← New search

2013 GMC Yukon

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2013 GMC Yukon do not stand out strongly from the model-year median of 103.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Yukon years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

74 reports with mileage · 43 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports0 fire reports3 injury reports

Air Bags complaints

32 reports
Clear category filter
Mileage unknown · Aug 14, 2018
Air Bags

I OWN A 2013 YUKON XL WITH JUST OVER 88000 MILES ON IT, VEHICLE IS IN VERY GOOD CONDITION, IT HAD BEEN SITTING IN THE GARAGE A COUPLE OF DAYS, I OPENED THE PASSENGER DOOR TO RETRIEVE AN ITEM AND HEARD A LITTLE CRACK SOUND, THE DASH HAD CRACKED ON TOP FROM THE PASSENGER AIR BAG TOWARD THE DEFROSTER, CONTACTED GMC AND WAS INFORMED…

Read full complaint

I OWN A 2013 YUKON XL WITH JUST OVER 88000 MILES ON IT, VEHICLE IS IN VERY GOOD CONDITION, IT HAD BEEN SITTING IN THE GARAGE A COUPLE OF DAYS, I OPENED THE PASSENGER DOOR TO RETRIEVE AN ITEM AND HEARD A LITTLE CRACK SOUND, THE DASH HAD CRACKED ON TOP FROM THE PASSENGER AIR BAG TOWARD THE DEFROSTER, CONTACTED GMC AND WAS INFORMED THAT THIS IS THE FIRST TIME THEY HAD HEARD OF THIS PROBLEM AND VEHICLE IS OUT OF WARRANTY AND THIS WOULD BE AN OUT OF POCKET EXPENSE. UPON FURTHER INVESTIGATION AS I WAS TALKING TO UPHOLSTREY SHOPS AND CAR RESTORATION PEOPLE TRYING TO FIND SOMEONE TO REPAIR CRACK BEFORE IT GETS WORSE, THEY TOLD ME IT'S A COMMON PROBLEM AND MORE THAN LIKELY THIS IS JUST THE BEGINNING. I LIVE IN ND WHERE WE HAVE EXTREME TEMPERATURE SWINGS SO I'M A BIT CONCERNED. LASTLY, WITH THE CURRENT CRACK BEING WHERE IT IS, SHOULD THE AIRBAG EVER DEPLOY AM I GOING TO HAVE DASH PIECES FLYING THROUGHOUT THE VEHICLE?

NHTSA ODI #11119836

78,000 miles · Aug 12, 2018
Air Bags

CRACK IN DASHBOARD AT CORNER OF AIRBAG PASSENGER SIDE.

NHTSA ODI #11119503

50,000 miles · Sep 16, 2017
Air Bags

THE DASHBOARD IS CRACKED AND IN THE EVENT OF AN AIRBAG DEPLOYMENT THE LOOSE DASH PIECES COULD COME LOOSE AND CAUSE ADDITIONAL INJURIES TO THE OCCUPANRS

NHTSA ODI #11023777

50,000 miles · Sep 14, 2017
Air BagsUnknown Or Other

I HAVE TWO COMPLAINTS ABOUT THIS CAR. 1ST THE DASH HAS CRACKED STARTING AT THE LEFT REAR OF THE AIR BAG COVER TO THE REAR SEAM OF THE DASH. EVEN WITH A MAJOR GUARD PROTECTION PLAN 901770667 I'M BEING TOLD IT'S NOT COVERED. THIS CAR IS ONLY 3 YEARS OLD AND 50,000 MILES AND I'VE LEARNED THAT THERE ARE MANY MORE CUSTOMERS OF GM V…

Read full complaint

I HAVE TWO COMPLAINTS ABOUT THIS CAR. 1ST THE DASH HAS CRACKED STARTING AT THE LEFT REAR OF THE AIR BAG COVER TO THE REAR SEAM OF THE DASH. EVEN WITH A MAJOR GUARD PROTECTION PLAN 901770667 I'M BEING TOLD IT'S NOT COVERED. THIS CAR IS ONLY 3 YEARS OLD AND 50,000 MILES AND I'VE LEARNED THAT THERE ARE MANY MORE CUSTOMERS OF GM VEHICLES WITH CRACKED DASHBOARDS. 2ND THE INSIDE DOOR HANDLE ON THE DRIVERS SIDE IS BROKEN. THE SMALL PIECES OF PLASTIC UNDER THE DOOR HANDLE ARE ALL BROKEN. THIS TOO ISN'T COVERED I'M BEING TOLD. THE DOOR HANDLE HAS BEEN CRACKED FOR OVER A YEAR . THE CRACK IN THE DASH JUST HAPPENED YESTERDAY ON 9/13/2017

NHTSA ODI #11023454

Mileage unknown · Aug 21, 2017
Air BagsElectrical System

CRACKING DASHBOARD! DEEP CRACKS RUNNING UP TO AND ALONG THE AIRBAG

NHTSA ODI #11016435

Mileage unknown · Aug 14, 2017
Air Bags

MY DASH WAS CRACKED AROUND AND ABOVE MY PASSENGER AIR BAG. THE DEALER SAID THEY WONT FIX IT BECAUSE IT IS A COMMON PROBLEM. IT IS A MAJOR SAFTEY HAZARD BECAUSE MY PASSENGER WILL GET PLASTIC IN THEIR FACE IF THE AIR BAG DEPLOYS. *JS

NHTSA ODI #11015172

48,000 miles · Aug 13, 2017
Air Bags

DASH CRACKED BY AIRBAG

NHTSA ODI #11014937

39,000 miles · Jul 11, 2017
Air BagsUnknown Or Other

THE DASH HAS CRACKED AROUND THE PASSENGER SIDE DASH MOUNTED AIRBAG. THIS COULD CAUSE THE FRAGILE PLASTIC TO ACT AS SHRAPNEL IF THE AIRBAG ACTIVATES. THE VEHICLE IS 4 YEARS OLD AND HAS 39000 MILES.

NHTSA ODI #11004673

Mileage unknown · Jun 13, 2017
Air BagsUnknown Or Other

I TRADED IN A GMC HYBRID JUNE 2014 & PURCHASED A 2013 GMC YUKON XL 1500 SLT. THE HYBRID I TRADED IN HAD A CRACKED DASH. I JUST THOUGHT IT WAS A RARE THING THAT HAPPENED FOR WHATEVER REASON. MY CURRENT YUKON ALSO NOW HAS A CRACKED DASH. AFTER MINIMAL DIGGING, I HAVE FOUND THIS TO BE AN ISSUE IN THEIR VEHICLES MADE BETWEEN A C…

Read full complaint

I TRADED IN A GMC HYBRID JUNE 2014 & PURCHASED A 2013 GMC YUKON XL 1500 SLT. THE HYBRID I TRADED IN HAD A CRACKED DASH. I JUST THOUGHT IT WAS A RARE THING THAT HAPPENED FOR WHATEVER REASON. MY CURRENT YUKON ALSO NOW HAS A CRACKED DASH. AFTER MINIMAL DIGGING, I HAVE FOUND THIS TO BE AN ISSUE IN THEIR VEHICLES MADE BETWEEN A CERTAIN NUMBER OF YEARS. MY DASH CRACK IS AT MY AIRBAG. #1, & MOST IMPORTANT, IS THE SAFETY OF MY PASSENGER. #2 IS THE FACT THAT I PAID A HUGE AMOUNT FOR THIS VEHICLE. ANY FLAWS OR ISSUES THAT ARE CAUSED BY THE MAKER SHOULD 100% BE COVERED AND REPAIRED. I HAVE AN APPT. WITH THE DEALER. LADY SAID DASH REPLACEMENT IS PROBABLY NOT COVERED AND COULD COST ME $500.00 TO REPAIR. THIS IS NOT MY FAULT. I FOUND WHERE ONLINE THAT MANY PEOPLE HAVE THIS SAME PROBLEM. WHAT DO I NEED TO DO? I AM UNABLE TO PROVIDE THE DATE IT HAPPENED. I WENT TO CLEAN IT AND NOTICED IT WAS CRACKED. TOOK IT INTO A LOCAL DEALERSHIP; AT THAT POINT IT WAS RECOMMENDED I GO TO THE DEALERSHIP I PURCHASED IT FROM.

NHTSA ODI #10994987

Mileage unknown · Nov 30, 2016
Air BagsUnknown Or Other

CRACKED DASHBOARD AROUND AIRBAG AND ALL ACROSS DASH VERY CONCERNED ABOUT PLASTIC PARTS OF DASH CAUSING INJURY OR DEATH DUE TO SHARP FLYING PIECES STRIKING PASSENGERS 2013 GMC YUKON XL DENALI MODEL GM WILL NOT REPAIR OR REPLACE THIS OBVIOUS AND DANGEROUS DEFECT

NHTSA ODI #10928732

Official recalls

4

21V053000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

14V614000 · Electrical System

Oct 1, 2014

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

Consequence & remedy

Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM’s number for this recall is 14515.

13V001000 · Power Train:automatic Transmission; Steering:column LOCKING:ANTI-THEFT Device

Jan 2, 2013

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence & remedy

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Additional source detail variants (2)

Power Train:automatic Transmission

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Steering:column LOCKING:ANTI-THEFT Device

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.