← New search

2011 GMC Yukon

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 GMC Yukon do not stand out strongly from the model-year median of 103.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Yukon years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

85 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports2 injury reports

Air Bags complaints

79 reports
Clear category filter
Mileage unknown · Aug 25, 2023
Air Bags

As per Tread Act that confirms reimbursement for recalled items, I replaced the Takata airbag on 09/18/2019 after a recall issue by NHTSA, but prior to GMC manufacture initiating the repair. General Motors refused to reimburse the cost of the replacement of the airbag. Under Tread Act the manufacturer is required to reimburse a…

Read full complaint

As per Tread Act that confirms reimbursement for recalled items, I replaced the Takata airbag on 09/18/2019 after a recall issue by NHTSA, but prior to GMC manufacture initiating the repair. General Motors refused to reimburse the cost of the replacement of the airbag. Under Tread Act the manufacturer is required to reimburse any repair prior to actual recall.

NHTSA ODI #11540799

Mileage unknown · Nov 8, 2021
Air Bags

Takata recall. The contact owns a 2011 GMC Yukon. The contact received a notification for NHTSA Campaign Number: 21V054000 (Air Bags) however, the part for the recall repair was unavailable. The dealer had been notified of the recall; however, the contact was informed that parts were not yet available. The manufacturer had been …

Read full complaint

Takata recall. The contact owns a 2011 GMC Yukon. The contact received a notification for NHTSA Campaign Number: 21V054000 (Air Bags) however, the part for the recall repair was unavailable. The dealer had been notified of the recall; however, the contact was informed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI #11439688

Mileage unknown · Nov 3, 2021
Air Bags

Takata Recall. The contact owns a 2011 GMC Yukon. The contact received notification of NHTSA Campaign Number: 21V054000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of …

Read full complaint

Takata Recall. The contact owns a 2011 GMC Yukon. The contact received notification of NHTSA Campaign Number: 21V054000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and informed the contact that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI #11439170

Mileage unknown · Oct 25, 2021
Air Bags

2011 GMC YUKON. CONSUMER WRITES IN REGARDS TO TAKATA AIRBAG SAFETY RECALL. THE CONSUMER STATED THE DEALER REFUSED TO HONOR THE RECALL DUE TO THE VEHICLE'S AGE.

NHTSA ODI #11438105

90,000 miles · May 13, 2021
Air BagsCrashInjury

THE CONTACT OWNS A 2011 GMC YUKON. THE CONTACT STATED WHILE ATTEMPTING TO STOP AT A STOP SIGN, THE VEHICLE REAR-ENDED ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A HEAD INJURY AND HAD TO SEEK MEDICAL ATTENTION. THE VEHICLE WAS DRIVABLE AND THE CONTACT WAS ABLE TO DRIVE THE VE…

Read full complaint

THE CONTACT OWNS A 2011 GMC YUKON. THE CONTACT STATED WHILE ATTEMPTING TO STOP AT A STOP SIGN, THE VEHICLE REAR-ENDED ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A HEAD INJURY AND HAD TO SEEK MEDICAL ATTENTION. THE VEHICLE WAS DRIVABLE AND THE CONTACT WAS ABLE TO DRIVE THE VEHICLE BACK TO HIS HOME ADDRESS. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 90,000.

NHTSA ODI #11416501

Mileage unknown · Mar 22, 2021
Air Bags

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 GMC YUKON. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V054000 (AIR BAGS). THE CONTACT WAS FRUSTRATED THAT THERE WAS NO REMEDY FOR THE RECALL. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CONTACT NOTIFIED THE MANUFACTURER OF THE RECALL NOTICE HOWEVER, THE REPRESENTAT…

Read full complaint

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 GMC YUKON. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V054000 (AIR BAGS). THE CONTACT WAS FRUSTRATED THAT THERE WAS NO REMEDY FOR THE RECALL. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CONTACT NOTIFIED THE MANUFACTURER OF THE RECALL NOTICE HOWEVER, THE REPRESENTATIVE INFORMED THE CONTACT THAT THE VEHICLE WAS SAFE TO DRIVE BUT WOULD NOT PROVIDE DOCUMENTATION THAT STATED THAT THE VEHICLE WAS SAFE TO DRIVE. NO FURTHER ASSISTANCE WAS PROVIDED. THE CONTACT NOTIFIED SOUTHERN BUICK GMC GREENBRIER (1300 S MILITARY HWY, CHESAPEAKE, VA 23320) OF THE RECALL NOTICE AND THE DEALER OFFERED THE CONTACT ANOTHER VEHICLE FOR PURCHASE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #11404313

Mileage unknown · Jan 31, 2021
Air BagsUnknown Or Other

I RECENTLY PURCHASED A 2011 GMC YUKON FROM MY PARENTS. THEY ARE THE ORIGINAL OWNERS. THIS VEHICLE WAS KEPT UNDER THIER CARPORT AND NOT IN DIRECT SUNLIGHT. THE DASHBOARD HAS MULITPLE CRACKS. MOST CONCERNING IS THE CRACKS NEAR THE PASSENGER SIDE AIRBAG. WHAT IF I WERE IN AN ACCIDENT, THE DASHBOARD COULD BECOME SHRAPNEL IMPALING MY…

Read full complaint

I RECENTLY PURCHASED A 2011 GMC YUKON FROM MY PARENTS. THEY ARE THE ORIGINAL OWNERS. THIS VEHICLE WAS KEPT UNDER THIER CARPORT AND NOT IN DIRECT SUNLIGHT. THE DASHBOARD HAS MULITPLE CRACKS. MOST CONCERNING IS THE CRACKS NEAR THE PASSENGER SIDE AIRBAG. WHAT IF I WERE IN AN ACCIDENT, THE DASHBOARD COULD BECOME SHRAPNEL IMPALING MYSELF OR MY PASSENGER. ALSO THE DEFECTIVE DASHBOARD COULD SPLINTER AND PUNCTURE THE AIRBAG MAKING THEM INEFFECTIVE. AFTER RESEARCHING THIS ISSUE, THERE ARE NUMEROUS COMPLAINTS AND EVEN LAWSUITS. I AM APPALLED TO KNOW YOU AND GMC ARE AWARE OF THE RISKS OF THE CRACKED DASHBOARD CAUSING GREAT BODILY HARM OR DEATH. YOU AND GMC HAVE DONE NOTHING TO REMEDY THE PROBLEM. I HAVE A 2002 HONDA ACCORD THAT SITS IN THE SUN AND THE DASHBOARD IS IN PERFECT CONDITION.

NHTSA ODI #11390914

162,000 miles · Nov 24, 2020
Air Bags

THIS AIR BAG DANGER HAS BEEN GOING ON FOR A WHILE. I CONTACT THE DEALER AND NO ACTION TO FIX. THEY INDICATE NO SOLUTION AND NO PARTS TO REPAIR AT PRESENT.

NHTSA ODI #11376157

Mileage unknown · Nov 23, 2020
Air BagsUnknown Or Other

THE DASHBOARD HAS SEVERELY CRACKED AND COULD CAUSE HARMFUL PLASTIC TO SHOOT TOWARDS PASSENGER IF THE AIRBAG IS DEPLOYED. THIS ALSO CAUSES THE INTERIOR TO MAKE LOUD DASH SOUNDS WHILE DRIVING AFFECTING THE EXPERIENCE OF THE DRIVE.

NHTSA ODI #11376054

42,000 miles · Nov 9, 2020
Air BagsUnknown Or Other

THE DASHBOARD IS CRACKED FROM THE DRIVERS SIDE TO THE PASSENGER SIDE IN MULTIPLE PLACES ON TOP OF AND ALONG SIDE OF THE INNER AIRBAGS AND UNDER A COLLISION THESE PIECES OF THE DASH COULD AND IN MY OPINION AND THE OPINION OF GM BODY REPAIRMAN WILL VERY LIKELY BECOME A FLYING PROJECTILE CAUSING POSSIBLE INJURY OR DEATH TO OCCUPANT…

Read full complaint

THE DASHBOARD IS CRACKED FROM THE DRIVERS SIDE TO THE PASSENGER SIDE IN MULTIPLE PLACES ON TOP OF AND ALONG SIDE OF THE INNER AIRBAGS AND UNDER A COLLISION THESE PIECES OF THE DASH COULD AND IN MY OPINION AND THE OPINION OF GM BODY REPAIRMAN WILL VERY LIKELY BECOME A FLYING PROJECTILE CAUSING POSSIBLE INJURY OR DEATH TO OCCUPANTS. I AM REQUESTING IMMEDIATE REPLACEMENT OR REPAIR OF THIS UNSAFE SITUATION BEFORE TURNING IT OVER TO COUNCIL FOR RECOVERY. ALSO BE ADVISED THAT ALL PRECAUTIONS WERE TAKEN TO PROTECT THE DASHBOARD WITH USE OF WINDSHIELD SUN DEFLECTORS/SHADES.

NHTSA ODI #11373753

Official recalls

5

21V050000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

14V827000 · Electrical System:ignition

Dec 30, 2014

General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.

Consequence & remedy

Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.

Remedy: GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The recall began on February 12, 2015. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.

11V339000 · Steering:linkages

Jun 28, 2011

GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.

Consequence & remedy

Consequence: THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.

Remedy: GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

11V007000 · Suspension:rear:axle:spindle

Jan 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.