NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
17 reportsClear category filterMileage unknown · May 15, 2022
EnginePower TrainVehicle Speed Control
My 2010 Terrain had been been intermittent dash warnings for “Service StabiliTrac” and “Engine Power Reduced” which would force the engine to reduce the speed itself down to about 30 MPH. After turning off car and restarting, warnings would go away. Yesterday, while driving on a secondary road, with no check engine light on, the…
Read full complaint
My 2010 Terrain had been been intermittent dash warnings for “Service StabiliTrac” and “Engine Power Reduced” which would force the engine to reduce the speed itself down to about 30 MPH. After turning off car and restarting, warnings would go away. Yesterday, while driving on a secondary road, with no check engine light on, the engine stalled while traveling at approx 35 MPH. I was able to drop the vehicle into neutral and coast onto a side street, while also attempting to restart the engine. I was able to pull over without causing an accident. After letting the car sit for a few minutes I attempted to restart the engine, but only got a strange noise from the area of the upper cylinders. At his point the check engine light was now on. While waiting for a tow truck, and independent mechanic pulled up to ask if I needed help. After listening to the noice from the upper engine he asked if he could get tools and look in the engine. I said yes. He quickly pulled parts off the upper engine and opened and removed the upper cylinder cover. This revealed that the timing chain had no tension, as well as shards of shattered plastic all over the place, in and around the upper cylinders. After pointing this out he put everything back together and suggested I contact the dealership I got the vehicle from, which I have done already. He then stated that it appears that the engine would need to be replaced or rebuilt, due to catastrophic engine failure. He said my quick thinking of putting the vehicle into neutral probably avoided causing an accident and allowed me to get myself to a safe spot before stopping the vehicle. He also stated that this particular GM motor is known for catastrophic failure, which GM has failed or refused to acknowledge
NHTSA ODI #11464699
59,000 miles · Feb 15, 2021
Electrical SystemPower TrainVehicle Speed Control
DRIVING 50 MPH ON THE HIGHWAY, MY CAR DECIDED TO 'REDUCE ENGINE POWER' AND 'SERVICE STABILITRAK' CAME ON, IMMEDIATELY MAKING THE CAR SLOW DANCE FORCIBLY TO 25 MPH. THE CAR WAS SHAKING AND STEPPING ON THE GAS DID NOTHING. THAT'S DANGEROUS, BECAUSE THE PERSON BEHIND ME HAS TO SWERVE OR HIT INTO THE BACK OF ME FOR SUDDEN DROP IN SP…
Read full complaint
DRIVING 50 MPH ON THE HIGHWAY, MY CAR DECIDED TO 'REDUCE ENGINE POWER' AND 'SERVICE STABILITRAK' CAME ON, IMMEDIATELY MAKING THE CAR SLOW DANCE FORCIBLY TO 25 MPH. THE CAR WAS SHAKING AND STEPPING ON THE GAS DID NOTHING. THAT'S DANGEROUS, BECAUSE THE PERSON BEHIND ME HAS TO SWERVE OR HIT INTO THE BACK OF ME FOR SUDDEN DROP IN SPEED. YOU GUYS SHOULD KNOW BETTER! HAPPENED TWICE IN ONE DAY. I HAD TO RESTART THE CAR, AND IT HAPPENED GOING ONTO THE BRIDGE. SOMEONE COULD BE SERIOUSLY HURT, OR KILLED. DO BETTER!
NHTSA ODI #11396239
80,000 miles · Dec 20, 2019
EngineVehicle Speed Control
2010 GMC TERRAIN WITH V6 LOSS OF POWER, ENGINE CODES TIMING ISSUE, CAMSHAFT SENSOR FAULT, CRANKSHAFT SENSOR FAULT. STABIL-TRACK FAULT. ROUGH IDLE, OIL CONSUMPTION. THE LIST GOES ON. THIS IS A COMMON THING WITH THESE ENGINES AND GM HAS DONE NOTHING. THIS HAS BEEN GOING ON WITH THIS VEHICLE FOR AWHILE. STAY AWAY FROM GM VEHICLES T…
Read full complaint
2010 GMC TERRAIN WITH V6 LOSS OF POWER, ENGINE CODES TIMING ISSUE, CAMSHAFT SENSOR FAULT, CRANKSHAFT SENSOR FAULT. STABIL-TRACK FAULT. ROUGH IDLE, OIL CONSUMPTION. THE LIST GOES ON. THIS IS A COMMON THING WITH THESE ENGINES AND GM HAS DONE NOTHING. THIS HAS BEEN GOING ON WITH THIS VEHICLE FOR AWHILE. STAY AWAY FROM GM VEHICLES THEY DO NOT STAND BEHIND THERE PRODUCTS, I WILL BE BUYING A FORD AND I WILL TELL EVERYONE I KNOW!
NHTSA ODI #11290401
Mileage unknown · Jul 8, 2019
Electrical SystemVehicle Speed Control
TL* THE CONTACT OWNS A 2010 GMC TERRAIN. THE CONTACT STATED THAT VARIOUS WARNING INDICATORS AND GAUGES FLASHED. CADILLAC VERA PEMBROOKE PINES (954-517-7827, 300 SOUTH UNIVERSITY DRIVE, PEMBROKE PINES, FL 33025) WAS NOTIFIED OF THE FAILURE, BUT WAS NOT AUTHORIZED TO SCHEDULE AN APPOINTMENT. IN ADDITION, WHILE ATTEMPTING TO ACCELE…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC TERRAIN. THE CONTACT STATED THAT VARIOUS WARNING INDICATORS AND GAUGES FLASHED. CADILLAC VERA PEMBROOKE PINES (954-517-7827, 300 SOUTH UNIVERSITY DRIVE, PEMBROKE PINES, FL 33025) WAS NOTIFIED OF THE FAILURE, BUT WAS NOT AUTHORIZED TO SCHEDULE AN APPOINTMENT. IN ADDITION, WHILE ATTEMPTING TO ACCELERATE FROM A STOP SIGN, THE VEHICLE FAILED TO GAIN SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11230118
98,000 miles · Oct 19, 2018
Electronic Stability Control (esc)EngineVehicle Speed Control
WHILE DRIVING MY CAR THE STABILI-TRACK SERVICE LIGHT COMES ON. THEN THE CHECK ENGINE, BRAKE, ABS, AWD, AS WELL AS THE POWER STEERING LIGHTS COME ON. THEN I LOSE POWER STEERING AND MY SPEED IS THROTTLED DOWN A LOT. ITS HAPPENED ON THE EXPRESSWAY AND CITY STREETS. WHEN ON THE EXPRESSWAY I HAVE TO IMMEDIATELY GET TO THE SHOULDER…
Read full complaint
WHILE DRIVING MY CAR THE STABILI-TRACK SERVICE LIGHT COMES ON. THEN THE CHECK ENGINE, BRAKE, ABS, AWD, AS WELL AS THE POWER STEERING LIGHTS COME ON. THEN I LOSE POWER STEERING AND MY SPEED IS THROTTLED DOWN A LOT. ITS HAPPENED ON THE EXPRESSWAY AND CITY STREETS. WHEN ON THE EXPRESSWAY I HAVE TO IMMEDIATELY GET TO THE SHOULDER WITHOUT GETTING INTO AN ACCIDENT. I'VE HAD MY CAR TOWED TO THE MECHANICS SHOP MULTIPLE TIMES AND THEY'VE TOLD ME THAT THERE ARE NO CODES WHEN HOOKING UP THE COMPUTER. THEY KEPT IT A FEW TIMES IN THE LAST 3 YEARS AND HAVE TOLD ME THERE WERE MISFIRES AFTER LETTING THE CAR SIT AND TESTING IT OUT (TEST DRIVING) AND WORK WAS NEEDED (THROTTLE BODY REPLACEMENT, SPARK PLUG REPLACEMENT, CAM SHAFT SWAP OUT AND A FULL TUNE-UP). $1000 AND LESS THAN A YEAR LATER IT HAPPENS AGAIN AND THEN AGAIN. THIS IS THE 3RD YEAR (2016, 2017, 2018) IT HAS HAPPENED TO ME IN A ROW AND ALL THE MECHANIC CAN SAY IS THAT IT MAY BE SOMETHING GM SHOULD INVESTIGATE. I'VE CALLED GM WITH NO LUCK. THIS IS EXTREMELY UNSAFE AND I AM THANKFUL THAT MY KIDS WERE NOT IN THE CAR WHEN IT HAPPENS. TRYING TO NAVIGATE TRAFFIC ON THE EXPRESSWAY WHEN YOUR CAR THROTTLES DOWN TO 25-35 MPH IS INSANE.
NHTSA ODI #11141421
130,000 miles · Sep 25, 2017
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
THE DRAKES LOCK UP AND WILL NOT RELEASE UNTIL THE CAR SITS FOR SOMETIME ABOUT 2-8 HOURS.THE SERVICE STABILITRACK LIGHT COMES ON AND YOU LOSE ENGINE POWER ALMOST INSTANTLY. I HAVE HAD FOUR DIFFERENT SHOP FIX WHAT THEY SUSPECTED WAS THE PROBLEM AND THE LAST SHOP WAS A DEALERSHIP AND IT HAPPENED TO ME A WEEK LATER WHILE OUT OF TOWN…
Read full complaint
THE DRAKES LOCK UP AND WILL NOT RELEASE UNTIL THE CAR SITS FOR SOMETIME ABOUT 2-8 HOURS.THE SERVICE STABILITRACK LIGHT COMES ON AND YOU LOSE ENGINE POWER ALMOST INSTANTLY. I HAVE HAD FOUR DIFFERENT SHOP FIX WHAT THEY SUSPECTED WAS THE PROBLEM AND THE LAST SHOP WAS A DEALERSHIP AND IT HAPPENED TO ME A WEEK LATER WHILE OUT OF TOWN FOR A WEDDING.
NHTSA ODI #11025230
83,137 miles · Feb 25, 2017
Vehicle Speed Control
WHILE DRIVING ON FREEWAY IN SAN DIEGO, CA DURING MORNING RUSH HOUR, CAR SUDDENLY LOST POWER. DASHBOARD MESSAGE WAS "REDUCED POWER TO ENGINE." CAR WOULD SUDDENLY ONLY GO 30 MPH. VERY DANGEROUS. I WAS IN THE MIDDLE LANE OF FREEWAY AND LUCKILY AVOIDED COLLISIONS, AS TRAFFIC FLOW WAS 70 MPH. TOOK CAR TO GMC DEALER AND THROTTLE BODY …
Read full complaint
WHILE DRIVING ON FREEWAY IN SAN DIEGO, CA DURING MORNING RUSH HOUR, CAR SUDDENLY LOST POWER. DASHBOARD MESSAGE WAS "REDUCED POWER TO ENGINE." CAR WOULD SUDDENLY ONLY GO 30 MPH. VERY DANGEROUS. I WAS IN THE MIDDLE LANE OF FREEWAY AND LUCKILY AVOIDED COLLISIONS, AS TRAFFIC FLOW WAS 70 MPH. TOOK CAR TO GMC DEALER AND THROTTLE BODY HAD TO BE REPLACED. TOTAL COST WAS $458. I COULD HAVE EASILY CREATED A MAJOR TRAFFIC ACCIDENT CAUSING INJURY TO MYSELF AND MANY OTHERS BECAUSE I SUDDENLY COULD ONLY DRIVE 30 MPH.
NHTSA ODI #10956937
48,000 miles · May 5, 2016
Vehicle Speed Control
TL* THE CONTACT OWNS A 2010 GMC TERRAIN. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO REVERSE. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE V…
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC TERRAIN. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO REVERSE. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000.
NHTSA ODI #10863340
60,000 miles · Jan 6, 2015
Electronic Stability Control (esc)EngineVehicle Speed Control
DRIVING BACK FROM A TWO HOUR TRIP AT APROX 55 MPH OUR 2010 GMC STARTED FLASHING "REDUCED ENGINE POWER" WITH THE CHECK ENGINE LIGHT, AND "SERVICE STABILITRAK" WITH THE STABILITRAK LIGHT. SPEED DROPPED DOWN TO ABOUT 30 MPH WITHOUT CONTROL. THE CAR WAS IDLING HEAVING WITH RMPS JUMPING. WE PULLED OVER TO THE SIDE OF THE ROAD AND RE…
Read full complaint
DRIVING BACK FROM A TWO HOUR TRIP AT APROX 55 MPH OUR 2010 GMC STARTED FLASHING "REDUCED ENGINE POWER" WITH THE CHECK ENGINE LIGHT, AND "SERVICE STABILITRAK" WITH THE STABILITRAK LIGHT. SPEED DROPPED DOWN TO ABOUT 30 MPH WITHOUT CONTROL. THE CAR WAS IDLING HEAVING WITH RMPS JUMPING. WE PULLED OVER TO THE SIDE OF THE ROAD AND RESTARTED THE CAR, THE ONLY LIGHT THAT REMAINED ON WAS THE CHECK ENGINE LIGHT. SPEED CONTROL WAS RESTORED. BY THE TIME WE MADE IT HOME, APROX 20 MILES, THE CHECK ENGINE LIGHT TURNED OFF. THEN A COUPLE WEEKS LATER AGAIN, TWICE IN ONE NIGHT, BACK TO BACK. I CALLED THE DEALER FOR AN APPOINTMENT BECAUSE I ASSUMED IT WOULD BE COVERED BY A GMC WARRANTY, THEY DID NOT HAVE AVAILABILITY FOR 7+ DAYS. THE NIGHT BEFORE MY APPOINTMENT IT HAPPENED AGAIN BUT DID NOT CORRECT ITSELF AND WE HAD TO DRIVE IT TO THE DEALERSHIP AT 30 MPH. I JUST RECEIVED THE NEWS, $800 LATER, IT NEEDS A NEW THROTTLE BODY, EXHAUST CAM SOLENOID AND ANOTHER REPAIR TO THE CAMSHAFT. I DO NOT HAVE THE PAPERWORK BACK FROM THE DEALER YET FOR ADDITIONAL DETAILS, BUT AM DISAPPOINTED THAT THIS IS A COMMON PROBLEM WITH THE 2010 GMC TERRAINS AND THEY TAKE NO RESPONSIBILITY FOR THE REPAIRS. THIS SHOULD BE A RECALL. THERE IS A LOT OF POTENTIAL DANGER TO HAVING YOUR SPEED DROP WITH NO WARNING OR CONTROL.
NHTSA ODI #10670419
41,000 miles · Aug 13, 2014
SteeringVehicle Speed Control
VEHICLE QUICKLY DECELERATED FROM ABOUT 46 MPH TO 5 MPH. IT WOULD NOT ACCELERATE ABOVE 5 MPH. NO WARNING SIGNS BEFORE HAND, HAPPENED OUT OF NOWHERE. THEN AN ERROR LIGHT CAME ON THE DASHBOARD. GMC MECHANIC STATED THE THROTTLE BODY WAS BAD AND REPLACED IT, IT WAS NOT COVERED UNDER WARRANTY (COST $540.00). THIS COULD HAVE CAUS…
Read full complaint
VEHICLE QUICKLY DECELERATED FROM ABOUT 46 MPH TO 5 MPH. IT WOULD NOT ACCELERATE ABOVE 5 MPH. NO WARNING SIGNS BEFORE HAND, HAPPENED OUT OF NOWHERE. THEN AN ERROR LIGHT CAME ON THE DASHBOARD. GMC MECHANIC STATED THE THROTTLE BODY WAS BAD AND REPLACED IT, IT WAS NOT COVERED UNDER WARRANTY (COST $540.00). THIS COULD HAVE CAUSED A MAJOR ACCIDENT ON A FREEWAY OR BUSY STREET, OR COULD LEAVE SOMEONE STRANDED ON THE SIDE OF THE ROAD WITH NO WARNING. *TR
NHTSA ODI #10622150
Official recalls
3Mar 8, 2022
General Motors, LLC (GM) is recalling certain 2010-2017 GMC Terrain vehicles. A reflection caused by the headlight housings may illuminate areas above the vehicle and outside of the driver's view with excessively bright light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The bright reflection may cause a glare for other drivers, reducing their visibility and increasing the risk of a crash.
Remedy: Dealers will install headlamp appliques, free of charge. Owner notification letters were mailed September 8, 2022. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N222363740.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2010 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS AND WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS". THE SOFTWARE IN THE CENTER INSTRUMENT PANEL CAN CAUSE THE HEATING, AIR CONDITIONING, DEFROST, AND RADIO CONTROLS, AS WELL AS THE PANEL ILLUMINATION TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING WITHOUT A FUNCTIONING DEFROST SYSTEM CAN DECREASE YOUR VISIBILITY UNDER CERTAIN DRIVING CONDITIONS AND COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE COMPUTER MODULE IN THE CENTER INSTRUMENT PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Illustration