NHTSA owner reports · September 18, 2026 snapshot.
Seat Belts complaints
15 reportsClear category filter75,000 miles · Aug 7, 2007
Seat Belts
TL*THE CONTACT OWNS A 2001 GMC YUKON. HE STATED THAT THE REAR LAP BELTS WOULD BIND UP NEAR THE SHOULDER PANEL. WHEN THIS OCCURRED THE SEAT BELTS WOULD NOT RETRACT OR EXTEND WHICH CAUSED THEM TO REMAIN IN A LOCKED POSITION. THE MANUFACTURER STATED THAT A DIAGNOSTIC TEST SHOULD BE PERFORMED. THE FAILURE MILEAGE WAS 75,000 AND …
Read full complaint
TL*THE CONTACT OWNS A 2001 GMC YUKON. HE STATED THAT THE REAR LAP BELTS WOULD BIND UP NEAR THE SHOULDER PANEL. WHEN THIS OCCURRED THE SEAT BELTS WOULD NOT RETRACT OR EXTEND WHICH CAUSED THEM TO REMAIN IN A LOCKED POSITION. THE MANUFACTURER STATED THAT A DIAGNOSTIC TEST SHOULD BE PERFORMED. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 87,000. UPDATED 01-16-08. *KB THE REAR DRIVER SIDE AND PASSENGER SIDE SEAT BELTS BIND UP IN THE UPPER SHOULDER GUIDE CAUSING THE SEAT BELTS TO BE JAMMED. WHEN JAMMED, THE SEAT BELTS DO NO RETRACT OR EXTEND TO PROPERLY FIT A PASSENGER. THE DEALER STATED THE PROBLEM WAS A DESIGN FLAW IN THE SEAT BELT GUIDE ARRANGEMENT. UPDATED
NHTSA ODI #10198754
103,686 miles · Jun 16, 2006
Seat Belts
DT*: THE CONTACT STATED THE SEATBELT FOR THE MIDDLE ROW PASSENGER SEAT WOULD NOT RETRACT. THE DEALERSHIP DETERMINED THE RETRACTOR WAS BROKEN AND THE SEATBELT NEEDED TO BE REPLACED. THE MANUFACTURER HAS BEEN ALERTED.
NHTSA ODI #10160031
Mileage unknown · Nov 8, 2005
Electrical SystemSeat BeltsService Brakes, Hydraulic
DT: THE CONTACT WAS SLOWING DOWN TO COME TO A STOP AND THE ABS LIGHT AND PARKING LIGHT CAME ON. HE INCREASED HIS STOPPING DISTANCE IN ORDER TO GET THE VEHICLE TO COME TO A STOP. TOOK THE VEHICLE TO THE DEALER; THEY HOOKED IT UP TO A DIAGNOSTIC MACHINE. THE DEALER STATED IT NEEDED A NEW ELECTRONIC BOX. THERE WAS NO FREE REMED…
Read full complaint
DT: THE CONTACT WAS SLOWING DOWN TO COME TO A STOP AND THE ABS LIGHT AND PARKING LIGHT CAME ON. HE INCREASED HIS STOPPING DISTANCE IN ORDER TO GET THE VEHICLE TO COME TO A STOP. TOOK THE VEHICLE TO THE DEALER; THEY HOOKED IT UP TO A DIAGNOSTIC MACHINE. THE DEALER STATED IT NEEDED A NEW ELECTRONIC BOX. THERE WAS NO FREE REMEDY TO FIX THE BOX. THE SEAT BELT ON THE PASSENGER'S SIDE IN THE SECOND ROW OF THE VEHICLE LOCKED IN THE BUCKLE, OTHER TIMES IT WILL COME LOOSE WHILE IN THE SEAT BELT. ALSO WHEN TURNING THE VEHICLE TO THE RIGHT OR LEFT ONE COULD HEAR A CLICKING SOUND. THE DEALER WAS NOT WILLING TO FIX IT FREE OF CHARGE. *AK
NHTSA ODI #10142190
Mileage unknown · Oct 27, 2004
Electrical SystemEngine And Engine CoolingEquipment
MULTIPLE FAILURES; A/C ODORS, DOOR LOCK, SUSPENSION ALIGNMENT AND BRAKES. *BF THERE WERE PROBLEMS WITH THE FOLLOWING: WEATHER STRIP WAS LOOSE, THE A/C BLEW WARM, THE BELTS SQUEAKED, THERE WAS A MILDEW ODORS, THE WINDOW REGULATOR, THE FRONT SEAT BELT SQUEAKED, THE DOOR PANEL, THE STEERING WHEEL RATTLED, DRIVE SHAFT, ACCELERA…
Read full complaint
MULTIPLE FAILURES; A/C ODORS, DOOR LOCK, SUSPENSION ALIGNMENT AND BRAKES. *BF THERE WERE PROBLEMS WITH THE FOLLOWING: WEATHER STRIP WAS LOOSE, THE A/C BLEW WARM, THE BELTS SQUEAKED, THERE WAS A MILDEW ODORS, THE WINDOW REGULATOR, THE FRONT SEAT BELT SQUEAKED, THE DOOR PANEL, THE STEERING WHEEL RATTLED, DRIVE SHAFT, ACCELERATOR PEDAL, THE WIPERS WERE NOISY, THE HINGE PIN ON THE RADIO WAS LOOSE, ENGINE NOISES, A/C DRAIN WOULD NOT DRAIN AT TIMES UNTIL THE PASSENGER DOOR WAS CLOSED/WATER LEAD AND CAUSED BY THE LEFT FRONT FLOORBOARD. RECALL#01V159000, 02V253000, 03V094000. *SC
NHTSA ODI #10097219
Mileage unknown · Jun 23, 2004
Electrical SystemSeat BeltsSeats
VEHICLE HAVING MULTIPLE PROBLEMS WITH SEATBELTS. *MR THE FRONT SEAT BELT WOULD NOT PULL OUT OR RETURN TO POSITION, TWO WEEKS LATER, THE SAME PROBLEM OCCURRED IN THE PASSENGER SEAT BELT. THE REAR SEAT BELT EXPERIENCED THE SAME PROBLEM. THE BATTERY LEAKED ACID FROM THE POSITIVE BATTERY POST AND THE MATERIAL ON THE DRIVERS S…
Read full complaint
VEHICLE HAVING MULTIPLE PROBLEMS WITH SEATBELTS. *MR THE FRONT SEAT BELT WOULD NOT PULL OUT OR RETURN TO POSITION, TWO WEEKS LATER, THE SAME PROBLEM OCCURRED IN THE PASSENGER SEAT BELT. THE REAR SEAT BELT EXPERIENCED THE SAME PROBLEM. THE BATTERY LEAKED ACID FROM THE POSITIVE BATTERY POST AND THE MATERIAL ON THE DRIVERS SEAT WAS WEARING OUT. *SC *JB
NHTSA ODI #10079713
Mileage unknown · Feb 26, 2003
Seat Belts
THE FRONT SEAT BELTS DID NOT RETRACT BACK INTO POSITION AFTER BEING USED.*JB
NHTSA ODI #10009333
Mileage unknown · Feb 11, 2003
Seat Belts
THERE WAS A DESIGN ISSUE WITH THE PASSENGER FRONT SEAT BELT, WHEN THE SEAT BELT WAS FASTENED, IT LOCKED PERMANENTLY, AND DID NOT ALLOW THE PASSENGER TO MOVE FOWARD. *JB *JB
NHTSA ODI #10007070
Mileage unknown · Sep 25, 2002
Seat BeltsSeats
LACK OF 3 POINT RESTRAINT SYSTEM AND HEAD RESTS ON MIDDLE POSITION OF BENCHES. I HAVE SIX CHILDREN WHO ARE QUICKLY OUTGROWING CAR SEATS. I BELIEVE 2 PT RESTRAINTS ARE UNSAFE. WHEN WILL THEY BECOME STANDARD IN LARGE UTILITY VECHICLES LIKE THE YUKON XL? LESSER CARS ARE EQUIPPENT WITH THEM. HOW DOES A MOTHER CHOOSE WHICH 2 CHILDREN…
Read full complaint
LACK OF 3 POINT RESTRAINT SYSTEM AND HEAD RESTS ON MIDDLE POSITION OF BENCHES. I HAVE SIX CHILDREN WHO ARE QUICKLY OUTGROWING CAR SEATS. I BELIEVE 2 PT RESTRAINTS ARE UNSAFE. WHEN WILL THEY BECOME STANDARD IN LARGE UTILITY VECHICLES LIKE THE YUKON XL? LESSER CARS ARE EQUIPPENT WITH THEM. HOW DOES A MOTHER CHOOSE WHICH 2 CHILDREN TO PLACE IN THE LESS SAFE SEATS? NLM
NHTSA ODI #767704
Mileage unknown · Jul 11, 2002
Seat Belts
WHEN SITTING IN PASSENGER'S SEAT AND USING SEAT BELT, SEAT BELT WILL START TO LOCK UP ONCE CONSUMER MOVES, AND WILL NOT UNLOCK UNTIL CONSUMER UNLOCKS THE BUCKLE. CONTACTED DEALER. *AK
NHTSA ODI #8013730
Mileage unknown · Jun 27, 2002
Air BagsSeat BeltsCrashInjury
THE VEHICLE HAS BEEN INVOLVED IN TWO ACCIDENTS IN WHICH NEITHER TIME DID THE AIR BAGS DEPLOY,DURING ONE ACCIDENT THE CONSUMER SAYS SHE ALSO DOESNT REMEMBER THE SEAT BELT TIGHTENING CAUSING HER TO STRICK HER HEAD ON THE STEERING WHEEL AND KNEES TO HIT THE DASH. *MJ
NHTSA ODI #566304
Official recalls
6Nov 7, 2007
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN 8.1L V8 ENGINE, THE CRANKSHAFT POSITION CAN OPERATE INTERMITTENTLY OR FAIL COMPLETELY. IF THE SENSOR OPERATES INTERMITTENTLY, THE SES LIGHT MAY ILLUMINATE AND THE VEHICLE MAY RUN ROUGH. THE ENGINE MAY STALL, AND IF SO, MAY RE-START IMMEDIATELY OR AFTER A COOL DOWN PERIOD.
Consequence & remedy
Consequence: IF THE SENSOR BECOMES COMPLETELY INOPERATIVE, THE ENGINE WILL QUIT RUNNING AND WILL NOT RE-START. EITHER OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Aug 29, 2005
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence & remedy
Consequence: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Sep 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.
Consequence & remedy
Consequence: IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.
Remedy: DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR CADILLAC AT 1-800-458-8006.
May 17, 2001
VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.
Consequence & remedy
Consequence: IN A CRASH, INCREASED OCCUPANT INJURY COULD RESULT FROM THE NO-LOCK CONDITION.
Remedy: DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Oct 25, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
Consequence & remedy
Consequence: THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.
Remedy: DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE02067 · Alleged Failure Of 2ND Row Seatbelt Alr
Opened Sep 25, 2002 · Closed Feb 11, 2003
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:rear/other
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Seat Belts
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
Seat Belts:rear/other
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
Illustration