NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
11 reportsClear category filterMileage unknown · Nov 3, 2022
EnginePower TrainVehicle Speed Control
I still have more to add to my other complaint. The fire started with alternator apparently there were crossed wires took alternator back to Orielys where I got it warrented out fixed the expanded wiring and replaced a hose and other things damaged by the little fire. Then after that things kept getting worse. Then it was spark …
Read full complaint
I still have more to add to my other complaint. The fire started with alternator apparently there were crossed wires took alternator back to Orielys where I got it warrented out fixed the expanded wiring and replaced a hose and other things damaged by the little fire. Then after that things kept getting worse. Then it was spark plugs that were rusted that I replaced eventually I complained back to the dealership I got the car from and they agreed to help repair it after a posting by me on fb that I wasent a happy customer basically and that I literally had a sitting duck. Turns out the timing chain needed to be replaced and other little things. I've replaced O2 sensors camshaft sensors gaskets in catalytic converter had it inspected thinking it was a clogged exhaust the excessive oil usage was insane I would be going through 5quarts twice a month! I'm just tryna have a DECENT WORKING VEHICLE for my kids and I. I literally can't keep a job because I DONT HAVE RELIABLE transportation....I've put sooooo much money into this vehicle and now I might have a blown gasket!!! And that's because I haven't even been driving the vehicle. I got the car on Jan 7th 2021 with 129,043 miles on it as of today it has a total of 164,627 miles on it meaning in between the two years that I've owned the vehicle I have only put a total of 35,584 miles on it.....for it to have this many problems for so little mileage is INSANE!!! my kids were in the car with me today when the car started smoking like crazy from under hood and exhaust I pulled over turned the car off and took my baby off car seat in all and got away from vehicle thinking it was on fire again. I popped the hood and notice it was coming from under manifold.....meaning its probly a blown gasket after I just replaced the camshaft sensor AGAIN......it's ridiculous all the stuff thats going wrong with this vehicle with so little mileage that's been put on it.
NHTSA ODI #11492037
Mileage unknown · Nov 3, 2022
EnginePower TrainVehicle Speed ControlFire
First off before I got the car it had gone through a tune up. About a couple months after I got the car little things started to happen it would rock back and forth while idling I thought it was kind of an indicator that it needed oil but the percentage was still at a decent range and telling me it didn't need oil plus I hadent …
Read full complaint
First off before I got the car it had gone through a tune up. About a couple months after I got the car little things started to happen it would rock back and forth while idling I thought it was kind of an indicator that it needed oil but the percentage was still at a decent range and telling me it didn't need oil plus I hadent driven it 3000-5000 miles. Then engine light came on had it inspected codes ran came back telling me something about Throttle body So I purchased a whole new throttle body in Prosser at dealership costing me some booko buks and swapped it out when I got back home I then took it for test drive along with my 4 kids in the vehicle with me and then a little ways about 20 mins driving engine power reduced light came on along with stabilitrak and eventually lost power I was stranded in the middle of summer in the middle of nowhere with my kids windows rolled down ppl drove by and asked if I needed help and eventually came back with jumper cables tried to jump me but the car wouldn't budge I then left the car there overnight and took battery out to have it inspected the next day IT WAS FRIED (over 4 yrs old) so I had to purchase a new one costing me roughly 150 buks then took it back to where my car was stranded put it in and alarm went off and I clicked the button on key ring stuck it in ignition shit the door behind me locking keys in car while vehicle was still running and had to bust a window out to get to em. Got into car drove off made it back to my apt left it running outside while I went inside to get some stuff before I THOUGHT the problem was solved it shut off again.....I then had to replace the alternator costing me another pretty penny....about a couple weeks later I was starting a new job at a assisted living facility and arrived 10 mins early shit car off a noticed smoke coming from under hood I was confused because where the smoke was coming from couldn't have been it overheating I popped the hood and my car was on fire!!!!
NHTSA ODI #11492036
Mileage unknown · Dec 5, 2021
EngineFuel/propulsion SystemVehicle Speed Control
Once again, timing chain incident, this time while driving, wasn't expecting it, suddenly my Terrain steering when became stiff to turn, and happened to realize the car motor had shut off and rolling to the right, nearly hitting parked car. I tried to start vehicle, but made a whining sound, but did not start, yet check engi…
Read full complaint
Once again, timing chain incident, this time while driving, wasn't expecting it, suddenly my Terrain steering when became stiff to turn, and happened to realize the car motor had shut off and rolling to the right, nearly hitting parked car. I tried to start vehicle, but made a whining sound, but did not start, yet check engine light was on. I had my OBD reader handy, and got p0011, p0017 codes, which tell me it was the timing chain again in this car. This very dangerous because we could of collided with a parked vehicle, if not for me struggling so hard to steer vehicle while steering wheel was stiff.
NHTSA ODI #11442702
168,978 miles · Feb 14, 2021
EngineFuel/propulsion SystemVehicle Speed Control
VEHICLE BEGAN TO USE EXCESSIVE AMOUNT OF OIL AND IDEL UP AND DOWN AND SOMETIMES EVEN SHUTS DOWN. AFTER ABOUT 3 MONTHS WHILE DRIVING ON THE INTERSTATE IT BEGAN TO SHUT DOWN WHILE IN MOTION. I CALLED FOR SOMEONE TO CHECK THE VEHICLE OUT AND HE ARRIVED CALLED SOMEONE TO CHECK THE VEHICLE AND HE ACTUALLY TOLD ME IT SEEMS TO BE THE M…
Read full complaint
VEHICLE BEGAN TO USE EXCESSIVE AMOUNT OF OIL AND IDEL UP AND DOWN AND SOMETIMES EVEN SHUTS DOWN. AFTER ABOUT 3 MONTHS WHILE DRIVING ON THE INTERSTATE IT BEGAN TO SHUT DOWN WHILE IN MOTION. I CALLED FOR SOMEONE TO CHECK THE VEHICLE OUT AND HE ARRIVED CALLED SOMEONE TO CHECK THE VEHICLE AND HE ACTUALLY TOLD ME IT SEEMS TO BE THE MOTOR GONE BAD BUT HE ASKED WOULD I DRIVE IT BACK HOME IF HE FOLLOWED BEHIND. IT LITERALLY SCARED ME AND MY 4 CHILDREN TO DEATH WHEN IT SHUT DOWN WHILE IN MOTION WITH THAT KIND OF SPEED SO I DON'T TRUST PUTTING MY CHILDREN IN IT NOW. I DON'T THINK ITS SAFE AT ALL. THE VEHICLE I ONCE THOUGHT WAS PERFECT FOR MY FAMILY IS TURNING OUT TO BE A NIGHTMARE.
NHTSA ODI #11396131
114,500 miles · Nov 11, 2019
EngineFuel/propulsion SystemVehicle Speed Control
MY TERRAIN IS STALLING REALLY BAD SOME DAYS AND SOMETIMES NO PROBLEMS AT ALL. IT DOES IT MORE WHEN GOING INTO REVERSE, I HAVE TO KEEP GIVING GAS TO GET BACKED UP. IT HAS ALSO DIED ON ME WHEN I SLOW TO A STOP LIKE AT A LIGHT. THIS IS REALLY FRUSTRATING!!
NHTSA ODI #11279342
41,000 miles · Jul 3, 2019
Electronic Stability Control (esc)Unknown Or OtherVehicle Speed Control
SEVERAL TIMES IN 3 YEARS, THE DEALERSHIP CAN NOT DUPLICATE THE PROBLEM LOSS OF POWER STARTS RUNNING SLOW, WONT GO OVER 20 MPH, CHECK STABILITY LIGHT COMES ON, CHECK ENGINE LIGHT STARTS BLINKING, ACTS LIKE MISFIRE OR NO FUEL IN VEHICLE, STARTS ANYWHERE AT ANY TIME, VERY UNSAFE AND SCARY. AT LEAST TAKEN TO A CERTIFIED DEALERSHIP …
Read full complaint
SEVERAL TIMES IN 3 YEARS, THE DEALERSHIP CAN NOT DUPLICATE THE PROBLEM LOSS OF POWER STARTS RUNNING SLOW, WONT GO OVER 20 MPH, CHECK STABILITY LIGHT COMES ON, CHECK ENGINE LIGHT STARTS BLINKING, ACTS LIKE MISFIRE OR NO FUEL IN VEHICLE, STARTS ANYWHERE AT ANY TIME, VERY UNSAFE AND SCARY. AT LEAST TAKEN TO A CERTIFIED DEALERSHIP 7 OR 8 TIMES AND EVERY TIME THEY DO SOMETHING DIFFERANT , YET THE PROBLEM PERSISTS! THE VEHICLE CAN BE STATIONARY AT RED LIGHT AND BIG OR WHILE DRIVING GOING 45 OR 65 AND DROP TO 20 MPH AND NOT WANT TO GO, I PUSH THE GAS PADDLE TO FLOOR AND IT DOES NOTHING. THIS HAS BEEN INTERMEDIATE AND A PROBLEM SINCE MONTH 3 OF BUYING MY VEHICLE. THIS IS NOT SAFE AND THE DEALERSHIP HAS BASICALLY GIVIN UP ON ME AND MY VEHICLE.
NHTSA ODI #11229167
Mileage unknown · May 1, 2016
Air BagsUnknown Or OtherVehicle Speed ControlCrashInjury
SUDDEN UNINTENDED ACCELERATION WHEN VEHICLE SHIFTED FROM PARK TO DRIVE, RESULTED IN EXTREME HIGH SPEED ACCELERATION AND NO CONTROL OF VEHICLE. THIS RESULTED IN A HIGH IMPACT CRASH INTO GARAGE SIDE WALL. ALSO AIR BAG DID NOT DEPLOY. ASSUME THROTTLE WIDE OPEN CAUSING SUDDEN ACCELERATION. INSURANCE REPORT , AND POLICE REPORT PENDI…
Read full complaint
SUDDEN UNINTENDED ACCELERATION WHEN VEHICLE SHIFTED FROM PARK TO DRIVE, RESULTED IN EXTREME HIGH SPEED ACCELERATION AND NO CONTROL OF VEHICLE. THIS RESULTED IN A HIGH IMPACT CRASH INTO GARAGE SIDE WALL. ALSO AIR BAG DID NOT DEPLOY. ASSUME THROTTLE WIDE OPEN CAUSING SUDDEN ACCELERATION. INSURANCE REPORT , AND POLICE REPORT PENDING
NHTSA ODI #10862428
45,000 miles · Mar 8, 2016
Electronic Stability Control (esc)Vehicle Speed Control
SUMMARY: I HAD TO DECIDE TO BRAKE OR SHOOT THROUGH A YELLOW LIGHT, GOING ABOUT 35 MPH, I BRAKED! ALL OF A SUDDEN I HEARD A CLUNK AND THEN ALARM DING FROM THE DASH AS WELL AS MESSAGE "SERVICE STABILTRAK" THEN "REDUCED ENGINE POWER". I WAS UNABLE TO GO ANY FASTER THAN 25MPH. I DROVE IN THIS MODE FOR ABOUT 2 MILES TAKING THE BACK …
Read full complaint
SUMMARY: I HAD TO DECIDE TO BRAKE OR SHOOT THROUGH A YELLOW LIGHT, GOING ABOUT 35 MPH, I BRAKED! ALL OF A SUDDEN I HEARD A CLUNK AND THEN ALARM DING FROM THE DASH AS WELL AS MESSAGE "SERVICE STABILTRAK" THEN "REDUCED ENGINE POWER". I WAS UNABLE TO GO ANY FASTER THAN 25MPH. I DROVE IN THIS MODE FOR ABOUT 2 MILES TAKING THE BACK STREETS TO MY DESTINATION. AT DESTINATION SHUT VEHICLE OFF TO SEE IF THIS WOULD RESET SOMETHING, IT DID! IT WAS SUPER SCARY. SO NOW TERRIFIED TO BRAKE HARD.
NHTSA ODI #10845653
73,115 miles · Sep 21, 2015
Vehicle Speed Control
TL* THE CONTACT OWNS A 2012 GMC TERRAIN. UPON STARTING AND DRIVING THE VEHICLE, THE SPEEDOMETER FAILED TO FUNCTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,115. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10766422
44,039 miles · Mar 14, 2014
StructureVehicle Speed Control
ON 8/2/12 I PURCHASED MY GMC TERRAIN BRAND NEW IN ASHLAND CITY, TN. I MOVED TO WEST PALM BEACH IN OCTOBER 2012. THE CURRENT MILES ON THE VEHICLE ARE 44,039. I GOT AN OIL CHANGE, FILTER AND MULTI-POINT INSPECTION ON 10/24/13 BY THE LOCAL GMC DEALER. ON 10/23/13 I TOOK MY VEHICLE IN TO HAVE A RECALL REPAIRED AT SCHUMACHER BUICK/…
Read full complaint
ON 8/2/12 I PURCHASED MY GMC TERRAIN BRAND NEW IN ASHLAND CITY, TN. I MOVED TO WEST PALM BEACH IN OCTOBER 2012. THE CURRENT MILES ON THE VEHICLE ARE 44,039. I GOT AN OIL CHANGE, FILTER AND MULTI-POINT INSPECTION ON 10/24/13 BY THE LOCAL GMC DEALER. ON 10/23/13 I TOOK MY VEHICLE IN TO HAVE A RECALL REPAIRED AT SCHUMACHER BUICK/GMC. THE RECALL # IS 12312. A MONTH LATER THE VEHICLE WOULD LUNGE SHARPLY FORWARD WHILE DRIVING AND A HEAVY SHAKING VIBRATION (BOTH WHILE DRIVING AND AT A STOP) BELOW MY FEET IN THE VEHICLE (FLOOR BOARD). I TOOK THE VEHICLE TO SCHUMACHER BUICK/GMC 3031 OKEECHOBEE BLVD, ON 11/11/13 AND IT REMAINED UNTIL 11/15/14 AND THE PROBLEM WAS NOT IDENTIFIED. I RETURNED THE VEHICLE FOR THE SAME PROBLEM ON 12/21/13 (SAME DEALER) AND IT WAS PICKED UP ON 12/31/13. THE FIRST SERVICE ADVISOR WAS ROB DEAL HE TOLD ME THAT THE VEHICLE SHIFTS ITS DRIVABILITY TO THE DRIVER AND NOTHING WAS WRONG. I TOOK MY VEHICLE BACK A SECOND TIME FOR THE SAME PROBLEM THIS TIME (IT WAS GETTING WORST) MY REP WAS "[XXX]". HE SAID IT WAS THE "ECO" BUTTON IN THE CAR, IF PUSHED MAKES THE CAR RUN ROUGH." ON MARCH 7, 2014, I CONTACTED GMC CORPORATE OFFICE AND SPOKE TO SHERRY AND REQUESTED A FULL ANALYSIS OF MY CAR. THIS TIME I WENT TO ANOTHER GMC DEALER LOCALLY (LAKE PARK SCHUMACHER) AND MY SERVICE TECH WAS [XXX]. PER [XXX] IT IS A TRANSMISSION ISSUE -LEFT ON MY VOICEMAIL AND SAVED" SPECIFICALLY HE SAID IT WAS THE "CONTROL PRESSURE VALVE CAUSING IT TO LUNGE FORWARD AND IT WAS IMPROPER." HE SAID IT WAS "UNCOMMON TO SEE THIS ISSUE." THE REASON I TOOK THE VEHICLE IN IS THAT I ALMOST REAR ENDED TWO PEOPLE WHILE DRIVING DUE TO THE VEHICLES LUNGES AND HAVE MY BODY JOLTED INTO THE GLASS THE FORCE WAS SO STRONG WITH THE LUNGE. I FEAR FOR MY SAFETY AND THAT OF MY 12 YEAR OLD DAUGHTER IN THIS CAR. I WAS CONTACTED ON 3/13/14 THAT THE VEHICLE WAS READY FOR PICK-UP AND IT HAD BEEN FIXED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10569241
Official recalls
4Mar 8, 2022
General Motors, LLC (GM) is recalling certain 2010-2017 GMC Terrain vehicles. A reflection caused by the headlight housings may illuminate areas above the vehicle and outside of the driver's view with excessively bright light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The bright reflection may cause a glare for other drivers, reducing their visibility and increasing the risk of a crash.
Remedy: Dealers will install headlamp appliques, free of charge. Owner notification letters were mailed September 8, 2022. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N222363740.
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
Oct 19, 2011
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES, MANUFACTURED FROM JULY 18, 2011, THROUGH SEPTEMBER 6, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). THE TIRE PRESSURE MONITORING SYSTEM IS DESIGNED TO ILLUMINATE THE TIRE PRESSURE WARNING LIGHT WHEN THE PRESSURE IN A TIRE IS 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE. ON THESE VEHICLES, THE LIGHT WILL NOT ILLUMINATE UNTIL THE TIRE PRESSURE IS MORE THAN 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH. THE RESULTING CRASH COULD CAUSE SERIOUS INJURY. UNDERINFLATED TIRES CAN ALSO RESULT IN PREMATURE OR IRREGULAR WEAR, POOR HANDLING, AND POOR FUEL ECONOMY.
Remedy: GM DEALERS WILL UPDATE THE BODY CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 9, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Illustration