← New search

2011 GMC Yukon

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 GMC Yukon do not stand out strongly from the model-year median of 103.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Yukon years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

85 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports2 injury reports

Unknown Or Other complaints

55 reports
Clear category filter
85,000 miles · Nov 21, 2016
Unknown Or OtherWheels

1) DASHBOARD IS CRACKING ON THE DRIVERS SIDE. THE CRACK HAS PROGRESSED DIRECTLY OVER THE ARCHED AREA OF THE DASHBOARD OVER THE INSTRUMENT PANEL. THE CRACK HAS PROGRESSED TO THE POINT THAT THE DASHBOARD IS FLAPPING WHERE THE CRACK IS LOCATED. 2) TWO OF MY TIRES ARE LOSING AIR PRESSURE DUE TO CORROSION PROBLEMS WITH THE CHRO…

Read full complaint

1) DASHBOARD IS CRACKING ON THE DRIVERS SIDE. THE CRACK HAS PROGRESSED DIRECTLY OVER THE ARCHED AREA OF THE DASHBOARD OVER THE INSTRUMENT PANEL. THE CRACK HAS PROGRESSED TO THE POINT THAT THE DASHBOARD IS FLAPPING WHERE THE CRACK IS LOCATED. 2) TWO OF MY TIRES ARE LOSING AIR PRESSURE DUE TO CORROSION PROBLEMS WITH THE CHROME RIMS/WHEELS. ONE OF THE RIMS HAS A 2 INCH CRACK IN THE CHROME FINISH.

NHTSA ODI #10927254

45,000 miles · Oct 12, 2016
Air BagsUnknown Or Other

CRACKING DASH BOARD AROUND PASSENGER AIRBAG

NHTSA ODI #10915587

50,000 miles · Oct 6, 2016
Air BagsUnknown Or Other

THE DASHBOARD OF MY 2011 YUKON IS CRACKING IN MULTIPLE LOCATIONS, INCLUDING AROUND THE AIRBAG AREAS, CREATING A HAZARD IF THE AIRBAGS WERE TO EMPLOY.

NHTSA ODI #10914356

110,000 miles · Aug 26, 2016
Unknown Or Other

THERE ARE 3 CRACKS IN THE DASHBOARD OF MY 2011 GMC YUKON. ONE CRACK IS NEAR THE LEFT FRONT CORNER OF THE PASSENGER AIRBAG. TWO CRACKS ARE LOCATED NEAR THE FRONT RIGHT SIDE OF THE INSTRUMENT PANEL. I BELIEVE THIS IS A DEFECT IN THE MATERIALS AND THE GM SHOULD REPLACE THE DASHBOARD FREE OF CHARGE. VEHICLE WAS STATIONARY.

NHTSA ODI #10898676

62,000 miles · Aug 24, 2016
Unknown Or Other

FOUND 2 CRACKS IN MY DASHBOARD...THIS IS NOT NORMAL WEAR AND TEAR. ONE CRACK ABOVE THE INSTRUMENT PANEL AND ONE CRACK NEAR THE PASSENGER AIRBAG. I AM VERY CONCERNED ABOUT ONE DEEP CRACK BY THE AIRBAG. IS THIS SAFE? WITH THE CONCERN OVER THE TAKATA AIR BAG ISSUES AND NO POSSIBLE WAY TO REMEDY THAT AT THIS TIME I AM WORRIED THAT T…

Read full complaint

FOUND 2 CRACKS IN MY DASHBOARD...THIS IS NOT NORMAL WEAR AND TEAR. ONE CRACK ABOVE THE INSTRUMENT PANEL AND ONE CRACK NEAR THE PASSENGER AIRBAG. I AM VERY CONCERNED ABOUT ONE DEEP CRACK BY THE AIRBAG. IS THIS SAFE? WITH THE CONCERN OVER THE TAKATA AIR BAG ISSUES AND NO POSSIBLE WAY TO REMEDY THAT AT THIS TIME I AM WORRIED THAT THIS PRESENTS A SAFETY HAZARD TO MY FAMILY. CALLED GM AND THERE IS NOTHING THEY WILL DO UNLESS I WANT TO PURCHASE A NEW DASHBOARD??? HOW CAN THERE BE SO MANY COMPLAINTS WITH NO ACTION FROM GM?

NHTSA ODI #10898304

54,000 miles · Aug 2, 2016
Unknown Or Other

MY DASHBOARD IS CRACKING AND I PARK UNDERGROUND AT WORK AND IN THE GARAGE AT HOME, NO SUN EXPOSURE.

NHTSA ODI #10892539

55,000 miles · Jul 15, 2016
Unknown Or Other

MY DASHBOARD HAS 2 CRACKS IN IT. THIS BEGAN AROUND 55,000 MILES. ONE IS ABOVE THE AIRBAG AND THE OTHER IS IN THE MIDDLE ON TOP OF THE MIDDLE SPEAKER. I PURCHASED A $1500 EASY CARE EXTENDED WARRANTY WHEN I PURCHASED THIS VEHICLE TO HOPEFULLY TAKE CARE OF ANYTHING THAT MIGHT HAVE COME UP WHILE PAYING ON THIS VEHICLE. THIS WARRANTY…

Read full complaint

MY DASHBOARD HAS 2 CRACKS IN IT. THIS BEGAN AROUND 55,000 MILES. ONE IS ABOVE THE AIRBAG AND THE OTHER IS IN THE MIDDLE ON TOP OF THE MIDDLE SPEAKER. I PURCHASED A $1500 EASY CARE EXTENDED WARRANTY WHEN I PURCHASED THIS VEHICLE TO HOPEFULLY TAKE CARE OF ANYTHING THAT MIGHT HAVE COME UP WHILE PAYING ON THIS VEHICLE. THIS WARRANTY DOES NOT COVER THE DASHBOARD. OF COURSE! I SPENT COUNTLESS HOURS ON THE PHONE WITH THE DEALERSHIP, GMC SENIOR ADVISORS, AND THEN THE NEXT IN LINE TO FINALLY BE TOLD I WAS RESPONSIBLE FOR $300 PLUS TAX FOR THE REPAIR. WHAT UPSET ME THE MOST IS THE FACT THAT GMC TRIED TO BLAME WEAR AND TEAR AND THE SUN WITHOUT ACCEPTING THE RESPONSIBILITY OF THE DEFECT. THIS SHOULD NOT BE MY RESPONSIBILITY TO FIX. WHAT INCENTIVE DO I HAVE TO EVER BUY GMC AGAIN WHEN I AM DRIVING ONE OF THE TOP OF THE LINE VEHICLES WHICH COSTS $65,000 AND I'M TOLD THAT IT'S NOT THEIR FAULT THAT ST 55,000 MILES MY DASH IS CRACKED AND RATTLING AND I'M DRIVING AROUND WITH PAPER STUFFED IN IT TO STIFLE THE NOISE. SO DISGUSTED!!!!! THE BEST THEY COULD DO IS THAT I PAY $300 PLUS TAX TO FIX. WHAT AN INSULT! LAST GMC VEHICLE. MAKE IT RIGHT WITH YOUR CUSTOMERS WHEN IT'S YOUR FAULT!!

NHTSA ODI #10885057

52,000 miles · Jul 8, 2016
Unknown Or Other

THE DASHBOARD ON MY 2011 YUKON XL WITH ONLY 52,000 MILES ON IT. A COUPLE OF WEEKS AGO MY YUKON DASHBOARD CRACKED OVER THE INSTRUMENT PANEL AND AT THE RIGHT PASSENGER AIRBAG. THIS DASHBOARD HAS NO SUPPORT UNDER IT AND I CAN PUSH THE DASHBOARD DOWN WITH MY FINGER WITHOUT APPLYING ANY FORCE. WHEN THE AIRBAG DEPLOYS THE DASHBOAR…

Read full complaint

THE DASHBOARD ON MY 2011 YUKON XL WITH ONLY 52,000 MILES ON IT. A COUPLE OF WEEKS AGO MY YUKON DASHBOARD CRACKED OVER THE INSTRUMENT PANEL AND AT THE RIGHT PASSENGER AIRBAG. THIS DASHBOARD HAS NO SUPPORT UNDER IT AND I CAN PUSH THE DASHBOARD DOWN WITH MY FINGER WITHOUT APPLYING ANY FORCE. WHEN THE AIRBAG DEPLOYS THE DASHBOARD WILL BREAK OFF AT THE WEAK POINT BREAKING WITH POINTED SHARP AREAS THAT CAN EITHER PUNCTURE THE AIRBAG OR HIT THE PASSENGER. THIS IS A HUGE SAFETY ITEM. THE DEALERSHIP SAYS THAT THIS CRACKED DUE TO HEAT SO I AM NOW CONCERNED THAT THE FAULTY DASHBOARD IS CRACKING DUE TO HEAT THAT THE TAKATA RECALL IS A HUGE SAFETY ISSUE THAT ALSO RELATES TO HEAT IN THIS VEHICLE. BOTH OF THESE ITEMS SHOULD BE RECALLED.

NHTSA ODI #10883485

Mileage unknown · May 27, 2016
Unknown Or Other

THE DASH AROUND THE PASSENGER SIDE AIRBAG IS CRACKING.

NHTSA ODI #10871131

32,200 miles · May 12, 2016
Unknown Or Other

THIS MORNING AS I WAS DRIVING, I HEARD A VIBRATION SOUND COMING FROM THE DASH. SO I LOOKED OVER & I FIND A CRACK! NOT 1 BUT 2! OVER THE SPEEDOMETER & BY THE PASSENGER AIR BAGS. I'M SCARED ITS GONNA AFFECT THE PASSENGER AIRBAGS...

NHTSA ODI #10864684

Official recalls

5

21V050000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

14V827000 · Electrical System:ignition

Dec 30, 2014

General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.

Consequence & remedy

Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.

Remedy: GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The recall began on February 12, 2015. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.

11V339000 · Steering:linkages

Jun 28, 2011

GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.

Consequence & remedy

Consequence: THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.

Remedy: GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

11V007000 · Suspension:rear:axle:spindle

Jan 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.