NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
53 reportsClear category filter56,000 miles · Dec 29, 2006
Electrical System
IT STARTED THIS FALL MAYBE CLOSER TO WINTER. BUT ALL OF A SUDDEN THE SPEEDO STUCK AT ABOUT 70 MILES AN HOUR. AT FIRST I THOUGHT IT WAS A GLITCH BUT WHEN IT HAPPENED MORE AND MORE NOW I KNOW THAT IT IS A PROBLEM. THE SAFETY ISSUE IS THERE ARE OTHERS OUT THERE HAVING THE SAME PROBLEM AND WHEN YOU THINK YOU ARE GOING A CERTIAN M…
Read full complaint
IT STARTED THIS FALL MAYBE CLOSER TO WINTER. BUT ALL OF A SUDDEN THE SPEEDO STUCK AT ABOUT 70 MILES AN HOUR. AT FIRST I THOUGHT IT WAS A GLITCH BUT WHEN IT HAPPENED MORE AND MORE NOW I KNOW THAT IT IS A PROBLEM. THE SAFETY ISSUE IS THERE ARE OTHERS OUT THERE HAVING THE SAME PROBLEM AND WHEN YOU THINK YOU ARE GOING A CERTIAN MPH AND YOUR REALLY NOT SOME MIGHT GET FRUSTRATED WITH OTHERS EVEN THOUGH THEY MAY BE IN THE WRONG. I CAN JUST SEE ALL THE ROAD RAGE HAPPENING BECAUSE THEY THINK THEY ARE GOIND 70 AND THEY ARE REALLY GOING 80 OR MORE. I HAVE BEEN WATCHING MY TACHOMETER BUT I DONT KNOW WHAT OTHERS ARE DOING. THIS NEEDS TO BE ADDRESSED. BECAUSE I AM BEING TOLD THAT IT WILL COST 600+ TO FIX. HOW MANY OF THOSE HAVING THIS PROBLEM ARE GOING TO SPEND THAT KIND OF MONEY TO FIX A SPEEDOMETER?
NHTSA ODI #10177372
Mileage unknown · Dec 12, 2006
Electrical SystemEquipment
I HAVE A 2003 GMC YUKON WITH APPROX. 89,000 MILES. ALL OF A SUDDEN THE SPEEDOMETER BEGAN ACTING ERRATIC. SHOWING 60 MPH WHEN STOPPED. *JB
NHTSA ODI #10175932
55,000 miles · Dec 5, 2006
Electrical System
SPEEDOMETER NEEDLE IS ERRATIC AND AT TIMES STAYS ON ZERO WHILE TRAVELING. OFTEN DISPLAYS A SPEED FAR LESS THAN THE VEHICLE IS ACTUALLY TRAVELING. ESTIMATE TO REPLACE CLUSTER IS CLOSE TO $1,000.00. I AM FINDING OUT THAT THIS IS A VERY WIDESPREAD AND WELL KNOW PROBLEM. RECALL SOON? *JB
NHTSA ODI #10175268
38,000 miles · Dec 4, 2006
Electrical System
SPEEDOMETER READS INCORRECTLY IT JUST SITS AT ZERO,EVEN AT HIGHWAY SPEEDS. VERY ERRATIC NEEDLE MOVEMENT. *NM
NHTSA ODI #10175145
45,000 miles · Nov 21, 2006
Electrical System
SPEEDOMETER UNRELIABLE, DROPS SLOWLY FROM HIGHWAY SPEED TO 0 WHILE STILL ON HIGHWAY GOING FULL SPEED. FUEL GAGE ALSO ERRATIC. SERVICE 4WD POPS UP IN DISPLAY AND ONCE VEHICLE IS CUT OFF SERVICE MESSAGE IS GONE, SHOWS UP ONCE A MONTH OR SO. STEERING BOX REPLACED ONCE AT MY EXPENSE, CONTINUES TO MAKE NOISE AND NOW FEELS ERRATIC.…
Read full complaint
SPEEDOMETER UNRELIABLE, DROPS SLOWLY FROM HIGHWAY SPEED TO 0 WHILE STILL ON HIGHWAY GOING FULL SPEED. FUEL GAGE ALSO ERRATIC. SERVICE 4WD POPS UP IN DISPLAY AND ONCE VEHICLE IS CUT OFF SERVICE MESSAGE IS GONE, SHOWS UP ONCE A MONTH OR SO. STEERING BOX REPLACED ONCE AT MY EXPENSE, CONTINUES TO MAKE NOISE AND NOW FEELS ERRATIC. *JB
NHTSA ODI #10173959
62,950 miles · Oct 23, 2006
Electrical System
SPEEDOMETER IN 2003 GMC YUKON ACTING ERRATICALLY. INACCURATE REPORTING OF SPEED ON SPEEDOMOTER. TRUCK SHOWS 50 MPH WHEN STOPPED. THIS IS VERY UNSAFE AND CANT BE TRUSTED. I HAVE READ ON THE INTERNET WHERE THERE ARE NUMEROUS COMPLAINTS. GMC NEEDS TO ISSUE A RECALL ON THIS ISSUE. *NM
NHTSA ODI #10171618
16,551 miles · Sep 12, 2005
Electrical SystemEquipmentSteering
I HAVE HAD ONGOING PROBLEMS WITH MY 2003 GMC YUKON. IT STARTED IN SEPTEMBER OF 2004 WITH MY REAR AIR NOT WORKING, IT WAS INOPERABLE; AND, A POPPING NOISE IN MY STEERING, THE STEERING FELT LOOSE. THE REAR AIR WAS TEMPORARILY FIXED IN OCTOBER OF 2004 BUT CONTINUES TO BE A PROBLEM NOW IN SEPTEMBER OF 2005, ONE YEAR LATER. I'VE N…
Read full complaint
I HAVE HAD ONGOING PROBLEMS WITH MY 2003 GMC YUKON. IT STARTED IN SEPTEMBER OF 2004 WITH MY REAR AIR NOT WORKING, IT WAS INOPERABLE; AND, A POPPING NOISE IN MY STEERING, THE STEERING FELT LOOSE. THE REAR AIR WAS TEMPORARILY FIXED IN OCTOBER OF 2004 BUT CONTINUES TO BE A PROBLEM NOW IN SEPTEMBER OF 2005, ONE YEAR LATER. I'VE NEVER REALLY HAD REAR AIR SINCE I BOUGHT THE VEHICLE, IT WORKS OCCASIONALLY. I STILL HAVE NO REAR AIR AND VEHICLE HAS BEEN IN THE SHOP MORE THAN 7 TIMES FOR THIS PROBLEM. IT TOOK UNTIL JANUARY OF 2005 TO FIX THE STEERING PROBLEM. I'VE ALSO HAD PROBLEMS WITH MY SPEEDOMETER, WHICH QUIT WORKING IN DECEMBER OF 2004 AND THE PART WAS ON BACK ORDER AND I HAD TO TAKE MY VEHICLE IN AND LEAVE FOR THE DEALERSHIP TO SEND THE SPEEDOMETER TO CALIFORNIA FOR REPROGRAMMING, THIS PROBLEM WAS FIXED IN JANUARY OF 2005. *NM
NHTSA ODI #10136259
Mileage unknown · Jun 29, 2005
Electrical SystemEquipment
DT: CONTACT STATES WHILE DRIVING APPROXIMATELY 70 MPH VEHICLE LOSES COMPLETE POWER. THE SERVICE DEALER STATES THE VEHICLE HAS AN ELECTRICAL PROBLEM, AND THEY WILL TRY TO REPAIR THE PROBLEM. SERVICE DEALER REPLACED THE NAVIGATION SYSTEM, THINKING THIS WAS THE REMEDY, BUT THE PROBLEM RECURRED. VEHICLE IS AT THE SERVICE DEALER,…
Read full complaint
DT: CONTACT STATES WHILE DRIVING APPROXIMATELY 70 MPH VEHICLE LOSES COMPLETE POWER. THE SERVICE DEALER STATES THE VEHICLE HAS AN ELECTRICAL PROBLEM, AND THEY WILL TRY TO REPAIR THE PROBLEM. SERVICE DEALER REPLACED THE NAVIGATION SYSTEM, THINKING THIS WAS THE REMEDY, BUT THE PROBLEM RECURRED. VEHICLE IS AT THE SERVICE DEALER, AND HAS BEEN THEIR ON NUMEROUS OCCASIONS.*AK
NHTSA ODI #10127020
Mileage unknown · Nov 3, 2004
Electrical SystemFuel System, GasolineSteering
WHILE DRIVING 65 MPH AND PULLING A TRAILER VEHICLE STALLED. PRIOR TO STALLING THERE WAS SOME HESITATION AND JERKING AS IF NOT GETTING FUEL TO ENGINE. THE DEALER TOOK VEHICLE TO DEALERSHIP IN ARIZONA, AND FUEL PUMP HAD TO BE REPLACED. THIS WAS THE SECOND OCCURRENCE FOR FUEL PUMP PROBLEM. ALSO, EXPERIENCED STEERING PROBLEM. …
Read full complaint
WHILE DRIVING 65 MPH AND PULLING A TRAILER VEHICLE STALLED. PRIOR TO STALLING THERE WAS SOME HESITATION AND JERKING AS IF NOT GETTING FUEL TO ENGINE. THE DEALER TOOK VEHICLE TO DEALERSHIP IN ARIZONA, AND FUEL PUMP HAD TO BE REPLACED. THIS WAS THE SECOND OCCURRENCE FOR FUEL PUMP PROBLEM. ALSO, EXPERIENCED STEERING PROBLEM. THE STEERING WOULD BE STICKING, AND IT WOULD JAM WHEN MAKING TURNS EITHER LEFT OR RIGHT. THE MECHANIC AT DEALERSHIP HAD TO REPLACE A SEAL IN COLUMN SHAFT OF STEERING WHEEL. *AK THE LIGHT CLUNK NOISE IN THE STEERING, LOW VOLTAGE, AND INSUFFICIENT FUEL PRESSURE ON ACELERATION INTERMITTENTLY. *SC
NHTSA ODI #10094934
Mileage unknown · Jul 26, 2004
Electrical System
WHILE DRIVING VEHICLE LOST POWER. THE ACCELERATION PEDAL VIBRATED. CONSUMER WAS ABLE TO COAST TO THE SIDE OF THE ROAD. TOOK THE VEHICLE TO THE DEALERSHIP, AND DEALER STATED THAT IT WAS CAUSED BY RESTRICTION IN THE FUEL SENDER SCREEN. THIS HAPPENED AT LEAST NINE TIMES ON DIFFERENT OCCASIONS. *AK
NHTSA ODI #10083611
Official recalls
4Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Feb 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration