NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
142 reportsClear category filterMileage unknown · May 13, 2025
Electrical SystemEngineService Brakes
I was driving on a highway with my [XXX] son and 2 dogs when without any warning the vehicle just stopped and completely went dead. I was unable to turn on the hazards so I called 911, the police came within minutes and surrounded the vehicle to keep us from being crashed into. The brakes failed to work, the hazard lights would…
Read full complaint
I was driving on a highway with my [XXX] son and 2 dogs when without any warning the vehicle just stopped and completely went dead. I was unable to turn on the hazards so I called 911, the police came within minutes and surrounded the vehicle to keep us from being crashed into. The brakes failed to work, the hazard lights would not work, the doors would not open other than the driver door. The police had to help remove my child and 2 dogs from the vehicle through the driver door. The vehicle could not be put into neutral so the police had to tow the vehicle from the middle of the highway. The result could have been deadly. The vehicle was completely dead with absolutely no function. After the police towed it to the police tow facility it was then towed to the GMC dealership I purchased the vehicle from. The dealership is Jim Curly GMC in Keyport NJ. The dealership has had the vehicle since Saturday and is claiming to not know what is wrong with the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11660670
Mileage unknown · May 8, 2025
Electrical SystemEngineFuel/propulsion System
While driving at approximately 30 mph in moderate traffic on the interstate during a return leg of a 370-mile trip, my vehicle unexpectedly shifted into neutral and became unresponsive. The dashboard displayed the warning message: "condition not correct for shift," and despite repeated attempts to restart the engine, the vehicle…
Read full complaint
While driving at approximately 30 mph in moderate traffic on the interstate during a return leg of a 370-mile trip, my vehicle unexpectedly shifted into neutral and became unresponsive. The dashboard displayed the warning message: "condition not correct for shift," and despite repeated attempts to restart the engine, the vehicle would not engage. Although the electrical system remained active, I had no propulsion. Critically, the vehicle became immobilized in a **very dangerous curve on the interstate**, presenting an extreme safety risk to myself and others. The car could not be manually shifted into neutral for towing, prompting Illinois Department of Transportation (IDOT) to declare the location unsafe. I was stranded there for over three hours, after dark, in a vulnerable and exposed position. During the forced tow process, two rear tires were destroyed and the two front tires sustained major damage. In the days leading up to this incident, the vehicle had also shown signs of malfunction, such as delayed acceleration from a stop and occasional lurching forward — symptoms consistent with the defect described in the recall.
NHTSA ODI #11659663
Mileage unknown · Apr 30, 2025
EngineSteeringVehicle Speed Control
My vehicle stalled while driving on a busy highway & I had no option but to pull over, which left me & my family in a very dangerous position. Had to remove my daughter's wheelchair onto a tow truck as the vehicle had no power to use the hoist for her powerchair. Again, on the side of a busy road! Towed the vehicle to a GM deale…
Read full complaint
My vehicle stalled while driving on a busy highway & I had no option but to pull over, which left me & my family in a very dangerous position. Had to remove my daughter's wheelchair onto a tow truck as the vehicle had no power to use the hoist for her powerchair. Again, on the side of a busy road! Towed the vehicle to a GM dealership, who stated there was catastrophic engine failure & the engine had to be replaced. Had no way to transport my daughter until I got a new engine since her hoist was stuck at the dealership. This was our original vehicle, until the sold me another one with the same defect (2024 Yukon for MORE money!). That vehicle was reported in Complaint 11657786.
NHTSA ODI #11657798
Mileage unknown · Apr 30, 2025
EngineFuel/propulsion SystemPower Train
I am formally requesting a complete refund for my vehicle. It has only 6,300 miles, and the remedy provided for the recall does not adequately address the issue. The recall explicitly indicates defects in the engine components (rods/cam shafts) that may lead to a loss of propulsion. Merely inspecting the vehicle and adding thick…
Read full complaint
I am formally requesting a complete refund for my vehicle. It has only 6,300 miles, and the remedy provided for the recall does not adequately address the issue. The recall explicitly indicates defects in the engine components (rods/cam shafts) that may lead to a loss of propulsion. Merely inspecting the vehicle and adding thicker oil does not resolve the underlying problem; it only postpones the inevitable expiration of my warranty. Currently, there are no warning lights illuminated, as the vehicle is not driven frequently. The recall raises significant concerns, and GM should be taking more substantial measures than simply applying thicker oil as a solution. This approach feels like a temporary fix rather than a genuine resolution. I have communicated with the dealership, and have been informed there is currently no solution available for this matter. They are awaiting further instructions on how to proceed. I request a more thorough investigation into this issue for an appropriate refund, and I also wish to have this matter documented for future reference.
NHTSA ODI #11657745
Mileage unknown · Apr 29, 2025
Engine
Crankshaft bearing failed, leading to engine failure at 65MPH on highway. No warning.
NHTSA ODI #11657594
22,000 miles · Apr 29, 2025
Engine
The contact owns a 2023 GMC Yukon. The contact stated that upon taking the vehicle into the dealer for regular service, the dealer found that the engine oil level was extremely low, resulting in damages to the engine. The check engine warning light was illuminated. The contact was informed that the piston O-rings needed to be re…
Read full complaint
The contact owns a 2023 GMC Yukon. The contact stated that upon taking the vehicle into the dealer for regular service, the dealer found that the engine oil level was extremely low, resulting in damages to the engine. The check engine warning light was illuminated. The contact was informed that the piston O-rings needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 22,000.
NHTSA ODI #11657499
Mileage unknown · Apr 27, 2025
Engine
While driving on a busy highway, the engine stalled and could not be restarted. We were in the left lane and thankfully traffic was light and i was able to get to the shoulder. No warning and no check engine light before stall. After numerous attempts and about 15 minutes it did restart. A few miles later same issue and could no…
Read full complaint
While driving on a busy highway, the engine stalled and could not be restarted. We were in the left lane and thankfully traffic was light and i was able to get to the shoulder. No warning and no check engine light before stall. After numerous attempts and about 15 minutes it did restart. A few miles later same issue and could not restart. We were 200 miles from home. Called GM and they sent a tow truck. Dealer had the car for almost a month and replaced the engine because they found metal in the oil and determined that the main bearings had spun. The concern is that the replacement engine is presumably a 2024 and the issue could happen again.
NHTSA ODI #11657056
Mileage unknown · Apr 27, 2025
Engine
While driving without any warning the screen said press start. The vehicle shifted to neutral and lost all power while driving down a very busy road on the top of a hill going 55 mph. Once stopped we tried to turn the vehicle back on, vehicle would power on but wouldn’t start just click and screens flash
NHTSA ODI #11657046
Mileage unknown · Apr 22, 2025
Engine
While driving on the freeway at about 70mph, the lights on the dash lit up and the message "Push Button to Start" showed up. At that point the vehicle started decreasing in speed. When the accelerator was depressed, nothing happened. Luckily the freeway was not crowded and the vehicle was able to coast the side of the road where…
Read full complaint
While driving on the freeway at about 70mph, the lights on the dash lit up and the message "Push Button to Start" showed up. At that point the vehicle started decreasing in speed. When the accelerator was depressed, nothing happened. Luckily the freeway was not crowded and the vehicle was able to coast the side of the road where it came to a stop. Pushing the start button did nothing except bring up the dash information. Engine would not start or even try to start. AAA was called and the car was towed to a dealership. The dealer has since determined that the engine is locked up. The oil had metal in it and an engine replacement will be needed. They have put in an order for a new engine. There were no warning lights or CELs of any kind. The engine just stopped working without any warning. The 6.2l engine on the GM line of SUVs and trucks seems to be known for doing this. If this were a busy time of day or there was more traffic it may not have been so easy to pull to the side of the road. It is only a matter of time before these engine issues result in an injury or worse, a fatality. The solution to replace a faulty engine with another engine that has not been redesigned or fixed is an unsafe and risky solution.
NHTSA ODI #11656158
Mileage unknown · Apr 18, 2025
EnginePower Train
Multiple issues...I bought the vehicle in Oct. 2023 1. BRAND NEW.... First day I brought the vehicle home there was a whining sound coming from the transmission. The reaction carrier assembly had to be replaced along with all other components. The transmission had to be completely removed from the vehicle and repaired. 2. In Ma…
Read full complaint
Multiple issues...I bought the vehicle in Oct. 2023 1. BRAND NEW.... First day I brought the vehicle home there was a whining sound coming from the transmission. The reaction carrier assembly had to be replaced along with all other components. The transmission had to be completely removed from the vehicle and repaired. 2. In May of 2024 I had to have the lifters replaced on one side of the motor. 3. Right now it's in the shop with a blown motor. Yes there's only about 43,000 miles on it and the motor is blown and has to be fully replaced.
NHTSA ODI #11655483
Official recalls
4Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Sep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration