L87 recall service.The major L87 recall (ECM update) is a major, high-load software update that frequently causes the Gateway Module to "brick" or stop communicating during the update process resulting in failed module immediately following the service. (TSB) speak to this, The L87 recall …
Read full complaint
Gateway system module failed during the L87 recall service.The major L87 recall (ECM update) is a major, high-load software update that frequently causes the Gateway Module to "brick" or stop communicating during the update process resulting in failed module immediately following the service. (TSB) speak to this, The L87 recall is a safety-critical repair, a failure of a module directly caused by this repair should be covered under a recall warranty or GM warranty. Safety can be affected as warning lights will not work due to this failure. Timeline of events. As soon as warranty service was completed before leaving bay lights were not working like Onstar etc, app wouldnt connect to car, 1-2 hours after leaving service engine light came on in car. Never had an engine light on before. Took back to dealer who said it was a computer issue they corrected it. 2 hours later engine light was back on. My car has been at the dealer since Monday when they called to say the GSM had internal failure and wanted to charge me to replace it despite this internal failure being in response to the warranty service that was provided, There are Technical service bulletins about this issue, this has been a known issue with GM vehicles, My timeline shows strong evidence that the failure is a direct result of the recall repair. There is GM TechLink documentation that these modules can be ruined if the update process creates a high load. GM needs to extend the GSM repair/recall or extend coverage for this repair when this happens. This is just another thing GM is not taking responsibility for.
On Star module quit working in our Yukon, which in turn makes it useless to have any of the safety features. On Star and GM know this is an ongoing problem, but no recall has been issued. Neither company will repair unless an $1100 fee is paid. Why install On Star if you know it will malfunction. Since there is a monthly ser…
Read full complaint
On Star module quit working in our Yukon, which in turn makes it useless to have any of the safety features. On Star and GM know this is an ongoing problem, but no recall has been issued. Neither company will repair unless an $1100 fee is paid. Why install On Star if you know it will malfunction. Since there is a monthly service fee I think they need to make sure the vehicle has the correct parts.
- Rearview camera system (backup camera) which is malfunctioning increasing risk of a collision and safety concern. - Yes it can be available for inspection upon upon request. - Problem was reported to dealer 4/15/25 for inspection on 4/24/25 - Vehicle has not been reported to manufacturer, police, insurance representatives as…
Read full complaint
- Rearview camera system (backup camera) which is malfunctioning increasing risk of a collision and safety concern. - Yes it can be available for inspection upon upon request. - Problem was reported to dealer 4/15/25 for inspection on 4/24/25 - Vehicle has not been reported to manufacturer, police, insurance representatives as it is scheduled to be checked by GMC dealer who claims there are no outstanding recalls on vehicle when it is the same known problem on other 2022 GMC Yukons (SLT) and others. - No warning lights appeared prior to camera malfunctioning.
MY ONSTAR MODULE CRASHED. I CANT USE ANY OF MY FEATURES. WHAT IF IM IN A WRECK? I PAID SO MUCH MONEY FOR THIS CAR ONLY FOR IT TO CRAP OUT LIKE THIS. NOT TO MENTION THE PART IS ON BACK ORDER AND HAVE NO IDEA WHEN IT WILL COME IN!!
My vehicle was 8 months old and it completely stopped with no warning going down the interstate, I was in the left lane and the vehicle locked up, engine and all leaving me stranded in the left lane on a busy interstate. When the engine quits, there is absolutely no way to get the vehicle into neutral to get it to a safe locati…
Read full complaint
My vehicle was 8 months old and it completely stopped with no warning going down the interstate, I was in the left lane and the vehicle locked up, engine and all leaving me stranded in the left lane on a busy interstate. When the engine quits, there is absolutely no way to get the vehicle into neutral to get it to a safe location. When this happened I was almost hit by an 18 wheeler . After having the vehicle towed to the dealership, they informed me the engine was seized. It took 3 months to get an engine from GM, they finally got the engine in, started it up in the shop, it apparently ran for about 15 minutes before losing oil pressure. At that time they shut the vehicle off, pulled the oil filter, found metal shavings in it and GM told the dealer to order another engine. But there were no engines available. The dealership finally notified me 3.5 months later that they finally received an engine and were working on installing it. I finally got my vehicle back after more than 6 months at the dealership and it was on its 3rd engine. I drove the vehicle for almost 2 years before the Same thing happened, the vehicle locked up on the highway and I had to have it towed. It has taken the dealer over a month to diagnose the problem and called to inform me the engine had seized up again. This will be the fourth engine in a 2022 GMC Yukon AT4. Besides the issue of the engines going bad, it is a severe safety issue that the vehicle will completely lock up on the highway with no way to move it. Twice I have almost been in a serious accident because of this.
this yukon is leaking water into the cabin and mold has developed. i do not know when this issue started but i noticed the mold under the passenger rubber mat on 8/26/23. i contacted the local dealer, koon's gmc and they told me that they would charge me to just look at the car even though it is under a bumper to bumper 3 year…
Read full complaint
this yukon is leaking water into the cabin and mold has developed. i do not know when this issue started but i noticed the mold under the passenger rubber mat on 8/26/23. i contacted the local dealer, koon's gmc and they told me that they would charge me to just look at the car even though it is under a bumper to bumper 3 year warranty. the dealer was unable to locate the source of the leak, so nothing was fixed. i have been in touch with a gmc representative and she hasn't any useful information. the development of mold in the car is hazardous to our family and this should be looked into by the government.
On September 9th at approximately 5:00 pm, my wife and I left Augusta and headed to Atlanta to attend an event. While driving highway speeds of about 70-80mph, the vehicle began to decelerate rapidly and then shifted itself into neutral gear. Unable to shift back into drive, I was forced to maneuver my slowing vehicle onto the s…
Read full complaint
On September 9th at approximately 5:00 pm, my wife and I left Augusta and headed to Atlanta to attend an event. While driving highway speeds of about 70-80mph, the vehicle began to decelerate rapidly and then shifted itself into neutral gear. Unable to shift back into drive, I was forced to maneuver my slowing vehicle onto the shoulder of the highway, placing myself and my wife in danger of colliding with the other vehicles who were still travelling at highway speeds. After pulling over onto the shoulder, I was able to shift the vehicle into park and turn it completely off. After a few minutes, I turned the vehicle back on and integrated back into traffic. Approximately 20 minutes later, the vehicle began to have trouble accelerating and I was unable to exceed 65mph on a highway where the speed limit was 70mph, and the other vehicles were exceeding that. My wife and I were sitting ducks in Atlanta traffic. I once again planned to pull the vehicle over when it suddenly made a loud noise and began to vibrate violently. From the far left lane, I found myself fighting with a vehicle that refused to accelerate and was now becoming uncontrollable. I managed to take the next exit, and parked the vehicle. After turning off the vehicle, I waited a few moments and tried to start it again. The vehicle did start, but continued to vibrate aggressively, as well as make loud clunking and squeaking sounds from under the hood. There was also a smell of something burning. For our safety, my wife and I exited the vehicle, as it had been rendered completely inoperable. I was forced to have the vehicle towed. The vehicle is currently at John Miles Chevrolet Buick GMC in Conyers, GA. (678)374-4695. The dealer has not confirmed the problem. No inspection has been done to date. When to vehicle shifted to neutral I believe the only warning light said "Conditions not correct for shifting". It only appeared when the vehicle shifted into neutral.
The heads up display starting with the 2022 model removed the colored lane departure warning from the sides of the road graphic that is in line with the road and moved it to a very small display to the left side of the driver's field of view. Now to see the lane departure warning requires a shift of the driver's view to the lef…
Read full complaint
The heads up display starting with the 2022 model removed the colored lane departure warning from the sides of the road graphic that is in line with the road and moved it to a very small display to the left side of the driver's field of view. Now to see the lane departure warning requires a shift of the driver's view to the left and a head tilt if wearing progression bifocals. On prior year models the colored warning provided an early alert well before the seat vibrates as the warning. Taking my vision off the road caused me to come up on a very slow moving car that required the automatic braking to slow my vehicle
Official recalls
526V085000 · Power Train:automatic Transmission:control Module:software; Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
Feb 13, 2026
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
25V619000 · Fuel System, Diesel:storage:tank Assembly
Sep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Remedy: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
25V274000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
22V903000 · Exterior Lighting:lighting Control Module:software
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
22V617000 · Seat Belts:critical Fasteners
Aug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.