NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
108 reportsClear category filterMileage unknown · Feb 24, 2025
Electrical SystemEngine
In July of 2023, my wife and kids were driving to San Diego from Phoenix. About 40 miles west of El Centro, CA, all the lights on the dash came on instructing her to pull over. When she pulled over and shut the car off, it would not come back on. Got towed back to a GM Dealership in El Centro. The diagnosed it with a bad rad…
Read full complaint
In July of 2023, my wife and kids were driving to San Diego from Phoenix. About 40 miles west of El Centro, CA, all the lights on the dash came on instructing her to pull over. When she pulled over and shut the car off, it would not come back on. Got towed back to a GM Dealership in El Centro. The diagnosed it with a bad radiator and failed engine. The replaced both(at roughly 30,000 miles). The car was fine for about six months and then it started getting battery drains again, which continually happened starting a few months after purchasing the vehicle. They never could figure this part out. Anyway, early January of 2025, while driving back to Phoenix from San Diego, the car did the same thing. This time, it restarted and she could continue on her way home. On [XXX], while driving in town, the same thing happened, all lights came on, pulled over and car would not restart. It is diagnosed with the same issue. It has been in the shop at Van GMC since January 12th, 2025 waiting on a new engine, at 63,000 miles. This will be the 3rd engine in the vehicle. By looking online, this appears to be a common issue and happens more than it should. This needs to be addressed. My wife has our kids in this vehicle a majority of the time and this is a major safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11644459
Mileage unknown · Feb 22, 2025
Electrical SystemEngineVehicle Speed Control
Traveling North bound on Highway 14 in Southern California on January 24, 2025. In the fast lane traveling approximately 70MPH when with no warning what so ever the vehicle shifted into neutral and lost power. Nearly rear ended trying to get out of traffic and to the right shoulder. Once stopped the vehicle would not start, stuc…
Read full complaint
Traveling North bound on Highway 14 in Southern California on January 24, 2025. In the fast lane traveling approximately 70MPH when with no warning what so ever the vehicle shifted into neutral and lost power. Nearly rear ended trying to get out of traffic and to the right shoulder. Once stopped the vehicle would not start, stuck in Park, and could not turn the electronics off. Stuck in vehicle for 3 hours because it was too dangerous to exit vehicle. Tow truck arrived. Tried to jump the battery which by this time was dead. Had to drag the vehicle up the flatbed with wench do to vehicle unable to shift out of Park.
NHTSA ODI #11644309
Mileage unknown · Feb 19, 2025
Engine
Our car has 66,000 miles on it. My wife was driving it we have never hooked a trailer to it. Never done anything but drive our kids around go run errands in it. The motor seized and left my wife stranded. The car has been fully serviced ahead of schedule every time And very well taken care of it still looks new, but the dealersh…
Read full complaint
Our car has 66,000 miles on it. My wife was driving it we have never hooked a trailer to it. Never done anything but drive our kids around go run errands in it. The motor seized and left my wife stranded. The car has been fully serviced ahead of schedule every time And very well taken care of it still looks new, but the dealership is now telling me the motor and the transmission possibly are bad and I’m only 6000 miles past the factory warranty. There’s no reason for this motor to have failed or the transmission as the car has never seen any hard service and has only seen normal paved roads and running errands and dropping kids off. The dealership said it’s going to cost around $16,000 to fix both the engine and the transmission out of nowhere the motor just seized with no warning and no noises
NHTSA ODI #11643784
Mileage unknown · Feb 7, 2025
Engine
The engine failed and needs a full replacement. My vehicle was inoperable and died in the turn lane of a very busy highway.
NHTSA ODI #11641366
Mileage unknown · Feb 4, 2025
Engine
Hi there ., driving on the highway Ling island express way NYC ., car suddenly came to a complete stop due a engine failure., dealer saids engine sieze ., luckup it self ., it was not a good experience and very dangerous., to make matters worse., it happened twice ., first at 45k miles then with the second engine at 110k miles .…
Read full complaint
Hi there ., driving on the highway Ling island express way NYC ., car suddenly came to a complete stop due a engine failure., dealer saids engine sieze ., luckup it self ., it was not a good experience and very dangerous., to make matters worse., it happened twice ., first at 45k miles then with the second engine at 110k miles ., both identical lockup. Each time having to liave the car for over 6 weeks ., also i work with my car ., no car no money.
NHTSA ODI #11640710
55,000 miles · Feb 1, 2025
Engine
The contact owns a 2022 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who determined t…
Read full complaint
The contact owns a 2022 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that the engine had seized but were unable to provide a specific diagnosis. The contact was informed that the engine needed to be replaced. The vehicle was repaired, but the failure reoccurred a month later. The vehicle was towed back to the dealer, who again determined that the engine had seized and were unable to provide a specific diagnosis. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 55,000.
NHTSA ODI #11640139
Mileage unknown · Feb 1, 2025
Engine
6.2 (L87) Engine locked up, vehicle shifted itself to neutral, while driving west on [XXX] (just past [XXX]) in a construction zone. No indication/symptoms or warnings were displayed before this happened. Driver was able to coast to a stop on the shoulder. Engine would not restart. Driver was stranded on the side of a very bu…
Read full complaint
6.2 (L87) Engine locked up, vehicle shifted itself to neutral, while driving west on [XXX] (just past [XXX]) in a construction zone. No indication/symptoms or warnings were displayed before this happened. Driver was able to coast to a stop on the shoulder. Engine would not restart. Driver was stranded on the side of a very busy interstate with narrow lanes and shoulder due to construction. Vehicle was towed to GM dealership in Abilene and engine was replaced under powertrain warranty.
NHTSA ODI #11640102
Mileage unknown · Jan 30, 2025
Engine
Driving on a highway at 75 mph when car had multiple error messages popping up in screen (switching too fast to read) when the car made a loud noise & started to decrease speed. Nothing worked. Pulled off to side of road & car would not restart. Currently in the shop awaiting a new engine.
NHTSA ODI #11639633
Mileage unknown · Jan 29, 2025
Engine
Relatively uneventful ownership history for new 2022 Yukon XL Denali purchased April 2022. Yesterday, started noticing knocking noise from engine. On way to dealership today, the engine died on the interstate without any warning messages and the vehicle ultimately stopped in the middle of the road off of the exit with my 3 you…
Read full complaint
Relatively uneventful ownership history for new 2022 Yukon XL Denali purchased April 2022. Yesterday, started noticing knocking noise from engine. On way to dealership today, the engine died on the interstate without any warning messages and the vehicle ultimately stopped in the middle of the road off of the exit with my 3 young children on board. Dealership indicates that engine died and will need to be replaced. They stated that 3 other vehicles on the lot with the same issue.
NHTSA ODI #11639491
Mileage unknown · Jan 27, 2025
EnginePower Train
We were driving South on [XXX] when lights on the dash started flickering and the vehicle switched itself to Neutral and had a sudden loss of power. We were lucky enough to get out of traffic and spent 5 hours waiting on Roadside Assistance and a tow truck. It was a very dangerous situation. The service department at Sullivan G…
Read full complaint
We were driving South on [XXX] when lights on the dash started flickering and the vehicle switched itself to Neutral and had a sudden loss of power. We were lucky enough to get out of traffic and spent 5 hours waiting on Roadside Assistance and a tow truck. It was a very dangerous situation. The service department at Sullivan GMC Ocala (352)-414-4962 first said that replacing the Fuel Module would fix it. 5 days later they said it needs a new engine. They plan to replace it with the same 6.2 engine. (same part number that is defective) The electrical safety system should be recalled. With no warning, the vehicle loses power and stops. GMC and every service department manager that I have spoke to knows about this issue. GMC continues to market and sell these engines and vehicles. Someone is going to get seriously hurt or killed because of GMC's negligence. GMC Case [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11638823
Official recalls
4Feb 13, 2026
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Aug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration