Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 163 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports3 injury reports
What owners actually said
163 reports
60,990 miles · Mar 13, 2025
EngineEngine And Engine Cooling
The contact owns a 2022 GMC Yukon XL. The contact stated while the vehicle was idling, there was an abnormal ticking sound coming from the engine. The contact stated while driving 20 MPH and exiting the highway, the abnormal sound turned into a screeching, grinding, and squealing sound, and the vehicle lost motive power. The con…
Read full complaint
The contact owns a 2022 GMC Yukon XL. The contact stated while the vehicle was idling, there was an abnormal ticking sound coming from the engine. The contact stated while driving 20 MPH and exiting the highway, the abnormal sound turned into a screeching, grinding, and squealing sound, and the vehicle lost motive power. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that the engine had failed, and there were metal shavings in the oil. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact related to the failure was to NHTSA Action Number: PE25001 (Engine, Engine and Engine Cooling). The manufacturer was not notified of the failure. The failure mileage was approximately 60,990.
NHTSA ODI #11648119
Mileage unknown · Mar 12, 2025
Engine
The car all of a sudden started making wired noises during idling. While driving it would click and start shaking. Took it to a GM service center. They diagnosed as a flywheel. After investigating, it was not the fly wheel. They tore the motor apart as they though liftor 7 and 8 were bad. During that process, they found "large p…
Read full complaint
The car all of a sudden started making wired noises during idling. While driving it would click and start shaking. Took it to a GM service center. They diagnosed as a flywheel. After investigating, it was not the fly wheel. They tore the motor apart as they though liftor 7 and 8 were bad. During that process, they found "large parts" of metal in the oil and found a rod barring failed. They are now replacing the entire engine.
NHTSA ODI #11647877
Mileage unknown · Mar 11, 2025
Engine
I was driving my 3 children to a basketball tournament. I was going about 70 mph on the highway when my dash started flashing "Engine Oil Hot", a few seconds later my vehicle completely "shut off/died". I merged over to the shoulder of the highway and tried to restart my vehicle, yet it just "clicked" and seemed to be "dead". Th…
Read full complaint
I was driving my 3 children to a basketball tournament. I was going about 70 mph on the highway when my dash started flashing "Engine Oil Hot", a few seconds later my vehicle completely "shut off/died". I merged over to the shoulder of the highway and tried to restart my vehicle, yet it just "clicked" and seemed to be "dead". The safety of myself and my 3 children were at risk, being stranded on the side of the highway far from home waiting for the tow truck. To say I was scared is an understatement, there was no warning signs so I could prepare for this. My vehicle was towed into a dealership, later that week I received a call saying I will need a new engine. I was told this could take up to 1-4 months because so many other vehicles with the exact same failure are waiting for their engine replacements as well. I am a working mother of 3, and now I am out of a vehicle for 1-4 months. I bought this vehicle new to be a reliable and large enough for my family, little did I know I would be left with no means of transportation because of a faulty engine!
NHTSA ODI #11647677
Mileage unknown · Mar 11, 2025
EnginePower Train
1-'Engine Oil Low Add Oil' warning sign is being displayed. Vehicle is burning oil with no leakages. Warning sign has come on multiple times; authorized manufacture dealer service center finds no failure. Independent service center finds oil consumption to exist without leaks anywhere and beliefs this is due to a known engine fa…
Read full complaint
1-'Engine Oil Low Add Oil' warning sign is being displayed. Vehicle is burning oil with no leakages. Warning sign has come on multiple times; authorized manufacture dealer service center finds no failure. Independent service center finds oil consumption to exist without leaks anywhere and beliefs this is due to a known engine failure in this model. 2-'Service Transmission Now Unable to Shift Soon' warning sign appears while driving but authorized manufacture dealer service center is unable to reproduce or determine issue.
NHTSA ODI #11647626
Mileage unknown · Mar 10, 2025
Electrical SystemEnginePower Train
On [XXX] my vehicle displayed an engine light on the dash. The light went on and off randomly throughout the day. The vehicle was hooked up to a computer that said there were no issues and everything was fine. On [XXX] I drove the vehicle over 240 miles to Pittsburgh and back with no lights. At one point the vehicle did make a l…
Read full complaint
On [XXX] my vehicle displayed an engine light on the dash. The light went on and off randomly throughout the day. The vehicle was hooked up to a computer that said there were no issues and everything was fine. On [XXX] I drove the vehicle over 240 miles to Pittsburgh and back with no lights. At one point the vehicle did make a loud noise for the drive but I took it out of cruise control and everything was fine. On [XXX] while driving to Poconos, PA with my family (husband, self, children ages [XXX] , [XXX] , [XXX] and [XXX] ) on [XXX} at approximately mile marker [XXX] the vehicle's engine quit working. The engine light came on and we were able to coast off of a bridge and onto the shoulder of the highway. We were unable to exit the vehicle due to high rates of speed of oncoming traffic and the shoulder not having much room. We contacted OnStar who sent a state trooper to assist with traffic control until a tow could get to our area. The vehicle was towed to Blaise Alexander in Bloomsburg, PA. My and my three youngest children had to ride with the state police officer and my husband and older son rode with the tow truck due to not having anything to fit a family of 6. The police officer told me that he had a 2024 GMC Yukon Denali have the same issue in the same spot on the highway a week ago. The vehicle has just over 25,054 miles on it. On 3/10/25 Blaise Alexander called to state that there was metal in the engine and the engine would need to be replaced. The service manager stated that they have had a few GMC Yukon Denali vehicles with this issue and that the engines may be on back-order. I have also had issues with radio presets resetting, audio not working with turn signals, navigation, radio and phone and alignment since I owned it for the last [XXX] days. From my research, this is a known problem with GM engines for the engines in the 2022 GMC Yukon Denali. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11647451
Mileage unknown · Mar 10, 2025
Unknown Or Other
during my last oil change had the update for the software recall. Onstar module was killed with this update, and the part 85560244 is discontinued. Now I don't have onstar, wifi, along with other safety features like speed, maps, etc. This is a MAJOR concern.
NHTSA ODI #11647335
Mileage unknown · Mar 8, 2025
Engine
While driving the vehicle shut down and never would restart. It was taken to a GMC dealer and currently on a waitlist for a new engine. The wait period I was given is approximately 4 months as I was told the engine is on back order.
NHTSA ODI #11647101
Mileage unknown · Mar 5, 2025
Electrical SystemEngine
While driving on the highway the engine just shut off with no warning or other indication of problem. The dashboard computer instructed to restart the vehicle, which it would not restart. Managed to get to the side of the road. But the vehicle was unresponsive. After about an hour the lights in the rear of the vehicle flickere…
Read full complaint
While driving on the highway the engine just shut off with no warning or other indication of problem. The dashboard computer instructed to restart the vehicle, which it would not restart. Managed to get to the side of the road. But the vehicle was unresponsive. After about an hour the lights in the rear of the vehicle flickered, so I attempted to re-start -which it did, and was able to drive the vehicle to the dealer (about 20 miles away). Where the car remains today. The incident occurred Feb 2. Took the dealer until 2/6 to advise me that the engine would need to be replaced. At that time they indicated they would need to car for about 2 weeks. I contacted them on 3/3 and they informed me they had no idea when they might be able to get the parts to replace the engine - there was a 3,000 engine backlog? Clearly there is a major issues with these engines; how are they allowed to continue to sell these vehicles, and allow current owners to operate them without a notice? While I was fortunately able to get to the side of the road - have in the car lose power suddenly lose power is clearly a safety issue!
NHTSA ODI #11646527
Mileage unknown · Mar 5, 2025
Engine
I was 450 miles away from home. Travelling at 80 mph in the left lane of Interstate 35 when the Yukon stopped accelerating and started coasting. I looked at the gauge clusters on the dash and it said Press Start to Shift. I looked at the shifter and it had automatically moved from Drive to Neutral. It would not move back to Driv…
Read full complaint
I was 450 miles away from home. Travelling at 80 mph in the left lane of Interstate 35 when the Yukon stopped accelerating and started coasting. I looked at the gauge clusters on the dash and it said Press Start to Shift. I looked at the shifter and it had automatically moved from Drive to Neutral. It would not move back to Drive. I then pressed the Start button like it said on the dash and the whole vehicle shutoff while still at highway speed going 70mph and still coasting. I put hazards on and moved to the right sliding in-between two 18 wheelers who gave me space thankfully then I was able to get it to the shoulder. Once stopped I moved it into Park and pressed the Start button and the dash said "unsafe conditions unable to shift", or something like that. After 2 minutes of pressing the Start button, I was able to get it started again and we started back on the road. After 2 miles, I was once again back to 80 mph in the left lane when it happened again. This time I was barely able to move off the road. We were on a long turn to the left and several 18 wheelers were all around. Once stopped, it never started again. The engine shutting off at highway speed with 18 wheelers all around put myself and 2 family members at serious risk for injury and we were just leaving a family funeral. And the 2nd time it happened, I was not able to fully pull over either causing 18 wheelers to come very close to hitting us as we were stuck on a left hand turn with a 60 mph left to right cross wind making it very dangerous for us while we waited 80 minutes for a tow truck. The only indication of a problem was the engine light on after we were stopped nothing before hand. no sound, no warning, no vibration, just an immediate shutdown. The dealership it was towed too said it is a complete engine failure and the bearings more than likely failed and I will have to wait for a new engine. Most likely the same faulty 6.2 engine. Please do something before someone dies.
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2022 GMC Yukon Xl Problems, Complaints & Recalls | Skip That Year
Illustration