Illustration1996 GMC SUBURBAN, CAUGHT ON FIRE. BF OHIO TRAFFIC CRASH REPORT #10-0580-91 UPDATED 05/03/10 *BF
1996 GMC Suburban
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 172 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports2 fire reports9 injury reports
Electrical System complaints
18 reportsDT: THE CONTACT OWNS A 1996 GMC SUBURBAN. WHEN HE PURCHASED THE VEHICLE IT HAD 26,000 MILES ON IT. HE WAS PULLING A TRAILER, WITH THE TRAILER AND THE TRUCK IT WEIGHS FROM ANY WHERE 10-15,000 POUNDS. THERE IS A BOLT THAT 3 QUARTERS INCH LONG . PUT THE TWO CABLES TOGETHER AND BOLTED IT INTO THE SIDE BATTERY. THE BOLT BECAME LOOSE…
Read full complaint
DT: THE CONTACT OWNS A 1996 GMC SUBURBAN. WHEN HE PURCHASED THE VEHICLE IT HAD 26,000 MILES ON IT. HE WAS PULLING A TRAILER, WITH THE TRAILER AND THE TRUCK IT WEIGHS FROM ANY WHERE 10-15,000 POUNDS. THERE IS A BOLT THAT 3 QUARTERS INCH LONG . PUT THE TWO CABLES TOGETHER AND BOLTED IT INTO THE SIDE BATTERY. THE BOLT BECAME LOOSE. HAD ALL THE POWER NECESSARY TO STEER OR TO STOP THE VEHICLE. WHILE PULLING THIS TRAILER IT WAS EXTREMELY HARD TO CONTROL THE VEHICLE. THE INSERT IN THE BATTERY, WHERE THE THREAD SECTION WAS PUT THE BOLT INTO. IF TIGHTEN EDIT IT PUTS A HOLE IN THE BATTERY AND STARTS TO LEAK BATTERY ACID. EVERY MORNING HE TIGHTENS THE BOLT A LITTLE BIT. CONSUMER SPOKEN WITH GM , AND THEY IGNORED IT. ALSO SPOKE WITH THE DEALERSHIP . THEY DID NOT EVEN BELIEVE HIM. ONE OF THE PEOPLE AT THE DEALERSHIP REPLACED ONE CABLE BECAUSE IT DETERIORATED. HE HAS REPLACED FOR FOUR BATTERIES SINCE HE PURCHASED THE VEHICLE .*AK
WHILE THE VEHICLE WAS PARKED AND THE IGNITON WAS OFF THE SWITCH ON THE DRIVERS DOOR FOR THE SIDE VIEW MIRRORS SUDDENLY IGNITED . THE KEYS WERE NOT IN THE CAR AND IN FACT THE CAR HAD NOT BEEN IN USE FOR OVER FIVE HOURS. LUCKILY OUR SON WENT OUT INTO THE GARAGE AND REPORTED BACK THAT THE CAR WAS FULL OF SMOKE. WHEN I WENT OUT THE …
Read full complaint
WHILE THE VEHICLE WAS PARKED AND THE IGNITON WAS OFF THE SWITCH ON THE DRIVERS DOOR FOR THE SIDE VIEW MIRRORS SUDDENLY IGNITED . THE KEYS WERE NOT IN THE CAR AND IN FACT THE CAR HAD NOT BEEN IN USE FOR OVER FIVE HOURS. LUCKILY OUR SON WENT OUT INTO THE GARAGE AND REPORTED BACK THAT THE CAR WAS FULL OF SMOKE. WHEN I WENT OUT THE FLAMES WERE ALREADY COMING UP THROUGH THE MELTED HOLES IN THE DOOR TRIM PANEL.
ON GOING ELECTRIAL PROBLEMS, REPLACE BATTERY, BATTERY CABLE, ALTERNATER, DUE TO BATTERY ACID LEAKING DOWN CABLE AND CORRODED CABLE.
ELECTRICAL WIRES OVERHEATED. *AK
EA00013. BATTERY LEAKED ACID AND CORRODED MAIN BATTERY CABLE. *AK
NO SUMMARY
PROBLEM STARTED IN MAY WITH PREVIOUS OWNER. BATTERY LEAKING, ALTERNATOR WENT. RADIO WENT INYO ANTI-THEFT. BATTERY HAS BEEN REPLACED 5 TIMES (BATTERY LEAKING) & ALTENATOR 2 TIMES SINCE MAY. THE RADIO HAD TO BE REPLACED. AFTER ANTI-THEFT MODE WAS FIXED, ONLY CD WOULD WORK. CAR HAS JUST FIED AGAIN. SAW ARTICLE IN PAPER REFERR…
Read full complaint
PROBLEM STARTED IN MAY WITH PREVIOUS OWNER. BATTERY LEAKING, ALTERNATOR WENT. RADIO WENT INYO ANTI-THEFT. BATTERY HAS BEEN REPLACED 5 TIMES (BATTERY LEAKING) & ALTENATOR 2 TIMES SINCE MAY. THE RADIO HAD TO BE REPLACED. AFTER ANTI-THEFT MODE WAS FIXED, ONLY CD WOULD WORK. CAR HAS JUST FIED AGAIN. SAW ARTICLE IN PAPER REFERRING THIS PROBLEM BUT WHEN CHECKED WITH DEALER (RT 22-BRIDGEWATER) THEY KNEW NOTHING ABOUT THIS. *AK
THE BATTERY IS LEAKING ACID FROM THE POSITIVE TERMINAL, CAUSING VEHCILE NOT TO START. ENGINEER ANALYSIS# EA00013. PLEASE GIVE ANY FURTHER DETAILS.*AK
VEHICLE BATTERY WENT BAD. DEALER REPLACED BATTERY WITH NEW GMC ORIGNAL AND REPLACED ALTERNATOR. NEW BATTERY FAILED MONTHS LATER. POSITIVE TERMINAL ON BATTERY LEAKED AND DESTORYED CONNECTOR. FAILED WHLIE DRIVING CAR ON INTERSTATE AT 65MPH. TOTAL ELECTRICAL FAILURE WAS ABLE TO PULL OVER. CAR STATRED BACK UP. FAILURE WAS ON AND…
Read full complaint
VEHICLE BATTERY WENT BAD. DEALER REPLACED BATTERY WITH NEW GMC ORIGNAL AND REPLACED ALTERNATOR. NEW BATTERY FAILED MONTHS LATER. POSITIVE TERMINAL ON BATTERY LEAKED AND DESTORYED CONNECTOR. FAILED WHLIE DRIVING CAR ON INTERSTATE AT 65MPH. TOTAL ELECTRICAL FAILURE WAS ABLE TO PULL OVER. CAR STATRED BACK UP. FAILURE WAS ON AND OFF AND HARD TO DETECT. FINALLY FAILED FOR GOOD FEW DAYS LATER. DEALER WANTED TO CHARGE $600 FOR NEW CABLES & BATTERY. BATTERY DESTORYED ALL POWER CABLES. HAD "COMING TO JESUS" TALK WITH DEALER. WASN'T GOING TO PAY FOR DAMAGE THAT WAS DONE BY THEIR BATTERY THAT THEY INSTALLED UNDER WARRANTY. AGREED PAINFULLY TO PAY FOR NEW BATTERY ($79). INSTALLED INTERSTATE BATTERY INTEAD. NO PROBLEMS SINCE.
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V057000 · Vehicle Speed Control
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
PE99073 · Battery Leaks Acid
Opened Dec 3, 1999 · Closed May 2, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION OF THE RIGHT FRONTBRAKE LINE AS A RESULT OF SULFURIC ACID CONTAMINATION.THE REMAINING 11 COMPLAINTS PERTAIN PRIMARILY TO SULFURIC ACID LEAKAGE FROM THE BATTERY CASE.AT LEAST ONE COMPLAINANT STATED THAT THE REPLACEMENT BATTERY ALSO FAILED.SEVERAL OF THE COMPLAINANTS NOTE THAT THE LEAKING ACID HAD COME IN CONTACT WITH A WIRE HARNESS AT THE FRAME IN THE VICINITY OF THE STEEL BRAKE LINE.A FIELD INSPECTION BY ODI INDICATES THAT THE DESCRIBED HARNESS IS THE ABS CONNECTION TO THE RIGHT FRONT WHEEL SPEED SENSOR.PRIOR TO THE BATTERY CASE FAILURE, THERE IS USUALLY NO WARNING (SHORT OF AN UNDERHOOD INSPECTION), AND THE ENSURING DAMAGE (SULFURIC ACID CONTAMINATION) IS PROGRESSIVE.OF THE KNOWN BATTERY FAILURES, THERE MAY BE A TEMPERATURE CORRELATION, AS 60% OF THE OWNER COMPLAINTS CAME FROM FOUR STATES; CALIFORNIA, FLORIDA, GEORGIA AND TEXAS.THERE IS ALSO A PRODUCT IMPROVEMENT PROGRAM AND ENGINEERING CHANGE NOTICE TO ADD 1% SILVER TO THE BATTERY'S POSITIVE SIDE TERMINALL, WITH THE EARLIEST IMPLEMENTATION DATE FOR THIS BEING FEB 2, 1998.THE EFFECT OF THIS DESIGN CHANGE IS AS YET UNKNOWN; FURTHER REVIEW IS WARRANTED.AN EA IS BEING OPENED TO GATHER FURTHER APPROPRIATE INFORMATION, CLARIFY ANY DEFECT TRENDS, AND TO ASSESS THE SAFETY IMPLICATIONS AND RISKS CONCERNING THESE FAILURES.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES