2020 GMC Terrain

The brake suddenly became impossible to depress more than 3/4 of an inch. Almost unable to stop nearly hitting another vehicle. The dashboard then lit up with a "service brake system" warning. Luckily was only a few minutes from home brought it home and began the search for the issue. The brake vacuum pump failed. Unsure of further damage at this point. It being Sunday am unable to contact a shop or dealer.

While driving, I suddenly smelled something burning. Immediately after, a warning popped up stating 'Engine power is reducing,' the check engine light came on, and I experienced a sudden, near-total loss of power braking assist, making the brake pedal extremely hard to press. I had to use intense force to bring the vehicle to a stop. A scan of the vehicle's OBD-II codes revealed codes P0556 (Brake Booster Pressure Sensor Circuit), P0014 (Exhaust Camshaft Position Timing Over-Advanced), and P0017 (Crankshaft Position - Camshaft Position Correlation). This is a known failure where the engine-driven mechanical brake vacuum pump seizes up, destroys the braking vacuum assist, and bends or shifts the exhaust camshaft reluctor wheel, causing a severe and immediate safety hazard while in motion.

While driving north in interstate 79, the brakes became very hard to push making it difficult to stop the vehicle. We got off the interstate and proceeded back home. The brakes were as hard as a rock to push and it was difficult to stop the vehicle. When this happened, the check engine light came on and stayed on. It was very dangerous to drive due to the brakes not working properly and the stopping distance was greatly reduced and it was difficult to stop the vehicle putting our family at risk for their safety. We took the vehicle to a repair shop and they checked and diagnosed the issue and told us the vacuum pump for the brakes was no good and needed replaced. We found that this is a common issue for breakdown on our type of vehicle. Repairs were made and the total cost was $352.24 including tax.

I was traveling down the interstate at 70mph. Traffic began slowing ahead of me. I hit the brakes and the pedal was rock hard and I could not stop my vehicle safely. Service brake assist light flashed momentarily. Ended up being the vacuum pump. I was told by the dealership I had it towed to that the vacuum pump had broken off and failed. This was an absolutely horrifying situation that could have caused severe injury or death.

During my daily commute to work on the interstate the service break assist message came on my dash and when attempting to break the pedal was very hard, to the point where I had to push extremely hard and quickly realized I had to brake much much soon than normal to prevent hitting other vehicles. Sudden loss of brakes put me and other drivers at risk due to my near inability to slow down or stop and the sudden and unexpected nature of the event.

The brake vacuum pump had a catastrophic failure which resulted in the immediate loss of all brakes in the vehicle. I had the vehicle repaired only to find that GM has issued numerous repair bulletins to dealers and mechanics. This appears to be an issue known to them. As the vehicle was repaired, the parts are no longer available for inspection. This was a danger to me and others around me because I was traveling 60mph down hill with no means to slow or stop. I narrowly avoided an accident. There were no warning lamps before the incident. A warning lamp did come on after the loss of brakes but only after I attempted to brake.

On June 7, 2026, I was driving my 2020 GMC Terrain. I was going at about 40MPH along a very busy main road. While slowing for a red light the Check Engine Light turned on and the car displayed a notice about reduced engine power. Seconds later, the brake pedal became stuck and would not press down all the way and I lost braking ability. The car rattled/shook violently, made a grinding noise, and then the engine shut off and the car stopped abruptly, narrowly avoiding hitting the car in front of us. I turned on the hazard lights. I was not able to get the car to start again, nor was I able to get the car to shift into any other gear including neutral. We were nearly hit by other vehicles multiple times while attempting to get the car to move again, and to get myself and my child safely out of the road. Myself and multiple bystanders attempted to engage the transmission interlock override multiple time. We were eventually able to engage it and push the car to the side of the road. This failure created an extremely unsafe situation for all involved as this road is very busy and there were numerous near-collisions both with my disabled vehicle, and with other drivers serving out of the way and into other lanes at the last second. As time went on and the battery drained, most of the car's exterior lights turned off and other drivers had a hard time seeing my car. I used a strobe flashlight to alert other drivers but this required that I had to stand in the road near the vehicle. Police were called immediately when I found that we could not move the car out of the road, but they did not arrive. Ultimately the vehicle was stuck and inoperable in a travel lane for over two hours. The car was then towed to a nearby repair shop. The mechanic evaluation stated that the brake vacuum pump had failed resulting in loss of braking ability and expensive damage to the engine and other components. The manufacturer is aware of this issue. See: Thieme, et al. v. General Motors LLC.

I am a [XXX] resident. While commuting to work in [XXX], my GMC Terrain experienced a sudden, catastrophic failure of the brake vacuum pump while traveling at highway speeds. When I attempted to slow down for the exit, the brake pedal instantly became extremely stiff and nearly impossible to depress. I realized I had suffered an absolute loss of power braking assist. To avoid a high-speed collision with heavy highway traffic, I was forced to deliberately steer onto the roadside rumble strips, relying on tire friction to slow the vehicle down. This severe near-miss left me terrified and distraught. Because the shoulder was narrow, my disabled vehicle was left partially protruding into the active roadway. Passing cars sped by so close that my vehicle was violently rocking, creating an incredibly unsafe situation. I was forced to call the State Police for emergency assistance. They dispatched a trooper and a tow truck to remove me and the vehicle safely from the highway. The vehicle was towed to a mechanic in Massachusetts. The mechanic discovered that the vacuum pump had internally exploded. This explosion sent catastrophic metal shards and debris directly into the engines oil galleys and oiling system. While the vehicle has 121,776 miles, this is not a normal wear-and-tear component failure. The brake vacuum pump suffered a catastrophic internal mechanical explosion at highway speeds, completely eliminating my ability to stop the vehicle. A mechanical component failure should never cause an immediate, life-threatening loss of brake control, regardless of mileage. This is a known, systemic engineering defect that is currently the subject of active federal class-action litigation (XXX v. General Motors LLC). This defect did not just cause an immediate life-threatening braking failure, it completely contaminated the oiling system, destroyed the entire engine, and rendered the vehicle a total loss requiring a full engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

I am submitting this complaint regarding a serious and dangerous brake failure involving my 2020 GMC Terrain SLT with approximately 150,000 miles. While driving, the vehicle suddenly experienced a vacuum pump failure that caused a severe loss of braking ability with no warning beforehand. The brake pedal became extremely hard, and the vehicle would barely stop. This created a very dangerous situation and could have easily resulted in a serious accident. Thankfully, I was not driving at a high speed when the failure occurred, and there were no vehicles directly in front of me at the time. However, only minutes earlier I had been traveling approximately 65–70 mph on the highway. If this brake failure had occurred while driving at highway speeds or in heavy traffic, I truly believe it could have caused a major crash resulting in serious injury or death. What concerns me most is that there was no warning before the brakes failed. No warning lights and no issues with my brakes. The sudden loss of braking power was extremely frightening and created an immediate safety hazard. After researching this issue, I discovered that other GMC and GM vehicle owners have reported similar vacuum pump failures and brake assist problems. I believe this is a significant safety issue that should be investigated further. Drivers should not experience sudden brake failure without warning, especially on a vehicle that otherwise appeared to be operating normally beforehand. I am very thankful no one was injured in my situation, but I am concerned that another driver may not be as fortunate. My vehicle had to be towed to a nearby shop and they suspected it was the vacuum pump failure and the car started smoking badly. so I had it towed to the GMC dealership and they called me today to confirm that was the problem and it also caused damage to the camshaft. This is a known issue with the terrain and there is currently a class action lawsuit.