NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
142 reportsClear category filterMileage unknown · Nov 4, 2025
Engine
While traveling on the interstate my vehicle shuttered and lost power we went to a friend’s neighborhood and the vehicle stalled when we pulled in no lights had come on until then and a knock had started. With no where to pull over I finally got the vehicle started and drove it straight to our friends house and left in on the si…
Read full complaint
While traveling on the interstate my vehicle shuttered and lost power we went to a friend’s neighborhood and the vehicle stalled when we pulled in no lights had come on until then and a knock had started. With no where to pull over I finally got the vehicle started and drove it straight to our friends house and left in on the side of the street. I had to take there vehicle home and called ONSTAR to tow it to the dealership. I have to pay for the over mileage because I was out of town when it happened.
NHTSA ODI #11697347
Mileage unknown · Nov 2, 2025
Engine
The vehicle underwent a recall inspection on September 8, but on October 2, the vehicle still experienced a serious engine failure. The vehicle was undrivable, and the dealer inspected it and opened a TCA case. However, General Motors stated that it had passed the recall test and was not covered under special warranty, and asked…
Read full complaint
The vehicle underwent a recall inspection on September 8, but on October 2, the vehicle still experienced a serious engine failure. The vehicle was undrivable, and the dealer inspected it and opened a TCA case. However, General Motors stated that it had passed the recall test and was not covered under special warranty, and asked me to pay $5,000 for vehicle repairs. I believe this is an engine malfunction related to the recall, and the manufacturer should replace the engine for me free of charge and refund my 5,000 .
NHTSA ODI #11697078
Mileage unknown · Nov 2, 2025
Engine
The vehicle has experienced numerous losses of power, it has nearly stalled during normal operation, there is a horrible knocking noise coming from the engine. I have had the vehicle into the dealership who state they are unable to recreate the issue, and since the vehicle has been turned off the recorder shows noting either. Th…
Read full complaint
The vehicle has experienced numerous losses of power, it has nearly stalled during normal operation, there is a horrible knocking noise coming from the engine. I have had the vehicle into the dealership who state they are unable to recreate the issue, and since the vehicle has been turned off the recorder shows noting either. They have performed an inspection and changed the oil, but the vehicle still has the issue. It knocks and shudders like it's cold, it comes very close to stalling and then seems to recover, this has happend twice while making left hand turns, it has completly lost power even while depressing the gas, but again they indicate they can't recreate it, so there is nothing they can do. I am scared for my safety, and that of the child I drive daily. There have been several instances in the last few months.
NHTSA ODI #11697077
Mileage unknown · Oct 31, 2025
EnginePower Train
On May 23, 2025, I purchased a 2023 GMC Yukon XL VIN: [XXX] from the GMC dealership.
At the time of sale, I specifically asked about the active GM engine recall. They assured me the vehicle had been inspected and was unaffected. On October 30, 2025, the engine catastrophically failed on a highway while my family — including my…
Read full complaint
On May 23, 2025, I purchased a 2023 GMC Yukon XL VIN: [XXX] from the GMC dealership.
At the time of sale, I specifically asked about the active GM engine recall. They assured me the vehicle had been inspected and was unaffected. On October 30, 2025, the engine catastrophically failed on a highway while my family — including my two small children — were in the vehicle. This created a dangerous emergency situation as I had to avoid high-speed traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11696722
Mileage unknown · Aug 9, 2025
Engine
Driving and pulling up into my driveway when suddenly the message “push start button to start engine” comes on with an alert sound - I notice my gear is lighting up “N” and when I pushed the start button it sounded like my engine restarted. I remained in neutral and had to change it back to drive myself. The engine randomly cut…
Read full complaint
Driving and pulling up into my driveway when suddenly the message “push start button to start engine” comes on with an alert sound - I notice my gear is lighting up “N” and when I pushed the start button it sounded like my engine restarted. I remained in neutral and had to change it back to drive myself. The engine randomly cut off
NHTSA ODI #11679574
Mileage unknown · Jul 30, 2025
Engine
I have had two incidents. The vehicle is hesitant. It’s spudders, it stalls. You can hear it in the engine at idle and especially at cold start.
NHTSA ODI #11677292
Mileage unknown · Jul 28, 2025
Electrical SystemEngineService Brakes
My vehicle’s engine failed for the second time while driving on the road. The first time a few months ago while my wife was driving. The engine failed and brakes failed. Fortunately she was on a back road a coasted to a stop. Car was towed to dealership. They said there was no problem. Received recall letter about a month ago ou…
Read full complaint
My vehicle’s engine failed for the second time while driving on the road. The first time a few months ago while my wife was driving. The engine failed and brakes failed. Fortunately she was on a back road a coasted to a stop. Car was towed to dealership. They said there was no problem. Received recall letter about a month ago outlining this issue. Yesterday, [XXX], I was driving with my daughter and the car stopped again while driving. I was in traffic and narrowly missed an accident. Gwinnett county police came to the scene and towed the vehicle to the dealership. I am not sure if the female officer made a report. But she requested the tow truck because I was blocking traffic. We often drive on the highway for work commutes. This could have happened and anyone in my family could have been fatally injured. I would like GMC purchase this vehicle back or replace with a safer model comparable or better. The service department called me this morning from Jim Ellis GMC in Buford, Georgia 678-902-8677, 3600 Buford Drive 30519.I was told that there is no recall for my truck. He told me that there is a safety investigation for a recall. I told him I can bring the letter. He decline. I asked for a courtesy vehicle. He said no, he would have to make a report and it would be up to 48 hours. Once it’s reviewed , then I could go to enterprise car rental to pick up a car. Maybe. The first time Rick Hendrick GMC Duluth , Ga 470-822-3779, 3344 Commerce Ave, Duluth, ga had my truck for about 2 weeks. No fix. No courtesy vehicle or rental. Now I’m without my vehicle for unlimited time. The Jim Elis tech, did acknowledge that there is no fix for what is going on. The local GMC dealers are not making this easy or putting the safety of its customers as a priority. These trucks are NOT safe on the road. This truck cost nearly $100,000 and it is not safe to drive.GMC has a record of the 1st service incident and this latest just happened yesterday. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(
NHTSA ODI #11676562
Mileage unknown · Jul 22, 2025
Engine
GM issued a recall, N25249000 after hundreds if not thousands of complaints of catastrophic engine failure. My engine was impacted. It failed Sunday, [XXX]. I limped it to Mike Marroone dealership in Longmont, CO, on August 5th. That afternoon they confirmed my engine and various other components needed to be replaced. At t…
Read full complaint
GM issued a recall, N25249000 after hundreds if not thousands of complaints of catastrophic engine failure. My engine was impacted. It failed Sunday, [XXX]. I limped it to Mike Marroone dealership in Longmont, CO, on August 5th. That afternoon they confirmed my engine and various other components needed to be replaced. At this time GM was flooded with recalls and the whereabouts of all necessary parts were unknown and could not be tracked. It was so bad that the dealer could give no timeline as they had 5 vehicles waiting for engines. They also were replacing engines, and the replacement engine would fail immediately. Without notice, an engine and parts arrived after 3 painful weeks of sitting in the unknown. The vehicle was returned to me on August 23nd, 2024, 19 days after I dropped it off. During this time I was paying $977.50 for a car payment plus $130 for insurance per month. I had to pay this despite not having use of the vehicle for a recall that GM knew about but didn't do anything until it garnered national attention. The following is my response to the proposed warranty coverage for GM recall N25249400 and NHTSA recall 25V274: Based on the above information provided, I am requesting the 10 year warranty and 150,000 mile warranty be effective from the date the vehicle was returned to me on August 23rd, 2024. Additionally, I am requesting a check in the amount of $1,106.50 for payments directly associated with a vehicle that was not able to be used due to GM's failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11675314
Mileage unknown · Jul 18, 2025
Engine
the coolant control valve failed, and now its been in the dealership for over a month. I have been reading online that this is not an isolated issue, and many people experience months of wait time getting the part because its apparently nationally backordered because of this problem.
NHTSA ODI #11674616
Mileage unknown · Jul 17, 2025
Engine
All of a sudden while driving on [XXX] in PA, the vehicle made a loud click noise, started squealing and randomly slowing down as if we were slamming on the brakes, but it was all engine related. Then it was shaking vigorously while we were parked. We got towed to a local shop in the middle of nowhere, and they just called stati…
Read full complaint
All of a sudden while driving on [XXX] in PA, the vehicle made a loud click noise, started squealing and randomly slowing down as if we were slamming on the brakes, but it was all engine related. Then it was shaking vigorously while we were parked. We got towed to a local shop in the middle of nowhere, and they just called stating it could be a valve spring that broke and they’d have to take the valve cover off to determine it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11674213
Official recalls
4Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Sep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration