IllustrationReduce spreed unknown if related to fuel pressure regulator since repaired twice told could be to service bulletin. Warning lights keeps appearing while driving at a speed of 40 to 50 mph.
2010 GMC Terrain
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 GMC Terrain do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Terrain years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
420–25K
3525–50K
4550–75K
5375–100K
51100–150K
10150K+
236 reports with mileage · 54 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports0 fire reports9 injury reports
Fuel/propulsion System complaints
14 reportsENGINE - SLOWS DOWN AND SPEED UP AND JOLT AS IT ACCELERATE IN SPEED. HEATED SEATS - A MONTH AFTER PURCHASE THEY STOPPED WORKED OIL PUMP - THE FILTER GETS CLOGGED WITH METAL SHAVING AND WOULD NOT ALLOW THE OIL TO GET TO THE ENGINE. AS A RESULT, I HAD TO GET OIL CHANGES 3 TIMES IN A MONTH. DASH BOARD AND STEREO LIGHT WOUL…
Read full complaint
ENGINE - SLOWS DOWN AND SPEED UP AND JOLT AS IT ACCELERATE IN SPEED. HEATED SEATS - A MONTH AFTER PURCHASE THEY STOPPED WORKED OIL PUMP - THE FILTER GETS CLOGGED WITH METAL SHAVING AND WOULD NOT ALLOW THE OIL TO GET TO THE ENGINE. AS A RESULT, I HAD TO GET OIL CHANGES 3 TIMES IN A MONTH. DASH BOARD AND STEREO LIGHT WOULD FLICKER AND DIM. STEREO WOULD REPEAT WORDS AND GET STUCK IN ONE PLACE. THE WIND SHIELD WIPERS STOPPED WORKING DURING A RAIN STORM AND WERE WIPING IN TWO SEPARATE DIRECTIONS AT THE SAME TIME.
I HAVE THIS GMC VEHICLE, IT HAS OIL CONSUMPTION ISSUES WHICH ALSO AFFECTS THE PISTONS, TIMING CHAIN AND THE PERFORMANCE AND DRIVABILITY OF THE VEHICLE, THERE WAS A RECALL OF SORTS ON THIS MAKE AND MODEL UP TO SO MANY MILES. I NEVER SAW ANYTHING MAILED OR SENT TO ME ABOUT THIS. RECENTLY I HAVE HAD PROBLEMS WITH IT STALING OUT WH…
Read full complaint
I HAVE THIS GMC VEHICLE, IT HAS OIL CONSUMPTION ISSUES WHICH ALSO AFFECTS THE PISTONS, TIMING CHAIN AND THE PERFORMANCE AND DRIVABILITY OF THE VEHICLE, THERE WAS A RECALL OF SORTS ON THIS MAKE AND MODEL UP TO SO MANY MILES. I NEVER SAW ANYTHING MAILED OR SENT TO ME ABOUT THIS. RECENTLY I HAVE HAD PROBLEMS WITH IT STALING OUT WHEN DRIVING AND PULLING INTO HIGHWAYS. I TOOK IT IN TO A GMC DEALERSHIP AND HAD THEM WORK WITH ME TO GET GMC TO FIX THE PROBLEM. THE VEHICLE IS NOW OVER THE ALLOWED MILES AND THEY WILL NOT ATTEMPT TO HELP CORRECT THE ISSUE, I DON'T UNDERSTAND HOW I'M SUPPOSED TO MAGICALLY KNOW THERE WAS AN ISSUE AND A RECALL ON PROBLEMS IF I NEVER WAS NOTIFIED AND IT DIDN'T START EXHIBITING MAJOR PROBLEMS UNTIL IT WAS NOT WITHIN THE ALOTED MILES THEY HAVE SET. AS I STATED EARLIER, THE DRIVEABLITY IS AFFECTED AND IT SEEMS LIKE AN UNSAFE AND POTENTIALLY DANGEROUS ISSUE, I'M REACHING OUT AND TRYING TO FIND OUT IF THERE IS ANY KINDA OF SOLUTION THAT CAN BE RESOLVED WITHOUT ME SPENDING THOUSANDS OF DOLLARS ON A VEHICLE THAT HAS A DOCUMENTED HISTORY IF ISSUES. THANKS
MY VEHICLE, 2010 GMC TERRAIN, AT TIMES WOULD SPUTTER AND ACT LIKE IT WANTS TO DIE AT IDLE, SO I TOOK IT INTO THE DEALERSHIP AND THEY FOUND THAT THE HIGH PRESSURE FUEL PUMP WAS LEAKING INTO THE CRANKCASE CONTAMINATING THE OIL WITH FUEL. THERE IS CURRENTLY A RECALL FOR THIS ISSUE, #43180: PRODUCT EMISSION RECALL ' HIGH PRESSURE FU…
Read full complaint
MY VEHICLE, 2010 GMC TERRAIN, AT TIMES WOULD SPUTTER AND ACT LIKE IT WANTS TO DIE AT IDLE, SO I TOOK IT INTO THE DEALERSHIP AND THEY FOUND THAT THE HIGH PRESSURE FUEL PUMP WAS LEAKING INTO THE CRANKCASE CONTAMINATING THE OIL WITH FUEL. THERE IS CURRENTLY A RECALL FOR THIS ISSUE, #43180: PRODUCT EMISSION RECALL ' HIGH PRESSURE FUEL PUMP, REFERENCE # N16204318, RELEASE DATE: SEPTEMBER 2016. I WAS TOLD THAT MY VEHICLE WAS NOT PART OF THIS RECALL BECAUSE IT DID NOT INCLUDE MY VIN. I BELIEVE THAT THE RECALL NEEDS TO BE EXPANDED TO COVER MORE VEHICLES BECAUSE THERE ARE MORE VEHICLES THAT ARE AFFECTED BY THIS ISSUE.
I OWN A 2010 GMC TERRAIN THAT ONLY HAS 51,000 MILES. I WAS EXCELLERATING TO GET ONTO THE HIGHWAY WHEN MY CHECK ENGINE LIGHT CAME ON AND MY VEHICLE ALL THE SUDDEN HAD LACK OF ENGINE POWER. I WAS ABLE TO PULL TO THE SHOULDER OF THE ROAD, THANKFULLY WITHOUT GETTING HIT. MY VEHICLE WAS TOWED TO MY MECHANIC'S SHOP. A TEST WAS DONE AN…
Read full complaint
I OWN A 2010 GMC TERRAIN THAT ONLY HAS 51,000 MILES. I WAS EXCELLERATING TO GET ONTO THE HIGHWAY WHEN MY CHECK ENGINE LIGHT CAME ON AND MY VEHICLE ALL THE SUDDEN HAD LACK OF ENGINE POWER. I WAS ABLE TO PULL TO THE SHOULDER OF THE ROAD, THANKFULLY WITHOUT GETTING HIT. MY VEHICLE WAS TOWED TO MY MECHANIC'S SHOP. A TEST WAS DONE AND THE CODE P2135 THROTTLE/PETAL SENSOR SWITCH WAS REVEALED. THE CAR WAS TURNED OFF AND THEN BACK ON AND THE ENGINE LIGHT WAS NOT ON. NOW, TWO WEEKS LATER, THIS HAPPENED AGAIN ON A CITY STREET. THIS TIME ANOTHER WARNING CAME ON ALONG WITH THE ENGINE LIGHT. THE WARNING SAYS ENGINE STABILITY TRAK. THIS IS A HUGE CONCERN AS BOT TIMES, I NARROWLY ESCAPED AN ACCIDENT. MY VEHICLE ONLY HAS 51,000 MILES AND IT IS WELL TAKEN CARE OF. MY CONCERN IS THIS IS A MANUFACTURER DEFECT.
WHILE DRIVING AT ABOUT 5 MILES AN HOUR, TURNING VEHICLE AROUND A CUL-DE-SAC THE VEHICLE COMPLETELY TURNS OFF. I HAVE CONTACTED THE GMC DEALERSHIP ABOUT THIS AND THE ONLY RECALL I WAS TOLD WAS THE FUEL PUMP. I WAS TOLD THEY WOULD ORDER MY PARTS AND THEY WOULD CALL ME; I NEVER RECEIVED A CALL. I HAVE TOWED THE VEHICLE TO TWO REPA…
Read full complaint
WHILE DRIVING AT ABOUT 5 MILES AN HOUR, TURNING VEHICLE AROUND A CUL-DE-SAC THE VEHICLE COMPLETELY TURNS OFF. I HAVE CONTACTED THE GMC DEALERSHIP ABOUT THIS AND THE ONLY RECALL I WAS TOLD WAS THE FUEL PUMP. I WAS TOLD THEY WOULD ORDER MY PARTS AND THEY WOULD CALL ME; I NEVER RECEIVED A CALL. I HAVE TOWED THE VEHICLE TO TWO REPAIR SHOPS AND I HAVE BEEN TOLD BY BOTH THAT IT IS A TIMING CHAIN ISSUE AND I NEED TO INSTALL A NEW ENGINE! I CALLED THE GMC DEALERSHIP AND ASKED IF THE RECALL COULD BE A DIRECT RESULT OF MY TIMING CHAIN ISSUE, AND IF I HAD ANY OTHER RECALLS? I WAS TOLD I WOULD HAVE TO PAY FOR THEM TO LOOK AT MY VEHICLE IF NOT APART OF THE RECALL. I DO NOT HAVE THE EXTRA MONEY TO PAY MULTIPLE TIMES FOR MY CAR TO BE LOOKED AT OR TO PUT AN ENGINE IN A VEHICLE THAT HAS LESS THAN 85K MILES. I PURCHASED THIS VEHICLE IN LATE DECEMBER OF 2015 AND HAVE NOT BE ABLE TO DRIVE THE VEHICLE SINCE ABOUT SEPTEMBER OF 2016. I HAVE GOTTEN AT LEAST TWO OIL CHANGES IN THAT TIME FRAME (DEC-SEPT) FROM THE SAME GMC DEALERSHIP AND WAS NEVER TOLD ABOUT ANY RECALLS OR ANY ISSUES WITH MY VEHICLE BESIDES NEEDING TIRES/BRAKES. ONE OF THE MECHANICS THAT I TOOK THE VEHICLE TO SAID I HAVE OTHER RECALLS. I WAS NOT ABLE TO LOCATE ANY OTHERS ONLINE AND THAT IS MY REASON FOR WRITING THIS. I AM VERY UNSATISFIED AND DO NOT KNOW HOW TO PROCEED.
GETTING GAS IN OIL RUNS WHEN YOU SHUT IT OFF RUFF IDLE
I PURCHASE MY TRUCK CERTIFIED USED AND I ALREADY HAVE TO DROP $1400 BECAUSE THE O2 SENSOR WENT OUT, THE EXHAUST MANIFOLD IS CRACKED AND THE HOSE THAT RECYCLES THE GAS (I'M GUESSING THE INTAKE VALVE) IS LEAKING! I STILL HAVE TO MAKE CAR PAYMENTS AND INSURANCE PAYMENTS WHICH TOTAL UP TO ABOUT $700 PER MONTH!!!! I AM REALLY DISSATI…
Read full complaint
I PURCHASE MY TRUCK CERTIFIED USED AND I ALREADY HAVE TO DROP $1400 BECAUSE THE O2 SENSOR WENT OUT, THE EXHAUST MANIFOLD IS CRACKED AND THE HOSE THAT RECYCLES THE GAS (I'M GUESSING THE INTAKE VALVE) IS LEAKING! I STILL HAVE TO MAKE CAR PAYMENTS AND INSURANCE PAYMENTS WHICH TOTAL UP TO ABOUT $700 PER MONTH!!!! I AM REALLY DISSATISFIED AS MUCH AS I LOVE MY TRUCK.
I ORDERED THIS VEHICLE IN 12/2009 AND RECEIVED IT 2/2010. THERE HAVE BEEN SEVERAL RECALLS AND MOST RECENTLY I HAD TO REPLACE CAM SHAFT ACCUATORS AND HIGH PRESSURE FUEL PUMP TO THE TUNE OF $1800.00. MY WIFE WAS DRIVING HOME FROM WORK AND THE CAR WAS RATTLING AND VIBRATING LIKE IT HAD TWO FLAT TIRES. BEFORE THAT SHE INFORMED THAT…
Read full complaint
I ORDERED THIS VEHICLE IN 12/2009 AND RECEIVED IT 2/2010. THERE HAVE BEEN SEVERAL RECALLS AND MOST RECENTLY I HAD TO REPLACE CAM SHAFT ACCUATORS AND HIGH PRESSURE FUEL PUMP TO THE TUNE OF $1800.00. MY WIFE WAS DRIVING HOME FROM WORK AND THE CAR WAS RATTLING AND VIBRATING LIKE IT HAD TWO FLAT TIRES. BEFORE THAT SHE INFORMED THAT THE SERVICE ENGINE AND STABILITRAK LIGHTS HAD COME ON. THERE IS A NOISE THAT RATTLES IN THE EXHAUST AND I HAVE HAD PROBLEMS WITH THE HEATER NOT WORKING IN THE COLD DAYS OF WISCONSIN. I AM HIGHLY DISAPPOINTED IN GMC, WHO RECEIVED A "BAIL OUT" NOW OWNERS OF THIS VEHICLE NEED A "BAIL OUT" FROM THIS TERRIBLE DESIGN OF A VEHICLE.
TL* THE CONTACT OWNS A 2010 GMC TERRAIN. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE AND NOTICED THAT THE TIMING CHAIN HAD FRACTURED. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT NOTICED FUEL FUMES EMITTING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO …
Read full complaint
TL* THE CONTACT OWNS A 2010 GMC TERRAIN. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE AND NOTICED THAT THE TIMING CHAIN HAD FRACTURED. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT NOTICED FUEL FUMES EMITTING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE TIMING CHAIN, WATER PUMP, FUEL PUMP, PISTONS, SPARK PLUGS, GASKET AND MULTIPLE UNKNOWN PARTS NEEDED TO BE REPLACED. THE VEHICLE REPAIRED. HOWEVER, THE CONTACT STATED THAT WHILE REVERSING AT A LOW SPEED, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000.
Official recalls
322V137000 · Exterior Lighting:headlights
Mar 8, 2022
General Motors, LLC (GM) is recalling certain 2010-2017 GMC Terrain vehicles. A reflection caused by the headlight housings may illuminate areas above the vehicle and outside of the driver's view with excessively bright light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The bright reflection may cause a glare for other drivers, reducing their visibility and increasing the risk of a crash.
Remedy: Dealers will install headlamp appliques, free of charge. Owner notification letters were mailed September 8, 2022. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N222363740.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
09V489000 · Visibility:defroster/defogger/hvac System
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2010 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS AND WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS". THE SOFTWARE IN THE CENTER INSTRUMENT PANEL CAN CAUSE THE HEATING, AIR CONDITIONING, DEFROST, AND RADIO CONTROLS, AS WELL AS THE PANEL ILLUMINATION TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING WITHOUT A FUNCTIONING DEFROST SYSTEM CAN DECREASE YOUR VISIBILITY UNDER CERTAIN DRIVING CONDITIONS AND COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE COMPUTER MODULE IN THE CENTER INSTRUMENT PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.