NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
30 reportsClear category filterMileage unknown · May 27, 2022
Electrical SystemService Brakes
Both brake lamp assemblies are non-op, no warning in dash and no fuses. GMC #SCA N182180270 stating that 2015 and 2016 Yukon. Extended warranty to 6 years or 72,000 miles. We are out of warranty as of last month. $2,500 to replace the tail lamp assemblies. No letter was sent to owners regarding this safety hazard. This should…
Read full complaint
Both brake lamp assemblies are non-op, no warning in dash and no fuses. GMC #SCA N182180270 stating that 2015 and 2016 Yukon. Extended warranty to 6 years or 72,000 miles. We are out of warranty as of last month. $2,500 to replace the tail lamp assemblies. No letter was sent to owners regarding this safety hazard. This should be a RECALL
NHTSA ODI #11466444
Mileage unknown · Jan 3, 2022
Electrical SystemService BrakesCrash
THE ENGINE MOUNTED MECHANICAL VACUUM PUMP OUTPUT MAY DECREASE OVER TIME DECREASING THE AMOUNT OF VACUUM/ POWER BRAKE ASSIST. AND THE DRIVERSIDE BRAKE STOP LIGHT WAS DEFECTIVE. .ME AND MY WIFE WERE SCARED AND SHOOK UP. .YES. DEALERSHIP. .DEALERSHIP. NO. .
NHTSA ODI #11446035
Mileage unknown · Dec 1, 2021
Electrical SystemExterior Lighting
LED tail light unit continues to crack (metal inside) and not work. Each replacement is over $500. You have to replace or you’ll be ticketed because it is a safety hazard. It is not a bulb replacement it is a faulty design that is costing people thousands to fix and it’s not right. GMC is aware of this defect and they aren’t doi…
Read full complaint
LED tail light unit continues to crack (metal inside) and not work. Each replacement is over $500. You have to replace or you’ll be ticketed because it is a safety hazard. It is not a bulb replacement it is a faulty design that is costing people thousands to fix and it’s not right. GMC is aware of this defect and they aren’t doing anything about it. Please help and recall these taillights to be replaced by the updated lights!! Thank you for your time and consideration.
NHTSA ODI #11442256
Mileage unknown · Jul 30, 2021
Electrical SystemExterior LightingService Brakes
The brake light LED panel stopped working on one side and goes out intermittently in the other side
NHTSA ODI #11427247
71,125 miles · Mar 8, 2021
Electrical System
TL* THE CONTACT OWNS A 2016 GMC YUKON XL. THE CONTACT STATED WHILE DRIVING, THE AIR CONDITIONER FAILED TO OPERATE. THE CONTACT INSPECTED THE AIR CONDITION CONDENSER AND NOTICED THAT IT WAS DAMAGED AND LEAKING. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHA…
Read full complaint
TL* THE CONTACT OWNS A 2016 GMC YUKON XL. THE CONTACT STATED WHILE DRIVING, THE AIR CONDITIONER FAILED TO OPERATE. THE CONTACT INSPECTED THE AIR CONDITION CONDENSER AND NOTICED THAT IT WAS DAMAGED AND LEAKING. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 71,125. THE VIN WAS UNAVAILABLE.
NHTSA ODI #11399737
30,000 miles · Jan 2, 2021
Electrical SystemExterior Lighting
THIRD TIME THE LED CIRCUIT BOARD LED LIGHTS ON REAR TAIL LIGHT ASSEMBLY HAS SHORTED OUT AND REQUIRED REPLACEMENT DUE TO BRAKE LIGHTS NOT WORKING. GMC IS WELL AWARE THAT THIS IS A FREQUENT ISSUE ON THE YUKONS AND HAS DONE NOTHING ABOUT IT. INDIVIDUAL BRAKELIGHT CIRCUIT BOARD OF LED BULBS CANNOT BE CHANGED OUT BECAUSE IT IS PL…
Read full complaint
THIRD TIME THE LED CIRCUIT BOARD LED LIGHTS ON REAR TAIL LIGHT ASSEMBLY HAS SHORTED OUT AND REQUIRED REPLACEMENT DUE TO BRAKE LIGHTS NOT WORKING. GMC IS WELL AWARE THAT THIS IS A FREQUENT ISSUE ON THE YUKONS AND HAS DONE NOTHING ABOUT IT. INDIVIDUAL BRAKELIGHT CIRCUIT BOARD OF LED BULBS CANNOT BE CHANGED OUT BECAUSE IT IS PLASTIC WELDED AND SEALED INTO THE TAIL LIGHT, COSTING $600.00 TO REPAIR EACH TIME IT SHORTS OUT. THIS IS A SAFETY ISSUE THAT SHOULD NOT KEEP HAPPENING. THERE ARE FOLKS DRIVING W/O FUNCTIONAL BRAKELIGHTS BECAUSE THEY CANNOT AFFORD THE COST AND FREQUENCY IF REPAIR. IT IS A POORLY MADE ENGINEERING FLAW BY GM THAT DEALER ADMITS HAPPENS ALL THE TIME DUE TO MOISTURE GETTING INTO LIGHT AND SHORTING CIRCUIT BOARD. BRAKELIGHT WILL NOT WORK WHEN STATIONARY OR WHEN IN ANY MOTION.
NHTSA ODI #11386172
38,000 miles · Jul 1, 2020
Electrical SystemService BrakesStructureCrash
RECEIVED A RECALL NOTICE FOR MY 2016 YUKON XL, DUE TO BRAKE VACUUM PUMP FAULTY. HOWEVER MCGRATH AUTO IN CEDAR RAPIDS, IA RESOLVE TO THIS RECALL WAS TO SIMPLY REPROGRAM THE ELECTRONIC BRAKE CONTROL MODULE. THIS WAS COMPLETED 12/19. BY 2/20 MY BRAKES WERE REQUIRING ME TO PUSH HARDER AND AT TIMES SOUNDED LIKE THEY WERE SKIPPING A…
Read full complaint
RECEIVED A RECALL NOTICE FOR MY 2016 YUKON XL, DUE TO BRAKE VACUUM PUMP FAULTY. HOWEVER MCGRATH AUTO IN CEDAR RAPIDS, IA RESOLVE TO THIS RECALL WAS TO SIMPLY REPROGRAM THE ELECTRONIC BRAKE CONTROL MODULE. THIS WAS COMPLETED 12/19. BY 2/20 MY BRAKES WERE REQUIRING ME TO PUSH HARDER AND AT TIMES SOUNDED LIKE THEY WERE SKIPPING AND BRAKING FELT DELAYED. I ALSO WAS HEARING A SQUEAK/CLICKING SOUND COMING FROM WHAT SEEMS THE FRONT OF MY VEHICLE ENGINE AREA. DUE TO QUARANTINE I WAS NOT DRIVING OR GOING PLACES BUT ONCE OUR STATE RE-OPENED I CALLED THIS DEALERSHIP TO REPORT THE BRAKE CONCERN AND SCHEDULED APPT. A DAY BEFORE APPT, WHILE STOPPED AT A RED LIGHT AS I MOVED FORWARD IN A VERY SLOW CRAWL MY BRAKES FAILED ME AND I COULD NOT STOP. I BUMPED THE CAR IN FRONT OF ME WHICH RESULTED IN DAMAGE TO BOTH VEHICLES. I REPORTED THIS TO MCGRATH AS I WAS SCARED IMMENSELY ABOUT THE SAFETY OF MY VEHICLE. DURING THE SERVICE APPT 6/11/20 MY CAR WAS DIAGNOSED WITH A FAULTY BRAKE VACUUM PUMP. THE VACUUM PUMP WAS REPLACED AND I WAS TOLD I WAS STILL WITHIN THE WARRANTY . HOWEVER THEY REPLACE ALL 4 TIRES AND CLAIMED TO RECALIBRATE. ON 6/25 WHILE IN COLORADO BRAKE, ABS AND CAL LIGHTS LIT UP, THE STEERING WHEEL POWER WAS GONE, TRAILER BRAKE SYSTEM ILLUMINATE, (NEVER EVEN TOWED A TRAILER) CALLED MCGRATH FROM COLORADO AS I COULDN'T DRIVE MY CAR, I EXPLAINED WHAT WAS HAPPENING, THEIR RESOLVE WAS TO GOOGLE GMC DEALERSHIP IN AREA FOR ME. I FOUND MY OWN IN CADILLAC/GMC DEALERSHIP IN BOULDER. MY CHILDREN AND I ARE WITHOUT A VEHICLE WHILE OUT OF STATE. DEALERSHIP IN BOULDER DIAGNOSED MY VEHICLE WITH FAULTY ELECTRONIC BRAKE CONTROL MODULE. I AM FURIOUS AS THEY SAY IT WILL NOT BE COVERED THROUGH WARRANTY. MY 2016 YUKON IS IN IMPECCABLE CONDITION, ISSUES ALL HAPPENED UPON RECALL WITH ONLY 35,000 MILES. MY EXPERIENCE IS EXACTLY WHAT IS BEING REPORTED BY OTHERS IMPACTED BY THIS RECALL. *TR
NHTSA ODI #11331946
91,000 miles · Jun 15, 2020
Electrical SystemService Brakes
RIGHT REAR BRAKE LIGHT WORKS INTERMITTENTLY. NO WARNING LIGHTS OR MESSAGES ON THE DASH. PEOPLE HAVE TOLD ME WE HAVE A BRAKE LIGHT OUT, BUT WHEN I CHECK IT LATER IT WORKS. WAS PULLED OVER FOR INOPERABLE BRAKE LIGHT, BUT LATER THAT EVENING THE TAIL LIGHT WAS WORKING. SEEMS TO BE A LOT OF INFO ON INTERNET ABOUT A BROKEN STRIP O…
Read full complaint
RIGHT REAR BRAKE LIGHT WORKS INTERMITTENTLY. NO WARNING LIGHTS OR MESSAGES ON THE DASH. PEOPLE HAVE TOLD ME WE HAVE A BRAKE LIGHT OUT, BUT WHEN I CHECK IT LATER IT WORKS. WAS PULLED OVER FOR INOPERABLE BRAKE LIGHT, BUT LATER THAT EVENING THE TAIL LIGHT WAS WORKING. SEEMS TO BE A LOT OF INFO ON INTERNET ABOUT A BROKEN STRIP OF METAL. SAFETY ISSUE. *TR
NHTSA ODI #11329074
96,000 miles · Jun 15, 2020
Electrical SystemExterior Lighting
REAR TAIL LIGHTS (BRAKE LIGHTS) WORK INTERMITTENTLY. THERE IS A "SPECIAL COVERAGE ADJUSTMENT" BUT IT IS SET FOR A MAXIMUM NUMBER OF MILES OR TIME (6-YEARS). I HAVE A 2016 GMC YUKON XL. THE PASSENGER'S SIDE WAS REPLACED IN 2018 AND NOW THE DRIVER'S SIDE IS DEFECTIVE/INOPERABLE. BUT BECAUSE WE ARE AT 96000 THEY WON'T REPAIR. …
Read full complaint
REAR TAIL LIGHTS (BRAKE LIGHTS) WORK INTERMITTENTLY. THERE IS A "SPECIAL COVERAGE ADJUSTMENT" BUT IT IS SET FOR A MAXIMUM NUMBER OF MILES OR TIME (6-YEARS). I HAVE A 2016 GMC YUKON XL. THE PASSENGER'S SIDE WAS REPLACED IN 2018 AND NOW THE DRIVER'S SIDE IS DEFECTIVE/INOPERABLE. BUT BECAUSE WE ARE AT 96000 THEY WON'T REPAIR. *TR
NHTSA ODI #11329062
29,500 miles · Feb 27, 2020
Electrical SystemExterior Lighting
I HAVE BEEN NOTIFIED ON TWO OCCASIONS ON THE ROAD THAT MY TAIL LIGHT WAS OUT. WHEN I WAS ABLE TO CHECK THEM, BOTH TAIL LIGHTS LIT UP THEN TURNED ON. IT MUST BE AN INTERMITTENT ISSUE.
NHTSA ODI #11311829
Official recalls
3Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Apr 28, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.
Consequence & remedy
Consequence: Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 42190.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration