Illustration1996 GMC YUKON STRUCK TREE HEAD ON @ 30 MPH, AIRBAG DID NOT DEPLOY. I AM ORIGINAL OWNER. VEHICLE WAS COLLISION FREE PRIOR TO INCIDENT. *JB
1996 GMC Yukon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 GMC Yukon do not stand out strongly from the model-year median of 103.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 70 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports7 injury reports
What owners actually said
70 reportsNAR 02/28/2003 MR HEAD ON DEAD CENTER, FRONTAL CRASH TO A TREE, 25-30MPH, HIGH IMPACT, NO AIR BAG INFLATED. *CB
CONSUMER WAS CHECKING ALTERNATOR AND HE ACCIDENTLY TOUCHED HEATER HOSE NIPPLE THAT IS ATTACHED TO ENGINE MANIFOLD. NIPPLE IS MADE OF ALUMINIUM AND BROKE. WATER GUSHED OUT ALL OVER CONSUMER.*AK
FAILURE OF INTAKE MANIFOLD GASKETS DUE TO INCOMPATIBILITY WITH DEXCOOL COOLANT
WINDSHIELD WIPERS WORK INTERMITTENTLY. WHEN WINDSHIELD WIPERS STOP WORKING CONSUMER CAN HEAR MOTOR STILL RUNNING. CURRENTLY, WINDSHIELD WIPERS DON'T WORK AT ALL. *AK
INSIDE THE REAR AXLE ASSEMBLY, THE CARRIER PART # 12471391 COMPLETLY SHEARED FROM THE PUMPKIN. THE ONLY THING HOLDING THE AXLE AND WHEEL IN PLACE WAS A C-CLAMP. I DID NOT NOTICE ANYTHING WRONG WITH THE SUSPENSION OTHER THAN A PULLING TO THE RIGHT WHICH I HAD TAKEN IT TO THE DEALER FOR PREVIOUSLY ONLY TO BE TOLD THAT THERE IS N…
Read full complaint
INSIDE THE REAR AXLE ASSEMBLY, THE CARRIER PART # 12471391 COMPLETLY SHEARED FROM THE PUMPKIN. THE ONLY THING HOLDING THE AXLE AND WHEEL IN PLACE WAS A C-CLAMP. I DID NOT NOTICE ANYTHING WRONG WITH THE SUSPENSION OTHER THAN A PULLING TO THE RIGHT WHICH I HAD TAKEN IT TO THE DEALER FOR PREVIOUSLY ONLY TO BE TOLD THAT THERE IS NOTHING WRONG WITH IT. IT FINALLY TOOK OUT THE FRONT BEARING AND STARTED TO MAKE A HOWLING NOISE UPON ACCELERATION. I QUIT DRIVING THE VEHICLE AT THIS POINT. IF I HAD NOT QUIT DRIVING THE VEHICLE THE TIRE AND AXLE WOULD OF COMPLETELY WALKED AWAY FROM THE VEHICLE AND COULD OF CAUSED GREAT HARM TO ME AND MY FAMILY. THE MANUFACTOR WAS NOT WILLING TO PAY TO REPLACE THIS DEFECTIVE PART AT FIRST. ACCORDING TO THE DEALER THE CARRIER WAS A DEFECTIVE PART FROM THE MANUFACTOR DUE TO A BAD CASTING. THE VEHICLE WAS JUST 85 DAYS OUTSIDE AN EXTENDED WARRENTY PURCHASED WITH THE TRUCK. THE DEALER DID BUY A NEW CARRIER AND HAD IT INSTALLED AT A 50/50 COST ON THE LABOR. I HAD TO BUY THE NEW BEARINGS, HAVE THE AXLES CHECKED FOR TRU-NESS, HAVE THE VEHICLE TOWED TO THE DEALER, AND FIND ALTERNATIVE TRANSPORTATION FOR A MONTH AT MY EXPENSE. I WORK FOR THE MANUFACTOR GM IN JANESVILLE WISCONSIN WHERE THE TRUCK WAS BUILT AND THEY DID BACK IN THIS MODEL YEAR HAVE A SHIPMENT OF DEFECTIVE REAR AXLES COME INTO THE PLANT SOME WERE FIXED BECAUSE OF A HOWLING NOISE BEFORE THEY LEFT THE MANUFACTOR, I BELIEVE SOME WERE NOT. THE REAR CARRIER SHOWS SIGNS OF FRACTURES IN THE METAL THAT HAVE BEEN THERE A LONG TIME AND ALSO SHOWS NEW FRACTURES THAT ARE ROUGH AND WHERE THE PART FINALLY LET LOOSE AND SHEARED COMPLETELY. I BELIEVE THAT GMC SHOULD OF COVERED THIS DEFECTIVE PART 100%. PLEASE CALL ME IF YOU NEED ADDITIONAL INFO. I STILL DO HAVE THE DEFECTIVE PART IN MY POSSESION. THANK YOU, [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
WHILE DRIVING ABOUT 35 MPH REAR AXLE DISATTACHED FROM VEHICLE WITHOUT PRIOR WARNING. VEHICLE HAD TO BE TOWED TO A GARAGE, AND THEY TOLD CONSUMER THAT CAUSE WAS SOME BUBBLES ON AXLE.*AK *SLC
DURING FRONT CRASH AT 30-35 MPH BOTH DRIVER'S AND PASSENGER'S SEATBELTS DID NOT LOCK UPON IMPACT.*AK
REAR ENDED VEHICLE WHILE DRIVING 30-35 MPH, DRIVER'S AIRBAG DID NOT DEPLOY. DAMAGE TO VEHICLE WAS $ 5100. *AK
WHILE TRYING TO COME TO A STOP FROM 55 MPH CONSUMER HAD APPLIED BRAKES. SLOWED DOWN TO 30-35 MPH AND PEDAL WENT TO FLOOR. NO BRAKING ACTION AND VEHICLE REAR ENDED VEHICLE IN FRONT. $ 5100 DAMAGE. *AK SEAT BELT DID NOT LOCK AND THE DRIVER BRUISED HIS CHEST. THE AIR BAGS FAILED TO DEPLOY AS WELL. THE VEHICLE HAD BEEN REPAIRE…
Read full complaint
WHILE TRYING TO COME TO A STOP FROM 55 MPH CONSUMER HAD APPLIED BRAKES. SLOWED DOWN TO 30-35 MPH AND PEDAL WENT TO FLOOR. NO BRAKING ACTION AND VEHICLE REAR ENDED VEHICLE IN FRONT. $ 5100 DAMAGE. *AK SEAT BELT DID NOT LOCK AND THE DRIVER BRUISED HIS CHEST. THE AIR BAGS FAILED TO DEPLOY AS WELL. THE VEHICLE HAD BEEN REPAIREED AND THE BELTS, AIR BAG AND BRAKE SYSTEM HAD BEEN CHECKED. *YH
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V057000 · Vehicle Speed Control
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01018 · Seat Belt Anchorage Separation
Opened Dec 20, 2001 · Closed Dec 9, 2002
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
No summary supplied.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
PE99073 · Battery Leaks Acid
Opened Dec 3, 1999 · Closed May 2, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION OF THE RIGHT FRONTBRAKE LINE AS A RESULT OF SULFURIC ACID CONTAMINATION.THE REMAINING 11 COMPLAINTS PERTAIN PRIMARILY TO SULFURIC ACID LEAKAGE FROM THE BATTERY CASE.AT LEAST ONE COMPLAINANT STATED THAT THE REPLACEMENT BATTERY ALSO FAILED.SEVERAL OF THE COMPLAINANTS NOTE THAT THE LEAKING ACID HAD COME IN CONTACT WITH A WIRE HARNESS AT THE FRAME IN THE VICINITY OF THE STEEL BRAKE LINE.A FIELD INSPECTION BY ODI INDICATES THAT THE DESCRIBED HARNESS IS THE ABS CONNECTION TO THE RIGHT FRONT WHEEL SPEED SENSOR.PRIOR TO THE BATTERY CASE FAILURE, THERE IS USUALLY NO WARNING (SHORT OF AN UNDERHOOD INSPECTION), AND THE ENSURING DAMAGE (SULFURIC ACID CONTAMINATION) IS PROGRESSIVE.OF THE KNOWN BATTERY FAILURES, THERE MAY BE A TEMPERATURE CORRELATION, AS 60% OF THE OWNER COMPLAINTS CAME FROM FOUR STATES; CALIFORNIA, FLORIDA, GEORGIA AND TEXAS.THERE IS ALSO A PRODUCT IMPROVEMENT PROGRAM AND ENGINEERING CHANGE NOTICE TO ADD 1% SILVER TO THE BATTERY'S POSITIVE SIDE TERMINALL, WITH THE EARLIEST IMPLEMENTATION DATE FOR THIS BEING FEB 2, 1998.THE EFFECT OF THIS DESIGN CHANGE IS AS YET UNKNOWN; FURTHER REVIEW IS WARRANTED.AN EA IS BEING OPENED TO GATHER FURTHER APPROPRIATE INFORMATION, CLARIFY ANY DEFECT TRENDS, AND TO ASSESS THE SAFETY IMPLICATIONS AND RISKS CONCERNING THESE FAILURES.
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.